Toshiba 43VJ22P Quick start guide

SCHEMATIC DIAGRAM
WARNING: BEFORE SERVICING THIS CHASSIS, READ THE "X-RAY RADIATION PRECAUTION", "SAFETY
PRECAUTION" AND "PRODUCT SAFETY NOTICE" ON THE MANUAL FOR THIS MODEL.
CAUTION: The international hazard symbols "*" in the schematic diagram and the parts list designate components
which have special characteristics important for safety and should be replaced only with types identical to those in the
original circuit or specified in the parts list. The mounting position of replacements is to be identical with originals.
Before replacing any of these components, read carefully the PRODUCT SAFETY NOTICE on the MANUAL for this
model. Do not degrade the safety of the receiver through improper servicing.
NOTE:
1. RESISTOR Resistance is shown in ohm [K = 1.000, M = 1.000.000]. All resistors are 1/6W and 5%
tolerance carbon resistor, unless otherwise noted as the following marks.
1/2R = Metal or Metal oxide of 1/2 watt 1/2S = Carbon compsistion of 1/2 watt
1RF = Fuse resistor of 1 watt 10W = Cement of 10 watt
K = ±10% G = ±2% F = ±1%
2. CAPACITOR Unless otherwise noted in schematic, all capacitor values less than 1 are expressed in
?F, and the values more than 1 in pF.
All capacitors are ceramic 50V, unless otherwise noted as the following marks.
Electolytic capacitor Mylar capacitor
3. The parts indicated with " *" have special characteristics, and should be replaced with identical parts only.
4. Voltages read with DIGITAL MULTI-METER from point indicated to chassing ground, using a color bar signal with all
controls at normal, line voltage 220 volts.
5. Waveforms are taken receiving color bar signal with enough sensitivity.
6. Voltage reading shown are nominal values and may vary ±20% except H.V.
MODEL : 43VJ22P
– 51 –
SCHEMATIC DIAGRAM STRUCTURE:
SIGNAL Circuit ( MAICON / OTHER ) [ SHEET - 1/4 ] ................. 1/8
( VCD / IF / V.OUT ) [ SHEET - 2/4 ] ................. 2/8
( AV / AUDIO ) [ SHEET - 3/4 ] ................. 3/8
( D-CONVER ) [ SHEET - 4/4 ] ................. 4/8
POWER Circuit ......................................................................................................... 5/8
DEF / CONV Circuit ( DEF ) [ SHEET - 1/2 ] ................. 6/8
( CONV ) [ SHEET - 2/2 ] ................. 7/8
CRT-D / SVM / FRONT Circuit ................................................................................. 8/8

–52 –
SPECIFIC INFORMATIONS
RearCenter
Main
CRT.RCRT.GCRT.B
Q
Q
Q
Q
VIDEO OUT
SVM OUT
VIDEO OUT
SVM OUT
VIDEO OUT
SVM OUT
Q
Q
V OUT
Q301
H OUT
Q404
CONVER OUT
Q751,Q752
DY
DY
DY
SVMSVMSVM
D CONVER RGBYs
Q
Rear AMP
Q
Center AMP
Q
Main AMP
BACK END PROCESSOR
Q510
RGB
YM
OSD
QR01
RGB
RGB
MIXER
E/W
CORRECTION
VP
H
UP C ONVERTER
BLK/CP/B-MASK
YCbCr->YUV
Y2/U/Vin
Q302
FBT
AFC
AMP
Y
U
V
ADC
MPX ADC
TC90A61F
DFS
VD
PLL
PLL
HD
EM626327Q
SGRAM
TIF
MAA
H001
H002
L,R,SL,SR,C
L,R
C
SL,SR
W
L,R OUT-1 TV-L,R
TV-V
ANT
DIGITAL
AUDIO IN
W-OUT
AMP
W
AV S WQV01
E1
E2
E3
I/O1
I/O2
I/O3
#8
#8
#8
TV-L, R out
V,L , R OUT - 2
AUDIO OUT
FIX
RGBYs
Y/V,C,L,R S1
V1
V,L , R
V,L , R S2
FRONT
S+AV
MICRO&TEXT
PROCESSOR
QA01
EEP-ROM
QA02
RGB Ys
SDA,SCL
SYNC-AV
SYNC-OUT
RGB
MULTI COLOR DECODER
Q501
EPG SW
CVBSout
Y1 in
Yviout
SYNCin
YCbCr
HD/VD
RGB1in
E4(YCbCr)
YCbCr1in
CVBS/Y2in
C-OUT C1in
D-COMB
Y-OUT
CVBS/Y1in
COMBin
Q
2001 Euro PJTV CIRCUIT BLOCK DIAGRAM
CIRCUIT BLOCK DIAGRAM

