Action Sports Stats User manual

138cm (4.5ft) Trampoline
S001961
Instruction Manual
WARNING: To ensure your safety, please do not attempt to assemble this product without reading this instruction
manual carefully. Failure to comply with this warning may result in injury or property damage.
• Prior to assembly, this product includes small parts/accessories that are not suitable for children under 3 years
of age as they may cause a choking hazard.
• This product should be assembled by 2 adults.
• Onlyusethisproductonasoft,atlevelsurface.
• This trampoline has a maximum user weight of 34kg.
• Do now allow more than one person on the trampoline at any time.
• Thisproductisdesignedfordomesticuseonly,itisnotintendedforgymnasticsorhighlevelacrobaticstunts.
Forpartsandserviceenquiries,pleasecontactActionSpareson1800465070ore-mail[e-mail]

2
S001961 4.5ft Trampoline
Contents
3Important Safety Information
5Parts List
6Assembly Instructions
11 Warranty

3
S001961 4.5ft Trampoline
ImportantSafetyInformation
To reduce the risk of serious injury, read the entire manual before you assemble or use this product.
In particular, please note the following safety precautions. Please keep this manual in a safe place for
future reference.
1. Priortoassembly,thisproductincludessmallparts/accessoriesthatarenotsuitableforchildren
under 3 years of age as they may cause a choking hazard.
2. Itistheresponsibilityoftheownertoensurethatallusersofthisproductareadequatelyinformed
of all warnings and precautions. This product is not intended for use by persons (including children)
with reduced physical, sensory or mental capabilities; or lack of experience and knowledge
unlesstheyhavebeengivensupervisionorinstructionconcerninguseoftheproductbyaperson
responsible for their safety.
3. This product should be assembled by two adults.
4. Placethisproductonasoftlevelsurfacewithatleast2.5mdiameterofclearspacesurroundingthe
unit.Thereshouldalsobeatleast7mofspaceabovethemattoensuretheuserhasasufcientto
jump in.
5. Thistrampolineissuitableforusersaged3to6yearsofage.
6. This trampoline has a maximum user weight of 34kg.
7. Donotallowmorethanonepersononthetrampolineatanytime.
8. Thisproductisdesignedfordomesticuseonly,itisnotintendedforgymnasticsorhighlevel
aerobic stunts.
9. Do not use the trampoline without the enclosure net.
10. Donotattemptorallowsomersaults.
11. Donotusethetrampolinewhenwet.
12. Donotjumpintooroffoftheenclosurenet.
13. Donousethetrampolinewhileundertheinuenceofalcoholordrugs.
14. Donotallowanyactivityunderneaththetrampoline.
15. Usersshouldbebarefootedoronlywearingsockswhenusingthetrampoline,footwearmustnot
be worn.
16. Donotuseforeignobjectswiththetrampoline,useofanyforeignobjectswillvoidthewarranty.

4
S001961 4.5ft Trampoline
ImportantSafetyInformation(cont)
17. Inspectthetrampolinebeforeeachuse,replaceanywornordefectiveparts.Ifyourequire
replacementpartstobesentout,pleasecontactourNationalServiceCentre(detailscanbefound
in the warranty pages at the back of this manual.
18. Ensurethattheframepaddingiscorrectlyandsecurelypositionedpriortouse.
19. Climbonandoffthetrampoline,donotjumponoroff.Itisdangeroustojumpfromthe
trampolinetothegroundwhendismounting,orontothetrampolinewhenmounting.Alwaysuse
twohandstoholdontotheframewhengettingonoroffthetrampoline.Neverusetheelastic
togglesorenclosurepolesashandgrips.Smallchildrenmayneedassistancegettingonoroffof
the trampoline.
20. Whenbouncingonthetrampoline,alwaysaimforthecentreofthejumpingmat.Bouncingnear
the edge of the trampoline mat can lead to injury. The frame pad is not designed to support the
weight of the trampoline user.
21. Donotusethetrampolineasaspringboardtootherobjects.
22. It is recommended that you do not use the trampoline immediately after a meal.
23. Jewelleryshouldberemovedbeforeusingthetrampolineasthismaycauseaninjurytotheuser
and/or damage the trampoline.
24. Usersshouldonlyusethetrampolineunderadultsupervision.

