Volvo V70 SPORT Quick start guide

WIRING DIAGRAM 2010
VOLVO V70 (08-), XC70 (08-) & S80 (07-)
TP 39152201

© Volvo Car Corporation
Vehicles with SRS (Airbag)/SIPS bag/
IC (Inflatable curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never fit accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C
and D-posts.
Test terminal
Fuse in cargo compartment auxiliary fuse box
Changes implemented up to and including December 2008
Any changes made to the vehicle after this date are not included in the manual. If necessary,
refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.
Ordering:
Electronic Wiring Diagram (EWD) can be ordered from Technical Information Shop (TIS) at
www.volvocarstechinfo.ford.com/vss
We retain the right to make modifications.

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 3
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable curtain)......................................................... 2
Explanations .................................................................. 6
How to use the wiring diagrams 1:2............................... 7
Electrical distribution 1:2 ................................................ 9
Fuses
Distribution box in engine compartment F1-F7............. 11
Engine compartment distribution box F9-F24............... 12
Distribution box in engine compartment F25-F31......... 13
Distribution box in engine compartment F32-F37......... 14
Distribution box in engine compartment F38 ................ 15
Distribution box in engine compartment F38-F39......... 16
Distribution box in engine compartment F39-F44......... 17
Fuses in the Central electronic module (CEM)
F1 - F11 .................................................................... 18
Central electronic module (CEM) F13 - F19 ................. 19
Central Electronic Module (CEM) F20 - F28................. 20
Passenger compartment............................................... 21
Rear electrical center FA1-FA12 .................................. 22
Distribution box in cargo compartment FB1-FB12........ 23
Rear electrical center FD1-FD7.................................... 24
Battery PF1-PF2........................................................... 25
Relays
Relays in engine compartment R2............................... 26
Relays in engine compartment R8 - R9....................... 27
Relays in engine compartment R10 - R13................... 28
Cargo compartment..................................................... 29
Distribution box in cargo compartment RA1-RD1........ 30
Central Electronic Module (CEM) ................................ 31
Ground connections
Overview...................................................................... 32
31/1 - 31/6 ................................................................... 33
31/7 - 31/15 continues ................................................. 34
31/15 - 31/48 ............................................................... 35
31/65 - 31/83 continues ............................................... 36
31/83 - 31/90 ............................................................... 37
31/93 - 31/XX10........................................................... 38
31/XX14 - 31/AL .......................................................... 39
Control modules
Overview of locations................................................... 40
Overview of designations............................................. 41
Central Electronic Module (CEM) 1:3 .......................... 42
Data communication high speed CAN......................... 45
Data communication High speed CAN, 4-Cyl.............. 46
Midspeed CAN data communication, LHD .................. 47
Midspeed CAN data communication, RHD.................. 48
Data communication LIN, 1:2....................................... 49
Data communication MOST......................................... 51
Steering Wheel Module (SWM) ................................... 52
Group 23 Fuel system
Engine management system, 4-Cyl. 1:2 ...................... 53
Engine management system, 5-Cyl. Turbo 1:2............ 55
Engine management system, 6-Cyl. 1:2 ...................... 57
Engine management system 6-Cyl. B6324S2 1:2 ....... 59
Engine management system, 6-Cyl. Turbo 1:2............ 61
Engine management system, 8-Cyl. 1:2 ...................... 63
Emission control, 4-Cyl. ............................................... 65
Emission control, 5-Cyl. Turbo..................................... 66
Emission control, 6-Cyl. ............................................... 67
Emission control, 8-Cyl. ............................................... 68
Engine management system, 4-Cyl. Diesel
DW10 1:2................................................................... 69
Engine management system, 4-Cyl. Diesel
DV6B 1:3 ................................................................... 71
Engine management system, 5-Cyl. Diesel
Single Turbo 1:3 ........................................................ 74
Engine management system, 5-Cyl. Diesel
Twin Turbo 1:3........................................................... 77
Group 26 Cooling system
Cooling fan, 4-Cyl. ....................................................... 80
Cooling fan, 5-Cyl. Turbo & 6-Cyl. ............................... 81
Cooling fan, 4-Cyl. Diesel ............................................ 82
Cooling fan, 5-Cyl. Diesel ............................................ 83
Cooling fan, 8-Cyl. ....................................................... 84
Group 27 Engine controls
Cruise control 4-Cyl. .....................................................85
Cruise control 4-Cyl. Diesel ..........................................86
Cruise control 5-Cyl. & 6-Cyl.........................................87
Cruise control 5-Cyl. Diesel ..........................................88
Cruise control 8-Cyl. .....................................................89
Group 32 Alternator and voltage regulator
Power supply 4-Cyl. ..................................................... 90
Power supply ............................................................... 91
Group 33 Starting system
Starting system 4-Cyl................................................... 92
Starting system 5, 6 & 8-Cyl. ....................................... 93
Starting system 5-Cyl. Diesel....................................... 94
Table of Contents 1:3