SIGNAL-MAICON/OTHER
43VJ22P
[SHEET-1/4]
5.0
5.0
0
0
0
0
0
0
0
0
0
0
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.5
5.0
5.0
0
0
0
0
0
0
0
0
5.0
5.0
0
0
5.0
5.0

5.0
5.0
0
0
0
0
0
0
0
0
0
0
4.5
4.5
4.5
4.5
4.5
4.5
4.5
4.5
5.0
5.0
0
0
0
0
0
0
0
0
5.0
5.0
0
0
5.0
5.0

SIGNAL-MAICON/OTHER
43VJ22P
[SHEET-1/4]
5.0
0
0
0
0
0
4.5
4.5
4.5
4.5
5.0
0
0
0
0
5.00
5.0

43VJ22P
SIGNAL-VCD/IF/V.OUT
[SHEET-2/4]
2
2
1
1
(H)
(H)
0.8V(p-p)
0.8V(p-p)
(H)
(H)
(H)
(H)
0.6V(p-p)
0.6V(p-p)
(H)
(H)
0.7V(p-p)
0.7V(p-p)
(H)
(H)
0.53V(p-p)
0.53V(p-p)
(H)
(H)
0.75V(p-p)
0.75V(p-p)
(H)
(H)
0.9V(p-p)
0.9V(p-p)
0.78V(p-p)
0.78V(p-p)
Q301
Q301
in
in
1
1
0
0
0
0
out
out
5
5
1
1
2
2
1
1
2
2
1
1
5ms/DIV.
5ms/DIV.
2
2
0.5V/DIV.
0.5V/DIV.
5ms/DIV.
5ms/DIV.
20V/DIV.
20V/DIV.
0
0
9.0
9.0
9.0
9.0
-15.0
-15.0
15.0
15.0
5.0
5.0
32.0
32.0
4.1
4.1
4.1
4.1
2.4
2.4
3.5
3.5
3.5
3.5
3.5
3.5
9.0
9.0
2.3
2.3
0
0
4.5
4.5
5.0
5.0
4.5
4.5
0
0
9.0
9.0
3.0
3.0
2.4
2.4
2.4
2.4

2
1
(H)
(H)
0.8V(p-p)
0.8V(p-p)
(H)
(H)
(H)0.6V(p-p)
(H)
(H)
0.7V(p-p)
0.7V(p-p)
(H)0.53V(p-p)
(H)
(H)
0.75V(p-p)
0.75V(p-p)
(H)
(H)
0.9V(p-p)
0.9V(p-p)
0.78V(p-p)
0.78V(p-p)
Q301
in
1
0
0
out
5
1
2
1
21
5ms/DIV.
2
0.5V/DIV.
5ms/DIV.
20V/DIV.
0
0
9.0
9.0
9.0
9.0
-15.0
15.0
5.0
5.0
32.0
32.0
4.1
4.1
4.1
4.1
2.4
2.4
3.5
3.5
3.5
3.5
3.5
3.5
9.0
9.0
2.3
2.3
0
0
4.5
4.5
5.0
5.0
4.5
4.5
0
0
9.0
9.0
3.0
3.0
2.4
2.4
2.4
2.4

