Astria Fireplaces LIBRA 40CL Series User manual

Page 1 of 2
LIBRA 40CL
P/N 900661-03, REV. NC, 05/2016
Fireplace Dimensions Framing Dimensions
DIRECT-VENT FIREPLACES
Inches (millimeters)
NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
5-5/8"
(143 mm)
3-1/8"
(79 mm)
Route a 1/2” (13 mm) gas line to the
right side of the appliance as shown
®
®
Gas Line
Center of gas line
is 3" (77 mm)
up from floor
* This dimension can be reduced to 41” (1042 mm). This results in 0” (0 mm) clearance between
framing and unit framing spacers. The 41-1/2” (1054 mm) dimension permits easier fireplace
installation, if unit is installed after framing is erected.
Optional Gas Line Location
Center of gas line is 3" (77 mm)
up from floor
NOTE: Unit has a factory-installed
vent seal cap and vent cover plate in
each flue outlet. The vent seal cap is
not shown in this figure.
Inches (millimeters)
10-3/8
(264)
12
(305)
3
(77)
6-7/8
(175)
41
(1042)
34-1/8
(867)
1 (26)
25-5/8 (651)
23-7/8 (607)
21-3/8 (543)
37-3/4 (959)
45-1/2 (1156)
11-3/8
(289)
10
(254)
21-3/8
(543)
TOP VIEW
FRAMING
SPACERS
(Top and
both sides)
FINISHED WALL BRACKET
(Front and back edge of unit top)
CONTROL
COMPARTMENT
ACCESS PANEL
FRONT VIEW
LEFT SIDE VIEW RIGHT SIDE VIEW
1/2
(13)
DETAIL OF
FINISH WALL BRACKET
ELECTRICAL
INLETS
GAS
INLET
fire-parts.com

4 (102)
2
(51)
4
(102)
6
(152)
8
(203)
10
(254)
12
(305)
6 (152)
10 (254)
14 (356)
12 (305)
8 (203)
Printed in U.S.A. © 2016 Innovative Hearth Products
P/N 900661-03 REV. NC 05/2016 Page 2 of 2
Specifications and clearances are subject to change without notice.
Refer to Installation Manual before installation of these appliances for
updated dimensions and instructions.
10-1/2”
(267mm)
7"
(178)
5-1/8”
(130 mm)
12-1/8”
(308 mm)
3"
(77 mm)
1"
(26 mm)
Adaptor SV4.5RCH
Square Horizontal Termination (SV4.5HT-2)
6 to 48” Vent Section,
Telescopic vent section,
Elbow or Appliance
Collar
See Page 1 for Min.
Distance to Base of Appliance.
NOTE: Center line of
Vent Piping is NOT
the Same as the
Center line of the
Framed Opening.
To help minimize water infiltration it is recom-
mended that the Firestop/Spacer (SV4.5HF) be
installed on the exterior side of the wall.
* Ceiling Firestop/
Spacer (SV4.5VF)
Vertical Termination
Cap SV4.5CGV-1
(rated for high winds
and freezing conditions)
Ceiling Framing
10-1/2”
(267 mm)
10-1/2”
(267 mm)
Typical
Installation
Venting Clearances Shelf Height
Listing
Product Info
Minimum Clearances
Inches (millimeters)
Back & Sides 1/2 (13)
0 (0) from Spacers or
Dimples
Top Spacers 0 (0)
Floor 0 (0)
From Bottom of
Unit To Ceiling 64 (1626)
Vent 3 (77) Top* / 1 (26)
Sides & Bottom
Service Clearances - Feet (meters)
Front, Back &
Sides 3 feet (0.9 meters)
LIBRA 40CL
NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
Report No. 14-171
Shelf Above Fireplace
With Rear Venting
Do not insulate the
space between the
appliance and the
area above it.
Shelf Height
(see table)
Shelf Above Fireplace
With Top Venting
Do not insulate the
space between the
appliance and the
area above it.
Shelf Height
(see table)
Model Combustible Shelf Height - Inches (millimeters)
Top Vent - with One 90º Elbow Rear Vent - Straight Out the Back
Secure Vent
®Secure Flex®Secure Vent Secure Flex
LIBRA 40CL
53-7/8 (1368) 55-5/8 (1413) 41-1/8 (1045) 41-1/8 (1045)
*NOTE: 3” (77 mm) above any horizontal/
inclined vent component.
inches (millimeters)
Top of
Appliance
Mantel Depth
Front or Rear Face
of Appliance
PFS
®
USC
Top View of
Fireplace
Combustible Walls
A Combustible Wall
may extend to any
length on one side only.
If installed as shown,
opposite side is limited
to 6" (153 mm).
6" (153 mm)
These appliances comply with National Safety
Standards and are tested and listed by PFS to
ANSI Z21.88 (in Canada, CSA-2.33), and CAN/
CGA-2.17-M91, latest editions, in both USA
and Canada, as vented gas fireplace heaters.
Product Reference Information
Cat. No. Model Shipping
Weight
Shipping
Volume
F1591 LIBRA 40CLDMN 299 lbs. 42.0 cu.ft.
F1592 LIBRA 40CLDMP 299 lbs. 42.0 cu.ft.
F1593 LIBRA 40CLDEN 299 lbs. 42.0 cu.ft.
Uses 4.5” / 7.5” Secure Vent®Rigid and
Secure Flex®Direct-Vent Components
fire-parts.com