Vermont Castings EYF18 User manual
LO
HI OFF
ON
I
G
N
651009
EYF cover
65D1009 12/12 Rev. 8
65D1009
2
EYF Series Unvented Gas Log Set
Codes .......................................................................7
Pilot Flame Appearance .........................................17
Burner Flame Appearance .....................................18
For Your Safety Read Before Lighting ...................19
Manual Control Lighting Instructions ......................20
Millivolt Control Lighting Instructions ......................21
Match Lighting Instructions ....................................22
Early signs of carbon monoxide poisoning are similar to the u with headaches,
dizziness and/or nausea. If you have these signs, the insert may not have been installed properly. Get fresh air at
once! Have the insert inspected and serviced by a qualied service person. Some people are more affected by carbon
monoxide than others. These include pregnant women, people with heart or lung disease or anemia, those under the
inuence of alcohol, and those at high altitudes.
Propane/LP gas and natural gas are both odorless. An odor-making agent is added to each of these gases. The odor
helps you detect a gas leak. However, the odor added to these gases can fade. Gas may be present even though
no odor exists.
65D1009
EYF Series Unvented Gas Log Set
Please leave these instructions with the appliance.
Please retain these instructions for future reference
.
1. Due to high temperatures, the appliance should be
located out of trafc and away from furniture and
draperies.
2. Children and adults should be alerted to the hazard
of high surface temperature and should stay away
to avoid burns or clothing ignition.
. Young children should be carefully supervised when
they are in the same room with the appliance.
4. Do not place clothing or other ammable material
on or near the appliance.
5. Any safety screen or guard removed for servicing
an appliance, must be replaced prior to operating
the heater.
6. Installation and repair should be done by a qualied
service person.
7. To prevent malfunction and/or sooting, an unvented
gas heater should be cleaned before use and at
least annually by a professional service person.
More frequent cleaning may be required due to ex-
cessive lint from carpeting, bedding materials, etc.
It is imperative that control compartments, burners
and circulating air passageways be kept clean.
12. Correct installation of the ceramic ber logs, proper
location of the heater, and annual cleaning are neces-
sary to avoid potential problems with sooting. Sooting,
resulting from improper installation or operation, can
settle on surfaces outside the replace. See log place-
ment instructions for proper installation.
1. Avoid any drafts that alter burner ame patterns. Do not
allow fans to blow directly into replace. Do not place
a blower inside burn area of rebox. Ceiling fans may
create drafts that alter burner ame patterns. Sooting
and improper burning will occur.
14. Candles, incense, oil lamps, etc. produce
combustion by-products including soot. Vent-free
appliances will not lter or clean soot produced by
these types of products. In addition, the smoke and/or
aromatics (scents) may be reburnt in the vent-free ap-
pliance which can produce odors. It is recommended
to minimize the use of candles, incense, etc. while the
vent-free appliance is in operation.
15. This is an unvented gas-red heater. It uses air (oxy-
gen) from the room in which it is installed. Provisions
for adequate combustion and ventilation air must be
provided. Page 6
16. This heater shall not be installed in a room or space
unless the required volume of indoor combustion air is
provided by the method described in the National Fuel
Gas Code, ANSI Z223.1/NFPA 54, the International
Fuel Gas Code or applicable local codes.
17. Keep room area clear and free from combustible
materials, gasoline and other ammable vapors and
liquids.
18. Unvented gas heaters are a supplemental zone heater.
They are not intended to be a primary heating appli-
ance. Water vapor produced by an unvented heater
can create moisture problems in a home when oper-
ated for extended periods of time.
19. During manufacturing, fabricating and shipping, various
components of this appliance are treated with certain
oils, lms or bonding agents. These chemicals are not
harmful but may produce annoying smoke and smells
8. For propane/LP insert, do not place propane/LP supply
tank(s) inside any structure. Locate propane/LP supply
tank(s) outdoors. To prevent performance problems,
do not use propane/LP fuel tank of less than 100
lbs. capacity.