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 4
Group 35 Lighting
High and low beam ...................................................... 95
High and low beam (Dual Xenon)................................ 96
Beam length adjustment, manual ................................ 97
Beam length adjustment, automatic (Dual Xenon) ...... 98
Running-/ Parking lights, Tail lights V70 ...................... 99
Running-/ Parking lights, Tail lights S80 .................... 100
Running/ Parking light, Tail lights(Dual Xenon) V70.. 101
Running/ Parking light, Tail lights (Dual Xenon) S80. 102
Fog lights V70............................................................ 103
Fog lights S80............................................................ 104
Brake light V70 .......................................................... 105
Brake light S80 .......................................................... 106
Reversing lights V70.................................................. 107
Reversing lights S80.................................................. 108
Follow-me-home lighting, LHD .................................. 109
Follow-me-home lighting, RHD.................................. 110
Interior lighting, LHD 1:2............................................ 111
Interior lighting, RHD 1:2 ........................................... 113
Active headlights........................................................ 115
Lighting in sill moldings.............................................. 116
Auxiliary lights............................................................ 117
Lighting in doors LHD ................................................ 118
Lighting in doors RHD................................................ 119
Lighting mug holder and floor .................................... 120
Group 36 Additional electrical equipment
Rain sensor................................................................ 121
Direction indicator and Hazard warning flashers
LHD V70.................................................................. 122
Direction indicator and Hazard warning flashers
LHD S80.................................................................. 123
Direction indicator and Hazard warning flashers
RHD V70 ................................................................. 124
Direction indicator and Hazard warning flashers
RHD S80 ................................................................. 125
Windshield wiper/washer........................................... 126
High-pressure headlight washer ................................ 127
Wiper/washer rear window ........................................ 128
Horn ...................................................................... 129
Keyless vehicle 1:2 .................................................... 130
Anti-theft alarm .......................................................... 132
Parking assistance..................................................... 133
Collision warning with brake servo ............................ 134
Tire pressure warning (TPMS)................................... 135
Alcolock ..................................................................... 136
Group 37 Wiring and fuses
Diagnostics system .................................................... 137
12V outlet................................................................... 138
Tow hitch cable harness, 4-pin V70........................... 139
Tow hitch cable harness, 4-pin S80........................... 140
Tow hitch cable harness, 7-pin V70........................... 141
Tow hitch cable harness, 7-pin S80........................... 142
Tow hitch cable harness, 13-pin V70......................... 143
Tow hitch cable harness, 13-pin S80......................... 144
Accessory USB unit (AUU) ........................................ 145
Group 38 Instruments
Seat belt reminder ..................................................... 146
Driver information module.......................................... 147
Analog clock .............................................................. 148
Group 39 Other
Audio Premium 1:3 .................................................... 149
Audio 1:2.................................................................... 152
Cellular phone 1:2...................................................... 154
DAB Radio ................................................................. 156
Bluetooth phone system ............................................ 157
Bluetooth Handsfree .................................................. 158
Multimedia & Traffic information ................................ 159
Rear seat entertainment ............................................ 160
Satellite radio ............................................................. 161
Parking camera.......................................................... 162
Navigation system, portable....................................... 163
Group 43 Transmission
M66 transmission....................................................... 164
Automatic transmission TF-80SC AWD..................... 165
Automatic transmission MPS6................................... 166
Differential Electronic Module (DEM)......................... 167
Group 55 Parking brake
Electronic parking brake ............................................ 168
Group 59 Brake system
Brake control system & DSTC ................................... 169
Group 64 Steering
Speed dependent power steering .............................. 170
Group 76 Shock absorbers
Four-C ...................................................................... 171
Table of Contents 2:3

