Volvo 6849963 User manual

Instruction No Version Part. No.
6849963 1.0
Loudspeakers, front door
D3904282
Instruction No Version Part. No.
6849963 1.0
Loudspeakers, front door
D3904282
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Loudspeakers, front door - 6849963 - V1.0
Page 1 / 5

Equipment
A0000162
D3904283
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Loudspeakers, front door - 6849963 - V1.0
Page 2 / 5

INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
Note!
This accessory is connected to the electrical system of the car.
It requires software unique to the car.
1
D8501926
Remove the clips (1) by pressing in the centre of the clips
Remove the blind cover plug (2) and the screw from under it
Carefully remove the frame (3) around the door handle. Use a
weatherstrip tool and start at the bottom edge
Remove the cover (4) for the door mirror by pulling it straight out
Detach the door panel (5) by sliding the panel upwards and
unhooking the top edge.
2A Illustration A shows the door
Illustration B shows the side of the door
Remove the connectors (1) from the module for the door control,
the bass speaker and the treble speaker
Carefully remove the moisture inhibitor (2) at the front edge
Drill out the rivets (3) from the bass loudspeaker. Use a 6 mm
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Loudspeakers, front door - 6849963 - V1.0
Page 3 / 5

D3902319
2B
D3904248
(15/64") drill bit
Remove the bass loudspeaker and any rivet swarf from the rivet
holes. Also remove any rivet remnants from the door.
3
D3904249
Carefully place the door side on a clean surface
Unscrew the screws (1) for the treble speaker and remove it.
4
Screw the new treble loudspeaker into place into the same
position as the old one. Use the screws from the kit.
5
Screw the new bass loudspeaker into place into the same
position as the old one. Use the screws and nuts (1) from the kit
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Loudspeakers, front door - 6849963 - V1.0
Page 4 / 5

D3902320
Reinstall the moisture inhibitor (2)
Connect the connectors (3) to the bass loudspeaker and to the
module for the door controls
Reinstall the door panel and the cover for the door mirror.
6
Repeat the operations in points 1 -5 on the other front door
Program the software using VCT2000 according to the service
information in VIDA.
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
© Volvo Car Corporation Loudspeakers, front door - 6849963 - V1.0
Page 5 / 5