9. The installation must conform with local codes or, in
the absence of local codes, with the
10. This unit complies with the latest edition of ANSI
Z21.11.2, Unvented Heaters and also complies with
ANSI Z21.60 Decorative Vented Appliances for Solid
Fuel Burning Fireplaces. State and local codes may
only allow operation of this appliance in a vented con-
guration. Check your state or local codes. For vented
operation, see Vented Instructions in this manual.
11. Do not install the heaters in a bathroom or bedroom.
65D1009
4
EYF Series Unvented Gas Log Set
as they are burned off during the initial operation of the
appliance; possibly causing headaches or eye or lung
irritation. This is a normal and temporary occurrence.
The initial break-in operation should last two to three
hours with the burner at the highest setting. Provide
maximum ventilation by opening windows or doors to
allow odors to dissipate. Any odors remaining after this
initial break-in period will be slight and will disappear
with continued use.
20. Input ratings are shown in BTU per hour and are for
elevations up to 2,000 feet. For elevations above 2,000
feet, input ratings should be reduced 4 percent for each
1,000 feet above sea level. See the National Fuel Gas
Code.
21. The heater and its individual shutoff valve must be
disconnected from the gas supply piping system during
any pressure testing of that system at test pressures
in excess of 1/2 psig (.5 kPa).
22. The heater must be isolated from the gas supply piping
system by closing its individual manual shutoff valve
during any pressure testing of the gas supply piping
system at test pressures equal to or less than 1/2 psig
(.5 kPa).
2. Do not use this room heater if any part has been under
water. Immediately call a qualied service technician
to inspect the room heater and to replace any part of
the control system and any gas control which has been
under water.
24. This appliance must not be used with glass doors in
the closed position. This can lead to pilot outages and
severe sooting outside the replace.
25. Never burn solid fuels in a replace where a unvented
room heater is installed.
25. Always have a replace screen in place when the ap-
pliance is in operation and , unless other provisions for
combustion air are provided, the screen shall have an
opening(s) for induction of combustion air.
Adhere to all local codes or, in their absence, the latest
edition of THE NATIONAL FUEL GAS CODE ANSI Z22.1
or NFPA54 which can be obtained from…
140 Broadway
New York, NY 10018
or
Batterymarch Park
Quincy, MA 02269
National
Fuel Gas Code, ANSI Z223.1/NFPA 54
International Fuel Gas Code
5
65D1009
EYF Series Unvented Gas Log Set
Check your packing list to verify that all listed parts have
been received. You should have the following:
• Unvented gas log burner assembly
• Plastic bag containing crushed volcanic rock
• Installation/operating instructions
• Two (2) anchoring screws
• Ceramic Fiber or Refractory Cement Logs
• Grate
The millivolt controlled version of this heater is the only
style designed to be operated with optional devices for
ON/OFF functions. The following options may be used
with the millivolt controlled heater. These options are not
packaged with the log set.
• Hand held Remote with receiver
• Wall thermostat with 15' wire
• Wall switch with 15' wire
• Hand held Thermostat Remote with receiver
Carefully inspect the contents for shipping damage. If any
parts are missing or damaged, immediately inform the
dealer from whom you purchased the appliance.
You must have the following items available before pro-
ceeding with installation:
• External regulator (for propane/LPG and 1/2 lb.
natural gas systems only)
• Piping which complies with local codes
• Screwdriver
• Drill with 5/2 bit
• Manual shutoff valve
• Pipe sealant approved for use with propane/LPG
(Resistant to sulfur compounds)
• Pipe wrench or appropriate size crescent wrench
set
• Tee joint.
• Sediment trap
EYF18NM Nat. Manual 0,000 18,000
EYF18NV Nat. Millivolt 0,000 20,000
EYF18PM LP Manual 0,000 22,500
EYF18PV LP Millivolt 0,000 24,500
EYF24NM Nat. Manual 6,000 19,000
EYF24NV Nat. Millivolt 6,000 24,000
EYF24PM LP Manual 6,000 25,000
EYF24PV LP Millivolt 6,000 29,000
An external regulator is required to reduce supply pres-
sure to a maximum of 1” w.c.
