Base Camp F235744 User manual

Instructions for use
IMPORTANT
Read this manual carefully before assembling, using or servicing these stoves. Keep this manual
for future reference. If you have any questions about assembly, operation, servicing or repair of
these stoves, please call Basecamp Service at 800.251.0001 for your nearest approved service
agent.
#F235744 3 Burner Propane Stove
4560 West 160th Street Cleveland Ohio, 44135
800.251.0001 www.basecampcamping.com
#F235782 3 Burner Deluxe Propane Stove
35203-Rev-A

FOR YOUR SAFETY
If you smell gas:
1. Do not attempt to
light appliance.
2. Extinguish any open
ame.
3. Disconnect from fuel
supply.
FOR YOUR SAFETY
Do not store or use
gasoline or other liquids
with ammable vapors in
the vicinity of this or any
other appliances.
This manual contains important
information about the assembly,
operation and maintenance of this
outdoor appliance. Safety information
is presented on this page and is also
located throughout these instructions.
Pay particular attention to the
information accompanied by the safety
alert symbol " DANGER"
" WARNING"
" CAUTION".
Keep this manual for future reference and to
educate new users of these products. This manual
should be read in conjunction with the labeling on
the product.
Safety precautions are essential when any
propane fueled equipment is involved. These
precautions are necessary when using, storing
and servicing. Following these safety alerts will
reduce the possibilities of personal injury or
property damage.
The following symbols shown below are used
extensively throughout these instructions. Always
heed these precautions, as they are essential
when using any propane fueled equipment.
DANGER
DANGER indicates an imminently
hazardous situation which, if not
avoided, will result in death or
serious injury.
WARNING
WARNING indicates a potentially haz-
ardous situation which, if not avoided
could result in death or serious injury.
CAUTION
CAUTION indicates a potentially haz-
ardous situation which, if not avoided,
may result in minor or moderate per-
sonal injury, or
property damage.
CARBON MONOXIDE
HAZARD
• This appliance can
produce carbon monoxide
which has no odor.
•Using it in an enclosed
space can kill you.
•Never use this appliance
in an enclosed space
such as a camper, tent,
car or home.
DANGER

The State of California requires the
following warnings:
WARNING: Combustion by-products produced
when using this product contain a chemical known
to the State of California to cause cancer and birth
defects (or other reproductive harm).
WARNING: This product contains chemicals
known to the State of California to cause cancer
and birth defects or other reproductive harm.
DANGER
• Failuretocomplywiththe
precautions and instructions
provided with these stoves can
result in death, serious bodily injury
or property loss or damage from
 hazardsofre,explosion,burn,
asphyxiation, and/or carbon
monoxide poisoning.
•Onlypersonswhocanunderstand
and follow the instructions should
use or service these stoves
- Keep out of reach of children.
• Ifyouneedassistanceorhave
inquiries please contact Basecamp
Service at 800.251.0001.
DANGER
EXPLOSION - FIRE HAZARD
• Neverstorepropanenearhighheat,open
 ames,pilotlights,directsunlight,orother
ignition sources or where temperatures
exceed 120º F (49ºC).
• Propaneisheavierthanairandcanaccumulate
in low places If you smell gas, leave the
area immediately.
• Neverinstallorremovepropanetankwhile
 outdoorstoveislighted,nearame,pilotlights,
other ignition sources or while outdoor
stove is hot to touch.
• Duringlightingandoperation,thisproduct
can be a source of ignition. Never use the stove
in spaces that contain or may contain
volatile or airborne combustibles, or products
such as gasoline, solvents, paint thinners, dust
particles or unknown chemicals.
• Minimumclearancefromcombustiblematerial:
12” from sides - 48” from top
• Provideadequateclearancesaroundair
openings into the combustion chamber.
DANGER
CARBON MONOXIDE HAZARD
• Thesestovesareacombustionappliance.
All combustion appliances produce carbon
 monoxide(CO)duringthecombustionprocess.
These products are designed to produce
extremely minute non-hazardous amounts of
 COifusedandmaintainedinaccordancewith
 allwarningandinstructions.Donotblockair
 owintooroutofthesestoves.
• CarbonMonoxide(CO)poisoningproduces
 u-likesymptoms,wateryeyes,headaches,
dizziness, fatigue and possibly death. You can’t
see it and you can’t smell it. It’s an invisible killer.
If these symptoms are present during operation
of these products GET FRESH AIR
IMMEDIATELY!
• FOR OUTDOOR USE ONLY.
• Never use inside a dwelling home, camper,
tent, vehicle or other unventilated or
enclosed areas. These stoves consume air
(Oxygen) and produce carbon monoxide
(CO). Do not use in unventilated or enclosed
areas to avoid endangering your life.
WARNING
• Thisproductisfueledbypropanegas.Propane
 gasisinvisible,odorless,andammable.An
odorant is normally added to help detect leaks
and can be described as a “rotten egg” smell.
The odorant can fade over time so leaking gas
is not always detectable by smell alone.
• Propanegasisheavierthanairandleaking
propane will sink to the lowest level possible. It
can ignite by ignition sources including matches,
 lighters,sparksoropenamesofanykindmany
feet away from the original leak, Use only
propane gas set up for vapor withdrawal.
• Propanegasshouldbestoredorusedin
compliance with local ordinances and codes or
with ANSI/NFPA 58. Turn off propane when
not in use.
• Donotconnecttoaremotegassupply.
 Duringstoveset-up,checkallttingsforleaks
 usingsoapywater.Neveruseaame.Ifstored
indoors, detach and leave cylinder outdoors.

