Bauknecht ESZB 5460 User manual

Instructions for use
Precautions and general recommendations
Installation
Electrical connection
Energy saving tips
Oven accessories
Cooktop accessories
Cooking charts
Cleaning the oven and accessories
Cleaning the cooktop
Troubleshooting guide
After Sales-Service

Precautions and general recommendations
Before using the appliances
• To make the most of your
new appliances, read the
users instructions carefully
and keep them on hand for
consultation in the future.
• Remove the cardboard
protections and the
protective plastic film.
• Remove the accessories
from the oven and heat it
200°C for about an hour to
eliminate the smell of
protective grease and
insulating materials. Keep
the window open during
this procedure.
N.B: The cooling fan runs
continuously at two
different speeds
according to the
temperature value of the
components when the
appliances are in use.
Full speed: for high
temperature of the
components.
Half speed pulsing: for
low temperature of the
components.
The pulsing speed has to
be considered a normal
appliance condition at
half speed. The fan may
continue to run for the
time necessary to
ensure sufficient cooling
of the components and
adjacent kitchen units
after the appliance has
been switched off.
Protecting the environment
1. Packing
• The packaging material can
be100% recycled, as
confirmed by the recycling
symbol .
2. Products
• The appliances are built
from recyclable materials.
If you decide to scrap the
appliances please observe
local waste disposal by-
laws. Cut off the power
cords so that the
appliances cannot be
connected to the mains.
Precautions and general
recommendations
• Before any maintenance on
the appliances disconnect
them from the electrical
power supply.
• Keep children away from
the appliances when they
are in use.
• The appliances must be
repaired or adjusted only
by a qualified technician.
• Make sure that the
electrical wires of other
electrical appliances near
the cooktop or the oven do
not come into contact with
hot parts and do not
become entrapped in the
oven door.
• The oven is equipped with
air cooling system to
prevent excessive
temperatures of the oven
front and furniture
housing. Following cooking
times greater than one
hour at temperatures of
200°C or more, it is
recommended that residual
heat from the oven and
housing be removed by use
of a cool down period. At
completion of cooking,
leave the oven on, in any
cooking function but grill
with the "temperature
knob" on "0" position, for
about 15 minutes. The
oven door must remain
closed during the cool
down period.
Oven
• Never stand or sit on the
oven open door. Never hand
any weight at the handle of
the oven open door.
• Use oven gloves to remove
baking trays and
accessories when the oven
is hot.
• Do not cover the bottom
of the oven with
aluminium foil.
• Do not place inflammable
material in the oven - risk
of fire if the oven is
inadvertently switched on.
• During the cooking
process, water evaporates
from food. All ovens
require this steam and
other fumes to be vented
from the oven cavity. For
reasons of safety and
aesthetics, we have
determined that an
opening at the bottom of
the door is the optimum
solution. Consequently,
vapour may be seen to be
coming from this area on
occasions (see picture).
This is a normal occurrence
and the bottom trim can
be cleaned after removal
of the door as described on
"Cleaning the oven and
accessories".
• Heavy weights must not be
placed on the open door as
this may result in damage
to the cavity and hinges.
Max weight: 7 kg (15lbs).
Fumes Exhaust

Precautions and general recommendations
Conventional
electric/glass-ceramic
cooktop
• Do not switch on the
hotplates/cooking zones
when there is no pan in
position.
• The cooktop features
different size
hotplates/cooking zones.
Use pans whose base
diameter is the same as or
slightly larger than the
diameter of the
hotplate/cooking zone.
• Use flat-bottomed pans.
The use of pans with
concave or convex bottoms
may damage the cooktop.
• Do not use the cooktop as
a worksurface or a support
surface.
• Do not leave the appliance
unattended when frying
food - risk of fire.
Specific recommendations
for glass-ceramic cooktops
• With the fast boiling
function, only use stainless
steel pans with double
layer bottoms.
• If the glass ceramic surface
should break or crack due
to violent impact (falling
objects, etc.) do not use it
and call After Sales Service
immediately.
• Do not place food wrapped
in aluminium foil, plastic
containers or cloths on the
hot cooking zones.
• Do not drag pans across
the glass-ceramic surface -
risk of scratches.
• If your hob is provided
with halogen lamps, we
recommend that you do
not stare at them during
the operation.
• Avoid spilling sugar and
similar substances on the
cooktop. If necessary, clean
the cooktop carefully
following the care and
maintenance instructions in
this handbook.
Declaration of conformity CE
• These appliances are
designed to come into
contact with foodstuffs
and they are constructed in
compliance with Directive
89/109/EEC.
• They are designed solely
for use as domestic cooking
appliances. Any other use
of the appliances (e.g. for
room heating) is
considered as improper use
and potentially dangerous.
• These appliances are
designed, built and sold in
compliance with:
- the safety requirements
of "Low Voltage" Directive
73/23/EEC;
- the protection
requirements of EMC
Directive 89/336/EEC;
- the requirements of
Directive 93/68/EEC.

