Toyota 2007 Tundra Operating manual

PASSPORT
toperformance
2007
Tundra
Scheduled
Maintenance Guide

dddddd

i
egular maintenance is essential to obtaining the highest level of perfor-
mance from your Toyota. It can also increase your vehicle’s resale value.
This booklet presents Toyota’s maintenance recommendations in conve-
nient checklists, so you can easily see what type of maintenance your vehicle
needs and document that the work was performed.
To ensure that your vehicle receives first-quality service and parts, Toyota
recommends having maintenance performed by an authorized Toyota dealer-
ship. Toyota dealership technicians are experts on Toyota vehicles, and they use
Genuine Toyota Parts designed to your vehicle’s exact specifications. When you
go to a Toyota dealership, you can be confident of the quality that is going on
your vehicle as well as the qualifications of the person under the hood.
Documenting Your Investment
To help you verify that you’ve invested in proper maintenance, each mainte-
nance checklist includes space for your Toyota dealership to certify that you
obtained Genuine Toyota Service for your vehicle. The dealership will mark
the dealer service verification area with the following stamp (which may be
customized with the dealership’s name):
Additional Maintenance
In addition to scheduled maintenance, your Toyota requires ongoing general
maintenance such as fluid checks and visual inspections. These procedures are
explained in the “Vehicle Maintenance and Care” section of the Owner’s Manual.
Be sure to perform these procedures regularly to ensure the most trouble-free
operation of your vehicle.
Your Passport to Performance
R

ii
Maintenance Records
Maintaining your vehicle according to the recommendations in this booklet is
required to ensure that your warranty coverage remains intact. You should keep
detailed records of vehicle maintenance, including date of service, mileage at
time of service and a description of service and/or parts installation performed.
The scheduled maintenance log in this booklet can help you document this
information. If you sell your vehicle, be sure to give your maintenance records
to the new owner.
Toyota will not deny a warranty claim solely because you do not have records
to show that you maintained your vehicle. However, damage or failures caused
by lack of proper maintenance are not covered under warranty.
Maintenance Providers
Maintenance and repair services may be performed by you or by any automotive
service provider you choose. Toyota will not deny a warranty claim solely because
you used a service provider other than a Toyota dealership for maintenance and
repairs. However, damage or failures caused by improper maintenance or repairs
are not covered under warranty.
Dealer-Recommended Maintenance
Your dealer may recommend more frequent maintenance intervals or more
maintenance services than those listed in the scheduled maintenance log. These
additional services are not required to maintain your warranty coverage. Ask your
dealer for an explanation of any recommended maintenance not included in the
scheduled maintenance log.
For a complete description of Toyota warranty coverages, see the booklet
entitled 2007 Owner’s Warranty Information located in your vehicle’s
glove box.
Maintenance and Toyota Warranty Coverage

1
Table of Contents
Vehicle Identification
Using the Maintenance Log Charts
Off-Road Daily Maintenance
Maintenance Log: 2007 Tundra
Explanation of Maintenance Items
Online Information
2
4
5
6
22
For your convenience, scheduled maintenance information for your vehicle is
also available at www.toyotaownersonline.com.
From the site’s home page, select
“Scheduled Maintenance.” This will
bring you to the screen shown below,
where you will select your vehicle’s
model name, year and current
mileage/time interval. After you click “Search,” you’ll be able to view your
vehicle’s recommended maintenance for that interval.

Vehicle Identification
2
Model
In-service date
Selling dealership
Key number
Body style
Mileage at delivery
Selling dealership phone number
Vehicle Identification Number
2

Notes
33

Using the Maintenance Log Charts
4
Miles or Months?
Toyota recommends obtaining scheduled maintenance for your vehicle every
5,000 miles or six months, whichever comes first.
For example:
•If you drive 5,000 miles in less than six months, you should obtain mainte-
nance at 5,000 miles —don’t wait until six months.
•If at six months you have driven less than 5,000 miles, you should obtain
maintenance at six months —don’t wait until 5,000 miles.
Be sure to keep an eye on your mileage so that you obtain maintenance when
recommended. If you are a low-mileage driver, mark your calendar to remind
yourself to obtain maintenance every six months.
Special Operating Conditions
In addition to standard maintenance items, the maintenance log indicates
services that should be performed on vehicles that are driven under especially
demanding conditions. These “special operating conditions” and their required
maintenance items are clearly indicated in each chart.
Note: You should perform these additional maintenance services if you drive
primarily under any of the special operating conditions indicated. If you drive
only occasionally under these conditions, it is not necessary to perform the
additional services.

