Twin-Star International 24FI061ARU User manual

ATTENTION
IF YOU HAVE ANY PROBLEMS OR QUESTIONS, EMAIL
OR CALL CUSTOMER SERVICE BEFORE YOU RETURN
THIS PRODUCT TO THE STORE WHERE IT WAS PURCHASED.
For Customer Service: email: par[email protected]
in English Call: 866-661-1218
in Spanish Call: 866-661-1218
in French Call: 866-374-9203
ATENCIÓN
SI TIENE ALGÚN PROBLEMA O PREGUNTAS,
ENVÍE UN MENSAJE DE CORREO ELECTRÓNICO O LLAME AL SERVICIO
DE ATENCIÓN AL CLIENTE ANTES DE DEVOLVER
ESTE PRODUCTO A LA TIENDA EN LA QUE LO COMPRÓ.
Servicio de atención al cliente: Correo electrónico: par[email protected]
Línea para llamadas en inglés: 866-661-1218
Línea para llamadas en español: 866-661-1218
Línea para llamadas en francés: 866-374-9203
STOP STOP
PARE PARE
ATTENTION
SI VOUS AVEZ DES PROBLÈMES OU QUESTIONS,
ENVOYEZ UN COURRIEL AU SERVICE À LA CLIENTÈLE OU APPELEZ LE
SERVICE À LA CLIENTÈLE AVANT DE RETOURNER
CE PRODUIT OÙ VOUS L’AVEZ ACHETÉ.
Pour le service à la clientèle : courriel : par[email protected]
pour le service en anglais, composez le 866-661-1218
pour le service en espagnol, composez le 866-661-1218
pour le service en français, composez le 866-374-9203
ARRÊT ARRÊT
INSTRUCTION MANUAL ENCLOSED
MANUEL D’INSTRUCTION Á L’INTÉRIEUR
MANUAL DE INSTRUCCIONES ADJUNTO
INSTRUCTION MANUAL ENCLOSED
MANUEL D’INSTRUCTION Á L’INTÉRIEUR
MANUAL DE INSTRUCCIONES ADJUNTO

CONSUMER SAFETY INFORMATION
PLEASE READ THIS MANUAL BEFORE USING THIS APPLIANCE.
WARNING!!
IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED
EXACTLY, AN ELECTRIC SHOCK OR FIRE MAY RESULT CAUSING
PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE.
DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS
AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE.
Twin-Star International, Inc.
Delray Beach, FL 33445
Made in China
Printed in China
FIREPLACE INSER T
HOMEOWNERS OPERATING MANUAL
MODELS: 24FI061ARU, 24FI061ARA,
30FI061ARU, 30FI061ARA
VENTFREEFIREPLACEWITHHEATER
Thank you and congratulations on your purchase of a Twin-Star International, Inc.
(Twin-Star) fireplace. Please read the Operating Instructions before using this
appliance.
IMPORTANT: Read all instructions and warnings carefully before using this appliance.
Failure to follow these instructions may result in a possible electric shock, fire hazard
and/or injury and will void the warranty.
E-1
E-Mail: [email protected]
In English Call: 866-661-1218
In French Call: 866-374-9203
In Spanish Call: 866-661-1218
For Customer Service:

IMPORTANT INSTRUCTIONS
1. Read all instructions before using this appliance.
do not let bare skin touch hot surfaces. If provid-
ed, use handles when moving this appliance.
Keep combustible materials, such as furniture,
pillows, bedding, papers, clothes and curtains at
least 3 feet (0.9 m) from the front of this appliance.
and unattended, extreme caution is necessary if
children or invalids are nearby.
4. If possible, always unplug this appliance when
not in use.
5. Do not operate any heater with a damaged cord or
has been dropped or damaged in any manner.
servicing must be replaced prior to operating
8. Do not use outdoors.
laundry areas and similar indoor locations.
Never locate this appliance where it may fall into
a bathtub or other water container.
10. Do not run cord under carpeting. Do not cover
cord with throw rugs, runners or the like. Arrange
be tripped over.
11. To disconnect this appliance, turn controls to
12. Connect to properly grounded outlets only.
cally grounded in accordance with local codes
CSAC22.1 Canadian Electrical Code or for U.S.A.
installations, follow local codesandthe National
Electrical Code, ANSI/NFPA NO. 70.
14. Do not insert or allow foreign objects to enter any
ventilation or exhaust opening as this may cause
intakes or exhaust in any manner. Do not use
become blocked.
parts inside. Do not use it in areas where gasoline,
for clothing. Christmas stockings or decorations
should not be hung in the area of it.
19. Use this appliance only as described in the
manual. Any other use not recommended by the
injury to persons.
20. Avoid the use of an extension cord because the
extension cord may overheat and causearisk of
the cord must be No. 14 AWG minimum size and
must be a three wire cord with grounding type
shall not be more than 20 feet in length.
21. See Figure 1 for the grounding instruction.
a plug as shown at A. An adapter as shown at C
is available for connecting three-blade grounding
grounding plug extending from the adapter must
be connected toapermanent ground such as a
not be used if a three-slot grounded receptacle is
available.
E-2
electrical shock, and injury to persons including the following:
Figure 1
GROUNDING PIN
METAL SCREW
COVER OF GROUNDED
OUTLET BOX
B
A
C
GROUNDING PIN
D
ADAPTER
GROUNDING
MEANS
a socket-outlet.
17.
of local
SAVE THESE INSTRUCTIONS
16. ere is a thermostat limiter inside the heater.
When the inner temperature over heating or occur
abnormal heating, the thermostat protective device
would cut o power supply to avoid the rplace
damaged or risk of re.
18.

E-3
Logs & Emberbed
Heater/Blower Assembly
Thermostat
Brightness Control button
Control Panel Circuit Board
Main Control Circuit Board
Front Projection Screen
Flame Generator Drive Motor
Flame Generator/Spinner
Remote Control - 3 Buttons
PARTS LIST
24FI061ARU 30FI061ARU 24FI061ARA 30FI061ARA
Part Name
Main Power Switch – Red Toggle
Knob for Heater Temperature control
Figure 3
PORDUCT ORIENTATION
CONTROL PANEL
FRONT PROJECTION
SCREEN
LOGS AND
EMBERBED
HEATER / BLOWER
ASSEMBLY
Flame Circuit Board
Logs & Emberbed Circuit Board
Remote Control - 4 Buttons

2. 2a.
2b.
3. 3a.
3b.
4a.
4b.
m
ELECTRIC FIREPLACE
1. No power,the power switch is in ON position.

OPERATING INSTRUCTIONS CONTROL FUNCTIONS
POWER
Power switch supplies power to all of
the
functions of the replace is switch must be
in ON position for any functions including the
remote to work.
HEAT
retaehehtnehW lliwtiNOdenrutsi
take several seconds for the unit to begin blowing
hot air.
TEMPERATURE
e Temperature control knobregulates the
temperature level of the heater. e further the
knob is rotated clockwise, the higher the set
point temperature.
Turning the knob counter-clock-wise will lower
the set point temperature. Use this function to help
regulate the ambient temperature level.
FLAME
Each time the ame button is pressed, the intensity
of the ame decreases ere are five brightness
levels you can cycle through including the OFF
setting.
WARNING: During any service of this appliance,
the power to the unit must be turned o irst turn
the main power switch to the “OFF” position en
remove the electrical plug from the wall outlet.
e
5
The HEAT button will turn on/off the heat
output.
Figure 3
Model#
24FI061ARU/30FI061ARU/24FI061ARA / 30FI061ARA
set.When the unit was on,the log set will be
light up to indicate the unit was on.