5
S001961 4.5ft Trampoline
Parts List
Part No. Description Qty
ATop Rail 6
B T-Joint 6
C Leg Tube 6
D Mat 1
EFrame Pad 1
F Net 1
GSkirting 1
HUpperEnclosurePole 6
ILowerEnclosurePole 6
JElasticToggleLoop 32
KScrew(Ø4*16mm) 30
LScrewdriver 1

6
S001961 4.5ft Trampoline
AssemblyInstructions
Frame Assembly
LayoutthepartsonacleardrylevelsurfaceasshowninFigure1.
TheT-Joints(B)shouldbeplacedbetweeneachTopRail.Connect
theTopRail(A)byslidingitintotheT-Joints(B)toformthetoprail
loopasshowninFigure2.1.
Attention: make sure the two ends with a groove on the Top Rail
Tube (A) are facing down to the ground. See Fig. 2.2
To complete assembly of the Legs. Join the Leg Tube (C) to the Top
Railandleavetheholewithoutscrewatthisstage.Thescrewwillbe
used in later step when the skirting is connected as well.
Once completed, the frame of the Trampoline should look like
Figure4.

7
S001961 4.5ft Trampoline
AssemblyInstructions(cont)
Mat Assembly
1.SpreadouttheMat(D)andtheElasticToggle(J)readyforassembly
asshowninFigure5.
ThreadtheElasticToggle(J)throughtheMat(D)onebyone,whenit
isnished,itshouldlooklikeFigures6&7.
SecuretheElasticToggle(H)totheTopRailsasshownin
Figures8–12.

8
S001961 4.5ft Trampoline
AssemblyInstructions(cont)
WhentheElasticToggleshavebeenproperlyconnected,
thetrampolineshouldlooklikeFigure13.
Frame Pad and Skirting Assembly
PlacetheFramePad(E)onthetopofthetrampolineas
showninFigure14.Straightenandadjustthehangover
ofthepad.Bringthebungeestrapwithcliparoundthe
outside of the frame and under the pad. Pull the bungee
strapandcliptothepre-sewnloop.SeeFigures15&16.
Attachtheskirting(G)tothebottomofthetrampolineand
securewithScrew(K).SeeFigures17&18.
Whenthescrewshavebeenproperlyscrewedinthe
trampolineshouldlooklikeFigure19.

9
S001961 4.5ft Trampoline
AssemblyInstructions(cont)
Pole Assembly
AttachtheUpperEnclosurePoles(H)andtheLower
EnclosurePoles(I)whichhavebothbeen
pre-assembledwithfoam;andsecurewithScrew(K).
SeeFigure20.
InserteachassembledEnclosurePoletoeveryT-Joint
(B)ofthetrampolineinanuprightposition;andfasten
withScrew(K).SeeFigures21&22.
Net Assembly
RaisethenetandattachtheNettothetopofeachEnclosurePole,aligntheholeandfastenwiththe
Screw(K).SeeFigures23&24.

10
S001961 4.5ft Trampoline
Thereisarowofsewn-inhookandlooptapes,twohookandlooptapesinline.Attachthesehook
andlooptapessecurelytoeachofthepoles.Adjustthenettomakesurethehookandlooptapesare
securely fastened.
The panel with a zipper doorway should be located in the place where it is easiest to get in and out of
thetrampoline.SeeFigures25&26.
Inspect the whole trampoline to make sure all the loops, hooks and loop tapes and elastic straps are
securelyattached.Checkthattheenclosureispositionedevenlyaroundthetrampolineandthatitis
not under strain on any particular one point.
IMPORTANT: When assembled, the padding should lie at on the trampoline bed with the net
tucked underneath.
Thereisaplasticwarningplacardenclosedwiththeenclosurepackage.Permanentlyafxthiswarning
placardtoanenclosurepolenexttotheentranceofthetrampolinesothatitisclearlyvisible.
AssemblyInstructions(cont)

