Art RM5 User manual

Printed in Canada
SERVICE MANUAL
RM5
SMT Disclaimer
Due to the complex nature of the use of SMT installed components
in Yorkville equipment, we highly caution all service technicians in
attempting to repair or replace SMT factory installed components.
Many of these components may be glued prior to initial soldering.
Replacing SMT components requires expensive
specialized de-soldering equipment and training.
Yorkville Sound will repair and replace defective SMT components
to ensure proper quality assurance and installation is maintained.
Printed in Canada
www.artproaudio.com
E-mail: [email protected]
© 2016 Applied Research & Technology • Yorkville Sound
APPLIED RESEARCH AND TECHNOLOGY
0DQXDO6HUYLFH$5750YÜ2FW

AUX IN INPUTS
XLR /
Phone
Stereo
LeftRight
TO LEFT
SPEAKER
1/4
Space Full Space
1/2 Space
APPLIED RESEARCH AND TECHNOLOGY
R
DESIGNED & MANUFACTURED BY
YORKVILLE SOUND • TORONTO, CANADA
DISCONNECT POWER BEFORE SERVICING!
DEBRANCHER L’APPEREIL AVANT D’ENLEVER LES COUVERCLES!
AC TO LEFT
SPEAKER
RM5 A-Z1396 / 2v0
230V
50Hz
0,6A
120VAC
60Hz 1.2A
Contains Transmitter Module FCC ID: A8TBM23SPKXYC2A
This device complies with Part 15 of the FCC Rules.
Operation is subject to the following two conditions: (1) this
device may not cause harmful interference, and (2) this
device must accept any interference received, including
interference that may cause undesired operation.
Pairing: Hold four seconds
On/Off: Single Press
RM5
Hi Fi
Theatre
Ref.
APPLIED RESEARCH AND TECHNOLOGY
FROM RIGHT
SPEAKER
L
RM5

88
SPECIFICATIONS
System Type Active 2-Way Stereo
Program Power (Watts) 300 W
Max SPL (dB) 109
Frequency Response (Hz +/- 3dB) 45-22,000
Crossover Frequency (Hz) 2200
HF Driver(s) High Resolution Ring Radiator
Center Plug to Improve Off Axis Response
HF Program Power (Watts) 25W (x 2)
refoowetisopmoCxaM-XhgiHhcni-5)s(revirDFL
LF Program Power (Watts) 125W (x 2)
LF Protection Thermal / Peak (X-max)
Inputs 2 x XLR & ¼-inch TRS Balanced Combi-Jacks (Left/Right),
Stereo 1/8-inch TRS Jack / Bluetooth™ Wireless Streaming
Mode Controls Reference, HiFi, and Theatre Room Compensation
1/4 Space, 1/2 Space and Full Space
Level Controls Master Level
Cabinet Material Aluminum Unibody Design
Power Supply USA – 105 to 125 VAC /60HZ
noitanitsedfoyrtnuocrofderugifnocerastinutropxE
Bass Principal Dual Opposing Passive Radiator
Dimensions (H, W, D) 12.4-inch x 7.6-inch x 3.6-inch each speaker
rekaepshcaemm9xmm91xmm13
)riaP(gk9/
sbl02thgieW
ART maintains a policy of constant product improvement. ART reserves the right to make changes in design,
or make additions to, or improvements upon, this product without any obligation to install same on products
previously manufactured. Therefore, specifications are subject tochange without notice.

Pre Amp
Sleeper
Timer
Amp
Mute
Biamp Biamp
RIGHT RM5
Level
BluetoothTM
BluetoothTM
Power
ADC
DSP Control
Processor
AUX IN
INPUTS
XLR /
Phone
Stereo
Theatre
Reference
Hi Fi
1/4 Space
Full Space
1/2 Space
L
R
L
R
LR
RL

M1494 03 Parts Reference List 10/22/2020
REF YS # Description REF YS # Description REF YS # Description REF YS # Description REF YS # Description
AI-ASS M1494-59 RM5 POWER AMP PCB Q3 7837 MMBT5401 PNP SOT-23 SMT R153A 7628 W100 15K0 1% 0805 SMT RES U8A 7817 33078 DUAL OPAMP SMT SO-8
C1A 7799 __5N6 50V 5%CAP 0805 SMT C0G Q4 7014 MJD127 PNP DARL DPAK3 SMT R153B 7628 W100 15K0 1% 0805 SMT RES U8B 7817 33078 DUAL OPAMP SMT SO-8
C1B 7799 __5N6 50V 5%CAP 0805 SMT C0G Q21A 7015 MJD122 NPN DARL DPAK3 SMT R156A 7628 W100 15K0 1% 0805 SMT RES U23A 7817 33078 DUAL OPAMP SMT SO-8
C2A 7799 __5N6 50V 5%CAP 0805 SMT C0G Q21B 7015 MJD122 NPN DARL DPAK3 SMT R156B 7628 W100 15K0 1% 0805 SMT RES U23B 7817 33078 DUAL OPAMP SMT SO-8
C2B 7799 __5N6 50V 5%CAP 0805 SMT C0G Q23A 8022 MMBTA64LT1G PNP DARL SOT-23 SMT R162A 7854 W125 47R 5% 0805 SMT RES W1 7883 26 PIN 25SQ 100 PIN SIL SMT
C3A 7693 __1N 50V 5%CAP 0805 SMT NPO Q23B 8022 MMBTA64LT1G PNP DARL SOT-23 SMT R162B 7854 W125 47R 5% 0805 SMT RES ZD1A 7830 MM3Z12VT1G 12V0 0W2 5% SMT ZEN
C3B 7693 __1N 50V 5%CAP 0805 SMT NPO Q24A 7806 MMBF4391LT1 NCH JFET SOT-23 SMT T&R R166A 7621 W100 1K0 1% 0805 SMT RES ZD1B 7830 MM3Z12VT1G 12V0 0W2 5% SMT ZEN
C4A 7780 _10U 16V 20%CAP SMT ELC Q24B 7806 MMBF4391LT1 NCH JFET SOT-23 SMT T&R R166B 7621 W100 1K0 1% 0805 SMT RES ZD2A 7830 MM3Z12VT1G 12V0 0W2 5% SMT ZEN
C4B 7780 _10U 16V 20%CAP SMT ELC Q25A 7014 MJD127 PNP DARL DPAK3 SMT R190A 8213 W250 330R 5% 1206 SMT RES ZD2B 7830 MM3Z12VT1G 12V0 0W2 5% SMT ZEN
