Yamaha SUPERJET 700 2005 Owner's manual

2005
SuperJet
700
OWNER’S/OPERATOR’S
MANUAL
LIT-18626-05-74
U.S.A. Edition
READ THIS MANUAL
CAREFULLY BEFORE OPERATION!
Printed in Japan
Jun. 2004—0.4 ×1 CR
F1N-28199-13
(E)
Printed on recycled paper
YAMAHA MOTOR CORPORATION, USA

E
EJU00989
To the owner/operator
Thank you for choosing a Yamaha water-
craft. This Owner’s/Operator’s Manual con-
tains information you will need for proper
operation, maintenance, and care.
A thorough understanding of these simple
instructions will help you to obtain maximum
enjoyment from your new Yamaha. If you
have any questions about the operation or
maintenance of your watercraft, please con-
sult a Yamaha dealer.
Because Yamaha has a policy of continu-
ing product improvement, this product may
not be exactly as described in this Owner’s/
Operator’s Manual. Specifications are sub-
ject to change without notice.
This manual should be considered a per-
manent part of this watercraft and should
remain with it even if the watercraft is subse-
quently sold.
EJU01265
Important manual information:
In this manual, information of particular
importance is distinguished in the following
ways:
The Safety Alert Symbol means
ATTENTION! BECOME ALERT!
YOUR SAFETY IS INVOLVED!
WARNING
@
Failure to follow WARNING instructions
could result in severe injury or death to
the machine operator, a bystander, or a
person inspecting or repairing the water-
craft.
@
CAUTION:
@
A CAUTION indicates special precau-
tions that must be taken to avoid damage
to the watercraft.
@
N
O
TE:
@
A NOTE provides key information to make
procedures easier or clearer.
@
EJU01142
SuperJet 700
OWNER’S/OPERATOR’S MANUAL
©2004 by Yamaha Motor Corporation, USA
1st Edition, April 2004
All rights reserved.
Any reprinting or unauthorized use
without the written permission of
Yamaha Motor Corporation, USA
is expressly prohibited.
Printed in Japan
P/N LIT-18626-05-74
UF1N13.book Page 1 Monday, May 31, 2004 9:02 AM

UF1N13.book Page 2 Monday, May 31, 2004 9:02 AM

E
EJU00992
CONTENTS
READ THIS OWNER’S/OPERATOR’S MANUAL CAREFULLY BEFORE
OPERATING YOUR WATERCRAFT.
GENERAL AND SAFETY
INFORMATION 1
FEATURES AND FUNCTIONS 2
OPERATION 3
MAINTENANCE AND CARE 4
TROUBLESHOOTING AND
EMERGENCY PROCEDURES 5
APPENDIX 6
UF1N13.book Page 3 Monday, May 31, 2004 9:02 AM

UF1N13.book Page 4 Monday, May 31, 2004 9:02 AM

E
1
EJU00993
GENERAL AND
SAFETY
INFORMATION
Identification numbers ............................1-1
Primary Identification (PRI-ID)
number ...................................................1-1
Hull Identification Number (HIN) ............1-1
Engine serial number .............................1-1
Emission control information ................1-2
Approval label of Emission control
certificate ................................................1-2
Manufactured date label ........................1-2
Important labels .......................................1-3
Label location .........................................1-3
Warning labels .......................................1-4
Other labels ............................................1-6
Safety information ...................................1-7
Limitations on who may operate the
watercraft ................................................1-7
Cruising limitations .................................1-8
Operation requirements .........................1-9
Recommended equipment ..................1-11
Hazard information ..............................1-12
Watercraft characteristics ....................1-12
Rules of the Road ..................................1-14
Steering and sailing rules ....................1-14
Rules when encountering vessels ......1-15
Other special situations .......................1-16
Reading buoys and other markers ......1-16
To get more boating safety
information .............................................1-18
United States Coast Guard .................1-18
Other sources ......................................1-18
Watercraft Education and Training ......1-18
Enjoy your watercraft responsibly ......1-19
UF1N13.book Page 1 Monday, May 31, 2004 9:02 AM

1-1
E
EJU01830
Identification numbers
Record the Primary Identification (PRI-ID)
number, Hull Identification Number (HIN)
and engine serial number in the spaces pro-
vided for assistance when ordering spare
parts from a Yamaha dealer. Also record
and keep these ID numbers in a separate
place in case your watercraft is stolen.
EJU01831
Primary Identification (PRI-ID)
number
The PRI-ID number is stamped on a
label 1attached inside the engine compart-
ment.
EJU18841
Hull Identification Number
(HIN)
The HIN is stamped on a plate 1attached
to the hull on the aft, starboard (right) side.
EJU09971
Engine serial number
The engine serial number is stamped on
a label 1attached to the engine unit.
UF1N13.book Page 1 Monday, May 31, 2004 9:02 AM