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 5
Group 83 Doors and openings
Central locking, front doors, LHD............................... 172
Central locking, front doors, RHD.............................. 173
Central locking, rear doors......................................... 174
Central locking, trunk lid V70 ..................................... 175
Central locking, trunk lid S80 ..................................... 176
Central locking, fuel filler flap..................................... 177
Signal receiver, central locking .................................. 178
Front door power windows, LHD ............................... 179
Front door power windows, RHD............................... 180
Rear door power windows ......................................... 181
Power sunroof............................................................ 182
Group 84 Exterior decorative elements etc.
Power door mirrors, LHD........................................... 183
Power door mirrors, RHD .......................................... 184
Heated door mirrors, LHD.......................................... 185
Heated door mirrors, RHD ......................................... 186
Blind spot information system LHD............................ 187
Blind spot information system RHD ........................... 188
Heated rear window................................................... 189
Group 85 Interior equipment
Power driver’s seat with memory function, LHD ........ 190
Power driver’s seat with memory function, RHD ....... 191
Power passenger seat, LHD...................................... 192
Power passenger seat, RHD ..................................... 193
Heated power front seats with fans............................ 194
Heated power front seats without fans....................... 195
Electrically heated rear seat....................................... 196
Massage seats........................................................... 197
Group 87 Climate control system
Climate control system PTC-element ........................ 198
Climate control system, 4-Cyl. 1:2 ............................. 199
Climate control system, 5-, 6- & 8-Cyl. 1:2 ................ 201
Climate control system 5-Cyl. Diesel 1:2 ................... 203
Parking heater, auxiliary heater ................................. 205
Parking heater, remote start ...................................... 206
Refrigeration box rear seat ........................................ 207
Group 88 Internal equipment
Rear-view mirror with automatic dimming.................. 208
Supplemental restraint system 1:2............................. 209
Electrically adjustable head restraint ......................... 211
Remote garage door opener...................................... 212
Index 1:2 ....................................................213
List of components 1:6 ............................215
Table of Contents 3:3

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 6
Explanations
Abbreviations
Groups
Group 23 = Fuel system
Group 26 = Cooling system
Group 27 = Engine controls
Group 32 = Alternator and voltage regulator
Group 33 = Starting system
Group 35 = Lighting
Group 36 = Additional electrical equipment
Group 37 = Wiring and fuses
Group 38 = Instruments
Group 39 = Other
Group 43 = Transmission
Group 55 = Parking brake
Group 59 = Brake system
Group 64 = Steering
Group 76 = Shock absorbers
Group 83 = Doors and openings
Group 84 = Exterior decorative elements, etc.
Group 85 = Interior equipment
Group 87 = Climate control system
Group 88 = Internal equipment
Ignition switch symbols
X = Accessories (audio position)
S = Powered upon insertion of key
15 = Contact remains connected during
start
15l = Contact is broken while starting
30 = Constant power from the battery
50 = Start
Countries/Markets
A = Austria
AUS = Australia
B = Belgium
CDN = Canada
CH = Switzerland
D = Germany
DK = Denmark
E=Spain
EU/OS = Markets outside USA and Canada
FIN = Finland
GB = Great Britain
ISR = Israel
J = Japan
KOR = Korea
N=Norway
NL = Netherlands
S = Sweden
USA = United States of America
WEU = Western Europe
Other
ACC = Adaptive Cruise Control
Ag = Silver plated
Au = Gold plated
AUTO = Automatic transmission
BLIS = Blind spot information system
CAN = CAN communication
DPY = Display
Du-X = Dual Xenon
ECC = Electronic climate control system
ETA = Throttle unit
EXC = Exclusive
GDL = Gas discharge lamp
HISPEED = High speed data bus
IR = Infrared sensor
LIN = LIN communication
LH = Left-hand side
LHD = Left-hand drive
MAN = Manual transmission
MEMORY = Memory driver’s seat
MIDSPEED = Midspeed data bus
MMS = Mass Movement Sensor
PETROL = Gasoline
RH = Right-hand side
RHD = Right-hand drive
SCR = Screened
SRS = Airbag
T = Turbocharged engine
W/O = Without
2WD = Two-wheel drive
4CYL, I4 = 4-cylinder engine
5CYL, I5 = 5-cylinder engine
6CYL, I6 = 6-cylinder engine
8CYL, V8 = 8-cylinder engine
Colors
BK, SB = Black
BN = Brown
BU, BL = Blue
GN = Green
GY, GR = Gray
LGN = Light Green
NL = Natural
OG, OR = Orange
PK, P = Pink
RD, R = Red
VT, VO = Violet
WH, W = White
YE, Y = Yellow