C5 7879 __1U 50V 20%CAP 3.3MM SMT ELE Q25B 7014 MJD127 PNP DARL DPAK3 SMT R190B 8213 W250 330R 5% 1206 SMT RES ZD3A 7831 MM3Z15VT1G 15V0 0W2 5% SMT ZEN
C6A 7693 __1N 50V 5%CAP 0805 SMT NPO Q26A 7840 IRF530NS NCH MFET D2PAK SMT TS R196A 8213 W250 330R 5% 1206 SMT RES ZD3B 7831 MM3Z15VT1G 15V0 0W2 5% SMT ZEN
C6B 7693 __1N 50V 5%CAP 0805 SMT NPO Q26B 7840 IRF530NS NCH MFET D2PAK SMT TS R196B 8213 W250 330R 5% 1206 SMT RES ZD4A 7830 MM3Z12VT1G 12V0 0W2 5% SMT ZEN
C7 7879 __1U 50V 20%CAP 3.3MM SMT ELE Q27A 7015 MJD122 NPN DARL DPAK3 SMT R197A 7854 W125 47R 5% 0805 SMT RES ZD4B 7830 MM3Z12VT1G 12V0 0W2 5% SMT ZEN
C38A 8510 220U 16V 20%CAP 8X6.5 SMT ELE Q27B 7015 MJD122 NPN DARL DPAK3 SMT R197B 7854 W125 47R 5% 0805 SMT RES ZD5A 7831 MM3Z15VT1G 15V0 0W2 5% SMT ZEN
C38B 8510 220U 16V 20%CAP 8X6.5 SMT ELE Q28A 7015 MJD122 NPN DARL DPAK3 SMT R199A 8213 W250 330R 5% 1206 SMT RES ZD5B 7831 MM3Z15VT1G 15V0 0W2 5% SMT ZEN
C49A 5979 100N 50V 5%CAP 0805 SMT X7R Q28B 7015 MJD122 NPN DARL DPAK3 SMT R199B 8213 W250 330R 5% 1206 SMT RES ZD6A 7831 MM3Z15VT1G 15V0 0W2 5% SMT ZEN
C49B 5979 100N 50V 5%CAP 0805 SMT X7R Q29A 8022 MMBTA64LT1G PNP DARL SOT-23 SMT R200A 8213 W250 330R 5% 1206 SMT RES ZD6B 7831 MM3Z15VT1G 15V0 0W2 5% SMT ZEN
C50A 7693 __1N 50V 5%CAP 0805 SMT NPO Q29B 8022 MMBTA64LT1G PNP DARL SOT-23 SMT R200B 8213 W250 330R 5% 1206 SMT RES
C50B 7693 __1N 50V 5%CAP 0805 SMT NPO Q30A 7806 MMBF4391LT1 NCH JFET SOT-23 SMT T&R R223A 7624 W100 100R 1% 0805 SMT RES
C51A 8510 220U 16V 20%CAP 8X6.5 SMT ELE Q30B 7806 MMBF4391LT1 NCH JFET SOT-23 SMT T&R R223B 7624 W100 100R 1% 0805 SMT RES
C51B 8510 220U 16V 20%CAP 8X6.5 SMT ELE Q31A 7014 MJD127 PNP DARL DPAK3 SMT R224A 7633 W100 2K74 1% 0805 SMT RES
C52A 7693 __1N 50V 5%CAP 0805 SMT NPO Q31B 7014 MJD127 PNP DARL DPAK3 SMT R224B 7633 W100 2K74 1% 0805 SMT RES
C52B
7693 __1N 50V 5%CAP 0805 SMT NPO Q32A 7014 MJD127 PNP DARL DPAK3 SMT R225A 7854 W125 47R 5% 0805 SMT RES
C53A
8143 _27P 50V 5%CAP 0805 SMT NPO Q32B 7014 MJD127 PNP DARL DPAK3 SMT R225B 7854 W125 47R 5% 0805 SMT RES
C53B 8143 _27P 50V 5%CAP 0805 SMT NPO Q33A 7839 IRF9530NS PCH MFET D2PAK SMT TS R226A 8192 W125 5K76 1% 0805 SMT RES
C59A 7799 __5N6 50V 5%CAP 0805 SMT C0G Q33B 7839 IRF9530NS PCH MFET D2PAK SMT TS R226B 8192 W125 5K76 1% 0805 SMT RES
C59B 7799 __5N6 50V 5%CAP 0805 SMT C0G R1A 7854 W125 47R 5% 0805 SMT RES R227A 7900 W125 30K 0.5% 0805 SMT RES
C60A 7780 _10U 16V 20%CAP SMT ELC R1B 7854 W125 47R 5% 0805 SMT RES R227B 7900 W125 30K 0.5% 0805 SMT RES
C60B 7780 _10U 16V 20%CAP SMT ELC R2A 7854 W125 47R 5% 0805 SMT RES R228A 7821 W125 10R0 1% 0805 SMT RES
C62A 7927 100P 50V 10%CAP 0805 SMT NPO R2B 7854 W125 47R 5% 0805 SMT RES R228B 7821 W125 10R0 1% 0805 SMT RES
C62B 7927 100P 50V 10%CAP 0805 SMT NPO R3 7821 W125 10R0 1% 0805 SMT RES R229A 7923 W333 33R 5% 1210 SMT RES
C64A 7780 _10U 16V 20%CAP SMT ELC R4 7709 W100 301R 1% 0805 SMT RES R229B 7923 W333 33R 5% 1210 SMT RES
C64B 7780 _10U 16V 20%CAP SMT ELC R5 7628 W100 15K0 1% 0805 SMT RES R230A 7854 W125 47R 5% 0805 SMT RES
C65A 7693 __1N 50V 5%CAP 0805 SMT NPO R6A 7882 W250 0R 1206 SMT RES R230B 7854 W125 47R 5% 0805 SMT RES
C65B 7693 __1N 50V 5%CAP 0805 SMT NPO R6B 7882 W250 0R 1206 SMT RES R231A 7859 W125 2K2 5% 0805 SMT RES
C66A 8510 220U 16V 20%CAP 8X6.5 SMT ELE R7 7821 W125 10R0 1% 0805 SMT RES R231B 7859 W125 2K2 5% 0805 SMT RES
C66B 8510 220U 16V 20%CAP 8X6.5 SMT ELE R8 7709 W100 301R 1% 0805 SMT RES R232A 8192 W125 5K76 1% 0805 SMT RES
C67A 5979 100N 50V 5%CAP 0805 SMT X7R R9 7628 W100 15K0 1% 0805 SMT RES R232B 8192 W125 5K76 1% 0805 SMT RES
C67B 5979 100N 50V 5%CAP 0805 SMT X7R R10 7821 W125 10R0 1% 0805 SMT RES R233A 7868 1W00 0R047 5% 2512 SMT RES
C68A 7693 __1N 50V 5%CAP 0805 SMT NPO R11A 7821 W125 10R0 1% 0805 SMT RES R233B 7868 1W00 0R047 5% 2512 SMT RES
C68B 7693 __1N 50V 5%CAP 0805 SMT NPO R11B 7821 W125 10R0 1% 0805 SMT RES R234A 7868 1W00 0R047 5% 2512 SMT RES
C69A 7748 _47P 100V 5%CAP 0805 SMT NPO R12 7821 W125 10R0 1% 0805 SMT RES R234B 7868 1W00 0R047 5% 2512 SMT RES
C69B 7748 _47P 100V 5%CAP 0805 SMT NPO R13A 5084 W125 33R 5% 0805 SMT RES R235A 7900 W125 30K 0.5% 0805 SMT RES
C70A 7693 __1N 50V 5%CAP 0805 SMT NPO R13B 5084 W125 33R 5% 0805 SMT RES R235B 7900 W125 30K 0.5% 0805 SMT RES
C70B 7693 __1N 50V 5%CAP 0805 SMT NPO R45A 7854 W125 47R 5% 0805 SMT RES R236A 7868 1W00 0R047 5% 2512 SMT RES
C71A