Off-Road Daily Maintenance
5
In addition to the maintenance items indicated for each mileage/month interval,
you should perform certain inspections daily when you drive off-road. Whenever
you take your vehicle off-road through deep sand, mud or water, perform these
inspections every day:
•Check ball joints and dust covers
•Check brake lines and hoses
•Check brake pads/discs
•Check differential oil
•Check drive shaft boots
•Check engine air filter
•Check nuts and bolts on chassis
•Check steering linkage and boots
•Check transfer case oil (4WD models)
•Check transmission fluid or oil
•Lubricate propeller shaft (4WD models)

Maintenance Log: 2007 Tundra
5,000 Miles or 6 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Visually inspect brake linings/drums and
brake pads/discs
Additional Maintenance Items for Special
Operating Conditions2
Driving off-road, on dirt roads or
on dusty roads:3
❑Inspect ball joints and dust covers
❑Inspect drive shaft boots (4WD only)
❑Inspect engine air filter
❑Inspect steering linkage and boots
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving on salted roads:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
10,000 Miles or 12 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Visually inspect brake linings/drums and
brake pads/discs
Additional Maintenance Items for Special
Operating Conditions2
Driving off-road, on dirt roads or
on dusty roads:3
❑Inspect ball joints and dust covers
❑Inspect drive shaft boots (4WD only)
❑Inspect engine air filter
❑Inspect steering linkage and boots
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving on salted roads:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
Dealer Service Verification:
Date: Mileage:
Dealer Service Verification:
Date: Mileage:
666

1Reset the oil replacement reminder (“MAINT REQD”) light after replacing engine oil.
2Perform these service items only if you drive primarily under the conditions indicated.
3See page 5 for daily maintenance required when driving off-road.
4See page 23 for details.
Maintenance Log: 2007 Tundra
15,000 Miles or 18 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Visually inspect brake linings/drums and brake pads/discs
❑Inspect the following:
__ Ball joints and dust covers
__ Brake lines and hoses
__ Drive shaft boots (4WD only)
__ Engine coolant4
__ Exhaust pipes and mountings
Note: Driving in heavy traffic, on dirt roads or in urban, dusty or desert areas may shorten
the life of the cabin air filter. Replacement may be needed if you notice reduced air flow
from the air conditioner and heater or if the windows fog easily when you use the "Fresh"
mode. Consult your dealer if any of these conditions occur.
Additional Maintenance Items for Special Operating Conditions2
Driving off-road, on dirt roads or on dusty roads:3
❑Inspect engine air filter
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Replace front differential oil (4WD only)
❑Replace rear differential oil
❑Tighten nuts and bolts on chassis
Dealer Service Verification:
Date:
Mileage:
77
__ Front differential oil (4WD only)
__ Radiator and condenser
__ Rear differential oil
__ Steering gear box
__ Steering linkage and boots

Maintenance Log: 2007 Tundra
20,000 Miles or 24 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Visually inspect brake linings/drums and
brake pads/discs
Additional Maintenance Items for Special
Operating Conditions2
Driving off-road, on dirt roads or
on dusty roads:3
❑Inspect ball joints and dust covers
❑Inspect drive shaft boots (4WD only)
❑Inspect engine air filter
❑Inspect steering linkage and boots
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving on salted roads:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
25,000 Miles or 30 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Visually inspect brake linings/drums and
brake pads/discs
Additional Maintenance Items for Special
Operating Conditions2
Driving off-road, on dirt roads or
on dusty roads:3
❑Inspect ball joints and dust covers
❑Inspect drive shaft boots (4WD only)
❑Inspect engine air filter
❑Inspect steering linkage and boots
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving on salted roads:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
Dealer Service Verification:
Date: Mileage:
Dealer Service Verification:
Date: Mileage:
88

1Reset the oil replacement reminder (“MAINT REQD”) light after replacing engine oil.
2Perform these service items only if you drive primarily under the conditions indicated.
3See page 5 for daily maintenance required when driving off-road.
4Required under the terms of the Emission Control Warranty.
5Inspect thickness measurement and disc runout.
6See page 23 for details.
Maintenance Log: 2007 Tundra
30,000 Miles or 36 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Lubricate propeller shaft (4WD only)
❑Replace cabin air filter
❑Replace engine air filter
❑Replace spark plugs (IGR-FE)4
❑Re-torque propeller shaft bolt
❑Inspect the following:
__ Ball joints and dust covers
__ Brake lines and hoses
__ Brake linings/drums and brake pads/discs5
__ Drive shaft boots (4WD only)
__ Engine coolant6
__ Exhaust pipes and mountings
__ Front differential oil (4WD only)
__ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
Additional Maintenance Items for Special Operating Conditions2
Driving off-road, on dirt roads or on dusty roads:3
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Replace front differential oil (4WD only)
❑Replace manual transmission oil
❑Replace rear differential oil
❑Replace transfer case oil (4WD only)
❑Tighten nuts and bolts on chassis
Dealer Service Verification:
Date:
Mileage:
99
__ Fuel tank cap gasket
__ Radiator and condenser
__ Rear differential oil
__ Steering gear box
__ Steering linkage and boots
__ Transfer case oil (4WD only)
__ Transmission fluid or oil

