Avantco Equipment 177FFDS1 User manual
User Manual
www.AvantcoEquipment.com 1
French Fry Warmer/Dump Station
User Manual
Models: 177FFDS1
Please read and keep these instructions. Indoor use only.
1/2015
User Manual
2 www.AvantcoEquipment.com
Introducon ........................................................................................ 3
Requirements and Safety Instrucons ................................................. 3
Operaon............................................................................................ 4
Cleaning .............................................................................................. 4
Parts Diagram...................................................................................... 5
Limited Warranty ................................................................................ 6
Index
User Manual
www.AvantcoEquipment.com 3
Introduction, Requirements and Safety
Introduction
1. Please read instrucons before using this appliance.
2. When using electrical appliances, basic precauons should always be followed to reduce the
risk of re, electric shock and injury.
3. Clean machine thoroughly before and aer each use following the cleaning instrucons
provided below.
Safety Instructions
WARNING!
All power must be disconnected at power source before any service procedure is performed.
1. This appliance is hot when in use. To avoid burns, do not let bare skin touch hot surfaces. Keep
combusble materials, such as drapes and other furnishings, away from appliance.
2. Extreme cauon is necessary when any appliance is used by or near children and whenever the
appliance is le unaended.
3. Always unplug appliance when not in use and before cleaning, adjusng or maintaining this
machine. To disconnect appliance, turn switch o and remove plug from power source.
4. Do not operate any appliance with a damaged cord or plug, aer the appliance malfuncons,
has been dropped or damaged. Return appliance to an authorized service facility for
examinaon, electrical or mechanical adjustment or repair.
5. Do not use outdoors. This appliance is not intended for wet or moist locaons. Never locate
appliance where it may fall into water.
6. Connect to properly grounded outlets only. Avoid the use of extension cords. Do not run cord
under carpeng, runners or the like. Arrange cord away from trac area and where it will not
create a tripping hazard.
7. This appliance is equipped with a power cord with a three blade plug. Plug ONLY into a matching
three blade outlet. DO NOT cut or break o the third blade or aempt to use with a two blade
extension cord.
8. To prevent a possible re, it is recommended that the unit is placed on a non-combusble surface.
9. This appliance has electrical parts. Do not use it in areas where gasoline, paint, or ammable
liquids are used or stored.
User Manual
4 www.AvantcoEquipment.com
Overview
Preparation
1. Set the unit on a at, dry surface near a grounded 120V outlet.
2. Using a phillips head screw driver, aached the 2 metal posts to the base. Line up the 4 holes on
each post with the threaded holes in the base.
3. Once posts are secured to the base, place the strip heater on top of the posts. Line up the holes
and insert 4 screws into each post.
4. Place the food pan in the base.
Operation
1. Plug cord into grounded electrical outlet of the correct voltage. Electrical shock can occur if
appliance is not grounded.
2. Flip both the heat and light switches to the on posion. Use of the light is oponal and operates
independently from the heang elements.
3. Place food products in the pan, located directly under the elements for best results.
4. Turn unit o when not in use.
5. To disconnect appliance, turn switches o and remove plug from power source.
Cleaning
1. Unplug the cord and let warmer cool before cleaning or moving.
2. This unit can be cleaned with a damp sponge and mild soap. Rinse with clean water and wipe dry.
3. Do not immerse in water or other liquid.
MODEL # POWER SUPPLY OVERALL
DIMENSIONS FOOD PAN NET WEIGHT PLUG
177FFDS1 120V 1000W 22.5"L x 13"W x 19.5"H 2"D 25 lbs. NEMA 5-15P
User Manual
www.AvantcoEquipment.com 5
Parts Diagram
# DESCRIPTION ITEM # QT Y.
1Waterproof Switch Cover 2
2On/O Rocker Switch 177PFFDSWTCH 2
3Switch Screws 2
4PVC Panel 1
5Front Panel 1
6Bulb Socket Screws 2
7Bulb Socket 1
8Warmer Bulb 177PFFDSLAMP 1
9Element Nut 4
10 Food Pan 1
# DESCRIPTION QT Y. QT Y.
11 Stainless Steel Base 1
12 Wiring Harness 1
13 Reex Housing 1
14 Calrod Heang Element 177PFFDSELEM 1
15 Power Cord 1
16 Base Screw 8
17 Power Relay 1
18 Feet 4
19 Foot Screws 4
User Manual
6 www.AvantcoEquipment.com
Limited Warranty
All equipment, which is sold under Avantco trademark and used for commercial purpose is warranted
against defects in materials and workmanship. The warranty runs for 6 months from the date
of original installaon and is for the benet of the original purchaser only. All other Warranes,
Expressed or Implied, Statutory or Otherwise, including Without Limitaon any implied Warranty of
Merchantability or Fitness for Purposes are excluded. The Seller shall in no event be liable for direct,
indirect or consequenal damages in connecon with Avantco commercial products.
This warranty is not eecve if damage occurs because of accident, carelessness, improper
installaon, lack of proper setup, supervision when required or if the equipment is installed or
operated in any manner contrary to the installaon and operang instrucons. Work performed by
unauthorized personnel or unauthorized service agencies voids this Warranty.
This warranty does not apply to, and Avantco is not responsible for, any warranty claims made on
products sold or used outside of the United States.
Table of contents
