Weber Q 300 User manual

Assembly - Pg. 9
mWARNING:
1. Do not store spare LPG cylinder within
10 feet (3m) of this appliance.
2. Do not store or use petrol or other
flammable liquids or vapors within
25 feet (8m) of this appliance.
mDANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
YOU MUST READ THIS OWNERS GUIDE
BEFORE OPERATING YOUR GAS BARBECUE.
m WARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
m WARNING: Do not try to light this
appliance without reading the Ignition
Instructions section of this manual.
#59752
PLACE STICKER HERE
59752 07/31/12 LP
AU - AUSTRALIA
NZ - NEW ZEALAND
Register your barbecue online at www.weber.com®
GAS BARBECUE
LPG Gas Grill Owner’s Guide

2
mDANGER
Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or
death, or in a fire or an explosion causing damage to property.
mWARNINGS
mFollow regulator connection instructions for your type of
gas barbecue.
mDo not store a spare or disconnected LPG cylinder under or
near this barbecue.
mDo not put a barbecue cover or anything flammable on or in
the storage area under the barbecue.
mImproper assembly may be dangerous. Please follow the
assembly instructions carefully.
mAfter a period of storage, and/or nonuse, the Weber®gas
barbecue should be checked for gas leaks and burner
obstructions before use. See instructions in this manual for
correct procedures.
mDo not operate the Weber®gas barbecue if there is a gas
leak present.
mDo not use a flame to check for gas leaks.
mCombustible materials should never be within 24 inches
(61 cm) of the back or sides of your Weber®gas barbecue.
mDo not put a barbecue cover or anything flammable on, or in
the storage area under the barbecue.
mYour Weber®gas barbecue should never be used by
children. Accessible parts of the barbecue may be very hot.
Keep young children away while it is in use.
mYou should exercise reasonable care when operating your
Weber®gas barbecue. It will be hot during cooking or
cleaning and should never be left unattended, or moved
while in operation.
mShould the burners go out while in operation, turn all
gas valves off. Open the lid and wait five minutes before
attempting to relight, using the lighting instructions.
mDo not use charcoal or lava rock in your Weber®gas
barbecue.
mNever lean over open barbecue or place hands or fingers on
the front edge of the cooking box.
mShould a grease fire occur, turn off all burners and leave lid
closed until fire is out.
mDo not enlarge valve orifices or burner ports when cleaning
the valves or burners.
mThe Weber®gas barbecue should be thoroughly cleaned on
a regular basis.
mLPG gas is not natural gas. The conversion or attempted
use of natural gas in a LPG unit or LPG gas in a natural gas
unit is dangerous and will void your warranty.
mDo not attempt to disconnect any gas fitting while your
barbecue is in operation.
mUse heat-resistant barbecue mitts or gloves when operating
barbecue.
mKeep any electrical supply cord and the fuel supply hose
away from any heated surfaces.
mDo not use this barbecue unless all parts are in place. The
unit must be properly assembled according to the assembly
instructions.
mDo not put a fuel tank inside the cabinet.
mDo not build this model of barbecue in any built-in or slide
in construction. Ignoring this Warning could cause a fire or
an explosion that can damage property and cause serious
bodily injury or death.
LPG GAS UNITS ONLY:
mUse the pressure regulator and hose assembly that is
supplied with your Weber®gas barbecue.
mDo not attempt to disconnect the gas regulator and hose
assembly or any gas fitting while your barbecue is in
operation.
mA dented or rusty LPG cylinder may be hazardous and
should be checked by your LPG supplier. Do not use a LPG
cylinder with a damaged valve.
mAlthough your LPG cylinder may appear to be empty,
gas may still be present, and the LPG cylinder should be
transported and stored accordingly.
mIf you see, smell or hear the hiss of escaping gas from the
LPG cylinder:
1. Move away from LPG cylinder.
2. Do not attempt to correct the problem yourself.
3. Call your fire department.
WARNINGS