1-2
E
EJU01846
Emission control
information
This engine conforms to 2004 U.S. Envi-
ronmental Protection Agency (EPA) regula-
tions for marine SI engines.
EJU01126
Approval label of Emission
control certificate
This label is attached to the electrical box
and muffler.
1Emission control information label
EJU01127
Manufactured date label
This label is attached to the electrical box
and muffler.
2Manufactured date label
UF1N13.book Page 2 Monday, May 31, 2004 9:02 AM

1-3
E
EJU00998
Important labels
EJU01351
Label location
UF1N13.book Page 3 Monday, May 31, 2004 9:02 AM

1-4
E
EJU01352
Warning labels
12
3
UF1N13.book Page 4 Monday, May 31, 2004 9:02 AM

1-5
E
5
67
4
UF1N13.book Page 5 Monday, May 31, 2004 9:02 AM

1-6
E
EJU01354
Other labels
0
89
A
B
UF1N13.book Page 6 Monday, May 31, 2004 9:02 AM

1-7
E
EJU01177
Safety information
The safe use and operation of this
watercraft is dependent upon the use of
proper riding techniques, as well as upon
the common sense, good judgment, and
expertise of the operator. Every operator
should know the following requirements
before riding the watercraft.
●Before operating the watercraft, read the
Owner’s/Operator’s Manual, the Riding
Practice Guide, the Riding Instruction
card and all warning and caution labels
on the watercraft. Also, watch the Basic
Orientation Video provided with your
watercraft. These materials should give
you an understanding of the watercraft
and its operation.
●Never allow anyone to operate this water-
craft until they too have read the Owner’s/
Operator’s Manual, the Riding Practice
Guide, the Riding Instruction card and all
warning and caution labels, and if possi-
ble watched the Basic Orientation Video.
Showing them the video may help rein-
force the information contained in these
materials.
EJU01143
Limitations on who may
operate the watercraft
●Yamaha recommends a minimum opera-
tor age of 16 years old.
Adults must supervise use by minors.
Know the operator age and training
requirements for your state. A boating
safety course is recommended and may
be required in your state. You can find
local rules by contacting the United
States Coast Guard (USCG), the National
Association of State Boating Law Admin-
istrators, or your local Power Squadron.
●This watercraft is designed to carry the
operator only. Never have more than one
person on the watercraft at any time.
UF1N13.book Page 7 Monday, May 31, 2004 9:02 AM

1-8
E
EJU01269
Cruising limitations
●Scan constantly for people, objects, and
other watercraft. Be alert for conditions
that limit your visibility or block your vision
of others.
●Operate defensively at safe speeds and
keep a safe distance away from people,
objects, and other watercraft.
●Do not follow directly behind watercraft or
other boats.
●Do not go near others to spray or splash
them with water.
●Avoid sharp turns or other maneuvers
that make it hard for others to avoid you or
understand where you are going.
●Avoid areas with submerged objects or
shallow water.
●Ride within your limits and avoid aggres-
sive maneuvers to reduce the risk of loss
of control, ejection, and collision.
●This is a high performance boat—not a
toy. Sharp turns or jumping wakes or
waves can increase the risk of back/spinal
injury (paralysis), facial injuries, and bro-
ken legs, ankles and other bones. Do not
jump wakes or waves.
●Do not operate the watercraft in rough
water, bad weather or when visibility is
poor; this may lead to an accident caus-
ing injury or death. Be alert to the possi-
bility of adverse weather. Take note of
weather forecasts and the prevailing
weather conditions before setting out on
your watercraft.
●As with any water sport, you should not
operate your watercraft without someone
else near by. If you operate further than
swimming distance from shore, you
should be accompanied by another boat
or watercraft, but make sure you stay a
safe distance away. It’s good, common
sense!
●Never operate in water that is less than
60 cm (2 ft) deep, otherwise you increase
your chance of hitting a submerged
object, which could result in injury.
UF1N13.book Page 8 Monday, May 31, 2004 9:02 AM

1-9
E
●This watercraft is not equipped with light-
ing required for night operation. Do not
operate the watercraft after sunset or
before dawn, otherwise you increase the
risk of colliding with another boat, which
could result in severe injury or death.
EJU01144
Operation requirements
●All riders must wear a Coast Guard
approved personal flotation device (PFD)
that is suitable for personal watercraft
use.
●Wear protective clothing. Severe internal
injuries can occur if water is forced into
body cavities as a result of falling into
water or being near the jet thrust nozzle.
Normal swimwear does not adequately
protect against forceful water entry into
rectum or vagina. All riders must wear a
wetsuit bottom or clothing that provides
equivalent protection.
Such clothing includes thick, tightly
woven, sturdy and snug-fitting apparel
such as denim, but does not include
spandex or similar fabrics, like those used
in bicycle shorts.
1Coast Guard approved PFD
2Wetsuit bottom
●Eye protection is recommended to keep
wind, water, and glare from the sun out of
your eyes while you operate your water-
craft. Restraining straps for eyewear are
made which are designed to float should
your eyewear fall in the water.
Footwear and gloves are recommended.
UF1N13.book Page 9 Monday, May 31, 2004 9:02 AM