Figure 4
REMOTE CONTROL FUNCTIONS
E-6
REMOTE CONTROL FUNCTION
POWER
The POWER button will put the insert in a standby mode. This will turn off
all functions at once but will hold the settings in memory. By pressing the
button again the unit will turn on at the same settings.
HEATER
The HEATER button will turn the power to the heater and blower on and off.
begin blowing hot air. The rotary switch (Temperature) controls the
thermostat feature to help regulate your room’s temperature accordingly.
FLAME
Each time the FLAME button is pressed, the intensity of the flame decreases.
NOTE: PLEASE OPERATE REMOTE TRANSMITTER AT A SLOW MEASURED PACE. DEPRESS THE REMOTE CONTROL BUTTONS
WITH AN EVEN MOTION AND GENTLE PRESSURE. REPEATEDLYPRESSING BUTTONS IN RAPID SUCCESION MAY
CAUSE THE TRANSMITTER TO MALFUNCTION.
FLAME
HEATER
POWER
ELECTRIC FIREPLACE REMOTE
NOTE: The unit Main Power Switch must be turn ON in order for the
Notice: This remote control uses 1 CR2032 Lithium lon button cell battery (Included). Never dispose of
batteries in fire, except under conditions of controlled incineration. (Failure to observe this
precaution may result in an explosion.)
24 / 30FI061ARU
24 /30FI061ARA
EMBERS
The EMBERS button press to turn ON or OFF the undulating embers effect.
Remote Control to function.
There are five
brightness levels you can cyclethrough including the OFF
when the heater is turned ON it will take several seconds for the unit to
POWER
The POWER button will put the insert in a standby mode. This will turn off
all functions at once but will hold the settings in memory. By pressing the
button again the unit will turn on at the same settings.
HEAT
The HEAT button will turn the power to the heater and blower on and off.
begin blowing hot air. The rotary switch (Temperature) controls the
thermostat feature to help regulate your room’s temperature accordingly.
FLAME
When the heater is turned ON it will take several seconds for the unit to
The FLAME button controls the flame effect. Press the “ ” button to
Each time the “ ” button is pressed
it will decrease the intensity of the flames. There are five brightness levels
including the “OFF” position.
increase the brightness of the flames.
For models: 24FI061ARA /30FI061ARA
For models: 24FI061ARU / 30FI061ARU Figure 5
See Figure 5.
See Figure 4.
setting.

E-7
MAINTENANCE
The motors used on the fan and the flame generator assembly are pre-lubricated for extended bearing life and
require no further lubrication. However, periodic cleaning/vacuuming of the fan/heater unit is recommended.
Make sure the unit is turned OFF and unplugged whenever you are cleaning the heater or fireplace.
WARNING: Make sure the power is turned off before proceeding. Any electrical repairs or
rewiring of this unit should be carried out by a licensed electrician in accordance with
national and local codes.
If repairing or replacing any electrical component or wiring, the original wire routing, color
coding and securing locations must be followed.
WARNING: Electrical outlet wiring must comply with local building codes and other
applicable regulations to reduce the risk of fire, electrical shock and injury to persons.
WARNING: Do not use this fireplace if any part of it has been under water. Immediately call a
qualified service technician to inspect the fireplace and replace any part of the electrical system.
Warning: Disconnect power before attempting any maintenance or cleaning to reduce the risk
of fire, electrical shock or personal injury.
WARNING: Do not use this fireplace if any part of it has been under water. Immediately call a
qualified service technician to inspect the fireplace and replace any part of the electrical system.
Warning:During any service of this appliance, the power to the unit must be turned off.
First turn the main power switch to the “OFF” position. Then remove the electrical plug from
the wall outlet.
NOTE: This equipment has been tested and found to comply with the limits for Class B digital device,
pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against
harmful interference in a residential installation. This equipment generates, uses, and can radiate radio
frequency energy and, if not installed and used in accordance with the instructions, may cause harmful
interference to radio or television reception, which can be determined by turning the equipment off and on,
the user is encouraged to try to correct the interference by one or more of the following measures:
• Reorient or relocate the receiving antenna.
• Increase the separation between the equipment and the receiver.
• Connect the equipment into an outlet on a circuit different from that to which the receiver is
connected.
• Consult the dealer or an experienced radio/TV technician for help.
This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions:
(1) This device may not cause harmful interference, and
(2) this device must accept any interference received, including interference that may cause undesired operation.
Modifications not approved by the party responsible for compliance could void user’s authority to
operate the equipment.
This Class B digital apparatus complies with Canadian ICES-003.