7780 _10U 16V 20%CAP SMT ELC R45B 7854 W125 47R 5% 0805 SMT RES R236B 7868 1W00 0R047 5% 2512 SMT RES
C71B
7780 _10U 16V 20%CAP SMT ELC R46A 8213 W250 330R 5% 1206 SMT RES R237A 7868 1W00 0R047 5% 2512 SMT RES
C72A
8510 220U 16V 20%CAP 8X6.5 SMT ELE R46B 8213 W250 330R 5% 1206 SMT RES R237B 7868 1W00 0R047 5% 2512 SMT RES
C72B
8510 220U 16V 20%CAP 8X6.5 SMT ELE R47A 8213 W250 330R 5% 1206 SMT RES R240A 7628 W100 15K0 1% 0805 SMT RES
C95A
7602 330P 50V 5%CAP 0805 SMT NPO R47B 8213 W250 330R 5% 1206 SMT RES R240B 7628 W100 15K0 1% 0805 SMT RES
C95B
7602 330P 50V 5%CAP 0805 SMT NPO R48A 7854 W125 47R 5% 0805 SMT RES R242A 5088 W125 49K9 1% 0805 SMT RES
D1
7830 MM3Z12VT1G 12V0 0W2 5% SMT ZEN R48B 7854 W125 47R 5% 0805 SMT RES R242B 5088 W125 49K9 1% 0805 SMT RES
D2
7830 MM3Z12VT1G 12V0 0W2 5% SMT ZEN R64A 7633 W100 2K74 1% 0805 SMT RES R243A 7856 W125 470R 5% 0805 SMT RES
D24A
7984 BAS21L 250V 200MA SOT23 SMT R64B 7633 W100 2K74 1% 0805 SMT RES R243B 7856 W125 470R 5% 0805 SMT RES
D24B
7984 BAS21L 250V 200MA SOT23 SMT R98A 7821 W125 10R0 1% 0805 SMT RES R244A 7821 W125 10R0 1% 0805 SMT RES
D30A
7750 CDSF4148 75V 0A15 1005 SMT R98B 7821 W125 10R0 1% 0805 SMT RES R244B 7821 W125 10R0 1% 0805 SMT RES
D30B
7750 CDSF4148 75V 0A15 1005 SMT R99A 7923 W333 33R 5% 1210 SMT RES R245A 7923 W333 33R 5% 1210 SMT RES
D32A
7984 BAS21L 250V 200MA SOT23 SMT R99B 7923 W333 33R 5% 1210 SMT RES R245B 7923 W333 33R 5% 1210 SMT RES
D32B
7984 BAS21L 250V 200MA SOT23 SMT R102A 7900 W125 30K 0.5% 0805 SMT RES R246A 7621 W100 1K0 1% 0805 SMT RES
D33A
7984 BAS21L 250V 200MA SOT23 SMT R102B 7900 W125 30K 0.5% 0805 SMT RES R246B 7621 W100 1K0 1% 0805 SMT RES
D33B 7984 BAS21L 250V 200MA SOT23 SMT R114A 7709 W100 301R 1% 0805 SMT RES R247A 7854 W125 47R 5% 0805 SMT RES
D34A 7984 BAS21L 250V 200MA SOT23 SMT R114B 7709 W100 301R 1% 0805 SMT RES R247B 7854 W125 47R 5% 0805 SMT RES
D34B 7984 BAS21L 250V 200MA SOT23 SMT R115A 7868 1W00 0R047 5% 2512 SMT RES R248A 7628 W100 15K0 1% 0805 SMT RES
D35A 7848 MURA240T3 400V 2A DIO 403D SMT R115B 7868 1W00 0R047 5% 2512 SMT RES R248B 7628 W100 15K0 1% 0805 SMT RES
D35B 7848 MURA240T3 400V 2A DIO 403D SMT R116A 7900 W125 30K 0.5% 0805 SMT RES R249A 7854 W125 47R 5% 0805 SMT RES
D37A 7848 MURA240T3 400V 2A DIO 403D SMT R116B 7900 W125 30K 0.5% 0805 SMT RES R249B 7854 W125 47R 5% 0805 SMT RES
D37B 7848 MURA240T3 400V 2A DIO 403D SMT R118A 7859 W125 2K2 5% 0805 SMT RES R250A 8213 W250 330R 5% 1206 SMT RES
D38A 7750 CDSF4148 75V 0A15 1005 SMT R118B 7859 W125 2K2 5% 0805 SMT RES R250B 8213 W250 330R 5% 1206 SMT RES
D38B 7750 CDSF4148 75V 0A15 1005 SMT R119A 8192 W125 5K76 1% 0805 SMT RES R251A 8213 W250 330R 5% 1206 SMT RES
D41A 7984 BAS21L 250V 200MA SOT23 SMT R119B 8192 W125 5K76 1% 0805 SMT RES R251B 8213 W250 330R 5% 1206 SMT RES
D41B
7984 BAS21L 250V 200MA SOT23 SMT R141A 7868 1W00 0R047 5% 2512 SMT RES R252A 7624 W100 100R 1% 0805 SMT RES
D42A
7984 BAS21L 250V 200MA SOT23 SMT R141B 7868 1W00 0R047 5% 2512 SMT RES R252B 7624 W100 100R 1% 0805 SMT RES
D42B
7984 BAS21L 250V 200MA SOT23 SMT R143A 7856 W125 470R 5% 0805 SMT RES TP1A 8002 TEST POINT MINIATURE SMT
P2A
4512 _10K 25% ACP KAP TRIM POT SMT T&R R143B 7856 W125 470R 5% 0805 SMT RES TP1B 8002 TEST POINT MINIATURE SMT
P2B
4512 _10K 25% ACP KAP TRIM POT SMT T&R R144A 5088 W125 49K9 1% 0805 SMT RES TP2A 8002 TEST POINT MINIATURE SMT
P3A
4512 _10K 25% ACP KAP TRIM POT SMT T&R R144B 5088 W125 49K9 1% 0805 SMT RES TP2B 8002 TEST POINT MINIATURE SMT
P3B
4512 _10K 25% ACP KAP TRIM POT SMT T&R R145A 7821 W125 10R0 1% 0805 SMT RES TP3A 8002 TEST POINT MINIATURE SMT
PCB
M1494BLANK 2_OZ 1SD 77.44SQIN 06PER 1.5MM ALUM R145B 7821 W125 10R0 1% 0805 SMT RES TP3B 8002 TEST POINT MINIATURE SMT
Q1
7015 MJD122 NPN DARL DPAK3 SMT R146A 7923 W333 33R 5% 1210 SMT RES TP4A 8002 TEST POINT MINIATURE SMT
Q2
7838 MMBT3904 NPN SOT-23 SMT R146B 7923 W333 33R 5% 1210 SMT RES TP4B 8002 TEST POINT MINIATURE SMT

M1705 02 Parts Reference List 10/22/2020
REF YS # Description REF YS # Description REF YS # Description REF YS # Description REF YS # Description
AI-ASS
M1705-59 RM5 POWER AMP, SUPPLY, INPUT PCB~ C112 7871 470P 50V 5%CAP 0603 SMT NPO R24 7624 W100 100R 1% 0805 SMT RES R118 8135 W125 47K 5% 0805 SMT RES
C1
7916 _10U 25V 20%CAP 5X5.4 SMT EL C117 8139 _22U 25V 20%CAP 1210 SMT X7R R25 8135 W125 47K 5% 0805 SMT RES R119 7624 W100 100R 1% 0805 SMT RES
C2
6451 __4N7 250V 20%CAP BLK 'Y' 10MM AC C134 5979 100N 50V 5%CAP 0805 SMT X7R R26 7854 W125 47R 5% 0805 SMT RES R120 7624 W100 100R 1% 0805 SMT RES
C3
5863 6800U 25V 20%CAP BLK 16X40MM EL C145 5635 1000U 35V 20%CAP BLK RADIAL ELECT R27 7624 W100 100R 1% 0805 SMT RES R121 7625 W100 10K0 1% 0805 SMT RES
C4
5863 6800U 25V 20%CAP BLK 16X40MM EL C195 7916 _10U 25V 20%CAP 5X5.4 SMT EL R28 7795 W063 4K02 1% 0603 SMT RES R122 7745 W125 0R 5% 0805 SMT RES
C5
5863 6800U 25V 20%CAP BLK 16X40MM EL D1 7889 ES3D 200V 3A0 D214 SMT SMC R29 7866 W125 1M 5% 0805 SMT RES R123 7745 W125 0R 5% 0805 SMT RES
C6
7767 100N 16V 10%CAP 0603 SMT X7R D2 7889 ES3D 200V 3A0 D214 SMT SMC R30 7625 W100 10K0 1% 0805 SMT RES R124 7642 W100 4K75 1% 0805 SMT RES
C7
7819 _10U 10V 10%CAP 1206 SMT X5R D3 7889 ES3D 200V 3A0 D214 SMT SMC R31 7625 W100 10K0 1% 0805 SMT RES R125 7625 W100 10K0 1% 0805 SMT RES
C8
7767 100N 16V 10%CAP 0603 SMT X7R D4 7889 ES3D 200V 3A0 D214 SMT SMC R32 7678 W125 3K92 1% 0805 SMT RES R126 8135 W125 47K 5% 0805 SMT RES
C9
7767 100N 16V 10%CAP 0603 SMT X7R D5 7889 ES3D 200V 3A0 D214 SMT SMC R33 7624 W100 100R 1% 0805 SMT RES R127 8135 W125 47K 5% 0805 SMT RES
C10
7767 100N 16V 10%CAP 0603 SMT X7R D6 7750 CDSF4148 75V 0A15 1005 SMT R34 8135 W125 47K 5% 0805 SMT RES R128 7625 W100 10K0 1% 0805 SMT RES
C11
7819 _10U 10V 10%CAP 1206 SMT X5R D7 7889 ES3D 200V 3A0 D214 SMT SMC R35 7795 W063 4K02 1% 0603 SMT RES R129 7642 W100 4K75 1% 0805 SMT RES
C12
7767 100N 16V 10%CAP 0603 SMT X7R D8 7889 ES3D 200V 3A0 D214 SMT SMC R36 7678 W125 3K92 1% 0805 SMT RES R130 7680 W100 6K98 1% 0805 SMT RES
C13
7767 100N 16V 10%CAP 0603 SMT X7R D9 7889 ES3D 200V 3A0 D214 SMT SMC R37 7624 W100 100R 1% 0805 SMT RES R137 7621 W100 1K0 1% 0805 SMT RES
C14
7819 _10U 10V 10%CAP 1206 SMT X5R D10 7750 CDSF4148 75V 0A15 1005 SMT R38 8135 W125 47K 5% 0805 SMT RES R150 7854 W125 47R 5% 0805 SMT RES
C15
7767 100N 16V 10%CAP 0603 SMT X7R D11 7750 CDSF4148 75V 0A15 1005 SMT R39 7795 W063 4K02 1% 0603 SMT RES R151 7854 W125 47R 5% 0805 SMT RES
C16
7694 __3N3 25V 5%CAP 0805 SMT NPO D12 7893 MBRA340T3 40V 3A SHTKY 403D SMT R40 7625 W100 10K0 1% 0805 SMT RES R154 7854 W125 47R 5% 0805 SMT RES
C17
7601 220N 50V 10%CAP 1206 SMT X7R D13 7832 MM3Z18VT1G 18V0 0W2 5% SMT ZEN R41 7678 W125 3K92 1% 0805 SMT RES R155 7854 W125 47R 5% 0805 SMT RES
C18
7819 _10U 10V 10%CAP 1206 SMT X5R D14 7750 CDSF4148 75V 0A15 1005 SMT R42 7624 W100 100R 1% 0805 SMT RES R164 7854 W125 47R 5% 0805 SMT RES
C19
7767 100N 16V 10%CAP 0603 SMT X7R D15 7750 CDSF4148 75V 0A15 1005 SMT R43 7823 W100 18K2 1% 0805 SMT RES R169 7624 W100 100R 1% 0805 SMT RES
C20
7819 _10U 10V 10%CAP 1206 SMT X5R D17 7750 CDSF4148 75V 0A15 1005 SMT R44 8135 W125 47K 5% 0805 SMT RES R213 8222 W100 1K02 1% 0603 SMT RES
C21
7811 100U 25V 20%CAP 8X5.4 SMT ELE D18 7750 CDSF4148 75V 0A15 1005 SMT R45 8135 W125 47K 5% 0805 SMT RES R214 8222 W100 1K02 1% 0603 SMT RES
C22
7767 100N 16V 10%CAP 0603 SMT X7R D19 7750 CDSF4148 75V 0A15 1005 SMT R46 8222 W100 1K02 1% 0603 SMT RES R215 7624 W100 100R 1% 0805 SMT RES
C23
7819 _10U 10V 10%CAP 1206 SMT X5R D20 7750 CDSF4148 75V 0A15 1005 SMT R47 7866 W125 1M 5% 0805 SMT RES R216 7679 W100 4K99 1% 0805 SMT RES
C24
7767 100N 16V 10%CAP 0603 SMT X7R D21 7700 5237B 8V2 0W2 SOT-23 SMT ZEN R48 4615 W250 4R7 5% 1206 SMT RES R221 7679 W100 4K99 1% 0805 SMT RES
C25
8272 220P 100V 10%CAP 0805 SMT X7R D22 7750 CDSF4148 75V 0A15 1005 SMT R49 7998 W750 0R 1% 2010 SMT JMP R222 7679 W100 4K99 1% 0805 SMT RES
C26
7769 __1U 50V 20%CAP 4.3X3.9 SMT ELC D23 7750 CDSF4148 75V 0A15 1005 SMT R51 8222 W100 1K02 1% 0603 SMT RES R274 7854 W125 47R 5% 0805 SMT RES
C27
7769 __1U 50V 20%CAP 4.3X3.9 SMT ELC D24 7700 5237B 8V2 0W2 SOT-23 SMT ZEN R54 7795 W063 4K02 1% 0603 SMT RES S1 4200 SP3T ROTA SW PCMT H RS1201
C28
7769 __1U 50V 20%CAP 4.3X3.9 SMT ELC D25 7750 CDSF4148 75V 0A15 1005 SMT R55 7679 W100 4K99 1% 0805 SMT RES S2 3522 DPDT MINI PC VERT SNP ALT
C29
7767 100N 16V 10%CAP 0603 SMT X7R D26 7750 CDSF4148 75V 0A15 1005 SMT R60 4963 W125 64K9 1% 0805 SMT RES S3 3439 DPDT MINI PC VERT MOMENTARY
C30
7767 100N 16V 10%CAP 0603 SMT X7R D27 7750 CDSF4148 75V 0A15 1005 SMT R61 7795 W063 4K02 1% 0603 SMT RES S4 6548 2P3T SLID SW PCMT V
C31
7767 100N 16V 10%CAP 0603 SMT X7R D28 7750 CDSF4148 75V 0A15 1005 SMT R62 7679 W100 4K99 1% 0805 SMT RES T4 1254 1VA 16V XFMR 36X31X25MM 115/230
C32
7767 100N 16V 10%CAP 0603 SMT X7R D29 7750 CDSF4148 75V 0A15 1005 SMT R65 8222 W100 1K02 1% 0603 SMT RES U1 7918 LM1117 REGULATOR 5V0 SMT SOT223
C33
7767 100N 16V 10%CAP 0603 SMT X7R F1 2493 FUSE T3.15A 300V RAD SLOW T&R R67 7679 W100 4K99 1% 0805 SMT RES U2 8318 ADAU1401 28/56 DSP 2AD4DA SMT IC
C34
5979 100N 50V 5%CAP 0805 SMT X7R J1 4090 1/4IN &XLR PCB MT VERT COMBO NCJ6-V R68 4963 W125 64K9 1% 0805 SMT RES U3 8173 MKL15Z64VLH4 48MHZ MCU SMT LQFP64
C35
7767 100N 16V 10%CAP 0603 SMT X7R J2 4210 RECEPTACLE 2 PRONG IEC R69 8233 W100 19K6 1% 0603 SMT RES U4 7661 LM393D DUAL COMPARATOR SMT SO-8
C36
7769 __1U 50V 20%CAP 4.3X3.9 SMT ELC J3 4090 1/4IN &XLR PCB MT VERT COMBO NCJ6-V R70 7679 W100 4K99 1% 0805 SMT RES U5 7890 LM2671 3V3 REG 0A5 SMT SO8
C37
7767 100N 16V 10%CAP 0603 SMT X7R J4 4186 3.5MM JCK PCB MT VERT ST R71 7795 W063 4K02 1% 0603 SMT RES U6 7661 LM393D DUAL COMPARATOR SMT SO-8
C38
5863 6800U 25V 20%CAP BLK 16X40MM EL K1 4155 RELAY 1A 10AMP DC05 040MA PC-S HC R72 7679 W100 4K99 1% 0805 SMT RES U12 7817 33078 DUAL OPAMP SMT SO-8
C39
7886 __4U7 25V 20%CAP 4X5.5 SMT ELC L1 7730 __2.2UH COIL SMT R73 8222 W100 1K02 1% 0603 SMT RES U13 8285 BM23 BLUETOOTH DIGITAL SMT MOD
C40
7769 __1U 50V 20%CAP 4.3X3.9 SMT ELC L2 8256 FERRITE BEAD 600R @100MHZ 0805 SMT R74 7998 W750 0R 1% 2010 SMT JMP U14 7817 33078 DUAL OPAMP SMT SO-8
C41
7880 _47U 35V 20%CAP 6.3MM SMT ELE L3 8256 FERRITE BEAD 600R @100MHZ 0805 SMT R75 4963 W125 64K9 1% 0805 SMT RES U16 7817 33078 DUAL OPAMP SMT SO-8
C42
7737 _10N 50V 10%CAP 0805 SMT X7R L4 8256 FERRITE BEAD 600R @100MHZ 0805 SMT R76 7625 W100 10K0 1% 0805 SMT RES U18 7668 MC33079D QUAD OPAMP SMT SO14
C43
7880 _47U 35V 20%CAP 6.3MM SMT ELE L5 2910 120.0UH COIL SR4018T 1R6 SMT R77 7795 W063 4K02 1% 0603 SMT RES W1 6535 HEADER:SIL 26 SOCKET
C44
8140 _15U 35V 10%CAP 6032 SMT TNT LD2 5997 RD/GN LED 2V1 20MA 0805 SMT R78 7679 W100 4K99 1% 0805 SMT RES W3 2337 4 CIR XH-HEADER 0.098IN
C49
8141 100U 10V 20%CAP 3528 SMT TNT LD3 5997 RD/GN LED 2V1 20MA 0805 SMT R79 7625 W100 10K0 1% 0805 SMT RES W3_ 2337 4 CIR XH-HEADER 0.098IN
C50
7819 _10U 10V 10%CAP 1206 SMT X5R LD4 5998 BL/RD LED 2V1 20MA 0805 SMT R80 8233 W100 19K6 1% 0603 SMT RES W4 3465 WIRE TO BOARD CRIMP 16-18 AWG TIN
C51
7813 _47P 50V 5%CAP 0805 SMT NPO LD8 5998 BL/RD LED 2V1 20MA 0805 SMT R81 7679 W100 4K99 1% 0805 SMT RES W4_ 3465 WIRE TO BOARD CRIMP 16-18 AWG TIN
C52
8176 _47N 100V 10%CAP 1206 SMT X7R LED1 5997 RD/GN LED 2V1 20MA 0805 SMT R82 7679 W100 4K99 1% 0805 SMT RES W6 4162 2 PIN POWER PIN HEADER MALE POLZED
C53
8176 _47N 100V 10%CAP 1206 SMT X7R M1203 7998 W750 0R 1% 2010 SMT JMP R83 7679 W100 4K99 1% 0805 SMT RES W7 4163 5 PIN POWER PIN HEADER MALE POLZED
C54
8176 _47N 100V 10%CAP 1206 SMT X7R M1705 7998 W750 0R 1% 2010 SMT JMP R84 8131 W500 10R 5% 1210 SMT RES W8 2327 6 CIR XH-HEADER 0.098IN
C55
8176 _47N 100V 10%CAP 1206 SMT X7R P1 4453 _50K B LIN 12MM 4PIN HORZ DT P40 R85 7625 W100 10K0 1% 0805 SMT RES W8_ 2327 6 CIR XH-HEADER 0.098IN
C56
7769 __1U 50V 20%CAP 4.3X3.9 SMT ELC PCB X8009BLANK 1_OZ 2SD 65.50SQIN 01PER RM5 R86 7625 W100 10K0 1% 0805 SMT RES W9 3465 WIRE TO BOARD CRIMP 16-18 AWG TIN
C57
5979 100N 50V 5%CAP 0805 SMT X7R Q1 7805 MMBT3906LT1 PNP SOT-23 SMT T&R R87 8131 W500 10R 5% 1210 SMT RES W9_ 3465 WIRE TO BOARD CRIMP 16-18 AWG TIN
C59
7769 __1U 50V 20%CAP 4.3X3.9 SMT ELC Q2 6692 11.2896MHZ CRYSTAL 4-PIN SMT R88 8131 W500 10R 5% 1210 SMT RES W10 2358 9 CIR XH-HEADER 0.098IN
C60
7819 _10U 10V 10%CAP 1206 SMT X5R Q3 7837 MMBT5401 PNP SOT-23 SMT R89 7624 W100 100R 1% 0805 SMT RES W10_ 2381 09 CIR XH-HEADER RA 0.098IN
C61
5979 100N 50V 5%CAP 0805 SMT X7R Q4 7701 MMBTA14 NPN DARL SOT-23 SMT R90 7625 W100 10K0 1% 0805 SMT RES W11 4018 10 CIR WAFER DIL VT 0.1
C74
8277 __1N8 50V 5%CAP 0805 SMT NPO Q6 7837 MMBT5401 PNP SOT-23 SMT R91 8131 W500 10R 5% 1210 SMT RES W13 3538 24 PIN BREAKAWAY LOCK .156
C75
8272 220P 100V 10%CAP 0805 SMT X7R Q11 7837 MMBT5401 PNP SOT-23 SMT R92 7679 W100 4K99 1% 0805 SMT RES W14 2370 7 CIR PH-HEADER 2MM
C76
8139 _22U 25V 20%CAP 1210 SMT X7R R1 7673 W100 475R 1% 0805 SMT RES R93 8131 W500 10R 5% 1210 SMT RES W14_ 2370 7 CIR PH-HEADER 2MM
C77
8277 __1N8 50V 5%CAP 0805 SMT NPO R2 7673 W100 475R 1% 0805 SMT RES R94 7642 W100 4K75 1% 0805 SMT RES W15 4194 2X2 3 MM MICRO MATE-N-LOK VRT
C81
8272 220P 100V 10%CAP 0805 SMT X7R R3 7621 W100 1K0 1% 0805 SMT RES R95 8131 W500 10R 5% 1210 SMT RES
C82
8139 _22U 25V 20%CAP 1210 SMT X7R R4 8131 W500 10R 5% 1210 SMT RES R96 8131 W500 10R 5% 1210 SMT RES
C83
8277 __1N8 50V 5%CAP 0805 SMT NPO R5 7854 W125 47R 5% 0805 SMT RES R97 7834 _10K 5% THERMISTOR NTC 0603 SMT
