Travis Industries Fire Garden 94900432 User manual

F0
By Travis Industries, Inc.
Fire Garden™
Outdoor Linear Complete Fire Pit
Manual
48x24 Complete Fire Pit 94900432
72x24 Complete Fire Pit 94900449
132x24 Complete Fire Pit 94900467
Listed by
Omni-Test Laboratories, Inc.
Report # 0028GM127S
ANSI Z21.97-2017 /CSA 2.41-2017, CSA 2.17-2017
Outdoor Decorative Gas Appliances



DANGER
FIRE OR EXPLOSION HAZARD
If you smell gas:
• Shut off gas to the appliance.
• Extinguish any open flame.
• If odor continues, leave the area
immediately.
• After leaving the area, call your gas
supplier or fire department.
Failure to follow these instructions
could result in fire or explosion, which
could cause property damage, personal
injury, or death. 

WARNING
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance
An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
WARNING: For outdoor use only.
Installation and service must be
performed by a qualified installer,
service agency, or the gas supplier.

WARNING: Improper installation,
adjustment, alteration, service or
maintenance can cause injury or
property damage. Read the installation,
operating, and maintenance
instructions thoroughly before
installing or servicing this equipment.
DANGER
CARBON MONOXIDE HAZARD
This appliance can produce carbon
monoxide which has no odor.
Using it in an enclosed space can kill
you.
Never use this appliance in an
enclosed space such as a camper,
tent, car, or home.
WARNING: If the information in this
manual is not followed exactly, a fire or
explosion may result causing property
damage, personal injury, or loss of life.
INSTALLER: Leave this manual with the
appliance.
CONSUMER: Retain this manual for
future reference
Frenchlanguagemanualsatoutdoorfiregarden.com.ManuelsdelangueFrançaiseàoutdoorfiregarden.com
Travis Industries, Inc. 12521 Harbour Reach Dr., Mukilteo, WA 98275 www.travisproducts.com
$10.00 Copyright 2022, T.I. Part # 100-01579

2 Introduction
© Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits
Overview
This manual details the installation, operation, and
routine maintenance of the Outdoor Linear Fire Pit.
Listing Details
This appliance was tested to ANSI Z21.97-2017 / CSA
2.41-2017 “Outdoor Decorative Gas Appliances”,
CSA
2.17-2017 - “Gas-Fired Appliances for Use at High
Altitudes”. The listing label is chained to the appliance.
A copy is shown to the right.
Important Registration & Service Info
No other appliance has the same serial number as
yours. The serial number is on the safety label attached
by a chain under the media screen. This serial number
will be needed in case you require service of any type.
To receive full warranty coverage, you will need to show
evidence of the date of purchase. Visit
traviswarranty.com to register your appliance. If any
service issues arise, contact your dealer for assistance.
National Fireplace Institute
Dealer Information
Please record your dealer information here for future
reference:
Dealer Name: _________________________________
Dealer Address: _______________________________
Dealer E-Mail: _________________________________
Dealer Phone #:________________________________
CALIFORNIA RESIDENTS

WARNING: This product can expose you to
chemicals including Carbon Monoxide and
Benzene, which are known to the State of
California to cause cancer, birth defects, or
other reproductive harm. For more
information go to
www.P65Warnings.ca.gov.

Table of Contents 3
© Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits
Overview.......................................................... 2
Listing Details .................................................. 2
Important Registration & Service Info .............. 2
Safety Precautions .......................................... 4
Features: ......................................................... 5
Installation Options: ......................................... 5
Electrical Specifications:.................................. 5
Appliance Weight:............................................ 5
Gas Specifications:.......................................... 5
Linear Fire Pit Dimensions:.............................. 6
Installation Warnings: ...................................... 7
Recommended Order of Installation ................ 8
Packing List ..................................................... 8
Additional Items Required................................ 9
Weatherproofing the Installation ...................... 10
Appliance Placement Requirements................ 10
Clearances ...................................................... 11
Enclosure Ventilation Requirements................ 12
Gas Line Requirements ................................... 13
LP Conversion ................................................. 14
Electrical Connection Requirements 15
24VAC Transformer 15
Wiring Installation 16
Using More than One 24-volt Appliance 18
Wiring Multiple Transformers to One Switch 18
Wiring Multiple Appliances to One Transformer 19
Daisy-Chain Example .................................. 19
Direct-Run Example...................................19
Daisy-Chain Wire Length Chart .....................20
Direct-Run Wire Length Chart .......................21
Wiring Examples:...........................................21
Daisy-Chain Installations: ..........................21
Direct Run Installations:.............................21
Steps for Finalizing the Installation ................22
Crushed Glass Installation.............................22
Rock Ember Installation.................................23
Tumbled Stone Installation ............................24
Assembling the Glass Wind Guard................25
Before the First Fire.......................................27
Operating Instructions ...................................27
Location of Controls.......................................28
Maintaining Your Appliance...........................29
Accessing Components.................................30
Removing the Media Trays........................30
Accessing the Pressure Tap......................31
Removing the Burner.................................31
Accessing Pilot Components .....................31
Winterizing the Appliance ..............................32
Yearly Service Procedure..............................32
Replacement Parts List .................................33
Troubleshooting Table...................................34
Wiring Diagram..............................................36
Index..............................................................38