Maintenance Log: 2007 Tundra
35,000 Miles or 42 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Visually inspect brake linings/drums and
brake pads/discs
Additional Maintenance Items for Special
Operating Conditions2
Driving off-road, on dirt roads or
on dusty roads:3
❑Inspect ball joints and dust covers
❑Inspect drive shaft boots (4WD only)
❑Inspect engine air filter
❑Inspect steering linkage and boots
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving on salted roads:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
40,000 Miles or 48 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Visually inspect brake linings/drums and
brake pads/discs
Additional Maintenance Items for Special
Operating Conditions2
Driving off-road, on dirt roads or
on dusty roads:3
❑Inspect ball joints and dust covers
❑Inspect drive shaft boots (4WD only)
❑Inspect engine air filter
❑Inspect steering linkage and boots
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving on salted roads:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
Dealer Service Verification:
Date: Mileage:
Dealer Service Verification:
Date: Mileage:
1010

1Reset the oil replacement reminder (“MAINT REQD”) light after replacing engine oil.
2Perform these service items only if you drive primarily under the conditions indicated.
3See page 5 for daily maintenance required when driving off-road.
4See page 23 for details.
Maintenance Log: 2007 Tundra
45,000 Miles or 54 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Visually inspect brake linings/drums and brake pads/discs
❑Inspect the following:
__ Ball joints and dust covers
__ Brake lines and hoses
__ Drive shaft boots (4WD only)
__ Engine coolant4
__ Exhaust pipes and mountings
Note: Driving in heavy traffic, on dirt roads or in urban, dusty or desert areas may shorten
the life of the cabin air filter. Replacement may be needed if you notice reduced air flow
from the air conditioner and heater or if the windows fog easily when you use the "Fresh"
mode. Consult your dealer if any of these conditions occur.
Additional Maintenance Items for Special Operating Conditions2
Driving off-road, on dirt roads or on dusty roads:3
❑Inspect engine air filter
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Replace front differential oil (4WD only)
❑Replace rear differential oil
❑Tighten nuts and bolts on chassis
Dealer Service Verification:
Date:
Mileage:
1111
__ Front differential oil (4WD only)
__ Radiator and condenser
__ Rear differential oil
__ Steering gear box
__ Steering linkage and boots

Maintenance Log: 2007 Tundra
50,000 Miles or 60 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Visually inspect brake linings/drums and
brake pads/discs
Additional Maintenance Items for Special
Operating Conditions2
Driving off-road, on dirt roads or
on dusty roads:3
❑Inspect ball joints and dust covers
❑Inspect drive shaft boots (4WD only)
❑Inspect engine air filter
❑Inspect steering linkage and boots
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving on salted roads:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
55,000 Miles or 66 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Visually inspect brake linings/drums and
brake pads/discs
Additional Maintenance Items for Special
Operating Conditions2
Driving off-road, on dirt roads or
on dusty roads:3
❑Inspect ball joints and dust covers
❑Inspect drive shaft boots (4WD only)
❑Inspect engine air filter
❑Inspect steering linkage and boots
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving on salted roads:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
Dealer Service Verification:
Date: Mileage:
Dealer Service Verification:
Date: Mileage:
1212