1-10
E
●Helmets meeting Snell or DOT standards
are required for IJSBA-sanctioned races.
You must decide whether to wear a hel-
met while you ride for recreation. You
should know that a helmet could help pro-
tect you in certain kinds of accidents and
that it could injure you in others.
A helmet is designed to provide some
head protection. Although helmets cannot
protect against all foreseeable impacts, a
helmet might reduce your injuries in a col-
lision with a boat or other obstacle.
A helmet may have potential safety haz-
ards, as well. Falling into the water could
risk the chance of the helmet catching
water, commonly known as “bucketing,”
and the resulting strain on your neck
could cause choking, severe and perma-
nent neck injuries, or death. A helmet
could also increase the risk of an accident
if it reduces your vision or hearing, or if it
distracts you or increases your fatigue.
How should you decide if a helmet’s
potential safety benefits outweigh its
potential risks for you? Consider your par-
ticular riding conditions. Consider factors
such as your riding environment and your
riding style and ability. Also consider the
likelihood of traffic congestion, and the
water surface conditions. If you decide to
wear a helmet based upon your riding cir-
cumstances, choose one carefully. Look
for a helmet designed for personal water-
craft use, if possible. Consider a helmet
meeting Snell or DOT standards. If you
will be engaging in closed-course compe-
tition, follow the helmet requirements of
the sanctioning organization.
●NEVER operate the watercraft after con-
suming alcohol or taking other drugs.
●For reasons of safety and proper care of
the watercraft, always perform the pre-
operation checks listed on page 3-5
before operating the watercraft.
●The operator should always keep both
feet or knees on the riding tray when the
watercraft is in motion. Lifting your feet
increases your chances of losing your
balance, and your feet being hit by objects
outside the watercraft.
●Always consult your doctor on whether it
is safe for you to operate this watercraft if
you are pregnant or in poor health.
●Do not attempt to modify this watercraft!
Modifications to your watercraft may
reduce safety and reliability, and render
the watercraft unsafe or illegal for use.
UF1N13.book Page 10 Monday, May 31, 2004 9:02 AM

1-11
E
●Attach the engine shut-off cord (lanyard)
to wrist and keep it free from the handle-
bars so that the engine stops if the opera-
tor falls off. After riding, remove the
engine shut-off cord from the watercraft to
avoid accidental starting or unauthorized
use by children or others.
●Scan carefully for swimmers, and stay
away from swimming areas. Swimmers
are hard to see and you could acciden-
tally hit someone in the water.
●Avoid being hit by another boat! You
should always take the responsibility to
watch for traffic; other boaters may not be
watching for you. If they do not see you,
or you maneuver more quickly than other
boaters expect, you risk a collision.
●Maintain a safe distance from other boats
or watercraft, and also watch for boats’ski
ropes or fishing lines. Obey the “Rules of
the Road”and be sure to check behind
you before making a turn. (See Rules of
the Road on page 1-14.)
●This watercraft is included in the Class A
inboard boat classification of the
U.S.Coast Guard. A watercraft of this type
MUST carry a fire extinguisher of a B-1
classification, with a capacity of two
pounds or more when navigating in
waters under Coast Guard jurisdiction. In
addition, most state and local boating
laws also require that the fire extinguisher
be approved by the USCG.
EJU01381
Recommended equipment
The following items should be carried on
board your watercraft:
●Sound-signaling device
You should carry a whistle or other sound-
signaling device that can be used to sig-
nal other boats. See Rules of the Road for
more information.
●Visual distress signals
It is recommended that a USCG approved
pyrotechnic device be stored in a water-
proof container on your watercraft. A mir-
ror can also be used as an emergency
signal. Contact your Yamaha dealer or the
Coast Guard for more information.
●Watch
A watch is helpful so you will know how
long you have been operating.
●Towline
A towline can be used to tow a disabled
watercraft in an emergency.
UF1N13.book Page 11 Monday, May 31, 2004 9:02 AM

1-12
E
EJU01003
Hazard information
●When transporting or storing your water-
craft, always place the fuel cock knob in
the “OFF”position, otherwise gasoline
may overflow from the carburetor.
●Never start the engine or let it run for any
length of time in an enclosed area.
Exhaust fumes contain carbon monoxide,
a colorless, odorless gas that may cause
loss of consciousness and death within a
short time. Always operate the watercraft
in an open area.
EJU01271
Watercraft characteristics
●Jet thrust turns the watercraft. Releasing
the throttle lever completely produces
only minimum thrust. If you are traveling
at speeds above trolling, you will have
rapidly decreasing ability to steer without
throttle. You may still have some turning
ability immediately after releasing the
throttle, but once the engine slows down,
the watercraft will no longer respond to
handlebar input until you apply throttle
again or you reach a trolling speed. Prac-
tice turning in an open area without
obstructions until you have a good feel for
this maneuver.
●This watercraft are water-jet propelled.
The jet pump is directly connected to the
engine. This means that jet thrust will pro-
duce some movement whenever the
engine is running. There is no “neutral”
position.
UF1N13.book Page 12 Monday, May 31, 2004 9:02 AM