Installation
Technical information for
the installer
OVEN
• After removing the oven
from its packaging, before
making the connections
place it on the polystyrene
foam base to protect it
from damage.
• Do not attempt to lift the
oven by the handle.
Lift at the sides as shown
in the figure (see arrow).
• Check that the appliance
has not been damaged in
transit.
• Oven dimensions and
kitchen unit dimensions
are shown in the opposite
figure.
• Kitchen units in contact
with the oven must be
heat resistant (80°C).
• If plastic laminates or
cement are not sufficiently
heat-resistant, warping,
bubbling or detachment of
the finish may result.

Installation
• For correct ventilation,
follow the ventilation
opening directions shown
in the figure (at least 500 x
80 mm). Also provide for
at least 5 mm clearance
between the top of the
oven and the lower edge
of the worktop. This space
must not be obstructed by
cross rails or other
structural elements.
• During oven installation,
care must be taken to
ensure that the sides are
not touching the front
edges of the housing or
adjacent drawers and
doors (see picture).
• Carry out the electrical
connections between
cooktop and oven (see
chapter "Electrical
connection").
• Secure the oven to the
kitchen unit with screws
(A) as shown.
No Contacts

Cooktop with electric
hotplates
• If the worktop is made of
wood, fit the supplied clips.
1.Position the 4 spring clips
(B) and fit them in their
locations on the underside
of the cooktop.
2.Fit the cooktop into the
worktop.
•If the worktop is made
of marble, plastic,
ceramics, natural stone,
etc., the cooktop must be
secured with brackets (C)
code 4819 310 18528 (to be
requested from After Sales
Service).
1.Position the brackets over
the holes and secure them
with the supplied screws.
2.Fit the cooktop into the
worktop.
Cooktop
• The cooktop must be set
into a worktop between
20 mm and 50 mm
thick.
There must be nothing
between the cooktop
and the oven (cross
rails, brackets, etc.).
• If the cooktop is to be
installed next to a
column unit, leave a
distance of at least
100mm from the edge
of the cooktop to the
side of the column unit.
• Cut an opening in the
worktop of the dimensions
shown in the Product
Description Sheet supplied
separately.
• If not already present, fit
the supplied seal to the
cooktop flange after
cleaning the contact area
as shown in the figure.
Installation

Installation
Glass-ceramic cooktop
N.B.: Remove the protective
film before installing the
cooktop.
•If the worktop is made
of wood, use the supplied
spring clips and screws.
1.Position the 4 clips (D) as
shown and at the specified
dimensions.
2.Secure the clips using
screws (E).
3.Fit the cooktop into the
worktop.
• If the worktop is made of
marble, plastic, ceramics,
natural stone, etc., the
cooktop must be secured
with brackets (F) code 4819
404 78697 (to be requested
from After Sales Service).
1.Fit the cooktop into the
worktop.
2.Position the 4 brackets (F)
as shown in the figure, in
accordance with the
thickness of the worktop.
3.Fix the 4 screws (G)
in holes (H).