Maintenance Log: 2007 Tundra
60,000 Miles or 72 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Lubricate propeller shaft (4WD only)
❑Replace cabin air filter
❑Replace engine air filter
❑Replace spark plugs (IGR-FE)4
❑Re-torque propeller shaft bolt
❑Inspect the following:
__ Ball joints and dust covers
__ Brake lines and hoses
__ Brake linings/drums and brake pads/discs5
__ Charcoal canister (2UZ-FE)6
__ Drive belts7
__ Drive shaft boots (4WD only)
__ Engine coolant8
__ Engine valve clearance (2UZ-FE, IGR-FE)9
__ Exhaust pipes and mountings
__ Front differential oil (4WD only)
Additional Maintenance Items for Special Operating Conditions2
Driving off-road, on dirt roads or on dusty roads:3
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Replace front differential oil (4WD only)
❑Replace rear differential oil
❑Replace transfer case oil (4WD only)
❑Replace transmission fluid or oil
❑Tighten nuts and bolts on chassis
Dealer Service Verification:
Date:
Mileage:
1313
__ Fuel lines and connections, fuel tank band
and fuel tank vapor vent system hoses
__ Fuel tank cap gasket
__ Radiator and condenser
__ Rear differential oil
__ Steering gear box
__ Steering linkage and boots
__ Transfer case oil (4WD only)
__ Transmission fluid or oil
1Reset the oil replacement reminder (“MAINT REQD”) light after replacing engine oil.
2Perform these service items only if you drive primarily under the conditions indicated.
3See page 5 for daily maintenance required when driving off-road.
4Required under the terms of the Emission Control Warranty.
5Inspect thickness measurement and disc runout.
6Applies tovehicles registered in California, Massachusetts and New York.
7Initial inspection at 60,000 miles/72 months. Inspect every 15,000 miles/18 months thereafter.
8See page 23 for details.
9Check for tappet noise and engine vibration and adjust if necessary.

Maintenance Log: 2007 Tundra
65,000 Miles or 78 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Visually inspect brake linings/drums and
brake pads/discs
Additional Maintenance Items for Special
Operating Conditions2
Driving off-road, on dirt roads or
on dusty roads:3
❑Inspect ball joints and dust covers
❑Inspect drive shaft boots (4WD only)
❑Inspect engine air filter
❑Inspect steering linkage and boots
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving on salted roads:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
70,000 Miles or 84 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Visually inspect brake linings/drums and
brake pads/discs
Additional Maintenance Items for Special
Operating Conditions2
Driving off-road, on dirt roads or
on dusty roads:3
❑Inspect ball joints and dust covers
❑Inspect drive shaft boots (4WD only)
❑Inspect engine air filter
❑Inspect steering linkage and boots
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving on salted roads:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
Dealer Service Verification:
Date: Mileage:
Dealer Service Verification:
Date: Mileage:
1414

1Reset the oil replacement reminder (“MAINT REQD”) light after replacing engine oil.
2Perform these service items only if you drive primarily under the conditions indicated.
3See page 5 for daily maintenance required when driving off-road.
4See page 23 for details.
Maintenance Log: 2007 Tundra
75,000 Miles or 90 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Visually inspect brake linings/drums and brake pads/discs
❑Inspect the following:
__ Ball joints and dust covers
__ Brake lines and hoses
__ Drive belts
__ Drive shaft boots (4WD only)
__ Engine coolant4
__ Exhaust pipes and mountings
Note: Driving in heavy traffic, on dirt roads or in urban, dusty or desert areas may shorten
the life of the cabin air filter. Replacement may be needed if you notice reduced air flow
from the air conditioner and heater or if the windows fog easily when you use the "Fresh"
mode. Consult your dealer if any of these conditions occur.
Additional Maintenance Items for Special Operating Conditions2
Driving off-road, on dirt roads or on dusty roads:3
❑Inspect engine air filter
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Replace front differential oil (4WD only)
❑Replace rear differential oil
❑Tighten nuts and bolts on chassis
Dealer Service Verification:
Date:
Mileage:
1515
__ Front differential oil (4WD only)
__ Radiator and condenser
__ Rear differential oil
__ Steering gear box
__ Steering linkage and boots

1616
Maintenance Log: 2007 Tundra
80,000 Miles or 96 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Visually inspect brake linings/drums and
brake pads/discs
Additional Maintenance Items for Special
Operating Conditions2
Driving off-road, on dirt roads or
on dusty roads:3
❑Inspect ball joints and dust covers
❑Inspect drive shaft boots (4WD only)
❑Inspect engine air filter
❑Inspect steering linkage and boots
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving on salted roads:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
85,000 Miles or 102 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Visually inspect brake linings/drums and
brake pads/discs
Additional Maintenance Items for Special
Operating Conditions2
Driving off-road, on dirt roads or
on dusty roads:3
❑Inspect ball joints and dust covers
❑Inspect drive shaft boots (4WD only)
❑Inspect engine air filter
❑Inspect steering linkage and boots
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving while towing:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
❑Tighten nuts and bolts on chassis
Driving on salted roads:
❑Lubricate propeller shaft (4WD only)
❑Re-torque propeller shaft bolt
Dealer Service Verification:
Date: Mileage:
Dealer Service Verification:
Date: Mileage: