Aerobics AERO CURE ONE Series User manual

1
AERO CURE ONE™ Series
User Manual
Made in USA
from US and Int’l Components

2
IMPORTANT SAFETY INFORMATION
About this User Manual
Congratulations on your purchase of this Aerobiotix high-performance air purification and
disinfection system. Please study this user manual carefully to familiarize yourself with the
special features and functions of your system prior to use and keep it in a safe place for future
reference.
WARNING: NOT SUITABLE FOR USE WITH SOLID-STATE SPEED CONTROLS
AVERTISSEMENT : NE CONVIENT PAS A DES REGULATEURS DE VITESSEA SEMI-CONDUCTEURS.
The following symbols may be found in your user’s manual or on labels affixed to the unit itself:
Note This means pay particular attention. Notes contain helpful suggestions.
Caution This symbol means be careful. You are capable of
doing something that might result in injury, death, or damage to equipment.
Warning this symbol means UV Radiation. You could be exposed to UV Radiation that
could cause eye or skin injuries.
General Cautions & Electrical Safety
Always disconnect the power from this air cleaner by unplugging the power cord before
adding or removing parts and before cleaning.
Do not use the unit in wet environments. If for any reason the unit gets moisture of any
kind inside stop use and contact customer service.
Do not operate in the presence of flammable gasses, liquids or anesthetics.
The unit must NOT be used for the abatement of asbestos or other hazardous materials.
Shock and mechanical hazard: Be certain to unplug the unit before performing any
service or opening the cabinet.
Prior to changing the filters be sure to turn the unit off, then unplug the power cord.
Do not operate the unit with the filters removed.

3
IMPORTANT SAFETY INFORMATION (CONT’D)
Do not operate the unit with the front cover removed.
Do not stick any objects in any of the vent holes on the machine.
Do not exceed the power rating of the unit, may damage or destroy unit.
Do not use adapters or extension cords.
Do not use this air cleaner as sole protection against harmful pollutants.
Do not operate this air cleaner if it has a damaged cord or plug, if the motor fan fails to
rotate, if it is not working properly, if it has been dropped or damaged, or dropped into
water.
Only use this unit for its intended purpose of air cleaning in non-industrial
environments.
Do not use this unit in areas with very high concentrations of dust or powder to prevent
the danger of dust explosions.
Do not use attachments or filters not recommended/provided by Aerobiotix.
Do not use outdoors.
Do not obstruct the air inlet and air outlet of the air cleaner.
Do not place the unit on a soft surface such as a bed or other soft furnishings.
Only use this air cleaner in an upright position.
Do not place next to a humidifier.
Keep the power cord away from heated surfaces.
Do not stack heavy objects on the power cord; this may result in electric shock or fire.
Turn the power switch to off before unplugging the power cord.
Do not stack items on top of the unit.
Prior to moving make sure the power cord is unplugged. If only moving a short distance
ensure that there is enough cord length to make the move.
Disconnect the power immediately if strange sounds, smell or smoke comes from the
unit.

4
IMPORTANT SAFETY INFORMATION (CONT’D)
Use only on correctly grounded circuits.
Never tip the unit as severe injury may result.
Do not allow children or others climb or sit on unit. Falling of the unit can result in
injury.
Do not use in the unit in a window
UV Lamps, like all fluorescent lamps, contain mercury and must be handled and
disposed of properly. Refer to http://www.epa.gov/wastes/hazard/wastetypes/universal/lamps/recycle.htm
for additional information on how to dispose or recycle lamps.
ULTRAVIOLET WARNING
The AERO CURE ONE contains two 16 watt ultraviolet lamps. The lamps are designed to
disinfect the airstream from viruses, molds, and bacteria. The lamps automatically turn on
when the unit is turned on. NEVER OPERATE THE AERO ONE UNIT WITHOUT THE FRONT
COVER IN PLACE, WITH THE CABINET DAMAGED, OR WITHOUT FILTERS IN PLACE.
PROLONGED EXPOSURE TO ULTRAVIOLET RAYS CAN RESULT IN SKIN OR EYE IRRITATION.
You may notice a soft blue glow from the upper and lower grilles of unit in dark
environments. This is normal, and this blue light does not contain ultraviolet rays. Significant
ultraviolet exposure can result from DIRECT exposure to the UV lamps themselves.