WWW.WEBER.Com®3
TABLE oF CoNTENTS
WARNINGS ..........................................2
TABLE oF CoNTENTS .................................3
EXPLoDED VIEW - Q300 ...............................4
EXPLoDED VIEW LIST - Q300 ..........................5
EXPLoDED VIEW - Q320 ...............................6
EXPLoDED VIEW LIST - Q320 ..........................7
PARTS LIST .........................................8
ASSEmBLY ..........................................9
WARRANTY ........................................20
GENERAL INSTRUCTIoNS ............................21
OPERATING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
STORAGE AND/OR NON-USE ......................................21
GAS INSTRUCTIoNS .................................22
PURCHASE A FULL CYLINDER OF GAS FROM YOUR GAS DEALER.......22
MOUNT THE LPG CYLINDER.......................................22
CONNECTING THE LPG CYLINDER .................................23
CHECK FOR GAS LEAKS..........................................23
REFILLING THE LPG CYLINDER ....................................24
BEFoRE USING THE BARBECUE .......................25
CATCH PAN AND DISPOSABLE DRIP PAN ............................25
HOSE INSPECTION ..............................................25
IGNITER INSPECTION FOR MODELS WITH
ELECTRONIC IGNITION ...........................................25
IGNITIoN & USAGE ..................................26
IGNITION .......................................................26
TO EXTINGUISH .................................................26
MANUAL IGNITION ...............................................27
TO EXTINGUISH .................................................27
GRILLING TIPS & HELPFUL HINTS .....................28
PREHEATING THE BARBECUE .....................................28
COOKING METHODS .............................................28
GRILLING BASICS ...............................................28
TRoUBLESHooTING .................................29
mAINTENANCE .....................................30
CLEANING......................................................30
WEBER®SPIDER/INSECT SCREENS ................................30
BURNER TUBE CLEANING OR REPLACEMENT .......................31
PUSH-BUTTON IGNITION SYSTEM OPERATIONS (Q300)................32
ELECTRONIC IGNITION SYSTEM OPERATIONS (Q320) .................32
ELECTRONIC IGNITION SYSTEM REPLACEMENT .....................32
ANNUAL MAINTENANCE ..........................................33

4
Q300
EXPLoDED VIEW - Q300
1
2
3
4
5
6
7
8
9
11
12
13
15
14
16
17
18
19
20
21
22
23
24
25
26
27
28
29
10
Q300_AU_071312

WWW.WEBER.Com®5
EXPLoDED VIEW LIST - Q300
1. Swing-Up Work Surface
2. Thermometer Assembly
3. Handle Assembly
4. Cooking Grate
5. Wire Brace
6. Outside Burner Tube
7. Inside Burner Tube
8. Electrode Assembly
9. Front Cradle Frame
10. Igniter
11. Large Control Knob
12. Small Control Knob
13. Disposable Drip Pan
14. Catch Pan
15. Left Leg
16. Tank Skirt
1 7. Tank Base
18. Bottom Rack
19. Lid
20. Rear Cradle Frame
2 1. Cookbox
22. Valve & Manifold - Regulator Assembly
(Hose and Regulator may not be included)
23. Bridge Piece
24. Tank Bracket Assembly
25. Right Leg
26. Wheel Cover
2 7. Hubcap
28. Wheel
29. Axle

6
Q320
EXPLoDED VIEW - Q320
1
2
4
5
6
7
8
9
10
11
12
13
14
15
17
19
20
21
22
23
24
25
3
18
26
27
28
29
Q320_AU_071312
16

WWW.WEBER.Com®7
EXPLoDED VIEW LIST - Q320
1. Swing-Up Work Surface
2. Thermometer Assembly
3. Handle Assembly
4. Cooking Grate
5. Wire Brace
6. Outside Burner Tube
7. Inside Burner Tube
8. Electrode Assembly
9. Front Cradle Frame
10. Ignition Button/ Ignition Module
11. Large Control Knob
12. Small Control Knob
13. Disposable Drip Pan
14. Catch Pan
15. Left Leg
16. Tank Skirt
1 7. Tank Base
18. Bottom Rack
19. Lid
20. Rear Cradle Frame
2 1. Cookbox
22. Valve & Manifold - Regulator Assem-
bly (Hose and Regulator may not be
included)
23. Bridge Piece
24. Tank Bracket Assembly
25. Right Leg
26. Wheel Cover
2 7. Hubcap
28. Wheel
29. Axle

8
PARTS LIST
1-
12- 2-
2-
Q320
TOOLS NEEDED:
¼-20 x 2¼"
PAN HEAD
PHILLIPS SCREW
2- ¼-20 x 1"
TRUSS HEAD
PHILLIPS SCREW
(BLACK)
WOOD BLOCK
¼-20 x 1¼”
TRUSS HEAD
SCREW
(BLACK)

