Backyard Pro 554BP2D12 User manual

1
DOUBLE BURNER
OUTDOOR PATIO/STOVE
554BP2D12
KEEP THIS MANUAL FOR FUTURE REFERENCE.
THIS INSTRUCTION MANUAL CONTAINS INFORMATION NECCESSARY
FOR SAFETY, ASSEMBLY AND USE OF THIS APPLIANCE. DO NOT USE
THE APPLIANCE UNTIL YOU HAVE READ THIS MANUAL.

2
Contents
1. Assembly Instrucons
2. Pre-Cooking Precauons
3. Lighng Instrucons
4. Storage Instrucons
5. Important Reminders
FOLLOW ALL INSTRUCTIONS IN THIS MANUAL
FOR SAFE AND EFFECTIVE OPERATION.
FAILURE TO FOLLOW INSTRUCTIONS MAY
RESULT IN PROPERTY DAMAGE, GREASE FIRE,
PERSONAL INJURY OR DEATH.
VENDOR AND RETAILER ARE NOT RESPONSIBLE
FOR MISUSE OF THIS PRODUCT.

3
Contents
1. Assembly Instrucons
2. Pre-Cooking Precauons
3. Lighng Instrucons
4. Storage Instrucons
5. Important Reminders
1. ASSEMBLY INSTRUCTIONS
You will need:
1. An adjustable wrench
2. A Phillips head screwdriver
1. Remove all components from the box and individual packaging.
2. Turn base frame upside down.
3. Leg Aachment:
a. Align the leg holes with the corresponding frame holes to achieve desired height
(12” or 25”).
b. Aach long bolts, washers and nuts.
c. Tighten with wrench.
4. Shelf Aachment:
a. Align holes in shelf with guide slots on frame.
b. Insert a short bolt through the shelf and frame on the front of the unit, and one
through the shelf and frame on the back of the unit.
c. Aach washer and nut.
d. Tighten with wrench; be careful not to over-ghten so that shelf may slide.
e. Repeat Steps A through D for second shelf.
5. Hose to Burner Aachment:
a. If the air shuer is not already aached to the burner with screws, align the air
control disc over the end of the burner.
b. Burner’s screws may need ghtening; be careful not to over-ghten.
c. Aach each burner to dual gas connector by inserng threaded end into burner’s
faceplate and turn clockwise to ghten.
d. Insert brass hose connector into dual gas connector.
e. Turn hose connector clockwise with wrench unl snug; be careful not to
over-ghten.
6. Burner Aachment:
a. Remove nuts and washers from each burner’s boom.
b. Align each burner’s bolt to the corresponding hole in the crossbar.
c. Insert the burner’s bolt into the crossbar
d. Aach washer and nut.
e. Tighten with wrench.
7. Return base frame upright.

4
FAILURE TO FOLLOW THESE INSTRUCTIONS MAY RESULT IN
PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.
DO NOT OPERATE THIS APPLIANCE UNDER THE INFLUENCE OF DRUGS OR ALCOHOL.
1. Test your propane tank for gas leaks.
a. Aach the hose and regulator to the propane tank.
b. Close the regulator control valve on the hose to shut o gas ow.
c. Open LP cylinder valve by 1/8 to 1/4 turn.
d. Apply a soapy, non-abrasive liquid to all regulator and tank connecons.
e. If any bubbles appear, there is a gas leak.
DO NOT PROCEED WITH COOKING IF THERE IS A GAS LEAK
2. If you smell gas, immediately shut o the supply at the tank, hose and regulator.
a. Exnguish any and all open ames appropriately.
b. If odor connues, avoid appliance and call local re department.
3. Keep a BC or ABC re exnguisher on hand at all mes for emergencies.
4. Never place dry cookware on this burner.
5. Follow all lighng instrucons in this manual.
6. Never leave this cooker unaended.
7. Maintain 10 feet of clearance on all sides and 25 feet between fryer and other fuels.
8. Never touch used cookware unl liquids have cooled to 115 degrees Fahrenheit or less.
9. In the event of wildre, leave appliance, call re department and DO NOT aempt to
exnguish re with water.
10. In the event of precipitaon, cover cooking pot, turn o fuel supply and unhook equipment.
a. Do not aempt to move the equipment.
11. Do not operate this appliance underneath an overhead obstrucon or on a deck.
12. Thoroughly inspect and clean all equipment before cooking.
13. Always use heat protecve gloves when using this appliance.
14. Do not cook in bare feet or sandals.
15. Never move this appliance when it is in use.
16. KEEP AWAY FROM CHILDREN AND PETS.
2. PRE-COOKING PRECAUTIONS
USE COMMON SENSE WHEN OPERATING THIS APPLIANCE.

5
1. Aer inspecng all applicable ulies for leaks, close tank and hose regulator valves.
2. Reopen tank valve fully.
3. Turn burner’s air control shuer so that it’s almost closed.
4. Hold a lit match or long-nose lighter over the burner and slowly open regulator valve unl
burner ignites.
a. Keep hands and face away from cooker top.
5. Adjust air shuer on burner for a blue ame.
6. Adjust regulator control valve for desired ame height.
7. During rst use, you may smell burning paint. This is normal.
3. LIGHTING INSTRUCTIONS
1. Store all cleaned, maintained equipment in a cool, dry area.
2. Store propane tank away from other cooking equipment in an open area.
3. Unless repainted, the cooker will eventually rust.
4. STORAGE INSTRUCTIONS
1. Only adults who have read this manual may operate this appliance.
2. Never ll propane tanks over 80% full.
3. Never allow oil to exceed 350 degrees Fahrenheit.
4. Always use heat protecve gloves.
5. Never operate underneath an overhead obstrucon or on a deck.
6. Use common sense!
7. Misuse of this product may result in injury, property damage or death.
5. IMPORTANT REMINDERS