43VJ22P
SIGNAL-VCD/IF/V.OUT
[SHEET-2/4]
2
2
1
1
(H)
0.8V(p-p) (H)
(H)
(H)
0.6V(p-p)
0.6V(p-p)
(H)0.7V(p-p)
(H)
(H)
0.53V(p-p)
0.53V(p-p)
(H)0.75V(p-p)
(H)0.9V(p-p)
0.78V(p-p)
Q301
Q301
in
in
1
1
0
0
0
0
out
out
5
5
1
1
2
2
1
1
2
2
1
1
5ms/DIV.
5ms/DIV.
2
2
0.5V/DIV.
0.5V/DIV.
5ms/DIV.
5ms/DIV.
20V/DIV.
20V/DIV.
0
9.0
9.0
-15.0
-15.0
15.0
15.0
5.0 32.04.14.1
2.4
3.5
3.5 3.5
9.0
2.3
0
54.5
5.0
54.5
0
09.0
3.0
2.4
2.4

43VJ22P
SIGNAL-AV/AUDIO
[SHEET-3/4]
0
0
9.0
9.0
0
0
0
0
5.0
5.0
0
0
0
0
0
0
13.0
13.0
0
0
30.0
30.0
8.8
8.8
12.9
12.9
1.9
1.9
1.9
1.9
0
0
1.9
1.9
1.9
1.9
4.5
4.5
4.5
4.5
4.1
4.1
4.1
4.1
8.3
8.3
2.1
2.1
6.9
6.9
4.1
4.1
0
0
9.0
9.0
4.1
4.1
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
0
0
6.6
6.6
4.1
4.1
4.1
4.1
3.9
3.9
4.1
4.1
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
0
0
5.2
5.2

09.0005.00
00 13.00 30.08.8 12.91.9 1.901.91.9
4.5
4.5
4.5
4.5
4.1
4.1
4.1
4.1
8.3
8.3
2.1
2.1
6.9
6.9
4.1
4.1
0
0
9.0
9.0
4.1
4.1
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
0
0
6.6
6.6
4.1
4.1
4.1
4.1
3.9
3.9
4.1
4.1
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
5.2
0
0
5.2
5.2

43VJ22P
SIGNAL-AV/AUDIO
[SHEET-3/4]
0
0
9.0
9.0
0
0
0
0
5.0
5.0
0
0
0
0
0
0
13.0
13.0
0
0
30.0
30.0
8.8
8.8
12.9
12.9
1.9
1.9
1.9
1.9
0
0
1.9
1.9
1.9
1.9
4.5
4.5
4.1
4.1
8.3
2.1
6.9
4.1
0
9.0
4.1
5.2
5.2
5.2
5.2
5.2
0
6.6
4.1
4.1
3.9
4.1
5.2
5.2
5.2
5.2
5.2
5.2
5.2
05.2

43VJ22P
[SHEET-4/4]
SIGNAL-D-CONVER

43VJ22P
[SHEET-4/4]
SIGNAL-D-CONVER

TO SIGNAL
ANT-GND
POWER
43VJ22P
4
4
14
14
Q801
Q801
0
0
5
5
T862
T862
1
1
2
2
23
23
22
22
1
1
2
2
50V
50V
50V
50V
5
5
µ
µ
s
s
5
5
µ
µ
s
s
10
10
10
10
DC
DC
DC
DC
AC
AC
AC
AC
1 AC 0V
1 AC 0V
5
5
5
5
1
1
2
2
4
4
50
50
3
3
50
50
V
V
mV
mV
mV
mV
V
V
5
5
µ
µ
s
s
BWL
BWL
2
2
1
1
5.4
5.4
0
0
119.7
119.7
120.7
120.7
85.4
85.4
78.3
78.3
0
0
0.8
0.8
17.8
17.8
3.6
3.6
0.3
0.3
5.9
5.9
5.8
5.8
2.3
2.3
0
0
156.7
156.7
7.7
7.7