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 7
The descriptions below apply in general
to all wiring diagram manuals, although
not all sections are necessarily con-
tained in this manual.
How to use the wiring diagrams 1:2
A. Component designation
Every component has a component designation that
consists of two parts.
The first part is a type number that describes the
type of component in question, for example 3/xx.
The second part of the designation is a serial num-
ber, e.g. x/2.
Together, this constitutes a component designation,
e.g. 3/2.
At the end of the manual is a list of components,
where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.
List of type numbers
The list shows which type of component that respec-
tive type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
1 Battery
2Relay
3 Switch
4 Control module
5 Driver information module
6 Electric motor
7Sensor
8 Actuator
9 Heating element
10 Light
11 Fuse
15 Electrical distribution rail/box
16 Audio
17 Service/diagnostics
18 Contact reel
19 Meter
20 Ignition component/shunt
27 Optics
31 Ground connection
73 Branching point
74 Connector
B. Branching points
The wiring diagrams contain numbered branching
points, for example 73/5035.
This manual contains a section with a list of branch-
ing points. This list shows all the components that
are connected to each branching point.
The location of the branching points is shown in the
"Cable harness routing in vehicle" section.
C. Connectors
Connectors provide a bridge between two cable har-
nesses and are described in the "Connectors" sec-
tion.
D. Electrical distribution
Operation of the fuses and relays is shown in the
"Electrical distribution" section.
E. Data communication
Today’s cars contain CAN, LIN and MOST networks
that transfer information. Connections to these net-
works are not shown in their entirety in the respec-
tive wiring diagram. Complete information on CAN,
LIN and MOST communication is found in the sec-
tion "Control modules".
F. Abbreviations
A number of different abbreviations are used in the
manual. These are explained in the section "Abbre-
viations".
G. Component location
The end of the manual contains a section that
describes component appearance and location in
numerical order.

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 8
How to use the wiring diagrams 2:2
List of symbols
= System voltage
= Ground connection via wiring
= Ground connection in
component/chassis
= Screened wire
= Junction point
= Twisted cable
= Electrical connection
= Variant
= CAN communication
= CAN high data signal (CAN H)
= CAN low data signal (CAN L)
= LIN communication
= LIN communication
= DIN cable, coaxial cable, etc.
= Data communication
= CAN communication
= MOST communication
= MOST communication
= Connection with distribution box
= Further connection to...
= Connector between cable
harnesses
= Connector connected in
component

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 9
Electrical distribution 1:2
Overview, Electrical center and Cold zone in engine compartment
21
3
52/193
R9
15/31 15/33
11B/26
21
11B/25
21
11B/24
21
11B/36
21
11B/37
21
11B/38
21
11B/41 11B/18 12
11B/16 12
11B/17
73/3068
73/3085 12
11B/19 12
11B/20 12
11B/21 12
11B/22 12
11B/23 12
11B/28 12
11B/29 12
RD-VT
RD-VT
RD-VT
RD
RD
RD
GN-OG
RD
GY-BK
RD
RD
GN-VT
RD-BK
RD_BU
RD-GN
RD-GY
RD-BN 15/32
15/32
15/32
4/56C5:2
4/56C5:1
RD
RD
RDRD
RD
RD
RD
RD-GY
VT-GN
4/56C1:48
4/46B:16 5&6CYL
EXC 5CYL D
& 4CYL P
& DV6B
DW10
8CYL
4/46B:43
4/46B:54
RD
RD
RD
RD
RD
RD
RD
RD
RD-BU
RD
RD
BU-OG
GN-OG
RD
BU-OG
GY-VT
GY-VT
GY-VT
GY-VT
RD
RD-BK
RD
11B/27 12
11A/1
11A/2
11A/3
11A/4
11A/5
11A/6
12
11A/7
12
12
12
12
12
12
21
11B/40
21
11B/39
21
11A/43
21
11A/42
21
11A/44
21
11B/15
21
11B/33
21
11B/32
21
11B/31
21
11B/30
21
11B/35
21
11B/34
21
21
3
52/22
R13
21
3
5
7
R11
R10
R10
R11
2
1
35
2/31
R8
21
3
52/32
R11
2/32
21
3
52/17
R2
21
3
52/35
R12
11B/13
11B/11
11B/9
11B/12
11B/10
12
11B/14 12
12
12
12
12
11B/8 12
73/3076
6/25
31
M
ACM
30
C1:1
6/26
B+
31
G
C1:1
12V BK
31/3
1/1
PF1 PF2
2
1
1
2
LIN
9/42
4/56C1:45
4/56C1:65
73/3041
RD
RD-VT
{
RD
8CYL
8CYL & 4CYL D
5CYL D
5CYL T
5CYL T
5CYL T
& DV6B
4CYL D
(4 Cyl. Diesel)
2/133
2/14
2/239
(8 Cyl.)
(4 Cyl. Diesel)
R11
2/142
(5 Cyl. Diesel)
(5 Cyl. T) 74/301
16
4CYL D
& 5CYL D
G029145