WWW.WEBER.Com®9
ASSEmBLY
22-
12-

10
ASSEmBLY
mPlace wheel frame on the right.
3
48-

WWW.WEBER.Com®11
ASSEmBLY
5

12
ASSEmBLY
6

WWW.WEBER.Com®13
ASSEmBLY
7

14
ASSEmBLY
84-
9

WWW.WEBER.Com®15
ASSEmBLY
11
10 2-

16
ASSEmBLY
A) Uncoil the hose and regulator of the Weber®Q®300/320.
B) Remove leg screw and secure hose and retention clip (1) to cart leg.
mWARNING: The hose must be secured to the cart
leg by the hose retention clip. Failure to do so
could cause damage to hose resulting in a fire or
explosion, which can cause serious bodily injury
or death and damage to property.
12
13
1

WWW.WEBER.Com®17
ASSEmBLY
14 1 2
3

18
ASSEmBLY
15
1 2
3 4

WWW.WEBER.Com®19
17 Q320
16
ASSEmBLY
2-

20
Weber-Stephen Products LLC (Weber) hereby warrants to the ORIGINAL PURCHASER
of this Weber®gas barbecue that it will be free of defects in material and workmanship
from the date of purchase as follows:
Aluminum Castings: 5 years; 2 years paint
excluding fading or discoloration
Thermoplastic/Thermoset Parts: 5 years, excluding fading
Stationary Cart: 2 years
All Remaining Parts: 2 years
when assembled and operated in accordance with the printed instructions
accompanying it. Weber may require reasonable proof of your date of purchase.
THEREFORE, YOU SHOULD RETAIN YOUR SALES SLIP OR INVOICE.
Our goods come with guarantees that cannot be excluded under the Australian
Consumer Law. You are entitled to a replacement or refund for a major failure and
for compensation for any other reasonably foreseeable loss or damage.You are also
entitled to have the goods repaired or replaced if the goods fail to be of acceptable
quality and the failure does not amount to a major failure.
The benefits given under this Limited Warranty are in addition to other rights and
remedies you have under the Australian Consumer Law in relation to this Weber®gas
barbecue.
This Limited Warranty shall be limited to the repair or replacement of parts that prove
defective under normal use and service and which on examination shall indicate,
to Weber’s satisfaction, they are defective. Before returning any parts, contact the
Customer Service Representative in your area using the contact information on our
website. If Weber confirms the defect and approves the claim, Weber will elect to replace
such parts without charge. If you are required to return defective parts, transportation
charges must be prepaid. Weber will return parts to the purchaser, freight or postage
prepaid.
This Limited Warranty does not cover any failures or operating difficulties due to
accident, abuse, misuse, alteration, misapplication, vandalism, improper installation or
improper maintenance or service, or failure to perform normal and routine maintenance,
including but not limited to damage caused by insects within the burner tubes, as set out
in this owner’s manual.
Deterioration or damage due to severe weather conditions such as hail, hurricanes,
earthquakes or tornadoes, discoloration due to exposure to chemicals either directly or
in the atmosphere, is not covered by this Limited Warranty.
There are no other express warrants except as set forth herein and any applicable
implied warranties of merchantability and fitness are limited in duration to the period of
coverage of this express written Limited Warranty. Some regions do not allow limitation
on how long an implied warranty lasts, so this limitation may not apply to you.
Weber is not liable for any special, indirect or consequential damages. Some regions
do not allow the exclusion or limitation of incidental or consequential damages, so this
limitation or exclusion may not apply to you.
Weber does not authorize any person or company to assume for it any other obligation
or liability in connection with the sale, installation, use, removal, return, or replacement
of its equipment; and no such representations are binding on Weber.
This Limited Warranty applies only to products sold at retail.
WEBER-STEPHEN PRODUCTS LLC
R. McDonald Co. PTY. LTD.
A.C.N., 007 905 384
104 South Terrace
Adelaide, SA 5000
61.8.8221.6111
WEBER-STEPHEN PRODUCTS LLC
6 Maurice Road
Penrose
Auckland, 1061
New Zealand
Visit www.weber.com®, select your country of origin, and register your
barbecue today. ◆
WARRANTY