Waeco RPD190 User manual

CoolMatic RPD190, RPD218
MODE
MODE
EN Refrigerator
Installation and Operating Manual

RPD190, RPD218
3
MODE
RPD190
12
3
4
6
5
1

RPD190, RPD218
4
MODE
12
3
4
6
5
RPD218
2
MODE
1 2 3 4
5
6
3

RPD190, RPD218
5
>50 mm 1
3
5
2
4
4

RPD190, RPD218
6
min. 580 mm
610 – 620 mm
RPD190: 1422 – 1432 mm RPD218: 1580 – 1590 mm
5
21
6

RPD190, RPD218
7
1.
2.
7
8

RPD190, RPD218
8
1
9
∅/mm²
l/m
12 V 24 V
0 2 4 6 8 10 12 14 16 18 20 22 24 26 28
0
2
6
10
14
0
1
a

RPD190, RPD218
9
b
1.
2.
3.
c

RPD190, RPD218
10
d
1
e

RPD190, RPD218
11
21
f
1. 2.
4.3. 5.
g

RPD190, RPD218
12
600
1451
580
580
633
23040
1420
RPD190
MODE
h

RPD190, RPD218
13
MODE
RPD218
600
1607
40
580
633
230
1577
580
i

EN
RPD190, RPD218
14
Please read this instruction manual carefully before installation and
first use, and store it in a safe place. If you pass on the product to
another person, hand over this instruction manual along with it.
Table of contents
1 Explanation of symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
2 Safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
3 Scope of delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
4 Intended use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
5 Technical description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
6 Installing and connecting the refrigerator. . . . . . . . . . . . . . . . . . . . . 21
7 Using the refrigerator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
8 Cleaning and maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
9 Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
10 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
11 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
12 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

EN
RPD190, RPD218 Explanation of symbols
15
1 Explanation of symbols
D
!
!
A
I
➤Action: This symbol indicates that action is required on your part. The
required action is described step-by-step.
✓This symbol describes the result of an action.
Fig. 15, page 3: This refers to an element in an illustration. In this case,
item 5 in figure 1 on page 3.
DANGER!
Safety instruction: Failure to observe this instruction will cause
fatal or serious injury.
WARNING!
Safety instruction: Failure to observe this instruction can cause
fatal or serious injury.
CAUTION!
Safety instruction: Failure to observe this instruction can lead to
injury.
NOTICE!
Failure to observe this instruction can cause material damage and
impair the function of the product.
NOTE
Supplementary information for operating the product.

EN
Safety instructions RPD190, RPD218
16
2 Safety instructions
The manufacturer accepts no liability for damage in the following cases:
Faulty assembly or connection
Damage to the product resulting from mechanical influences and excess
voltage
Alterations to the product without express permission from the manu-
facturer
Use for purposes other than those described in the operating manual
2.1 General safety
DDANGER!
On boats: If the device is powered by the mains, ensure that the
power supply has a residual current circuit breaker. The break
distance must not be less than 3 mm.
!WARNING!
Have a qualified technician perform the installation in wet
rooms.
Do not operate the device if it is visibly damaged.
If this device's power cable is damaged, it must be replaced by
the manufacturer, customer service or a similarly qualified
person in order to prevent safety hazards.
This device may only be repaired by qualified personnel.
Inadequate repairs may cause serious hazards.
This device can be used by children aged 8 years or over, as
well as by persons with diminished physical, sensory or mental
capacities or a lack of experience and knowledge, providing
they are supervised, or have been taught how to use the device
safely and are aware of the resulting risks.
Cleaning and user maintenance must not be carried out by
children without supervision.
Children must be supervised to ensure that they do not play with
the device.
Always keep and use the device out of the reach of children
under 8 years of age.
Do not store any explosive substances, such as spray cans with
propellants, in the device.