4Safety Precautions
© Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits
Safety Precautions
! This appliance must be installed in
accordance with all local codes if any; if
not, follow ANSI Z223.1.
! This appliance must only be used outdoors
in a well-ventilated area. It may not be used
in a building, garage, or other enclosed
space.
This appliance is not for use with solid fuel.
The appliance must be kept clean and free of
leaves and debris to ensure safe operation.
Any hose or gas supply line that is damaged or
shows evidence of excessive abrasion or wear
must be replaced prior to use of the appliance.
If using a gas supply line to the appliance, make
sure it is properly located away from any walkway
or in an area where it may be subject to accidental
damage.
Educate all children and adults about the dangers
of the appliance. Young children should be
supervised when they are in the same area as the
appliance. Do not let children play with the
appliance.
Do not place clothing or other flammable items on
or near the appliance.
Any screen or guard removed for servicing must
be replaced prior to operating the appliance.
This unit must be installed and repaired by a
qualified installer to prevent the possibility of an
explosion. Your dealer will know the requirements
in your area and can inform you of those people
considered qualified. The appliance should be
inspected before use and at least annually by a
qualified service person. More frequent cleaning
may be required due to excessive debris from
leaves, dirt, insects, etc.
Do not use this appliance if any part has been
underwater. Immediately call a qualified service
technician to inspect the appliance and replace
any part of the control system and any gas control
that has been underwater.
The instructions in this manual must be strictly
adhered to. Do not use makeshift methods or
compromise in the installation. Improper
installation will void the warranty and safety listing.
This appliance is approved for either natural gas
(NG) or propane (LP). Burning the incorrect fuel
will void the warranty and safety listing and may
cause an extreme safety hazard. Direct questions
about the type of fuel used to your dealer. A label
is placed on the control panel to show which fuel
the appliance is designed for.
Contact your local building officials to obtain a
permit and information on any installation
restrictions or inspection requirements in your
area.
If the flame becomes sooty, dark orange in color,
or extremely tall, do not operate the appliance.
Call your dealer and arrange for proper servicing.
Do not operate the appliance if it is not operating
properly in any fashion or if you are uncertain.
Call your dealer for a full explanation of your
appliance and what to expect.
Do not store or use gasoline or other flammable
liquids in the vicinity of this appliance.
Never remove, replace, modify, or substitute any
part of the appliance unless instructions are given
in this manual for routine maintenance and
cleaning. A trained technician must do all other
work. Do not modify or replace orifices.
Allow the appliance to cool before carrying out any
maintenance or cleaning.
Operate the appliance according to the
instructions included in this manual.
If the burner does not start correctly turn the gas
off at the gas control valve and call your dealer for
service.
Do not use this appliance to cook food.
Instruct everyone in the house how to shut the gas
off to the appliance and at the gas main shutoff
valve. The gas main shutoff valve is usually next to
the gas meter or propane tank and requires a
wrench to shut off.
Do not operate the appliance during a lightning
storm or a possible lightning storm.
Do not operate the appliance during high wind
conditions.
Do not install in or on recreational vehicles and/or
boats.
Do not throw this manual away. This manual has
important operating and maintenance instructions
that you will need at a later time. Always follow
the instructions in this manual.
Travis Industries, Inc. grants no warranty,
implied or stated, for the installation or
maintenance of your appliance, and assumes
no responsibility for any consequential
damage(s).

Features and Specifications 5
© Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits
Features:
- Electronic Ignition (switch turns appliance on or off)
-Tempered glass wind guard
-Stainless Steel Construction
-Automatic Gas Shutoff Valve for Safety
Installation Options:
-For Outdoor Installation Only
-For Fixed Gas Line Installations Only
Electrical Specifications:
24 VAC., 60 Hz, 1.6 Amps.
Appliance Weight:
48x24
Complete Fire Pit 100 lbs (45.4 kg)
72x24
Complete Fire Pit 130 lbs (59 kg)
132x24
Complete Fire Pit 260 lbs (118 kg)
Gas Specifications:
All Fire Pits
Gas Pressures NG LP
Manifold Pressure 7" wc 11" wc
Max. Inlet Pressure 7" wc 11" wc
Min. Inlet Pressure 6" wc 10" wc
48x24
Fire Pit
Input Rating NG LP
Input Rating (BTU/h) 65,000 65,000
Orifice Size (DMS) (1) - #29 (1) - #41
72x24
Fire Pit
Input Rating NG LP
Input Rating (BTU/h) 120,000 120,000
Orifice Size (DMS) (2) - #30 (2) - #43
132x24
Fire Pit
Input Rating NG LP
Input Rating (BTU/h) 240,000 240,000
Orifice Size (DMS) (4) - #30 (4) - #43