C84
8272 220P 100V 10%CAP 0805 SMT X7R R7 7854 W125 47R 5% 0805 SMT RES R98 7625 W100 10K0 1% 0805 SMT RES
C85
8139 _22U 25V 20%CAP 1210 SMT X7R R8 7854 W125 47R 5% 0805 SMT RES R99 8222 W100 1K02 1% 0603 SMT RES
C86
7871 470P 50V 5%CAP 0603 SMT NPO R9 7823 W100 18K2 1% 0805 SMT RES R100 7624 W100 100R 1% 0805 SMT RES
C87
7871 470P 50V 5%CAP 0603 SMT NPO R10 7854 W125 47R 5% 0805 SMT RES R101 8257 W125 11K0 1% 0805 SMT RES
C88
5979 100N 50V 5%CAP 0805 SMT X7R R11 7621 W100 1K0 1% 0805 SMT RES R102 7625 W100 10K0 1% 0805 SMT RES
C89
5979 100N 50V 5%CAP 0805 SMT X7R R12 7854 W125 47R 5% 0805 SMT RES R103 8257 W125 11K0 1% 0805 SMT RES
C90
5979 100N 50V 5%CAP 0805 SMT X7R R13 7859 W125 2K2 5% 0805 SMT RES R104 7625 W100 10K0 1% 0805 SMT RES
C91
8277 __1N8 50V 5%CAP 0805 SMT NPO R14 7795 W063 4K02 1% 0603 SMT RES R105 7642 W100 4K75 1% 0805 SMT RES
C96
5979 100N 50V 5%CAP 0805 SMT X7R R15 7625 W100 10K0 1% 0805 SMT RES R106 7625 W100 10K0 1% 0805 SMT RES
C97
5979 100N 50V 5%CAP 0805 SMT X7R R16 8233 W100 19K6 1% 0603 SMT RES R107 7642 W100 4K75 1% 0805 SMT RES
C99
7871 470P 50V 5%CAP 0603 SMT NPO R17 8233 W100 19K6 1% 0603 SMT RES R108 7625 W100 10K0 1% 0805 SMT RES
C100
8272 220P 100V 10%CAP 0805 SMT X7R R19 7998 W750 0R 1% 2010 SMT JMP R110 7854 W125 47R 5% 0805 SMT RES
C102
7871 470P 50V 5%CAP 0603 SMT NPO R20 7859 W125 2K2 5% 0805 SMT RES R111 7621 W100 1K0 1% 0805 SMT RES
C103
8272 220P 100V 10%CAP 0805 SMT X7R R21 7854 W125 47R 5% 0805 SMT RES R112 7625 W100 10K0 1% 0805 SMT RES
C110
7871 470P 50V 5%CAP 0603 SMT NPO R22 7854 W125 47R 5% 0805 SMT RES R116 7642 W100 4K75 1% 0805 SMT RES
C111
8272 220P 100V 10%CAP 0805 SMT X7R R23 7678 W125 3K92 1% 0805 SMT RES R117 7854 W125 47R 5% 0805 SMT RES

1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
12
12
13
13
14
14
15
15
16
16
17
17
K K
J J
I I
H H
G G
F F
E E
D D
C C
B B
A A
Product(s):
M1705-M1203 1 10
Sheet OfPCB#: Rev#: V03
Powered Studio MonitorDescription:
RM5(CE)
Yorkville Sound Ltd.
550 Granite Court
Pickering, ON
Canada L1W 3Y8
www.yorkville.com
EML Rev#: 01
Top Sheet.SchDoc
Modified: File:
2018-07-30 Tmp Rev: V031
99 W10_:9
SPI_CLK
SPI_MISO
SS_DSP
SPI_MOSI
/RESET_DSP
BT_EN
MCLK
Standby_
WakeSig
BT_UART_RX BT_UART_TX BT_UART_TX_IND BT_P0_4
Space_Sw_B
Space_Sw_A
BT_Switch
Mute_Switch
Mode_Switch_A
Mode_Switch_B
PowerLED
Level_T
Level_W
Level_B
Microcontroller
PSgnd_
BT_RST_N
HotLimit_
Microcontroller
Microcontroller.SchDoc
ASSEMBLY NOTES
Assembly.SchDoc
PanelParts
ECO.SchDoc
DESIGN HISTORY
History.SchDoc
PSgnd
+44V_ -44V_
Standby
SBv+
+22V_ -22V_
AmpMute AmGnd
SBv-
HotLimit
PowerSupply
PowerSupply.SchDoc
+12V
BT_SDATA_OUT
BT_LRCLK
BT_BCLK
BT_EN
BT_P0_4
BT_RST_N
BT_UART_TX
BT_UART_RX
BT_UART_TX_IND
BluTth
BT
Bluetooth_BM23.SchDoc
Left_LO_SENS
Right_LO_SENS
WakeSig
Space_Sw_A Space_Sw_B
Preamp
Preamp.SchDoc
Left_LO_SENS
/RESET_DSP SPI_MOSI SPI_MISO SPI_CLK SS_DSP MCLK
R_HI
L_HI
R_LO
L_LO
Right_LO_SENS
BT_Data
LRCLK
BCLK
DSP
DSP.SCHDOC
L_LO_SIG
R_LO_SIG
R_HI_SIG
L_HI_SIG
R_HI
L_HI
R_LO
L_LO
AmpGND
Output
Output.SchDoc
BT_EN
BT_UART_RX BT_UART_TX BT_RST_N
BT_UART_TX_IND
BT_P0_4
BT_EN
BT_UART_RX
BT_UART_TX
BT_RST_N
BT_UART_TX_IND
BT_P0_4
-12V
L_HI_SIG_
L_LO_SIG_
AmpGND_
R_HI_SIG_
R_LO_SIG_
-44V_
+22V_
-22V_
CDSF4148
D1005
D6
BT_Ctrl
MOMENTARY
2PDT MINI
UPDOWN
3439
S3:1
BT_Ctrl
MOMENTARY
2PDT MINI
UPDOWN
3439
S3:2
UPDOWN
3522
Power
S2:1
UPDOWN
3522
Power
S2:2
9
1W10:1 9 1
W10_:1
9
2W10:2 9 2
W10_:2
9
8W10:8 9 8
W10_:8
9
6W10:6 9 6
W10_:6
9
5W10:5 9 5
W10_:5
W100
100R
0805
R215
4200
2
4
53
S1:1
Mode S1:2
1
S1:3
W100
100R
0805
R169
BLU
BluTth
5998
LD8:1
RED
BluTth
5998
LD8:2
9
3W10:3 9 3
W10_:3
9
4W10:4 9 4
W10_:4
B
50K
4453
TB
Level
P1:1
100N
0603
16V
C32
9
7W10:7 9 7
W10_:7
9
9W10:9
Control PCB
BluTth
P1:2
61 W8_:16
1W8:1
62 W8_:26
2W8:2
63 W8_:36
3W8:3
65 W8_:56
5W8:5
66 W8_:66
6W8:6
43 W3_:34
3W3:3
44 W3_:44
4W3:4
42 W3_:24
2W3:2
64 W8_:46
4W8:4
-12V
+12V
-12V_
+12V_
14 W13:1
2
4W13:2
3
4W13:3
44 W13:4
5997
RED
Power
LD2:1
5997
GRN Power
LD2:2
EC1
LT+LT-_
LW+
LW-_
RT+RT-_
RW+
RW-_
4
1W15:1
42 W15:2
4
3W15:3
44 W15:4
W500
10R
1210
R95
W500
10R
1210
R96
100V47N
1206
C52
100V47N
1206
C55
W500
10R
1210
R84
W500
10R
1210
R4
W500
10R
1210
R88
W500
10R
1210
R87
100V47N
1206
C54
100V47N
1206
C53
W500
10R
1210
R93
W500
10R
1210
R91
26 +12V_A
W1:1
26 -12V_A
W1:2
26
+22V_
W1:3
26 RT+
W1:4
26 LT+
W1:5
26 RT+
W1:6
26 LT+
W1:7
26
-22V_
W1:8
26 AMPGND_
W1:9
26 R_HI_SIG_
W1:10
26 L_HI_SIG_