Electrical connection
• Make sure the
appliances are installed
and connected to the
electricity supply by a
qualified technician in
accordance with the
manufacturer's
instructions and in
compliance with local
regulations.
• The installer is
responsible for the
correct electrical
connection of the
appliances and the
observance of the
relative safety
regulations.
• The appliance must be
connected to the
electricity supply by
means of an all-pole
disconnect switch with
minimum contact gap
of 3 mm.
• The appliances must be
earthed by law.
• Do not use multiple
plug adapters or
extension leads.
• After the appliances
have been installed, the
electrical components
must be inaccessible.
WARNING: DO NOT
CONNECT TO THE POWER
SUPPLY BEFORE YOU
HAVE FINISHED
CONNECTING THE OVEN
AND COOKTOP.
• Mount the oven in the
kitchen unit.
Make sure the power cord
is not trapped.
Connecting the oven to
the power supply
• Make sure that the voltage
shown on the rating plate
is the same as the power
supply voltage in your
home.
The rating plate is on the
front edge of the oven
cavity (visible with oven
door open).
• Use a type H05RR-F power
cord (minimum length 800
mm).
•Warning: All the oven's
components operate at
230-240 V. When using a
400 V connection, make
sure that the voltage
reaching the oven is
230-240 V, as illustrated
in the side table.
L3L2L1
E
400V 3N~
N
R
TS
230V
ETSR
N
N
230V
230V
L3L2L1
E
230V 1N~
N
R
ER
N
N
230V
L3L2L1
E
400V 2N~
N
R
S
230V
ESR
N
N
230V
230V
L3L2L1
E
230V 3 ~
N
R
S
230V
ESR
T
N
230V
230V
Interconnecting cooktop
and oven
• Before connecting the
oven to the power supply,
check that the cooktop is
among the ones listed in
the cooktop/oven pairing
product sheet.
Connect the 3 pole and 4
pole connectors to the
respective connectors on
the oven.
• The 3 pole connectors (H) is
located at the rear right
hand side of the control
panel, the 4 pole connector
(J) is located at the top of
the oven in the left hand
corner (see figure).
• Connect the yellow/green
striped earth wire( ) (K)
from the cooktop to the
screw located near the 3
pole connector.
Conductors x numbers Connection
1N+ ~HO5 RR-F 3 x 4 mmq
2N+ ~HO5 RR-F 4 x 2,5 mmq
3+ ~HO5 RR-F 4 x 2,5 mmq
3N+ ~HO5 RR-F 5 x 1,5 mmq

Oven accessories
Accessories supplied depend on the model
(refer to the Product Description Sheet supplied separately)
Drip tray
The drip tray is designed to
collect fat and food particles
when it is positioned under
the grid;
it can also be used as a
griddle to cook meat,
chicken and fish, with or
without vegetables.
When using the drip tray
under the grid, pour in a
little water to avoid fat
spatters and smoke.
Baking tray
For cooking biscuits,
meringues and pizzas.
Grid
The grid can be used to grill
food or as a support for
baking trays, cake tins and
other cooking receptacles.
It has two possible positions
( or ) and can be
placed on any of the runners
in the oven.
Energy saving tips
• Use pots and pans whose
bottom diameter is equal
to that of the cooking
zone or slightly larger.
• Important:
To avoid permanently
damaging the glass-
ceramic top, do not use:
- Pots with bottoms that
are not perfectly flat
- Metal pots with
enamelled bottom.
• If possible, keep the pot
covered when cooking.
• Cook vegetables, potatoes,
etc. with little water in
order to cut down cooking
time.
• A pressure cooker allows
you to save even more
energy and time.
NO!

Oven accessories
Accessories supplied depend on the model
(refer to the Product Description Sheet supplied separately)
Catalytic panels
(depending on model)
The catalytic panels have a
microporous coating that
absorbs fat spatters. We
recommend an automatic
cleaning cycle after cooking
particular fatty food.
1.To clean the oven heat it
to 200°C when empty and
leave it switched on for
about an hour.
2.At the end of the cycle and
when the oven is cool, use
a moist sponge to remove
food residues if necessary.
Do not use detergent or
cleaners - risk of damaging
the catalytic enamel coating
Spit
(depending on model)
Use the spit as indicated in
the relevant chapter in the
Product Description Sheet
supplied separately.
Cooktop accessories
Child guard accessory
AMH 122
This accessory can be
obtained from the After
Sales Service under
Part N° 4819 310 18436
or from your Dealer under
Ref. 017124.