11
S001961 4.5ft Trampoline
WarrantyInformation
Congratulations on your purchase!
This 138cm (4.5ft) Trampoline is warranted to be free from defects in material and workmanship under
normaluseandserviceconditionsforaperiodof2 years on the frame and mat, 12 months on all
otherparts,fromthedateofpurchaseofthisarticle.Evidenceofunfairusageorincorrectadjustment
bytheownerwillvoidthispromise.
OurgoodscomewithguaranteesthatcannotbeexcludedundertheAustralianConsumerLaw.Youare
entitled to a replacement or refund for a major failure and for compensation for any other reasonably
foreseeablelossordamage.Youarealsoentitledtohavethegoodsrepairedorreplacedifthegoods
failtobeofacceptablequalityandthefailuredoesnotamounttoamajorfailure.
Thebenetsconferredbythiswarrantyareinadditiontotheconsumerguaranteesandotherrights
andremediesinrespectoftheproductwhichtheconsumerhasundertheAustralianConsumerlaw.
Conditions of Warranty
Allwarrantycoverageextendsonlytotheoriginalretailpurchaserfromthedateofpurchase.Please
keepyourreceipt,taxinvoiceorotherproofofpurchase.
This warranty does not extend to any damage to a product caused by abuse, improper or abnormal
usage,orrepairsnotprovidedbyusorourServiceCentre.Nordoesthiswarrantyextendtoproducts
usedforcommercialorrentalpurposes.Thiswarrantydoesnotcoverordinarywear,tearand
weathering, failure to follow directions, improper installation, improper maintenance or acts of God
(suchasdamagecausedbystorms,lightning,heavywindsandbysnoworice).
Making A Warranty Claim
InordertomakeaclaimunderthiswarrantypleasedirectyourenquiriestoourServiceCentre.Youcan
contact them on our Freecall 1800 465 070numberorsendmailtothematNationalServiceCentre:
2/24AndersonRoad,SmeatonGrange,NSW2567–ifmailingpleaseincludeyourcontactdetails.
Aservicerepresentativewillthenassistyouintheappropriateactiontobetaken.Forefcient
processingofyourenquirypleasehaveproofofpurchase,thedateofpurchaseandtheretailername
you purchased the item from, and the brand on the product. Photos of the product, and scans of
receipts,mayberequestedtoassistwithyourclaim.

12
S001961 4.5ft Trampoline
WarrantyInformation(cont)
Theservicecentrerepresentativewillassesstheclaim.If:
1)there is a minor fault, they can offer either a replacement spare part, replacement unit, repair or
other suitable remedy.
2) there is a major fault, they can offer a replacement, repair or suggest you return to the store you
purchased it from for a full refund.
Please note: arequestforcompensationwillneeddocumentaryevidenceofthelossordamage
suffered.Itwillalsoneedtobeevidencedthatsuchalosswasareasonablyforeseeableresultof
afailuretocomplywithaconsumerguaranteeundertheAustralianConsumerLaw.
3) The product was damaged through abnormal use, no refund or repair can be offered.
The sending of replacements, spare parts or the cost of repair carried out will be organized and
coveredbytheServiceCentre.IfcollectionoftheitemisrequiredthiswillbeorganizedbytheService
Centre and at our expense. Do not return any products without authorization as this will be at your
expense.
Oursalesandservicecentrehasbeensetuptoprovideassemblyassistance,replacementpartsand
accessories,andtoefcientlyhandleallwarrantyrelatedmatters.Pleasenoteuponreceivingyour
warrantyclaimourServiceCentrewillsend,viapostoremail,arepairandrefurbishedgoodsorparts
notice.
SERVICE CENTRE
Contact details and hours of operation.
Freecall 1800 465 070
9:00am–4:30pmMondaytoFriday(excludingPublicHolidays)
9:00am–3:00pmSaturday
This product is warranted and distributed by:
Action Sports of 48B Egerton St, Silverwater NSW, 2128
Phone: [phone]
©2017ActionSportsEquipmentPtyLtd.