Berkley Jensen GREENVAIL GRILL GAZEBO User manual

8’ x 5’
Pistol Drill Ladder 2 people
Note: The gazebo needs to be installed in cooperation with five people.
The following tools are not included and needed for assembly:
GREENVAIL GRILL GAZEBO
If you have comments or questions, please contact BJ’s Wholesale Club at 1-800-934-1204.
If you have any issues with the product, do not return the product back to the store.
For any questions, replacement parts or issues about our product, call Sunjoy Customer
Service 1(866) 578 6569. For further assistance, please email us at [e-mail].
ASSEMBLY INSTRUCTIONS
ARTICLE# 240084

2/ 23
Warning! To reduce the risk of serious injury, read the following safety instructions before assembling
and using the gazebo.
Caution! Always keep children under close supervision while they are using or around this product.
Never leave children unattended.
This product is intended for outdoor use only.
The product should be assembled on a flat stable surface.
Do not assemble the gazebo on unstable surfaces.
Ensure the location and clearance of your gazebo is acceptable.
The gazebo must be anchored with stakes into the ground for added safety. It is recommended that
it should not be permanently attached to a concrete floor or platform.
Arrange the necessary manpower when assembling or moving the product.
Some parts may contain sharp edges. Wear protective gloves and glasses if necessary.
Keep children and pets away while setting up the gazebo.
Check all nuts and bolts periodically for tightness. When required, tighten them again.
Repairing and replacing parts should be done by a qualified technician.
The gazebo is intended for decorative and shade purposes only, and is not designed to withstand
harsh weather, including high winds, rain and snow.
If the product is not being used for long periods of time (e.g. winter), it should be stored in a clean,
dry environment.
Do not put a liquid propane or Wood Burning fire pit or fireplace inside the product.
Do not climb or place heavy objects onto the gazebo roof.
Retain the original packaging to store and protect the gazebo during the winter months.
Do not use or enter the gazebo if the following conditions exists：
1. Visible movement of supports, roofing panels or a sagging roof.
2. Unusual noise from the gazebo.
3. Deformed roof panels.
4. Damaged or missing bolts/fasteners.
Please check your HOA, Local, and State Governments prior to purchasing and assembling
gazebos. These local organizations may require permits and specific requirements for installation.
Maintain your instruction manual for future reference
Warranty: Please retain you receipt for proof of purchase.
Important Safety Instructions

3/ 20
EXPLODED DRAWING

4/ 20
Parts List
Label Part Number Description Qty Part Image
A1 P000200366 Post1 2
A2 P000200381 Post22
B P006100143 Base Cover 4
C P000100269 Base 4
D1 P005000325 Support Bar 1 4
D2 P005000326 Support Bar 2 4
E1 P000400757
Long side left
cross beam 2
E2 P000400758
Long side right
cross beam 2
F P000400759 Short side beam 2
G P002100248 Shelf 2
H P005000327 Shelf Support 4
I P000601168
Big Roof Sloping
Beam 4
J P005800001 Hook 1
K1 P000500950
Roof Connector
Long Bar 1 1
K2 P000500951
Roof Connector
Long Bar 2 1
L1 P000500952
Roof Connector
Short Bar 1 2
L2 P000500953 Roof Connector
Short Bar 2 2

5/ 20
M P001100454 Big Canopy 1
N P000601167 Small Roof
Sloping Beam 4
O P001100455 Small Canopy 1

6/ 20
Hardware Pack
Label Part Number Description Qty Add Part Image
AA H010030032 M6 x 20 mm
Bolt 76 4
BB H050030001 M6 Flat
Washer 84 4
CC H010030023 M6 x 35 mm
Bolt 4 1
DD H040010004 M6 Nut 4 1
EE H050020017 M6 Spring
Washer 44 3
GG H070010001 ￠6 x 230 mm
Stake
8 0
Z1 H090030002 M6 Allen Key 1 0
Z2 H090010017 M6 Wrench 1 0

7/ 20
2
1

8/ 20
2

9/ 20
3

10 / 20
2
4
2
4

11 / 20
25

12 / 20
CLICK!
26

13 / 20
27
CLICK!

14 / 20
28
CLICK!
CLICK!

15 / 20
29

16 / 20
2
10
CLICK!

17 / 20
11

18 / 20
z
12

19 / 20
13

23 / 23
Caution!
Check all screws and nuts periodically for tightness, fastening them again as required.
Disassemble the gazebo in the reverse order of the assembly steps. Always disassemble the
gazebo completely. A partially disassembled gazebo is not stable enough to resist wind and bad
weather, and therefore can be damaged and/or cause damage.
Clean the gazebo with mild soap and water. Rinse thoroughly，and wait until the product is dry
before reassembling it.
Snow must be cleared off regularly during snowy days. Remove the snow at the roof top when it is
thicker than 2 inches. In order to avoid damage, use a plastic snow rake to remove excessive snow
and ice buildup from roof and keep away from falling debris.
Do not use bleach, acid, or other abrasive cleaners on the canopies or frame parts.
Steel components for this gazebo are treated with rust inhibiting paint it form rusting. However, due
to the nature of steel, surface oxidation (rusting) will occur if theses protective coatings are
scratched. This is not a defect and thus not covered by the warranty, To minimize this condition, it is
recommended to use care when assembling and handling the product to prevent scratching the
paint. Should any scratching or damage occur, it is recommended to cover the scratch immediately
with rust inhibiting paint（not included）. Surface rust can also be easily removed with a very light
application of regular cooking oil or WD-40. If surface oxidation(rusting) occurs and if no measure is
taken to prevent this, the oxidation may start dripping onto deck or patio and caused damaging
stains, which may be difficult to remove. This can be prevented if the above-mentioned measures
are taken to keep the product from oxidizing.
Keep instruction manual for future reference.
Keep the original packaging to store the gazebo.
Carefully check all packaging materials before discarding. Do not assemble if there are missing pieces. For
comments or questions please contact BJ’s Wholesale Club at 1-800-934-1204.
Please do not return this product to the store. For technical assistance on assembly or replacement parts call
Sunjoy Group at 1(866) 578-6569 anytime 24 hour /7 days a week or Email [email protected] or visit
www.sunjoyonline.com to place your order or fax your parts replacement order form together with your purchase
receipt to 951-667-3447 for assistance.
Production Number: 2021200007
Cleaning and Maintenance
Warranty