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 10
Electrical distribution 2:2
Overview, rear electrical center
73/5040
11D/A7
21
11D/A6
21
11D/A5
21
11D/A8
21
11D/A3
21
11D/A2
21
11D/A1
21
11D/A4
21
11D/A10
21
11D/A9
21
11D/A11
21
11D/A12
21
21
3
5
2/75
2/82
15/32
15/31
RA2
21
3
5
A
BK NL
BU
B
D
RA1
11D/B3 12
2
11D/B2 12
11D/B1 12
11D/B4 1
YE-VT
YE-VT
BU-RD
RD-BN
BU-RD
RD-GY
RD-GY
RD-GY
RD-GY
RD-GY
RD-GY
RD-GY
11D/B7 12
11D/B6 12
11D/B5 12
11D/B8 12
11A/5
12
11A/3
12
11A/4
30+
74/504B
12
RD-GN
RD-GN
RD-BN
RD-GN
RD-GN
RD-GN
RD-GN
RD-VT
RD-VT
11D/B9 12
11D/B10 12
11D/B11 12
11D/B12 12
11D/D8 12
11D/D9 12
11D/D10 12
11D/D11 12
11D/D12 12
2
1
3
5
RB2
2
1
3
5
2/88
RB1
11D/D3 12
11D/D2 12
11D/D1 12
11D/D4 12
11D/D7 12
11D/D6 12
11D/D5 12
2
1
3
5
RD1
2
1
3
5
4
RD2
1
74/505
2
73/5075
1
RD-GN
2/16
V70
RD-BN
G029143

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 11
Fuses
Distribution box in engine compartment F1-F7
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F1 11A/1 Main fuse for fuses in CEM - 50
F2 11A/2 Main fuse for fuses in CEM - 50
F3 11A/3 11D/A1-11D/A12 Fuses in cargo compartment fuse box - 60
F4 11A/4 2/88 Relay, 15-feed rear
11D/B1-11D/B8 Fuses in cargo compartment fuse box
11D/B9-11D/B12 Fuses in cargo compartment fuse box
-
2/88
-
60
F5 11A/5 11D/D1-11D/D7 Fuses in cargo compartment fuse box - 50
F7 11A/7 9/42 PTC-element - 100
continues

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 12
Fuses
Engine compartment distribution box F9-F24
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F9 11B/9 6/1 Wiper Motor Module (WMM) - 30
F10 11B/10 4/7 Combustion Preheater Module (CPM) - 25
F11 11B/11 4/31 Passenger compartment fan control module
6/28 Motor, passenger compartment fan
-
-
40
F13 11B/13 4/16 Brake Control Module (BCM), pump - 40
F14 11B/14 4/16 Brake Control Module (BCM), valves - 20
F16 11B/16 4/118 Headlamp Control Module (HCM)
10/1 Lamp housing, front left
10/2 Lamp housing, front right
-
-
-
10
F17 11B/17 F2-F4 Fuses in the Central Electronic Module (CEM) - 20
F18 11B/18 4/80 Forward Sensing Module (FSM)
7/203 Forward-aimed radar (FLR)
-
-
5
F19 11B/19 4/99 Electronic power steering control module - 5
F20 11B/20 4/28 Transmission Control Module (TCM)
4/28B Transmission Control Module (TCM) MPS6
4/46 Engine Control Module (ECM)
4/9 Supplemental Restraint System Module (SRS)
-
-
-
-
10
F21 11B/21 9/43 Heated windshield washer nozzle, left
9/44 Heated windshield washer nozzle, right
-
-
10
F22 11B/22 6/114 Vacuum pump, 5-Cyl. Turbo
6/164 Electrical power steering module (EPS)
2/133 5
F23 11B/23 3/111 Light Switch Module (LSM) - 5
F24 11B/24 6/104 High pressure headlight washer motor - 15
continues

