Bertazzoni MAS304GASXT LP 01 User manual

1
IMPORTANTSAFETYINFORMATION
PLEASEREADANDFOLLOWTHESEIMPORTANT
INSTRUCTIONSFORTHESAFETYOFYOURHOMEAND
OFTHEPEOPLELIVINGINIT.
SavethisManualforlocalelectricalinspector’suse.
Readandsavetheseinstructionsforfuturereference.
Observeallgoverningcodes,ordinancesandregulations.





‐Donotstoreorusegasolineorotherflammable
substancesinthevicinityofthisoranyotherappliance.
‐WHATTODOIFYOUSMELLGAS
 Donotlightanyappliance.
 Donottouchanyelectricalswitch.
 Donotuseanyphoneinyourbuilding.
 Immediatelycallyourgassupplierfromaneighbor’s
phone.Followthegassupplier’sinstructions.
 Ifyoucannotreachyourgassuppliers,callthefire
department.
‐Installationandservicemustbeperformedbya
qualifiedinstaller,serviceagencyorthegassupplier
InMassachusetts:Allgasproductsmustbeinstalledbya
"Massachusetts"licensedplumberorgasfitter.A"T"
handletypemanualgasvalvemustbeinstalledinthegas
lineconnectedtothisappliance.

WARNING!
Readthisinstructionbookletbeforeinstallingandusing
theappliance.
Themanufacturerwillnotberesponsibleforany
damagetopropertyortopersonscausedbyincorrect
installationorimproperuseoftheappliance.
Themanufacturerreservestherighttomakechangesto
itsproductswhenconsiderednecessaryanduseful,
withoutaffectingtheessentialsafetyandoperating
characteristics.
Thisappliancehasbeendesignedfornon‐professional,
domesticuseonly.
Donotusethisappliancetoheataroom.
Donotplaceanypotorpanontheopenovendoor.The
doorismadeofglassanditcanbreakifloadedwitha
weight.
Beforebeginninginstallation,pleasereadthese
instructionscompletelyandcarefully.
Donotremovepermanentlyaffixedlabels,warnings,or
platesfromtheproduct.Thismayvoidthewarranty.‐
Pleaseobservealllocalandnationalcodesand
ordinances.
Pleaseensuretherangeisproperlygrounded.
Theinstallershouldleavetheseinstructionswiththe
consumerwhoshouldretainforlocalinspector'suseand
forfuturereference.
Theplugshouldalwaysbeaccessible.
Installationmustconformwithlocalcodesorinthe
absenceofcodes,theNationalFuelGasCodeANSI
Z223.1/NFPA54.Electricalinstallationmustbein
accordancewiththeNationalElectricalCode,
ANSI/NFPA70‐latesteditionand/orlocalcodes.IN
CANADA:Installationmustbeinaccordancewiththe
currentCAN/CGA‐B149.1NationalGasInstallationCode
orCAN/CGA‐B149.2,PropaneInstallationCodeand/or
localcodes.Electricalinstallationmustbeinaccordance
withthecurrentCSAC22.1CanadianElectricalCodes
Part1and/orlocalcodes.
Installationofanygas‐firedequipmentshouldbemade
byalicensedplumber.Amanualgasshut‐offvalvemust
beinstalledinthegassupplylineaheadoftheovenin
thegasflowforsafetyandeaseofservice.
WARNING
Thisapplianceshallnotbeinstalledwithaventilation
systemthatblowairdownwardtowardthe
range/rangetop/cooktop;thistypeofventilationsystem
maycauseignitionandcombustionproblemwiththegas
applianceresultinginapersonalinjuryorunintended
operation
WARNING
Anaircurtainorotheroverhead
range/rangetop/cooktophood,whichoperatesby
blowingadownwardairflowontoa
range/rangetop/cooktop,shallnotbeused/installedin
conjunctionwiththisgasrange/rangetop/cooktop,
Warning!
This range can tip. Injury to persons could result.
Install anti-tip device shipped with range. See
Installation Instructions.
WARNING!
Iftheinformationinthismanualisnotfollowed
exactly,afireorexplosionmayresultcausing
propertydamage,personalinjuryordeath.