5
TABLE OF CONTENTS
SAFETY INFORMATION 2
OVERVIEW OF AIR QUALITY 6
UNPACKING 6
INSTALLATION 7
OPERATION 7
MAINTENANCE 8
WARRANTY & OTHER INFORMATION 11
Aerobiotix, Inc. reserves the right to change specifications contained in this document at any
time without prior notice. If you have questions about the use of this product, contact your
customer service representative. Refer to the Customer Support section located in this guide.
Model Aero Cure One User’s Manual, Version C (10/15)
© 2014 Aerobiotix, Inc. All rights reserved. Patents pending.

6
OVERVIEW OF INDOOR AIR QUALITY
The AERO CURE ONE ™ system is designed to remove contaminants from the air using a carbon
pleated prefilter and a true HEPA post-filter. Additionally, the system includes an ultraviolet
disinfection system to deactivate microbes from the air. The unit treats approximately 200
cubic feet of air per minute.
In order to get the best performance from your system, certain factors should be considered:
•The larger the room, the more time it will take for the unit to complete a full delivery
cycle of treated air.
•The sources of air contamination should be considered and reduced as much as
possible.
•Ventilation is important to air quality, and a source of fresh air for the room should be
available.
•As the unit filters become saturated, soiled or obstructed, the treatment efficiency will
decrease. In unusually dirty or dusty environments, filter changes will need to be
performed more frequently.
UNPACKING YOUR UNIT
Upon shipping, the unit and packaging has been inspected and approved. Follow the step by
step instructions to safely remove the unit.
Do not tip the box on place on its side. Make certain that the box is sitting according to the
“this end up” labels that are placed on the box.
Do not try to lift the unit out of the box. This may result in personal injury and or damage
to the unit.
•Open the top of the box and remove packaging around the top of the unit.
•Carefully cut down two sides of the box until it is completely flat.
•Carefully lift the unit out of the bottom packaging.
•Remove the sealed plastic bag from the unit and discard.
•Your unit is ready for installation.

7
INSTALLATION
The choice of location for your Aero Cure One™ unit is a key factor to its performance. You
should place the unit in the room in which you want to focus you air treatment strategy.
Additionally, the unit should be placed as close as possible to any obvious sources of room air
contamination. Additional tips:
•Place the unit so that it is not obstructed by furniture or other items
•Place the power cord so that is not a tripping hazard
•Place the unit as close to the center of the room as practical
•Place the unit away from areas where it is likely to get wet, or objects can be
inadvertently placed on top of it.
The unit plugs into a standard 120 volt AC grounded receptacle.
Never attempt to plug the unit into an ungrounded receptacle. This could result in electric
shock, injury or death.
OPERATION
The Aero Cure One™ unit is designed to have the simplest possible operation.
The ON/OFF switch is located on the right side of the unit. The unit has been engineered to
operate at one predetermined speed for maximal efficiency of air disinfection. Below the power
switch is an indicator light which indicates that the ultraviolet lamps are working properly. If
this indicator light fails to illuminate, but the fan of the unit is running, this indicates that the
UV lamps need to be replaced. Contact customer service for authorized replacement lamps. To
the right of the switch you will see the filter life display screen. When the unit is powered on
the screen will illuminate and show the current filter life, starting with one hundred percent
and counting down to zero. When filter life hits zero the display will flash the message replace
filter, until the filter reset button has been pressed.

8
MAINTENANCE
In order to replace the AeroCure’s filters, lamps, and reset the filter display the front cover of
the device needs to be removed. This is performed by removing six Philips-head screws from
the front and top of the unit. The prefilter is mounted to the rear of the front cover and the
HEPA filter is mounted at the top of the unit. The filter reset button for the display screen is
located directly behind the screen on the inside of the unit, so you must remove the cover to
reset the filter. Once the cover is removed turn the unit on, there is a limit installed that will
only allow power to the filter life screen when the cover is removed ( If the motor or lamps
power on turn the unit off immediately and call customer support). Press and hold down the
small black button located at the far left (when looking at the screen from the inside), until the
screen flashes and resets back to filter life one hundred percent, it may take a few seconds for
the screen to reset.
CAUTION- Unplug the unit prior to removing the front cover. Failure to do so may result in
electrical shock, ultraviolet exposure, injury or death.
MAINTENANCE SCHEDULE
HEPA and Prefilter Filter life display screen will indicate when filters need changed.
When filter life hits zero, both filters will need replaced.
Change sooner if significant filter soiling or reduced airflow.
UV Lamps Every 8000 hours or every 2 years.
Sooner if indicator lamp fails to illuminate
CAUTION: Use only genuine Aerobiotix® Aero Cure One ™ replacement filters and lamps to ensure
proper filter fitment and function of your unit. Failure to use specified products voids warranty.

