6Waterford E63-1 EMERALD Freestanding Gas Stove
12)Under no circumstances should this appli-
ance be modified. Parts that have to be
removed for servicing should be replaced
prior to operating this appliance.
13)Installationandanyrepairs to this appliance
should be done by a qualified service per-
son. A professional service person should
be called to inspect this appliance annually.
Make it a practice to have all of your gas
appliances checked annually.
14)Do not strike the glass door.
15)Under no circumstances should any solid
fuels (wood, paper, cardboard, coal, etc.)
be used in this appliance.
16)The appliance area must be kept clear and
free of combustible materials, (gases and
other flammable vapours and liquids).
17)Thisunit can be installedonasolidcombus-
tible surface like a wood floor as well as on
carpeting.
18)Do not connect this gas appliance to chim-
ney flue serving a separate sold-fuel burn-
ing appliance.
19)WARNING:Operationofthisappliancewhen
not connected to a properly installed and
maintainedventingsystemortamperingwith
the blocked vent shutoff system can result
in carbon monoxide (CO) poisoning and
possible death.
20)This appliance needs fresh air for safe
operationand must be installedso there are
provisions for adequate combustion and
ventilation air.
INSTALLATION
CHECKLIST
1) CheckClearancestoCombustibles,page7.
2) Install Optional Fan, page 7.
3) Install venting, page 8.
4) Make gas connections, page 9. Test the
pilot. Must be as per diagram, page 17. If
converting to Propane (see page 10, or if
converting to lower Btu Rating (see page
11).
5) Test Gas Pressure, page 9.
6) Install log set where indicated on page 12.
7) Test for flue spillage (draft test), page 13.
INSTALLATION
BEFORE YOU START
Safeinstallationandoperationofthisappliance
requires common sense, however, we are
required by the Canadian Safety Standards
and ANSI Standards to make you aware of the
following:
IMPORTANT:
SAVE THESE
INSTRUCTIONS
The EMERALD Freestanding Gas Stove must
be installed in accordance with these instruc-
tions. Carefully read all the instructions in this
manualfirst. Consult the"authorityhavingjuris-
diction" to determine the need for a permit prior
to starting the installation.
GENERAL SAFETY
INFORMATION
1) The appliance installation must conform
with local codes or, in the absence of local
codes,withthecurrentCanadianorNation-
al Gas Codes, CAN1-B149 or ANSI-223.1
InstallationCodes.
2) Theappliancewheninstalled,mustbeelec-
trically grounded in accordance with local
codes,orintheabsence of local codes with
the current National Electrical Code, ANSI/
NFPA70orCSAC22.1CanadianElectrical
Code.
3) Thisapplianceis Listed for bedroom instal-
lations when used with a Listed Millivolt
Thermostat. Some areas may have further
requirements, check local codes before
installation.
4) This appliance is Listed for Alcove installa-
tions,maintainminimumAlcoveclearances
as follows, minimum ceiling height of 47",
minimumwidthof41"andamaximumdepth
of 24".
5) Thisunitis not approved for installationinto
amobile home.
6) See general construction and assembly
instructions.
7) Thisappliancemust be connected to a vent
and terminate to the outside of the building
envelope. Never vent to another room or
inside a building.
8) Inspect the venting system annually for
blockage and any signs of deterioration.
9) Any safety glass removed for servicing
must be replaced prior to operating the
appliance.
10)To prevent injury, do not allow anyone who
is unfamiliar with the operation to use the
fireplace.
11)Wear gloves and safety glasses for pro-
tection while doing required maintenance.
INSTALLATION AND REPAIR
SHOULD BE DONE BY A QUALI-
FIEDSERVICEPERSON.THEAP-
PLIANCESHOULDBEINSPECTED
BEFOREUSEANDATLEASTAN-
NUALLY BY A PROFESSIONAL
SERVICE PERSON. MORE FRE-
QUENT CLEANING MAY BE RE-
QUIREDDUETOEXCESSIVELINT
FROMCARPETING,BEDDINGMA-
TERIAL, ETC. IT IS IMPERATIVE
THAT CONTROL COMPART-
MENTS,BURNERSANDCIRCULAT-
INGAIRPASSAGEWAYS OFTHE
APPLIANCEBEKEPTCLEAN.
DUE TO HIGH TEMPERATURES,
THEAPPLIANCESHOULDBELO-
CATED OUT OF TRAFFIC AND
AWAY FROM FURNITURE AND
DRAPERIES.
WARNING:FAILURETOINSTALL
THIS APPLIANCE CORRECTLY
MAY CAUSE A SERIOUS HOUSE
FIREANDWILLVOIDYOURWAR-
RANTY.
CHILDRENANDADULTSSHOULD
BE ALERTED TO THE HAZARDS
OF HIGH SURFACE TEMPERA-
TURES, ESPECIALLY THE FIRE-
PLACE GLASS, AND SHOULD
STAYAWAYTOAVOIDBURNSOR
CLOTHINGIGNITION.
YOUNG CHILDREN SHOULD BE
CAREFULLY SUPERVISEDWHEN
THEYAREINTHESAMEROOMAS
THEAPPLIANCE.
CLOTHING OR OTHER FLAMMA-
BLEMATERIALSHOULDNOTBE
PLACEDONORNEARTHEAPPLI-
ANCE.
Emissions from burning wood or gas could
contain chemicals known to the State of
California to cause cancer, birth defects or
other reproductive harm.