Regulator Pressure Nat. 4.0” w.c. .5” w.c.
Pilot Regulator Nat. n/a .5” w.c.
Max. Inlet Pressure Nat. 10.5” w.c. 10.5” w.c.
Min. Inlet Pressure Nat. 5.0” w.c. 5” w.c.
Regulator Pressure LP 10.0” w.c. 10.0” w.c.
Max. Inlet Pressure LP 1.0” w.c. 1.0” w.c.
Min. Inlet Pressure LP 11.0” w.c. 11.0” w.c.
Piezo ignitor allows ignition of the pilot without the use of
matches or batteries.
- All gas to the gas logs is shut off at the valve.
- Valve position to light/maintain a standing pilot.
- Variable position corresponding to desired
ame height (heat input)
- All gas to the gas logs is shut off at the valve.
- Valve position to light/maintain a standing pilot.
- Valve position to turn ON/OFF log set with remote
switch/thermostat.
- Variable position to control ame height (heat
output).
The gas log heater is tted with a specially designed safety
pilot light (ODS assembly) which senses the amount of
oxygen available in the room and shuts the gas log heater
off if the oxygen level begins to drop below a satisfactory
level. The pilot can only be relit when adequate fresh air
is available.
The millivolt gas log pilot is tted with a millivolt generator
to provide power for remote activation.
This manual suits for next models
1
Table of contents
Other Vermont Castings Gas Heater manuals
Vermont Castings
Vermont Castings SA18SHKSN User manual
Vermont Castings
Vermont Castings SDDVTBSSB User manual
Vermont Castings
Vermont Castings DEB20 User manual
Vermont Castings
Vermont Castings 3380 Mounting instructions
Vermont Castings
Vermont Castings 4050 User manual
Vermont Castings
Vermont Castings SDVR Series Mounting instructions
Vermont Castings
Vermont Castings Jefferson JUVSR3095 User manual
Vermont Castings
Vermont Castings UVS27R Mounting instructions
Vermont Castings
Vermont Castings RADVT(CS)CBSB User manual
Vermont Castings
Vermont Castings VCBV10TN Specification sheet
Vermont Castings
Vermont Castings INDVRBDSB User manual
Vermont Castings
Vermont Castings 3380 User manual
Vermont Castings
Vermont Castings SDDVRBD, SDDVRC, SDDVRCCB User manual
Vermont Castings
Vermont Castings SDDVTEB Mounting instructions
Vermont Castings
Vermont Castings 4030 - 4036 User manual
Vermont Castings
Vermont Castings Radiance RADVT Series Installation instructions
Vermont Castings
Vermont Castings Stardance SDDVT Series Installation instructions
Vermont Castings
Vermont Castings 3095 Mounting instructions
Vermont Castings
Vermont Castings MJ27NR User manual
Vermont Castings
Vermont Castings Intrepid INDVRBDSB Installation instructions
Popular Gas Heater manuals by other brands
Desa
Desa ROPANE CONSTRUCTION HEATERS owner's manual
Desa
Desa BCLP375 owner's manual
Robur
Robur Line F1 Series User, installation and service manual
Superior
Superior BGE18NV Installation and operation instructions
Dru
Dru Room-sealed atmospheric gas-fired heating... user manual
klover
klover TKR 35 user guide
Rothenberger Industrial
Rothenberger Industrial 035984 instruction manual
Hargrove
Hargrove Timberland Glow Operation and installation guide
Kinder
Kinder Cameo BF Installation and maintenance instructions
Qlima
Qlima GH 438 B-2 Directions for use
Desa
Desa 125-R owner's manual
Gasmate
Gasmate AH100 Series instructions
Brant Radiant Heaters
Brant Radiant Heaters QTD Series User instruction
Medallion
Medallion MBP20TLB OWNER'S OPERATION AND INSTALLATION MANUAL
Sealey
Sealey LP35.V5 instructions
Italkero
Italkero Falo Evo User manual and assembly instructions
Desa
Desa 30LP owner's manual
Williams
Williams 2509822A owner's manual