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 13
Fuses
Distribution box in engine compartment F25-F31
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F25 11B/25 9/1 Front 12V outlet
9/25 Rear 12V outlet
16/45 Portable navigation system
16/109 DVD player/control module
-
-
-
-
15
F26 11B/26 3/117 Switch unit, ceiling light
4/33 Sunroof control module
6/48 Damper Motor Module (DMM), recirculation
6/95 Damper Motor Module (DMM), temperature, left side
6/96 Damper Motor Module (DMM), temperature, right side
6/102 Damper Motor Module (DMM), defroster
6/103 Damper Motor Module (DMM), floor/ventilation
7/159 Air Quality Sensor (AQS)
-
-
-
-
-
-
-
-
5
F27 11B/27 2/31 Relay, 15-feed
2/193 Relay, comfort functions
-
-
5
F28 11B/28 2/64 Relay, auxiliary lights
10/65 Auxiliary light, front right
10/69 Auxiliary light, front left
-
2/64
2/64
20
F29 11B/29 2/17 Relay, horn
16/10 Horn 1
16/11 Horn 2
-
2/17
2/17
15
F30 11B/30 2/32 Main relay, engine management system
4/46 Engine Control Module (ECM)
-
-
10
F31 11B/31 4/28 Transmission Control Module (TCM)
4/28 Transmission Control Module (TCM) MPS6
-
-
15
continues

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 14
Fuses
Distribution box in engine compartment F32-F37
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F32 11B/32 8/3 Electromagnetic clutch, climate control system 2/22 15
F33 11B/33 2/14 Relay, glow plug system. 4-Cyl. Diesel
2/22 Relay, climate control system
2/239 Relay, coolant pump, 8-Cyl.
-
-
-
5
F34 11B/34 6/25 Starter motor 2/35 30
F35 11B/35 20/3-8 Spark plug with ignition coil, 5-, 6- & 8-Cyl.
20/12-13 Spark plug with ignition coil, 8-Cyl.
20/16 Capacitor
-
-
-
20
4/109 Control module glow plug, 5-Cyl. Diesel
20/3-6 Spark plug with ignition coil, 4-Cyl.
8/82 Solenoid, variable turbo geometry, 4-Cyl. Diesel
8/111 Control valve fuel flow, 4-Cyl. 1.6L Diesel
8/132 Control valve intake, 4-Cyl. 2.0L Diesel
-
-
-
-
-
10
F36 11B/36 4/46 Engine Control Module (ECM), 4-, 5-, 6-, 8-Cyl.
6/120 Throttle unit
-
4/46
10
4/46 Engine control module (ECM), 4-, 5-Cyl. Diesel
6/120 Throttle unit, 5-Cyl. Diesel
-
4/46
15
F37 11B/37 4/46 Engine Control Module (ECM), 6-Cyl. & 5-Cyl. Diesel
6/99 Engine EGR, 4-Cyl. 1.6L Diesel
7/35 Oil level sensor
8/6-11 Injection valves
8/98 Control valve fuel pressure, Diesel
8/111 Control valve fuel flow, 5-Cyl. Diesel
8/115 Injector
8/116 Injector
7/17 Mass airflow sensor (MAF)
-
-
-
-
-
-
-
-
-
15
continues

