Abbott USB PRINTER User manual

USB PRINTER
USER GUIDE
EN

USER GUIDE 3
 Aenonsymbol.Indicatesspecialproblemsorimportant
informaon.Readtheaccompanyingtextcarefully.
Manufacturer
Cataloguenumber
 Consultinstruconsforuse
NiMH Nickelmetalhydride
 Baery
SerialNumber
Tokeepdry
 CEMark
 Directcurrent
INDEX OF SYMBOLS

USBPRINTER4
 Thermalpaperroll
 FEEDkey
 Statuslight
 USBcable
1 INTRODUCTION
Intended Use
TheUSBPrinterisaportablethermalprinterforthem-PIMA™Analyser
andthePima™Analyser.Connectedtoandpoweredbytheanalyzervia
aUSBport,theUSBPrinterenablesprinngoftestreports.Itcontains
maintenance-freerechargeablebaeries.
4
1
2
3
4
1
2
3

USER GUIDE 5
Specicaons
Printer
Dimensions L95mm×W93mm×H66mm
Weight approx.350gincl.paperroll
Printprocedure completexedthermalline
Resoluon 8dots / mm(203dpi),
384dots /printline
Printspeed upto50mm / s
Baeries 4rechargeableNiMHcells,
AAHR6,1.2V
Operang Condions
Operangtemperature 10 -40 °C
Altude 0-2000m
Relavehumidity 10-95%(nocondensaon)
Transport/Storagetemperature 2 -50 °C
Environment protectfromdirectsunlight,
humidityanddust
Powersupply DCwith5V,0.5AviaUSBinterface
Declaraon of Conformity
TheUSBPrintercomplieswiththefollowingstandardoftheEUandwas
testedaccordingtoEN61326-1.

USB PRINTER6
Transport & Unpacking
TheUSBPrinterisdeliveredinacushionedtransportaonbox.
Aerunpackinginspectforanyobvioussignsofdamage.
Reportanydamageimmediatelytoyourlocaldistributor.
Allowtemperatureequilibraonforatleast30minutesbeforeconnecng
totheanalyzertoensurethattheprinterhasreachedsurrounding
temperature.
Maintenance & Cleaning
TheUSBPrinterisamaintenance-freedevice.Ifcleaningofthehousing
isneeded,useabre-freeclothmoistenedwithamilddetergentora
disinfectant.Beforecleaning,disconnecttheprinterfromtheanalyzerand
removepaperroll.
DonotcleantheinsideoftheUSBPrinter.
 Beforeinstallingandusingtheprinterincombinationwiththe
m-PIMA™AnalyserorthePima™Analyser,carefullyreadthem-PIMA™
AnalyserUserGuide(UG-m-PIMA-01)andthePima™AnalyserUser
Guide(UG-PIMA-01),respectively.
 WheneverpossiblerechargetheUSBPrintertogetherwiththe
m-PIMA™AnalyserorthePima™Analyser.

USER GUIDE 7
2 OPERATION
Installaon
Allprinngprocessesarecontrolledbytheanalyzer.ConnecttheUSB
PrinterbyinserngtheUSBplugoftheprintercableintooneofthetwo
USBportslocatedatthebackoftheanalyzer.Starttheanalyzerandthe
instrumentwillautomacallydetecttheUSBPrinter.
 IftheanalyzerdoesnotautomaticallyrecognizetheUSBPrinter,
disconnecttheprinterfromtheUSBportandreconnectitwiththe
instrument.ShouldtheinstrumentstillnotrecognizetheUSBPrinter
shutdowntheanalyzerandrestartwiththeUSBPrinterattached.
ThestatuslightontherightsideoftheFEEDkeyindicatesfunconalityof
theUSBPrinter.Thelightmaybeashingorconstantlyilluminated.
Whentheprinterisdisconnectedfromtheanalyzer,thestatuslightwill
ceasetobeilluminatedaerashortwhile.
Green light: theprinterisfullyfunctionalandreadytoprint
(whenconnectedtotheanalyzer)
Orange light:theprinterbatteryislow
 (rechargetheUSBPrinterviatheanalyzer)
Red light:theprinterisnotreadytoprint
(ingeneralthisoccurswhentheprinterisoutofpaper;ifthecondition
persistsdespitereplacementofprinterpaper,pleasecontactyourlocal
distributor).

USB PRINTER8
Prinng
Prinngispossibleimmediatelyaerthesuccessfulconneconofthe
USBPrintertotheanalyzer.Allprinngiscontrolledviatheanalyzeruser
interface.Formoreinformaonpleaserefertothem-PIMA™Analyser
UserGuide(UG-m-PIMA-01)andthePima™AnalyserUserGuide
(UG-PIMA-01),respecvely.
Replacement of Printer Paper
Upondelivery,theUSBPrinterisprovidedwithonerollofthermalpaper.
Ifthepaperrollisnished,anewrollneedstobeinsertedintothepaper
compartmentoftheprinter.
 Openthelidoftheprinterby
slightlypullingtheleverinside
upwards.
 Completelyopenthelidto
exposethepapercompartment
andremovetheemptypaper
roll.

USER GUIDE 9
 Unwindapprox.10cmofpaper
fromanewrollandholdthe
layerstightlywound.Putthe
newpaperrollinthepaper
compartment,makingsurethat
theoutsideisturnedtowards
theprintermechanism.
 Makesuretopullthepaper
tightbeforeclosingthelid.
 Pressonthecentreofthelid
untilitaudiblysnapsintoplace.
Thepapercanbetornoffat
thetear-offedgewithoutthe
lidopeningupandwithoutthe
paperslidingthroughtheprint
head.

USB PRINTER10
Printer Paper
Upondelivery,theUSBPrinterisprovidedwithonerollofthermalpaper.
PleaseusethermalpaperprovidedfortheseUSBPrintersonly.Fororder
informaon,pleaserefertotheREFnumbersbeloworcontactyourlocal
distributor.
REF Product Descripon
26040R009 Printer
PaperI
Setof10rolls,thermalpaper,
width56.5±0.5mm,thickness60μm,
prinngimagestabilitymin.5years
(whenstoreddryandUV-lightprotected),
forapprox.65m-PIMA™TestReportsor
approx.100Pima™CD4TestReports
26040R010 Printer
PaperII
Setof10rolls,thermalpaper,adhesive,
width56.5±0.5mm,thickness120μm,
prinngimagestabilitymin.15years
(whenstoreddryandUV-lightprotected),
forapprox.30m-PIMA™TestReportsor
approx.50Pima™CD4TestReports
 Forfurtherinformationcontactyourlocaldistributor.