ANT-GND
4
4
14
14
Q801
Q801
0
0
5
5
T862
T862
1
1
2
2
23
23
22
22
1
1
2
2
50V
50V
50V
50V
5
5
µ
µ
s
s
5
5
µ
µ
s
s
10
10
10
10
DC
DC
DC
DC
AC
AC
AC
AC
1 AC 0V
1 AC 0V
5
5
5
5
1
1
2
2
4
4
50
50
3
3
50
50
V
V
mV
mV
mV
mV
V
V
5
5
µ
µ
s
s
BWL
BWL
2
2
1
1
5.4
5.4
0
0
119.7
119.7
120.7
120.7
85.4
85.4
78.3
78.3
0
0
0.8
0.8
17.8
17.8
3.6
3.6
0.3
0.3
5.9
5.9
5.8
5.8
2.3
2.3
0
0
156.7
156.7
7.7
7.7

TO SIGNAL
POWER
43VJ22P
4
14
Q801
0
5
T862
1
2
2322
1
2
50V
50V
5µs
5µs
10
10
DC
DC
AC
AC
1 AC 0V
5
5
1
2
450
350
V
mV
mV
V
5µs BWL
2
1
5.4
0119.7
120.7
85.4
78.3
0
0.8
17.8
3.6 0.3
5.9
5.8
2.3
0
156.7 7.7

DEF/CONV(DEF)
43VJ22P
[SHEET-1/2]
1
1
0
0
P414
P414
1
1
5
5
200V/DIV.
200V/DIV.
5ms/DIV.
5ms/DIV.
5
5
1
1
B
B
Q404
Q404
1
1
C
C
Q404
Q404
50V/DIV.
50V/DIV.
1
1
2
2
20
20
µ
µ
s/DIV.
s/DIV.
3
3
1
1
500V/DIV.
500V/DIV.
20
20
µ
µ
s/DIV.
s/DIV.
0
0
2
2
1
1
0
0
C
C
B
B
Q402
Q402
B
B
C
C
50V/DIV.
50V/DIV.
1
1
1
1
2
2
20
20
µ
µ
s/DIV.
s/DIV.
0.5V/DIV.
0.5V/DIV.
20
20
µ
µ
s/DIV.
s/DIV.
1
1
9
9
T461
T461
Heater
Heater
1
1
50
50
µ
µ
s/DIV.
s/DIV.
10V/DIV.
10V/DIV.
4
4
4
4
3
3
2
2
1
1
0
0
16.0
16.0
126
126
-17.6
-17.6
-17.6
-17.6
34.4
34.4
0
0
0.3
0.3

10
P414
1
5
200V/DIV.
5ms/DIV.
5
1
B
Q404
1
C
Q404
50V/DIV.
1
2
20µs/DIV.
3
1
500V/DIV.
20µs/DIV.
0
2
10
C
B
Q402
B
C
50V/DIV.
1
1
2
20µs/DIV.
0.5V/DIV.
20µs/DIV.
1
9
T
4T461
Heater
1
1
50
50
µ
µ
s/DIV.
s/DIV.
10V/DIV.
10V/DIV.
4
4
4
4
3
3
2
2
1
1
0
16.0
126
126
-17.6
-17.6
-17.6
-17.6
34.4
34.4
0
0
0.3
0.3

DEF/CONV(DEF)
43VJ22P
[SHEET-1/2]
1
1
0
0
P414
P414
1
1
5
5
200V/DIV.
200V/DIV.
5ms/DIV.
5ms/DIV.
5
5
1
1
B
B
Q404
Q404
1
1
C
C
Q404
Q404
50V/DIV.
50V/DIV.
1
1
2
2
20
20
µ
µ
s/DIV.
s/DIV.
3
3
1
1
500V/DIV.
500V/DIV.
20
20
µ
µ
s/DIV.
s/DIV.
0
0
2
2
1
1
0
0
C
C
B
B
Q402
Q402
B
B
C
C
50V/DIV.
50V/DIV.
1
1
1
1
2
2
20
20
µ
µ
s/DIV.
s/DIV.
0.5V/DIV.
0.5V/DIV.
20
20
µ
µ
s/DIV.
s/DIV.
1
1
9
9
T461
T461
Heater
Heater
1
50µs/DIV.
10V/DIV.
4
4
3
2
1
0
0
16.0
16.0
126
-17.6
-17.6
34.4
0
0.3