Cooking chart
Meat
Lamb (1,5 Kg)
Kid (1,5 Kg)
Mutton (1,5 Kg)
Veal (1,5 Kg)
Beef (1 Kg)
Pork (1 Kg)
Rabbit (1,5 Kg)
Chicken (1 Kg)
Turkey (3 Kg)
Goose (2 Kg)
Duck (1,5 Kg)
Fish (approx 1 kg)
Gilt head
Bass
Salmon
Tuna
Trout
Fish Steaks (1 kg)
Swordfish
Tuna
Salmon
Cod
Vegetables
Stuffed peppers
Stuffed tomatoes
Baked potatoes
Au gratin
Desserts etc.
Cakes
Cake with filling
(fruit - cheese)
Tarts
Apple strudel
Biscuits
Choux pastry
Pies
Bread
Pizza
Lasagne
Vol-au-vents
Soufflès
200
200
200
180
180
180
180
200
180
180
180
180
180
180
180
180
170
170
170
170
180
180
180
180
150
160
170
180
140
150
160
180
225
180
180
160
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
90-120
90-120
90-120
90-120
90-120
100-130
100-110
65-75
180-200
140-160
90-120
45-55
60-80
60-80
60-80
45-55
35-45
35-45
35-45
35-45
50-70
50-70
40-50
40-50
35-45
60-80
30-40
40-50
20-35
30-40
50-60
30-40
10-15
35-45
15-25
40-50
200
200
200
200
200
200
200
200
200
200
200
180
180
180
180
180
180
180
180
180
180
180
200
200
150
160
160
190
150
170
160
220
250
200
200
180
2
2
2
2
2
2
3
2
2
2
2
2
2
2
2
3
3
3
3
3
2
3
3
3
3
3
3
3
1-3
2-3
3
2
1-3
3
1-3
2
75-85
75-85
75-85
75-85
65-75
65-75
75-85
60-70
130-150
90-100
75-85
40-50
40-50
40-50
40-50
40-50
35-45
35-45
35-45
35-45
40-50
55-65
55-65
65-75
30-40
45-55
45-55
45-50
25-35
30-40
45-55
50-60
30-40
35-45
15-20
45-55
180
180
180
170
170
170
170
200
180
180
180
170
170
170
170
170
170
170
170
170
170
170
180
180
150
160
170
180
140
150
160
180
225
180
180
160
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2
2-4
2-4
2
2
2
2
2-4
2
80-110
80-110
80-110
80-110
80-110
90-120
90-120
65-75
180-200
140-160
90-110
45-55
60-80
60-80
60-80
45-55
35-45
35-45
35-45
35-45
50-70
50-70
40-50
40-50
35-45
60-80
30-40
40-50
20-35
30-40
50-60
30-40
10-15
35-45
15-25
40-50
N.B.: Cooking times and temperatures are purely guidelines. Oven functions
depend on the model. Refer to the separate Product Description Sheet.
Food Static function Fan function Static function+Fan
Temp.°C Shelf Cooking Temp.°C Shelf Cooking Temp.°C Shelf Cooking
from Time from Time from Time
bottom (Mins.) bottom (Mins.) bottom (Mins.)

Cooking chart
Sirloin steak
Cutlets
Sausages
Pork chops
Fish
Chicken drumstick
Kebabs
Spare ribs
Chicken halves
Whole chicken
Roast
(pork, beef, veal)
(approx 1 kg)
Duck
Leg of lamb
Roast Beef
200
200
200
200
200
200
200
200
200
-
-
-
-
-
4
4
4
4
4
4
4
4
3
-
-
-
-
-
25-35
20-30
25-35
20-30
20-30
30-40
25-35
35-45
45-55
-
-
-
-
-
225
225
225
225
220
200
200
200
200
200
175
180
200
200
3
3
3
3
3
3
3
3
3
3
2
2
2
2
20-30
15-25
20-30
15-25
15-25
30-40
25-35
35-45
45-55
60-70
90-100
90-120
80-100
40-60
Food Grill Grill+Fan
Temp.°C Shelf Cooking Temp.°C Shelf Cooking
from Time from Time
bottom (Mins.) bottom (Mins.)
N.B.: Cooking times and temperatures are purely guidelines. Oven functions
depend on the model. Refer to the separate Product Description Sheet.

Cleaning the oven and accessories
Removing the oven door
(for cleaning)
1.Open the oven door.
2.Press hinge catches (A)
forwards.
3.Lift the catches until they
engage and then remove
the door.
4.While you are cleaning the
oven, ensure you do not
disengage the hinge
retainer catches.
5.Refit the oven door by
following the above steps
in reverse order.
• When you finish cooking,
wait for the oven to cool
and then clean it to
prevent the build-up of
baked-on residues.
• If the food residues are
baked on, use a specific
oven cleaner and follow
the manufacturer's
instructions on the pack.
• Clean the exterior of the
oven with a sponge and
warm water.
• Do not use abrasive
cleaners or pan
scourers.
• Use a liquid detergent to
clean the oven door
window.
• Wash the accessories in a
dishwasher or in the sink,
using an oven cleaner.
• After the oven has been in
prolonged use and when
cooking on different levels
(especially food with high
water contents such as
pizzas, stuffed vegetables,
etc.) condensation may
form on the inside of the
door seal.
When the oven is cool, dry
any condensation with a
cloth or sponge.
Additional information
for appliances which have
an aluminium front:
The material has a sensitive
surface. In order to avoid
scratches, only use a soft
sponge and liquid cleaner to
clean the front of the
appliance.