W1:11
26 R_LO_SIG_
W1:12
26 L_LO_SIG_
W1:13
26
AMPMUTE
W1:14
26
+22V_
W1:15
26
+44V_
W1:16
26
+44V_
W1:17
26 RW+
W1:18
26 LW+
W1:19
26 RW+
W1:20
26 LW+
W1:21
26 RW+
W1:22
26 LW+
W1:23
26
-44V_
W1:24
26
-44V_
W1:25
26
-22V_
W1:26
AmpMute
W100
10K0
0805
R40
HiFi_
Theater_
HiFi
Theater
CDSF4148
D1005
D29 +12V_A
W100
100R
0805
R119
5997
GRN
Power
LD3:2
W100
100R
0805
R120
BLU
BluTth
5998
LD4:1
RED
BluTth
5998
LD4:2
5997
RED
Power
LD3:1
CON_HOLE_125
1
HC1
CHASSIS
LW-
LT-
RW-
RT-
N6
N8
N10
N12
N15 N16
N13
N11
N9
N7
N21 N22
N28
N32
N29
N33
N26
N30
N34
N36
N38
N27
N37
N31
N35
N18
N20
N23
N24
N25
N39
N41
N43
N45
N47
N49
N51 N52
N50
N48
N46
N44
N42
N40
N53
N56
N55
N54
N19
N14
N17
D1005
CDSF4148
D23
D1005
CDSF4148
D26
+44V_
-12V_A
PsGND
N5
N57
HotLimit_
HotLimit
Mute
LimitForHiTemp
Standby
41 W3_:14
1W3:1
35V47U
6x6mm
C41
35V47U
6x6mm
C43
C41 and C43 are
placed to prevent
S1 and P1 from
tilting.
PIC3201
PIC3202
COC32
PIC4101PIC4102
COC41
PIC4301PIC4302
COC43
PIC5201PIC5202
COC52
PIC5301 PIC5302
COC53
PIC5401PIC5402
COC54
PIC5501PIC5502
COC55
PID601PID602
COD6
PID2301PID2302
COD23
PID2601 PID2602
COD26
PID2901PID2902
COD29
COEC1
PIHC101
COHC1
PILD201
PILD202
COLD2:1
PILD203
PILD204
COLD2:2
PILD301
PILD302
COLD3:1
PILD303
PILD304
COLD3:2
PILD401 PILD402
COLD4:1
PILD403
PILD404
COLD4:2
PILD801 PILD802
COLD8:1
PILD803
PILD804
COLD8:2
PIN501
CON5
PIN601
CON6
PIN701
CON7
PIN801
CON8
PIN901
CON9
PIN1001
CON10
PIN1101
CON11
PIN1201
CON12
PIN1301
CON13
PIN1401
CON14
PIN1501
CON15
PIN1601
CON16
PIN1701
CON17
PIN1801
CON18
PIN1901
CON19
PIN2001
CON20
PIN2101
CON21
PIN2201
CON22
PIN2301
CON23
PIN2401
CON24
PIN2501
CON25
PIN2601
CON26
PIN2701
CON27
PIN2801
CON28
PIN2901
CON29
PIN3001
CON30
PIN3101
CON31
PIN3201
CON32
PIN3301
CON33
PIN3401
CON34
PIN3501
CON35
PIN3601
CON36
PIN3701
CON37
PIN3801
CON38
PIN3901
CON39
PIN4001
CON40
PIN4101
CON41
PIN4201
CON42
PIN4301
CON43
PIN4401
CON44
PIN4501
CON45
PIN4601
CON46
PIN4701
CON47
PIN4801
CON48
PIN4901
CON49
PIN5001
CON50
PIN5101
CON51
PIN5201
CON52
PIN5301
CON53
PIN5401
CON54
PIN5501
CON55
PIN5601
CON56
PIN5701
CON57
PIP101
PIP102
PIP103
PIP104
COP1:1
PIP105
COP1:2
PIR401 PIR402
COR4
PIR601 PIR602
COR6
PIR1801 PIR1802
COR18
PIR4001 PIR4002
COR40
PIR5201 PIR5202
COR52
PIR5301 PIR5302
COR53
PIR5601 PIR5602
COR56
PIR5701 PIR5702
COR57
PIR5801 PIR5802
COR58
PIR5901 PIR5902
COR59
PIR6301 PIR6302
COR63
PIR8401 PIR8402
COR84
PIR8701 PIR8702
COR87
PIR8801 PIR8802
COR88
PIR9101 PIR9102
COR91
PIR9301 PIR9302
COR93
PIR9501 PIR9502
COR95
PIR9601 PIR9602
COR96
PIR11901
PIR11902
COR119
PIR12001 PIR12002
COR120
PIR16901PIR16902
COR169
PIR21501
PIR21502
COR215
PIS102
PIS103
PIS104
PIS105
COS1:1
PIS106
COS1:2
PIS101
COS1:3
PIS201
PIS202
PIS203
COS2:1
PIS204PIS205PIS206
COS2:2
PIS301
PIS302
PIS303
COS3:1
PIS304
PIS305
PIS306
COS3:2
PIW101
COW1:1
PIW102
COW1:2
PIW103
COW1:3
PIW104 COW1:4
PIW105
COW1:5
PIW106
COW1:6
PIW107
COW1:7
PIW108
COW1:8
PIW109
COW1:9
PIW1010
COW1:10
PIW1011
COW1:11
PIW1012
COW1:12
PIW1013
COW1:13
PIW1014
COW1:14
PIW1015
COW1:15
PIW1016
COW1:16
PIW1017
COW1:17
PIW1018
COW1:18
PIW1019
COW1:19
PIW1020
COW1:20
PIW1021
COW1:21
PIW1022
COW1:22
PIW1023
COW1:23
PIW1024
COW1:24
PIW1025
COW1:25
PIW1026
COW1:26
PIW301 COW3:1
PIW302 COW3:2
PIW303 COW3:3
PIW304
COW3:4
PIW3001 COW30:1
PIW3002 COW30:2
PIW3003 COW30:3
PIW3004
COW30:4
PIW801
COW8:1
PIW802
COW8:2
PIW803
COW8:3
PIW804
COW8:4
PIW805
COW8:5
PIW806
COW8:6
PIW8001
COW80:1
PIW8002
COW80:2
PIW8003
COW80:3
PIW8004
COW80:4
PIW8005
COW80:5
PIW8006
COW80:6
PIW1001
COW10:1
PIW1002
COW10:2
PIW1003
COW10:3
PIW1004
COW10:4
PIW1005
COW10:5
PIW1006
COW10:6
PIW1007
COW10:7
PIW1008
COW10:8
PIW1009
COW10:9
PIW10001
COW100:1
PIW10002
COW100:2
PIW10003
COW100:3
PIW10004
COW100:4
PIW10005
COW100:5
PIW10006
COW100:6
PIW10007
COW100:7
PIW10008
COW100:8
PIW10009
COW100:9
PIW1301
COW13:1
PIW1302
COW13:2
PIW1303 COW13:3
PIW1304
COW13:4
PIW1501
COW15:1
PIW1502
COW15:2
PIW1503
COW15:3
PIW1504
COW15:4

1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
12
12
13
13
14
14
15
15
16
16
17
17
K K
J J
I I
H H
G G
F F
E E
D D
C C
B B
A A
ECAD Incidentals
Section:
Product(s):
ECO.SchDoc
M1705-M1203 1 10Sheet OfPCB#: Rev#:
Modified:
V03
File:
2018-07-30
RM5(CE)
EML Rev#: 01
Tmp Rev: V031
PANEL PARTS
Corners
Panel Fiducials
Tooling Holes
Clinch Origin
BEC LOC
TLH1
TLH2 TLH3
Insert Origin
TLH4
TLH5
CNR1 CNR2 CNR3 CNR4
PF1 PF2 PF3 PF4
CRG1
M1203 RM5CE
INS1 VCD 2nd HOLE
INS2
See PcbDoc for default clearance rules.