2




BERTAZZONISpA
ViaPalazzina8
42016GuastallaRE
ITALY

WWW.BERTAZZONI.COM

 
 
ModelsMAS304GASXTLP01[M7S0GNA8X2A]
FromthedeskofthePresident

DearnewownerofaBertazzoniproduct,
Iwanttothankyouforchoosingoneofour
beautifulPROranges.Weknowthatyouhavemany
brandsandproductstochoosefromandweare
thrilledthatyouhavedecidedtotakeoneofour 
productsintoyourhome.
Wetakeasmuchprideinmakingourrangesaswe
hopeyouwillinowningthem.Myfamilystarted
manufacturingcookingappliancesin1882.Eachof
ourproductsisablendofItaliandesignfinesseand
superiorappliancetechnology.Whilewecannot
replaceyouruniquetalentatcookingdelicious
recipesforyourself,yourfamilyandyourfriends,
wetryourbesttomakecookingeasier,more
effectiveandmorefun.
Ourappliancesaredesignedaccordingtothe
strictestsafetyandperformancestandardforthe
EuropeanandtheNorthAmericanmarket.We
followthemostadvancedmanufacturing
philosophy.Eachapplianceleavesthefactoryafter
thoroughqualityinspectionandtesting.Our
distributorsandourservicepartnersarereadyto
answeranyquestionsyoumayhaveregardinghow
toinstall,useandcareforyourBertazzoniproduct.
Thismanualwillhelpyoulearntousetheproduct
inthesafestandmosteffectivemannerandcare
foritsothatitmaygiveyouthehighestsatisfaction
foryearstocome.
Themanualalsoincludesdirectionsforthe
professionalinstallerthatwillinstalltheproductin
yourhome.Werecommendusingfactory‐trained
professionalsforthedelicatetaskofinstallingand
testingappliancesinyourhome.Pleasecall
CustomerServiceat(800)ifyouneedhelplocating
afactory‐trainedprofessionalinstallerinyourarea.
Pleasekeepthismanualforfutureuse.
Grazie!






3

TABLEOFCONTENTS
IMPORTANTSAFETYINFORMATION........................................................................................................................1
WARRANTYANDSERVICE........................................................................................................................................4
PRODUCTSPECIFICATIONS.......................................................................................................................................5
BEFOREINSTALLATION............................................................................................................................................6
INSTALLINGTHELEGS..............................................................................................................................................7
INSTALLINGTHEWORKTOPFRONTGUARD..............................................................................................................7
INSTALLINGTHEBACKGUARD..................................................................................................................................8
INSTALLINGTHEANTI‐TIPSTABILLTYDEVICE............................................................................................................9
INSTALLATIONREQUIREMENTS...............................................................................................................................9
INSTALLATIONADJACENTTOKITCHENCABINETS...................................................................................................10
EXHAUSTHOODINSTALLATION.............................................................................................................................10
ELECTRICALCONNECTION......................................................................................................................................11
GASCONNECTION.................................................................................................................................................12
GASCONVERSION.................................................................................................................................................14
STEP1:PRESSUREREGULATOR....................................................................................................................................14
STEP2:SURFACEBURNERS..........................................................................................................................................15
STEP3:MAINOVENBURNER.......................................................................................................................................15
STEP4:BROILERBURNER.............................................................................................................................................16
STEP5:VISUALCHECKS................................................................................................................................................17
STEP6:MINIMUMFLAMEADJUSTMENT.....................................................................................................................18
INSTALLATIONCHECKLLST.....................................................................................................................................20
FINALPREPARATION.............................................................................................................................................20
USERMANUAL......................................................................................................................................................21
ROOMVENTILATION.............................................................................................................................................21
SURFACEBURNERLAYOUT....................................................................................................................................21
SURFACECOOKING................................................................................................................................................22
SYMBOLS......................................................................................................................................................................22
SURFACEBURNEROPERATION....................................................................................................................................22
TIPSFORUSINGBURNERSCORRECTLY........................................................................................................................23
TIPSFORUSINGPANSCORRECTLY...............................................................................................................................23
OVENCOOKING.....................................................................................................................................................24
SYMBOLS......................................................................................................................................................................24
OVENSHELVES.............................................................................................................................................................25
GASOVENOPERATION.................................................................................................................................................25
CONVECTIONCOOKING...............................................................................................................................................26
COOKINGWITHTHEGASBROILER...............................................................................................................................26
ELECTRICIGNITION......................................................................................................................................................27
USINGTHETHERMOMETER...................................................................................................................................27
MAINTAININGYOURRANGE..................................................................................................................................27
REPLACINGTHEOVENLIGHTBULB..............................................................................................................................27
COOLINGFANFAILURE.................................................................................................................................................27
CLEANINGYOURRANGE........................................................................................................................................28
IMPORTANTAPPLIANCEINFORMATION................................................................................................................30

4
Pleasekindlyregisteronourwebsitewww.bertazzoni.comtovalidateyournewproductwarrantyandhelpusto
assistyoubetterincaseofanyinconvenience.
TWOYEARLIMITEDWARRANTY
ThewarrantiesprovidedbyBertazzoniSpainthisstatementapplyexclusivelytoBertazzoniappliancesandaccessories
soldasnewproductstotheoriginalownerbyaBertazzoniauthorizeddistributor,retailer,dealerorservicecenterand
installedintheUnitedStatesandCanada.Thewarrantiesprovidedinthisstatementarenottransferableandhave
validityfromthedateofinstallation.