Changing the oven lamp
1.Disconnect the oven from
electrical supply.
2.Unscrew the lamp cover.
3.Change the lamp (see
N.B.).
4.Refit the lamp cover.
5.Reconnect the electrical
supply.
Changing the lateral lamp
(depending on model)
1.Disconnect the oven from
electrical supply.
2.Remove the left hand side
grid.
3.Use a screwdriver to prize
off the lamp cover.
4.Remove the bulb (see N.B)
from the ceramic holder.
Fit the new bulb using
plastic gloves, or degrease
it with alcohol.
5.Reposition the lamp cover
and press it against the
oven wall until it clicks into
place.
6.Refit the side grid.
7.Reconnect the power
supply.
N.B: Use exclusively 25 W,
230 V, E-14 type, T300°C
lamps only, available from
After Sales Service.
Cleaning the oven and accessories
Dropping the grill
element to clean the oven
roof (depending on model)
• Do not attempt to clean
the oven until it is cool.
1.To clean the oven roof, pull
out the grill element and
lower it as far as it will go.
2.Clean the oven roof and
then return the grill
element to its original
position.

Cleaning the cooktop
Care and maintenance of
glass-ceramic cooktops
Clean the cooktop, when it is
cool, after each use. This will
prevent the build-up of dirt
and make cleaning easier.
• Use a clean cloth,
absorbent kitchen wipes
and washing up liquid or a
specific glass-ceramic hob
cleaner.
• Remove baked-on dirt
with the supplied scraper
tool and specific cleaning
products.
• Food spills should be
cleaned off before they
bake onto the glass-
ceramic surface.
• Do not use abrasive
products, bleach, oven-
cleaner spray or pan
scourers.
• The cooktop should be
treated periodically with a
proprietary brand of
protective wax for glass-
ceramic hobs.
Before cleaning the cooktop,
disconnect it from the
electrical supply and wait
until it has cooled.
Care and Maintenance of
conventional cooktop
• Use a cloth and warm
soapy water.
• Do not use abrasives,
corrosive cleaners, cleaners
containing chlorine or pan
scourers.
• Do not leave acidic
substances on the cooktop
(vinegar, salt, lemon juice,
etc.).
Stainless steel cooktop
• Use a proprietary cleaning
product for stainless steel.
N.B: Prolonged use of the
cooktop may result in slight
discoloration of the stainless
steel surfaces around the
hotplates. This is caused by
the high temperature of the
hotplates.
Cleaning the hotplates
Clean the hotplates when
they are warm
(not hot!). Use a cloth
moistened with water and
salt. Dry and clean with a
cloth moistened with
cooking oil.

Troubleshooting guide
Oven not working
• Switch the oven off and
then on again to see if the
problem persists.
• Check for the presence of
mains electrical power.
• Oven selector on position
"0" ?
• Check whether you have
made the temperature
setting and the function
setting.
• If the electronic
programmer display
(depending on model)
presents the message
"OFF", press any key to
reset the oven and then
set the clock.
• Ensure that the mechanical
programmer (depending
on model) is set to .
Cooktop not working
• Ensure that the cooktop is
receiving electrical power.
• Control knob set to "0"?
Set the main disconnect
switch upline of the
appliance to "OFF" for a
few minutes and then back
to "ON" and see if the
problem persists.
Before contacting After
Sales Service:
1.Try to solve the problem
(see "Troubleshooting
Guide").
2.Turn off the appliance and
restart it to see if the fault
is repeated.
If after the above checks
the fault still occurs, get
in touch with the nearest
After Sales Service.
Please give:
• a short description of the
fault,
• the exact type and
model,
• the service number
(number after the word
Service on the rating plate)
is located on the underside
of the cooktop or on the
Product Description Sheet
and on the right hand
edge of the oven cavity
(visible when the oven
door is open). The service
numbers are also indicated
on the guarantee booklet,
• your complete address and
phone number.
After Sales-Service
Printed in Italy
2/0101
GB
5019 410 54241/A