9
FILTER REPLACEMENT
HEPA
FILTER
PREFILTER
UV LAMPS
LIFT HEPA FILTER
UPWARD TO
REMOVE
LIFT PREFILTER
UPWARD TO
REMOVE

10
UV LAMP REPLACEMENT
UV EXPOSURE WARNING! Confirm that the unit is unplugged before attempting to
replace the UV lamps, and confirm that unit is completely re-assembled with all filters in
place before powering the unit back up.
Gently remove four prong plug from each lamp (plug wires not pictured).
Gently slide each lamp downward from retaining clips and slide forwards to release. Use caution
not to hit the lamp against the metal housing, as this may cause breakage. UV Lamps, like all
fluorescent lamps, contain mercury and must be handled and disposed of properly. Refer to
http://www.epa.gov/wastes/hazard/wastetypes/universal/lamps/recycle.htm for additional
information on how to dispose or recycle lamps. Installation of lamps is reverse of removal.

11
ADDITIONAL INFORMATION
DISCARDING USED FILTERS
Used filters can normally be put into the regular household trash for disposal. If the system may have been
exposed to potentially hazardous substances, the filters may have to be disposed of as hazardous waste. Please
refer to local regulations and laws for proper handling and disposal.
OZONE GENERATION
The Aero Cure One™ system is certified ozone-free by the California Air Resources Board (CARB).
BLOWER AND BLOWER MOTOR
The blower and blower motor are maintenance free and should last the lifetime of the unit. If a malfunction of the
blower or motor occur, contact customer service at the numbers below.
CUSTOMER SUPPORT
Call Aerobiotix, Inc. Monday through Friday 9AM to 5 PM ET at 888-978-7087. If your call is made after business
hours or on weekends, please leave your name, telephone number, and a brief description of the problem. A
representative will call back at the earliest opportunity
WARRANTY INFORMATION
Aerobiotix, Inc. warrants this product to be free from defects in material, manufacture and design for a period of
five years. If this product is defective in materials, manufacture or design during this warranty period, Aerobiotix,
Inc. will, at its option, repair or replace the product. Repair parts and /or replacement products may be either new
or reconditioned at Aerobiotix' discretion. This limited warranty does not include service to repair damage from
improper installation, improper connections with external electrical fault, accident, disaster, misuse, abuse or
modifications to the product not approved in writing by Aerobiotix, Inc. Any service repair outside the scope of this
limited warranty shall be at applicable rates and terms then in effect.
All other express and implied warranties for this product including the warranties of merchantability and fitness for
a particular purpose are hereby disclaimed. Some states do not allow the exclusion of implied warranties or
limitations on how long an implied warranty lasts, so the above limitation may not apply to you.
If this product is not as warranted above, your sole and exclusive remedy shall be repair or replacement as
provided above. In no event will Aerobiotix, Inc., or any of its authorized sales and service representatives be liable
to the customer or any third party for any damages in excess of the purchase price of the product. This limitation
applies to damages of any kind including any direct or indirect damages, lost profits, lost saving or other special,
incidental, exemplary or consequential damages whether for breach of contract, tort or otherwise or whether
arising out of the use of or inability to use the product, even if Aerobiotix, Inc. or an authorized Aerobiotix, Inc.
representative or distributor has been advised of the possibility of such damages or of any claim by any other
party. Some states do not allow the exclusion or limitation of incidental damages for some products, so the above
limitation or exclusion may not apply to you.
This warranty gives you specific legal rights, and you may also have other rights which may vary from state to state.