Technical
Characteristics
• Category: Pressure regulated propane
• Fuel: 16.4 oz. disposable propane cylinders
#F235744- 3 Burner Standard Stove:
2 x 10,000 BTU/HR - 1 x 6,400 BTU/HR
#F235782 - 3 Burner Deluxe Stove:
2 x 10,000 BTU/HR - 1 x 6,400 BTU/HR
DANGER
• Foroutdooruseonly.
• Neveruseinsidehouse,camper,tent,vehicle
or other unventilated or enclosed areas. This
 stoveconsumesair(Oxygen)andproduces
 carbonmonoxide(CO).Donotusein
unventilated or enclosed areas to avoid
endangering your life.
CAUTION
SERVICE SAFETY
• Keepallconnectionsandttingsclean.Inspect
propane cylinder and stove propane connections
for damage before attaching.
• Duringset-up,checkallconnectionsforleaks
 usingsoapywater.NEVERUSEAFLAME!
Bubbles from using soapy water indicate a
leak. Check that the connection is not cross-
threaded and that it is tight. Perform another
leak check. If there is still a leak, remove the
cylinder and contact Basecamp service for
support. 9800.251.0001.
• Useasacookingdeviceonly.Neveruseasa
space heater or leave unattended while lit.
Never alter in anyway or use with any device or
part not expressly approved by Basecamp.
• Cleanstovefrequentlytoavoidgrease
 accumulationandpossiblegreaseres.
WARNING
BURN HAZARD
• Neverleavestovesunattendedwhen
hot or in use.
• Keepoutofreachofchildren.
WARNING
Not for home or
recreational vehicle use.
We cannot foresee every use with which may be
madewithourproducts.Checkwithyourlocalre
authorityifyouhavequestionsaboutuse.Other
standards govern the use of fuel gases and heat
producingproductsforspecicuses.Yourlocal
authorities can advise you regarding these codes
and ordinances.
• Usethepresetregulatorthatcamewith
 appliances.Donoattempttoadjust.
• UseonlyBasecampaccessoriesorparts.
 Duringstoveset-up,checkallttingsfor
 leaksusingsoapywater.Neveruseaame.
Set Up
CARBON MONOXIDE HAZARD
NOTE: Use only 16.4 oz. disposable propane
cylinders. The LP gas cylinder(s) used with
portable propane stoves must be constructed
and marked in accordance with the
specications for LP-gas cylinders of the
U.S. Department of Transportation or Transport
Canada, CAN/CSA B339
1. Remove and inspect all
components from package.
2. Open Lid
3. Position wind
guard as
desired.

Set Up (continued)
Install
pot
support
grate
4.
5. Close both burner valves rmly.
CAUTION
SERVICE SAFETY
• Keepallconnectionsandttingsclean.Inspect
propane cylinder and stove propane connections
for damage before attaching.
• Duringset-up,checkallconnectionsandttings
for leaks using soapy water. Bubbles indicate a
 leak.Neveruseaame
6. Screw regulator into stove (Hand tight)
7. Remove plastic cap from top of pro-
pane bottle and screw propane bottle
into regulator (Hand tight)
8. Propane cylinder properly installed
9. Never operate stoves with propane
cylinder in an inverted position.
Leak Check
WARNING
• Perform leak test outdoors
• Extinguish all open ames
• NEVER leak test when smoking
• Do not use the outdoor stove until
connection has been leak tested and
does not leak
To Light
DANGER
• Propaneisheavierthanairandcanaccumulate
in low places. If you smell gas, leave the area
immediately.
• Alwaysattachordetachpropanesource
outdoors; never while stove is lighted, near
 ame,pilotlights,otherignitionsourcesor
while stove is hot to the touch
• Thesestovesareveryhotduringuseandcan
 igniteammablestooclosetotheburners.
 Keepammablesatleast12”fromthesidesand
48” from their top. Keep gasoline and other
 ammableliquidsandvaporswellaway
from stoves.
• Thesestovesmustnotbeexposedtoammable
vapors or liquids during lighting
EXPLOSION - FIRE HAZARD
WARNING
BURN HAZARD
• Neverleavestovesunattendedwhen
hot or in use.
• Keepoutofreachofchildren.