EN
RPD190, RPD218 Safety instructions
17
!CAUTION!
Danger of crushing! Do not put your fingers into the hinge.
Foodstuff may only be stored in its original packaging or in suit-
able containers.
ANOTICE!
Check that the voltage specification on the type plate is the
same as that of the power supply.
Never pull the plug out of the socket by the connection cable.
If the refrigerator is connected to the DC socket: disconnect the
refrigerator and other electric consumers from the battery
before connecting the quick charging device.
If the refrigerator is connected to the DC socket: disconnect the
refrigerator or switch it off when you turn off the engine. Other-
wise you may discharge the battery.
The refrigerator is not suitable for transporting substances
which are caustic or contain solvents.
Keep the drainage outlet clean at all times.
Do not open the refrigerant circuit under any circumstances.
Never transport the device in a horizontal position, so that no oil
can leak out of the compressor.
Make sure that the refrigerator circuit is not damaged during
transportation. The refrigerant in the refrigerator circuit is highly
flammable.
In the event of any damage to the refrigerator circuit:
– Avoid naked flames and sparks.
– Air the room well.
Set up the device in a dry location where it is protected against
splashing water.

EN
Safety instructions RPD190, RPD218
18
2.2 Operating the device safely
DDANGER!
Do not touch exposed cables with your bare hands. This applies
especially when operating the device from the AC mains.
!CAUTION!
Before starting the device, ensure that the power supply line
and the plug are dry.
If you connect the device to a battery, make sure that no food
comes into contact with the battery acid.
ANOTICE!
Do not use electrical devices inside the cooling device unless
they are recommended by the manufacturer for that purpose.
Do not place it near naked flames or other heat sources
(heaters, direct sunlight, gas ovens etc.)
Danger of overheating!
Always ensure sufficient ventilation so that the heat generated
during operation can dissipate. Make sure that the device is
sufficiently far away from walls and other objects so that the air
can circulate.
Ensure that the ventilation vents are not covered.
Do not fill the inner container with ice or fluid.
Never immerse the appliance in water.
Protect the appliance and the cable against heat and moisture.
Make sure that foodstuffs do not touch the walls of the cooling
area.

EN
RPD190, RPD218 Scope of delivery
19
3 Scope of delivery
4 Intended use
The RPD series refrigerators are suitable for refrigerating foodstuffs
and storing frozen foodstuffs.
The device is also suitable for use on boats.
The device is designed to be operated from a 12 V or 24 V on-
board supply socket of a vehicle, boat or caravan as well as from a
100 – 240 V mains.
!
The refrigerator is only suitable for installation in a fitted cavity. Once it is
installed, only the front of the appliance may be accessible.
Quantity Description
1 Refrigerator
1 Lower ventilation grille
1 Drain hose
2 Icecube tray
1 LH hinge conversion kit (with instruction)
2 Airing position card
1 Operating manual
CAUTION! Health hazard!
Please check if the cooling capacity of the device is suitable for
storing the food or medicine you wish to cool.

EN
Technical description RPD190, RPD218
20
5 Technical description
5.1 Function description
The device can refrigerate goods to +7 °C to +2 °C and keep them cool.
Products can be frozen to –10 °C to –18 °C in the freezer compartment. You
can use the variable thermostat to set the desired temperature.
The refrigerator is suitable for use with 12 V or 24 V DC voltage and can
therefore also be used e.g. for mobile homes, caravans or on boats. It can
also be connected to a 100 – 240 V mains supply.
When used on boats the refrigerator can be subjected to a constant
inclination of 30°.
All materials used in the refrigerator are compatible for use with foodstuffs.
The refrigerant circuit is hermetically sealed and CFC-free.
5.2 Control elements inside the refrigerator
The various types of refrigerators are shown in the following illustrations:
RPD190: fig. 1, page 3
RPD218: fig. 2, page 4
No. Description
1 Freezer compartment
2 Control panel
3 Wire shelf (folding, so that bottles can be put in the refrigerator)
4 Shelf
5 Crisper bin
6 Door shelf