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 15
Fuses
Distribution box in engine compartment F38
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F38 11B/38 6/99 Engine EGR, 4-Cyl.
8/18 EVAP valve, 4-Cyl.
8/45 Vacuum valve variable intake manifold, 4-Cyl.
8/114 Valve mixing air/fuel, 4-Cyl.
-
-
-
-
10
8/77 Control valve, fuel volume, 4-Cyl. 2.0L Diesel
8/122 Bypass valve charge air cooler, 4-Cyl. 1.6L Diesel
8/133 Control valve, fuel pressure, 4-Cyl. 2.0L Diesel
-
-
-
4/46 Engine Control Module (ECM)
8/3 Electromagnetic clutch climate control system, 5-Cyl. Turbo.
8/28 Turbocharger control valve, 5 & 6-Cyl. Turbo.
8/68 Relief valve, 6-Cyl. Turbo
8/81 Solenoid, variable valve timing, exhaust, 5-Cyl. Turbo.
8/117 Solenoid, variable valve timing, intake, 5-Cyl. Turbo.
-
-
-
-
-
-
6/143 Control motor, turbo, 5-Cyl. Diesel, 1T
7/35 Oil level sensor, 5-Cyl. Diesel
8/3 Electromagnetic clutch, climate control system, 5-Cyl. Diesel
8/113 Bypass valve, EGR cooling, 5-Cyl. Diesel
8/120 EGR valve, 5-Cyl. Diesel
8/157 Turbocharger control valve, Diesel, 2T
-
-
-
-
-
-
continues

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 16
Fuses
Distribution box in engine compartment F38-F39
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F38 11B/38 4/46 Engine Control Module (ECM), 6-Cyl.
6/139 Upper actuator motor, intake manifold, 6-Cyl. W/O T
6/140 Lower actuator motor, intake manifold, 6-Cyl. W/O T
8/3 Electromagnetic clutch climate control system, 6-Cyl.
8/117 Solenoid, variable valve timing, intake, 6-Cyl.
8/125 Solenoid cam profile front, 6-Cyl. W/O T
8/126 Solenoid cam profile rear, 6-Cyl. W/O T
-
-
-
-
-
-
-
10
4/46 Engine Control Module (ECM), 8-Cyl.
8/3 Electromagnetic clutch climate control system, 8-Cyl.
8/19 Solenoid, variable valve timing, intake, bank 2, 8-Cyl.
8/81 Solenoid, variable valve timing, exhaust, bank 2, 8-Cyl.
8/117 Solenoid, variable valve timing, intake, bank 1, 8-Cyl.
8/118 Solenoid, variable valve timing, exhaust, bank 1, 8-Cyl.
-
-
-
-
-
-
F39 11B/39 7/15 Front heated oxygen sensor, 4-Cyl.
7/82 Rear heated oxygen sensor, 4-Cyl.
-
-
10
7/15 Front heated oxygen sensor, 5-Cyl. Diesel -
7/15 Front heated oxygen sensor, 5-Cyl. Turbo.
7/103 Rear heated oxygen sensor, 5-Cyl. Turbo.
8/18 EVAP valve, 5-Cyl. Turbo.
-
-
-
15
continues

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 17
Fuses
Distribution box in engine compartment F39-F44
15/31 Distribution box in engine compartment
No. No. Fuse function via A
F39 11B/39 7/15 Front oxygen sensor, bank 1, 6-Cyl.
7/82 Rear oxygen sensor, bank 1, 6-Cyl.
7/103 Front heated oxygen sensor bank 2, 6-Cyl. W/O T
7/104 Rear heated oxygen sensor bank 2, 6-Cyl. W/O T
8/18 EVAP valve, 6-Cyl.
-
-
-
-
-
15
7/15 Front oxygen sensor, bank 2, 8-Cyl.
7/82 Front oxygen sensor, bank 1, 8-Cyl.
7/103 Rear oxygen sensor, bank 2, 8-Cyl.
7/104 Rear oxygen sensor, bank 1, 8-Cyl.
8/18 EVAP valve, 8-Cyl.
8/107 Variable intake valve, 8-Cyl.
-
-
-
-
-
-
F40 11B/40 6/114 Vacuum pump, 5-Cyl.
9/32 PTC resistor crankcase ventilation, 5-Cyl. Turbo & Diesel
9/38 Heated fuel filter, 5-Cyl. Diesel
9/47 PTC resistor crankcase ventilation in hose, 5-Cyl. Diesel
2/133
-
-
-
20
6/73 Coolant pump, 8-Cyl. 2/239 10
F41 11B/41 6/67 Fuel leakage control pump, not 4- & 5-Cyl.
7/200 Sensor coolant temperature, 6-Cyl.
9/32 PTC resistor, crankcase ventilation
-5
F42 11A/42 20/22-26 Glow plug, 5-Cyl. 4/109 70
20/22-25 Glow plug, 4-Cyl. 2/14 60
F43 11A/43 4/71 Control module, cooling fan, 5-Cyl. Diesel, 6-Cyl., 8-Cyl.
4/71 Control module, cooling fan, 4-Cyl., 5-Cyl.
-
-
80
60
F44 11A/44 6/164 Electrical power steering module (EPS), 4-Cyl. 1.6L Diesel - 80