• Make sure stoves is cool.
• Move stoves away from ame
(Including pilot lights) and other
ignition sources
• Remove propane cylinder from regulator
and replace protective cap on cylinder
• Remove regulator from stoves
• Lift off grate
Standard Ignition Stoves
To Light (Continued)
Set stove on sturdy, at surface. For
outdoor use only.
Hold lit match
near burner and
open burner
valve.
#F235744 3 Burner Propane Stove
2.
1.
Peizo Ignition Stoves
Set stove on sturdy, at surface. For
outdoor use only.
Select the burner to be ignited and
slowly turn the gas control in a counter-
clockwise direction approximately
¼ of a turn.
#F235782 3 Burner Deluxe Propane Stove
2.
1.
Depress the
Piezo button
rmly to get a
spark from the
electrode
positioned
above the
burner.
3.
Adjust ame with burner valve. Flame should
be blue with a hint of yellow in the tips.
4.
To Turn Off
With the ame still operating, turn the gas
control knob in the clockwise direction until
they are rmly “Off”. Allow the ame to burn
down then extinguish once all remaining gas in
the system has been used.
To Clean
• Keep stove areas clean and free from
combustible materials, gasoline and
other ammable vapors and liquids
• Do not obstruct the ow of combustion
and ventilation air
• A good ame should be blue with
minimal yellow tips on ends of ames.
Some yellow tips on ames are
acceptable as long as no carbon
or soot deposits appear.
• Wipe clean with soft cloth and mild
dish detergent. Do not use abrasives.
Maintenance
If Piezo does not light burner on rst try, close
gas control, wait 10 seconds and go back to
step 2.
5.

•Itisunsafeandillegalinsomeplaces
to store or use propane cylinders of
greater than 1.14 kg (2.5 lb.) water
capacity (approximately 1 lb.
propane) in occupied enclosures.
•Theusualstorageareasforcamping
and picnic equipment are the
basement, attic or garage. To avoid
the accumulation of dust, cobwebs
etc., that is common in these storage
areas, place your stove in a plastic
bag and seal with a rubber band or
keep the original carton.
•Forrepairservicecall800.251.0001.
If product must be returned to
Basecamp service, attach to the
product a tag stating your name,
address daytime phone number and
an email and a description of your
 issue.DONOTsendpropane
cylinder. Carefully package the
product and send either by courier or
insured mail with shipping and
insurance to us Basecamp Service:
For products purchased in the United
States:
Basecamp Service
4560 West 160th Street
Cleveland,OH. 44135
800.251.0001
If not completely satised with
the performance of your
product, please call
800.251.0001
www.basecampcamping.com
To Store Things you should know
DANGER
• NEVER STORE PROPANE near high
heat, open ames, pilot lights, direct
sunlight, other ignition sources or
where temperatures exceed 120º F
(49ºC).
• The cylinder must be disconnected
when the stove is not in use.
EXPLOSION - FIRE HAZARD
For storage or transport, the regulator
may be located below the pot support.
To carry stoves, rmly grasp by the
handle - making sure appliances is
properly locked by the 2 leg supports.

WARRANTY
This appliance is covered against faulty workmanship and materials for a period of 12 months from the date of
original purchase. The following items are not covered by warranty:
• Blockedjetnipples-Eachoftheseitemsareaserviceablepartandarereadilyavailablefromyourspecialist
outdoor retailer.
PART NO. SIZE BURNER PERFORMANCE WEIGHT
F 235744 23.22 x 11.02” 10,000 / 10,000/6,400 BTU 12.35lb
PART NO. SIZE BURNER PERFORMANCE WEIGHT
F 235782 23.22 x 11.02” 10,000 / 10,000/6,400 BTU 12.35lb
Parts List & Technical Data
1
2
3
3
10
11
12
13
13
14
5
4
6
6
6
6
6
6
7
7
7
8
8
8
9
9
9
Spare Part List
1 35420 Trivet
2 35421 Medium burner
3 35401 Large burner
4 35422 Gasjetmediumburner
5 35402 Gasjetlargeburner
6 35423 “O” ring for spindle
7 35404 Spindle
8 35405 Lock nut
9 35406 Control knob
10 35407 “O” ring for gas connector
11 35408 Regulator
12 35424 Piezo ignition
13 35425 Electrode-mid-right
14 35426 Electrode-left