Note: You must define your own rules for -HI and +HI.
PCB Title
Step & Repeat: [email protected]@123.4
1
1.234
1
123.4
HW22 HW10HW12 HW21
HW24
2335
HW23
2335
HW25
2335
PCB
AI-ASSY
DOCUMENTATION
Blank PCB
AI Sub-Assembly
FinePitchU8
Room1
FinePitchU10
Room2
IgnoreAC
Room3
IgnoreAC_1
Room4
BRK2 TH1 TH2
CON_HOLE_125
0
HC3

1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
12
12
13
13
14
14
15
15
16
16
17
17
K K
J J
I I
H H
G G
F F
E E
D D
C C
B B
A A
Assembly Documentation
Section:
Product(s):
Assembly.SchDoc
M1705-M1203 1 10Sheet OfPCB#: Rev#:
Modified:
V03
File:
2018-07-30
RM5(CE)
EML Rev#: 01
Tmp Rev: V031
THIS SHEET CONTAINS SPECIAL PRODUCTION NOTES AND A LIST OF PCB HARDWARE PARTS REQUIRED FOR THE BUILD.
SCREWS AND BOLTS STANDOFFSNUTS
PCB HARDWARESPECIAL PRODUCTION NOTES
MISCELLANEOUS
PCB ASSEMBLY DOCUMENTATION
1. Do not bend transformer leads on T1 YS# 1254.
2. Apply RTV to all tall caps and appropriate areas.
3. Use pizza cutter where possible to separate pcb from panel.
POTENTIOMETERS AND KNOBS
"STYLE_P32"
P1
S1
S2
S3
90864453
4200
3522
3439
.
.
.
.
.
.
.
.
9086
9089
9088
.
.
.
.
.
.
.
.
LEVEL
REF POT/SW YS#FUNCTION KNOB#
POTENTIOMETERS/SWITCHES AND KNOBS
BT Mode
.
.
.
.
.
.
.
.
MODE
On/Off
.. .
.
.
.
.
.
.
.
.
.
STYLE
P40
ROT3
.
.
.
.
.
.
.
.
.
.
9089
9088
M1203-RM5CE

1
1
2
2
3
3
4
4
5
5
6
6
7
7
8
8
9
9
10
10
11
11
12
12
13
13
14
14
15
15
16
16
17
17
K K
J J
I I
H H
G G
F F
E E
D D
C C
B B
A A
Bluetooth
Section:
Product(s):
Bluetooth_BM23.SchDoc
M1705-M1203 2 10Sheet OfPCB#: Rev#:
Modified:
V03
File:2018-07-30
RM5(CE)
EML Rev#: 01
Tmp Rev: V031
BT_EN
BT_SDATA_OUT
BT_UART_TX
BT_UART_RX
W125
47R
0805
R164
100N
0805
50V
C134
10U
ELE 5mm
25V
C195
W125
47R
0805
R274
BT_LRCLK W125
47R
0805
R110
BT_BCLK
BT_UART_TX_IND
DR0
5
DT0
6
P0_4
7
EAN
8
MIC1_P
9
MIC1_N
10
MIC_BIAS
11
VDDA
12
AIR
13
AIL
14
BAT_IN
23
P1_5
20
VDDIO
19
BK_OUT 26
MFB 27
LED1 28
LED2 29
P2_4 30
P0_2 31
P0_1
21
RST_N
16
ADAP_IN
22
NC
24
SYS_PWR
25
NC
18
NC
17
SLK0
4
TFS0
3
P0_3 32
HCI_TXD 33
P0_0
1
GND
15
P2_0 37
RFS0
2
HCI_RXD 34
GND 40
P2_0 39
P3_0 38
P0_5 35
P2_7 36
13.5X26mm SMT Module
BM23
8285
U13
1206
10V10U
C60
W125
DNS
0805
R114
BT_RST_N
AGND
AGND
AGND
AGND
BT_RST_N
BT_EN
W125
47R
0805
R117
4K75
W100
0805
R116
BT_P0_4 1
2
3
4
5
6
W2
BT_Pgm
AGND
5997
RED
BT_St
LED1:1
100N
0805
50V
C61
BT_EN
+5V_PROG
BluTth
W100
10K0
0805
R121
MMBT5401
7837
SOT-23
Q6
5997
GRN
BT_St
LED1:2
+5VBT
IN
REF
OUT
SOT-223
LM1117-5v
7918
U1
AGND
+12V_
ELE 5mm
10U 25V
C1
+5VBT
TST35
TST37
TST36
TST39
TST38
D1005
CDSF4148
D27
PIC101
PIC102
COC1
PIC6001
PIC6002
COC60
PIC6101
PIC6102
COC61
PIC13401PIC13402
COC134
PIC19501PIC19502
COC195
PID2701PID2702
COD27
PILED101
PILED102
COLED1:1
PILED103
PILED104
COLED1:2
PIQ601
PIQ602
PIQ603
COQ6
PIR11001 PIR11002
COR110
PIR11401 PIR11402
COR114
PIR11601 PIR11602
COR116
PIR11701 PIR11702
COR117
PIR12101 PIR12102
COR121
PIR16401 PIR16402
COR164
PIR27401 PIR27402
COR274
PITST3501
COTST35
PITST3601
COTST36
PITST3701
COTST37
PITST3801
COTST38
PITST3901
COTST39
PIU101
PIU102 PIU103
COU1
PIU1301
PIU1302
PIU1303
PIU1304
PIU1305
PIU1306
PIU1307
PIU1308
PIU1309
PIU13010
PIU13011
PIU13012
PIU13013
PIU13014
PIU13015
PIU13016 PIU13017 PIU13018 PIU13019 PIU13020 PIU13021 PIU13022 PIU13023 PIU13024 PIU13025
PIU13026
PIU13027
PIU13028
PIU13029
PIU13030
PIU13031
PIU13032
PIU13033
PIU13034
PIU13035
PIU13036
PIU13037
PIU13038
PIU13039
PIU13040
COU13
PIW201
PIW202
PIW203
PIW204
PIW205
PIW206
COW2
POBLUTTH
POBT0BCLK
POBT0EN
POBT0LRCLK
POBT0P004
POBT0RST0N
POBT0SDATA0OUT
POBT0UART0RX
POBT0UART0TX
POBT0UART0TX0IND