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 18
Fuses
Fuses in the Central electronic module (CEM) F1 - F11
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F1 7/149 Rain Sensor Module (RSM) - 5
F2 4/9 Supplemental Restraint System Module (SRS)
7/93 Occupant Weight Sensor (OWS)
-
-
10
F3 4/16 Brake Control Module (BCM) - 5
F4 3/65 Switch, heated rear seat
7/51 Accelerator pedal sensor
8/48 Auto-dimming rearview mirror
9/42 PTC-element
-
-
-
-
7.5
F6 3/281 Infotainment Control Module (ICM)
4/124 Accessory USB unit (AUU)
16/1 Integrated Audio Module (IAM)
16/109 DVD player/control module
-
-
-
-
15
F7 3/4 Steering wheel switch left (SWSL)
3/131 Steering wheel switch right (SWSR)
3/135 RTI switch
3/130
3/130
3/130,
3/131
7.5
F9 10/1 Lamp housing, front left
10/2 Lamp housing, front right
K2
K2
15
F10 4/33 Sunroof Module (SRM) - 20
F11 10/48 Right-hand reversing light
10/55 Left-hand reversing light
K3
K3
7.5
continues

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 19
Fuses
Central electronic module (CEM) F13 - F19
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F13 10/5 Fog light, front left
10/6 Fog light, front right
K1
K1
15
F14 6/127 Washer motor K5A, K5B 15
F15 4/80 Forward Sensing Module (FSM) - 10
F17 3/27 Switch unit, power passenger seat
3/176 Switch, driver’s door power window
3/291 Tailgate closing switch
4/76 Remote control unit for garage door opener
7/238 Alcolock sensor
10/22 Ceiling light
10/25 Ceiling light, cargo compartment, V70
10/29 Glove compartment lighting
10/114 Left-hand vanity mirror lighting
10/115 Right-hand vanity mirror lighting
10/125 Left-hand front courtesy lighting
10/126 Right-hand front courtesy lighting
10/127 Lighting, cargo compartment, left-hand side, S80
10/128 Lighting, cargo compartment, right-hand side, S80
10/150 Rear reading light
17/45 Alcolock outlet
26/5 DC/AC converter, fuel tank
26/6 Converter/control module, sill moldings, driver’s side
26/7 Converter/control module, sill moldings, passenger side
26/8 Alcolock charging cradle
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
7.5
F18 5/1 Driver Information Module (DIM) - 5
F19 4/52 Power Seat Module (PSM) - 5
continues

TP 39152201 V70(08-), XC70(08-) & S80(07-) 2010 20
Fuses
Central Electronic Module (CEM) F20 - F28
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F20 6/32 Rear window wiper motor, V70 2/16 15
F21 4/119 Signal receiver, keyless vehicle (RKE)
4/119.2 Remote Receiver Module (RRX)
7/199 Ultrasonic sensor (IMS)
7/214 Heartbeat sensor
-
-
-
-
5
F22 4/111 Additive Dosing Module (ADM)
6/33 Fuel pump
K8
K8, 4/83
20
F23 4/102 Steering Column Lock Module (SCL) K9 20
F25 K6-B Relay, soldered
K12 Relay, soldered
3/78 Lock unit, tailgate V70
6/8 Lock motor central locking, trunk lid/tailgate, S80
6/37 Lock motor, fuel filler cover
-
-
K6-B
K6-B
K12
10
F26 4/6 Climate Control Module (CCM)
16/35 Siren Control Module (SCM)
17/13 Data link connector
-
-
-
5
F27 3/132 Start Control Module (SCU) - 5
F28 3/9 Contact brake light
4/93 Keyless Vehicle Module (KVM)
-
3/9
5