BASIC WARRANTY
IF WARRANTY SERVICE IS NEEDED
1 YEAR LIMITED WARRANTY
Twin-Star ™ Electric Fireplace Models
Twin-Star International, Inc.
Delray Beach, FL 33445
Made in China
Printed in China
© 2009, Twin-Star International, Inc.
E-8
Twin-Star International, Inc. (hereinafter referred to
collectively as the (“Company”) warrants that your
new Twin-Star Electric Fireplace is free from
manufacturing and material defects for a period of
one year from date of purchase, subject to the
following conditions and limitations.
1. This electric fireplace must be installed and
operated at all times in accordance with the
installation and operating instructions furnished
with the product. Any unauthorized repair, alteration,
willful abuse, accident, or misuse of the product
shall nullify this warranty.
2. This warranty is non-transferable, and is made to
the original owner, provided that the purchase was
made through an authorized supplier of the company.
3. The warranty is limited to the repair or replacement
of part(s) found to be defective in material or
workmanship, provided that such part(s) have been
subjected to normal conditions of use and service,
after said defect is confirmed by the Company’s
inspection.
4. The Company may, at its discretion, fully discharge
all obligations with respect to this warranty by
refunding the wholesale price of the defective part(s).
5. Any installation, labor, construction, transportation,
or other related costs/expenses arising from defective
part(s), repair, replacement, or otherwise of same,
will not be covered by this warranty, nor shall the
Company assume responsibility for same.
6. The owner/user assumes all other risks, if any,
including the risk of any direct, indirect or
consequential loss or damage arising out of the
use, or inability to use the product, except as
provided by law.
7. All other warranties – expressed of implied –
with respect to the product, its components and
accessories, or any obligations/liabilities on the
part of the Company are hereby expressly excluded.
8. The Company neither assumes, nor authorizes any
third party to assume, on its behalf, any other
liabilities with respect to the sale of the Twin-Star
product.
9. The warranties as outlined within this document
do not apply to non Twin-Star accessories used in
conjunction with the installation of this product.
This warranty is void if:
a. The fireplace is subjected to prolonged periods of
dampness or condensation.
b. Any unauthorized alteration, willful abuse,
accident, or misuse of the product.
c. You do not have the original receipt of purchase.
For update and revisions to this manual
please see our website
www.twinstarhome.com/instructions
U.S.A.
Contact the company, at [email protected],
or call 866-661-1218 in English, 866-374-9203 in
French, 866-661-1218 in Spanish.Make sure you have
your warranty, your sales receipt, location of purchase
and the model/serialnumber of your Twin-Star products.
For Customer Service:
E-mail: [e-mail]
In English Call: 866-661-1218
In French Call: 866-374-9203
In Spanish Call: 866-661-1218
10. This warranty gives you specific legal rights, and
you may also have other rights which vary from
state to state.

INFORMACIÓN SOBRE SEGURIDAD PARA EL CONSUMIDOR
LEAESTE MANUAL ANTES DE USAR EL APARATO
ADVERTENCIA!!
EN CASO DE NO SEGUIR LA INFORMACIÓN EN ESTE MANUAL CON
EXACTITUD, PODRÍAN PROVOCARSE DESCARGA ELÉCTRICA O
INCENDIO Y DAÑOS A LA PROPIEDAD, LESIONES PERSONALESOLA
PÉRDIDA DE LA VIDA.
NO GUARDE NI USE GASOLINA NI OTROS VAPORES Y LÍQUIDOS
INFLAMABLES EN LA CERCANÍA DE ESTE APARATO NI DE
CUALQUIER OTRO.
Twin-Star International, Inc.
Delray Beach, FL 33445
Fabricado en China
Impreso en China
INSERTO PARA CHIMENEA
MANUAL DE OPERACIÓN DEL PROPIETARIO
MODELOS: 24FI061ARU,24FI061ARA,
30FI061ARU,30FI061ARA
CHIM E N E A S I N R E S P I R A D E R O C O N C A L E N T A D O R
Gracias y felicitaciones por su adquisición de una chimenea Twin-Star. Lea las
Instrucciones de operación antes de utilizar este aparato.
IMPORTANTE: lea todas las instrucciones y advertencias con detenimiento antes de
. Si no se cumplen con estas instrucciones, podría provocarse una
posible descarga eléctrica, riesgo de incendio y/o lesiones y, además, la garantía
perderá validez.
S-1
Correo electrónico: [email protected]
Línea para llamadas en inglés: 866-661-1218
Línea para llamadas en francés: 866-374-9203
Línea para llamadas en español: 866-661-1218
Servicio de atención al cliente:
usar este aparato