Whirlpool AWZ 234 User manual

SERVICE Whirlpool Europe
Customer Services
Model AWZ 234
Version 8575 234 01010 Page
Technical data 2 - 3
Spare part list 4
Exploded view 5 - 6
Wiring diagram 7
Circuit diagram 8
Text/Legend 9 - 14
Service Manual
Tumble dryer
Air Vent
AWZ 234
AWZ 234
This documentation is only intended for qualified technicians who are aware of the respec-
tive safety regulations.
Date: 03.04.2001 (Mod.01) Subject to modification
Document-No.: 4812 713 12167

SERVICE
11.09.2000 / Page 2 AWZ 234 Whirlpool Europe
Doc. No: 4812 713 12167 8575 234 01010 Customer Service
Technical data
Dimensions
Height 85 cm
Width 59.5 cm
Depth 56 cm
Weight
Gross weight 33 kg
Net weight 31 kg
Surroundings temperature
Room temperature
maximun 35 ˚C
Room temperature
minimum 5 ˚C
Humidity
Relative humidity
maximun 95 %
Power connection
Voltage 230 V
Frequency 50 Hz
Connected load 2.8 kW
Fuse 16 A
Drum data
Volume 104 l
Drum speed 56 ±3 rpm
Airflow 120-160 m3/h
Capacity of laundry
Cotton max. 5 kg
Easy care max. 2.5 kg
Exhaust hose
Inner diameter 10 cm
Maximum allowable
length (with 2 bows) 4 m
Electrical components
Heating
Type Aluminium mass heating
Nominal voltage 230 +10% / -15% V
Nominal power 2500 ±5% W
Heating resistances:
Connection points 19.5 - 23 Ω
Thermostats
Safety thermostat (in heater) TL
Switch off (temp.) 298 ±10 ˚C
Fluff thermostat (in heater) TH 1.2
Switch on (temp.) 195 ±7.5 ˚C
Switch off (temp.) 220 ±7.5 ˚C
Exhausting thermostat (in airchannel) TH 1.1
Switch on (temp.) 38 ±5˚C
Switch off (temp.) 53 ±4˚C
Control module Omega
Type Electronic Timer
Flextronics max.options
Nominal voltage 230±10% V
Frequency 50/60 Hz
Rated currents
Motor ≤6A
Heater ≤16 A
Drumlight ≤0.1 A
Ambient
temperature up to 50 ˚C
Storage
temperature up to 85 ˚C
Caution:
☞If one of the thermostats (TL, TH1.2)
is defective, the whole heating
element has to be changed for safety
reason !
☞Therefore, the thermostats are not
available as separate spare parts !

SERVICE Whirlpool Europe AWZ 234 11.09.2000 / Page 3
Customer Service 8575 234 01010 Doc. No: 4812 713 12167
Technical data
Main- and blower motor
Type 1-phase asynchronous
Nominal voltage 230 +10% / -15% V
Frequency 50 Hz
Power consumption 295±7% W
Resistances of coils:
Main coil (2-3) 24.7±7% Ω
Auxiliary coil (2-1) 25.6±7% Ω
Rated speed with 5 kg laundry
and 100% rest humidity 2730 rpm
Capacitor 10µF±7%/420V470V
Radio interference filter
Typ EICHHOFF BV 16.250/119
Voltage max. 250 V
Capacity 100 nF X1 + 2x 15nF Y2
Display
WH display module Low Flextronics
No. of LEDs 19 + Start LED
Options buttons - Start
- Gentle
- Rapid
- Buzzer
- Anticrease
Program selector 12 positions integrated ON/OFF contact 24V AC

SERVICE
03.04.2001 (Mod.01) / Page 4 AWZ234 Whirlpool Europe
Doc. No: 4812 713 12167 8575 234 01010 Customer Service
Spare part list
Model AWZ 234
Service No. 857523401010
Version 857523401010
Pos. No. 12NC Code Description
004 0 4812 530 48144 Bottom
011 0 4812 500 18054 Foot adjustable
012 0 4812 528 78033 Roll
012 1 4812 528 98003 Shaft Front
012 2 4812 520 28068 Shaft rear
021 0 4812 440 19387 Front,panel
022 0 4812 440 19445 Panel,side
024 0 4812 440 19467 Panel, rear from 98/34
030 0 4812 440 19779 Table top R0 VBL
033 0 4812 310 18582 Kit Push in cover
100 0 4812 416 18182 Door R0 WH VBL
131 1 4812 271 38362 Door lock
133 0 4812 417 28049 Pin Door
191 0 4812 466 68539 Gasket, door
220 0 4812 418 18199 Drum coated
223 0 4812 418 88027 Drum lifter
271 0 4812 358 18162 Belt 1965-H7 EH81
273 0 4812 358 18055 Pulley jokey
275 0 4812 492 68129 Spring
291 0 4812 466 68563 Gasket Drum front
291 1 4812 466 68541 Gasket Fluff Filter
291 2 4812 466 68562 Gasket Drum rear
301 0 4812 452 10486 Control panel
321 0 4812 452 10487 Insert panel AWZ 234
321 1 4812 446 88127 Fastener f. Inlay
331 0 4812 414 58111 Knob,timer VBL cpl.
332 0 4812 276 18329 Button VBL WH EL Start
332 1 4812 276 18328 Button VBL WH EL Opt.
350 0 4812 214 78487 Display board VBL AV low
401 0 4812 361 18247 Motor
401 1 4812 401 18421 Clamp Motor
420 0 4812 121 18144 Capacitor 10 µF
421 0 4812 121 18161 Interf.filter
443 0 4812 361 18248 Blower Wheel
456 0 4812 259 28674 Heating element 2500W
490 0 4812 321 18087 Cable,mains
490 1 4812 321 28367 Strain relief
492 1 4812 401 18195 Clip
521 0 4812 214 78456 Control board AV WH high (Y)
551 3 4812 271 28369 Thermostat
633 1 4812 276 18271 Pin Start Reset
692 0 4812 278 58001 Sensor
743 0 4812 530 48145 Air guide
743 1 4812 530 48147 Heating chamber
743 2 4812 466 68538 Seal for blower
761 0 4812 480 58077 Filter
794 0 4812 466 28107 Gasket
900 1 4812 290 88053 Clip
902 1 4812 256 38002 Bracket Roller
903 0 4812 532 28028 Clip,fix
910 0 4812 502 38057 Screw Torx 4,2 x 13
910 5 4819 502 38265 Screw VAB 4,5x20
910 8 4812 502 48347 Screw,selftap 3,5x14SS
912 4 4812 502 48015 Screw
922 0 4812 532 58005 Ring,circlip Triring
Pos. No. 12NC Code Description
922 1 4812 532 58007 Ring,circlip
962 0 4812 466 38012 Protector Motor
993 0 4812 263 78014 Adapter
993 1 4812 310 18413 Accessory hose kit AMH 577

SERVICE Whirlpool Europe AWZ 234 03.04.2001 (Mod.01) / Page 5
Customer Service 8575 234 01010 Doc. No: 4812 713 12167
Exploded view

SERVICE
03.04.2001 (Mod.01) / Page 6 AWZ 234 Whirlpool Europe
Doc. No: 4812 713 12167 8575 234 01010 Customer Service
Exploded view

SERVICE Whirlpool Europe AWZ 234 11.09.2000 / Page 7
Customer Service 8575 234 01010 Doc. No: 4812 713 12167
Wiring diagram

SERVICE
11.09.2000 / Page 8 AWZ 234 Whirlpool Europe
Doc. No: 4812 713 12167 8575 234 01010 Customer Service
Circuit diagram

SERVICE Whirlpool Europe AWZ 234 11.09.2000 / Page 9
Customer Service 8575 234 01010 Doc. No: 4812 713 12167
Text/Legend

SERVICE
11.09.2000 / Page 10 AWZ 234 Whirlpool Europe
Doc. No: 4812 713 12167 8575 234 01010 Customer Service
Text/Legend

SERVICE Whirlpool Europe AWZ 234 11.09.2000 / Page 11
Customer Service 8575 234 01010 Doc. No: 4812 713 12167
Text/Legend

SERVICE
11.09.2000 / Page 12 AWZ 234 Whirlpool Europe
Doc. No: 4812 713 12167 8575 234 01010 Customer Service
Text/Legend

SERVICE Whirlpool Europe AWZ 234 11.09.2000 / Page 13
Customer Service 8575 234 01010 Doc. No: 4812 713 12167
Text/Legend

SERVICE
11.09.2000 / Page 14 AWZ 234 Whirlpool Europe
Doc. No: 4812 713 12167 8575 234 01010 Customer Service
Text/Legend