B&G DUST-R User manual

• Keep the plunger tube lubricated; place a small amount of
graphite powder in the air port regularly.
• Keep the seal and top free of dust or granules when thread-
ing the cap on the Mini Dust-R and the Hand and ong-
Reach Dust-R.
Befo e Sta ting
T ouble Shooting
Ope ating Inst uctions
Adjusting Delive y
DUST-R & GRANU AR APP ICATORS
USER’S MANUA
Problem: Dust leaking around the cap
Solution: • Tighten the cap
• Replace the seal in the cap
Problem: Not enough dust delivered with each stroke
Solution: • Turn unit until the siphon tube is at the bottom,
resting in the dust
• Add marbles to container to keep dust from
clumping
Problem: Dust leaking around the handle
Solution: • Clean around the check valve at the bottom
of the pump cylinder
• Replace the check valve (PV-266)
Problem: Dust leaking around the handle
Solution: Replace worn plunger gland (#DR-020)
Problem: Granules not delivered through the diphon tube
Solution: • Upper siphon tube in ong Reach Dust-R must
be plugged
• Not enough dust or granules in container
• Some granular formulations have different size
particles, and some are too large for the siphon
• Always wear personal protection equipment required by the
insecticide label.
• Keep stopper and caps on all dusters while not in use and
while transporting the duster
• Always follow label directions on dust or granular insecticides.
• For the application of dust and granular formulations of in-
secticides in cracks and crevices and voids, and perimeter
treatment with granules, and dusting rodent burrows.
• The ong-Reach Granular Dust-R is for applying dust or
granules un areas high above ground, such as wasp nests,
attic soffits and eaves, and tree holes.
• Be sure the plunger moves back and forth smoothly; if not,
place a small amount of graphite powder into the air port in
the handle.
• Become familiar with the position of the siphon tube to en-
sure proper regulation of the dust applied.
• The volume of dust or granules applied can be adjusted by
rotating the position of the siphon tube.
Siphon t be at top - This position delivers
the least amount of dust or granules with
each stroke of the plunger.
Siphon t be at the bottom - This position
delivers the most amount of dust or small
granules.
Hand and Long-Reach D st-R - The
upper siphon tube in the bottle can be
positioned up or down to change output.
Ca e and Maintenance
The application tips and exten-
sions for the Mini Dust-R and
the other models are stored in-
side the plunger tube. Remove
end cap of the plunger tube to
access the tips.
Application Tips
Suggested Uses
Filling
• Unscrew the cap at the end of the Mini Dust-R and fill the
open end (0.5 lb. dust, 7 oz. granules)
•
Unscrew the 2-qt. bottle from the end of the Hand Dust-R and
ong- Reach Dust-R and add dust or granules to bottle (3/4 full).
Select Tip
•
Any of the tips supplied with the unit can be used to apply dust.
• The small tips and extensions may not allow the passage of
granules.
Safety P ecautions
95138404 Rev 8/09
Crack and Crevice Tip


# Part # Description
1 DR-003 Bottle – 1152-A
2 24050001 Bottle – ong Reach
3 DR-027 Outlet
4 2273 O-Ring
5 DR-029 Washer
6 DR-028 ocknut
7 DR-012 Barrel
8 DR-010 Seal, barrel
9 DR-009 Bottle cap
10 DR-006 Bottle seal
11 DR-008 Valve
12 DR-007 Valve plate
13 DR-005 Valve cap
14 1224 Screw, hex head #8
15 MDR-4A Plunger
16 DR-020 Pump gland
17 MDR-2 Collar
18 MDR-15 Ball
19 VT-616 Spring
20 1174 Screw, flat head #6
21 MDR-1 Cap
22 DR-002 Short extension
23 DR-011 ong extension
24 041 Tip, pencil
25 042 Tip, straw
26 DR-001 Stopper assembly
27 24050010 Stopper assembly
28 24050016 Extension clip
29 24050008 Granular outlet
30 24050012 Granular extension
31 24050011 Extension
32 24050014 Extension Velcro
33 24050015 Barrel Velcro
# Part # Description
1 MDR-1 Cap
2 MDR-2 Collar
3 1174 Screw, flat head #6
4 MDR-4 Plunger
5 DR-020 Pump gland
6 MDR-7 Barrel
7 MDR-8 Barrel seal
8 MDR-9 Closure
9 MDR-10 Stopper assembly
10 MDR-11 Tip, offset fan
11 MDR-12 Tip, straw
12 MDR-13 Extensions (3)
13 VT-616 Spring
14 MDR-15 Ball
MODEL 1152-A HAND DUST-R
LONG-REACH GRANULAR DUST-R
MODEL 1151-M MINI-DUST-R
135 REGION SOUTH DRIVE • JACKSON, GA 30233
Toll Free 800-544-8811 • Phone [phone]
www.bgequip.com • F x 678-688-5633
B&G Help Line
800-544-8811
Model 1151-M
Model 1152-A
Long-Reach Gran lar D st-R