COVERAGEINFORMATION
BertazzoniSpAwillrepairorreplaceanycomponentpartwhichfailsorprovesdefectiveduetomaterialsand/or
workmanshipwithin2yearsfromthedateofinstallationandunderconditionsofnormalresidentialuse.Repairor
replacementwillbefreeofcharge,includinglaboratstandardratesandshippingexpenses.Repairservicemustbe
performedbyaBertazzoniAuthorizedServiceCenterduringnormalworkinghours.

COSMETICWARRANTY
Bertazzoniwillcoverpartsshowingcosmeticdefectsinmaterialandworkmanshipforaperiodofthirty(30)daysfrom
dateofinstallationoftheunit.Thiscoveragewillincludescratches,stains,surfaceimperfectionsonstainlesssteel,
paintandporcelain,withtheexclusionofslightdifferencesincolorduetomaterialsandpainting/enamelling
technologies.
Exclusionsarelaborcosts,Bstockitems,out‐of‐boxappliancesanddisplayunits.

HOWTOOBTAINSERVICE
ToobtainwarrantyservicepleasecontactBertazzoniCustomerServiceatthenumbersbelowandprovidemodel
number,serialnumberanddateofpurchase.

ENGLISH8669050010‐FRANCAIS8005617265

Saveproofoforiginalpurchaseoroforiginalinstallationtoestablishwarrantyperiod.Copyoftheproductserialtagis
affixedtothebackcoveroftheinstructionmanual.

WHATISNOTCOVERED
1Theproductusedinanycommercialapplication
2RepairserviceprovidedbyotherthanaBertazzoniauthorizedserviceagency.
3Damageorrepairservicetocorrectserviceprovidedbyanunauthorizedagencyortheuseofunauthorized
parts.
4Installationnotinaccordancewithlocalelectricalcodesorplumbingcodes.
5Defectsordamageduetoimproperstorageoftheproduct.
6Defectsordamageormissingpartsonproductssoldoutoftheoriginalfactorypackagingorfromdisplays.
7Servicecallsorrepairstocorrecttheinstallationoftheproductand/orrelatedaccessories.
8Servicecallstoconnect,convertorotherwiserepairtheelectricalwiringand/orgaslinetoproperlyusethe
product.
9ServicecallstoprovideinstructionsontheuseofaBertazzoniproduct.
10 Repairserviceduetoproductusageinmannerotherthanwhatisnormalandcustomaryforhomeuse.
11 Replacementofwearandtearparts
12 Replacementofglassesandlightbulbsiftheyareclaimedtohavefailedlaterthan30daysafterinstallation
andinnocaselaterthan4monthsafterdateofpurchase
13 Defectsanddamagesarisingfromaccident,alteration,misuse,abuse,improperinstallation.
14 Defectsanddamagesarisingfromtransportationoftheproducttothehomeoftheowner.
15 DefectsanddamagearisingfromexternalforcesbeyondthecontrolofBertazzoniSpAsuchasfire,flood,
earthquakesandotheractsofGod.

Incasetheproductwillbeinstalledinaremotearea,wherecertifiedtrainedtechniciansarenotreasonably
available,thecustomerwillberesponsibleforthetransportationcostsforthedeliveryoftheproducttothe
nearestauthorizedservicecenterorforthedisplacementcostsofacertifiedtrainedtechnician.

Bertazzonidoesnotassumeanyresponsibilityforincidentalorconsequentialdamages.
Somestatesdonotallowtheexclusionorlimitationofincidentalorconsequentialdamages,sotheabovelimitation
orexclusionmaynotapplytoyou.Thiswarrantygivesyouspecificlegalrightsandyoumayalsohaveotherrights
whichmayvaryfromstatetostateorprovincetoprovince.


5

PRODUCTSPECIFICATIONS
Dimensions(insertdrawingsfront,sideandback


Weight
Burnerpower
NaturalgasLPgas
Auxiliary3730BTU/h3750BTU/h
Semi‐rapid6000BTU/h6300BTU/h
Rapid10400BTU/h11400BTU/h
Dualburner(inner)2730BTU/h2900BTU/h
Dualburner(outer)15000BTU/h16400BTU/h
Oven14500BTU/h14500BTU/h
broiler12000BTU/h12000BTU/h



6
BEFOREINSTALLATION
Thisapplianceshallonlybeinstalledbyan
authorizedprofessional.
Thisapplianceshallbeinstalledinaccordance
withthemanufacturer’sinstallationinstructions.
Thisappliancemustbeinstalledinaccordance
withthenorms&standardsofthecountrywhere
itwillbeinstalled.Theinstallationofthis
appliancemustconformtolocalcodesand
ordinances.Intheabsenceoflocalcodes,
InstallationsmustconformstoAmericanNational
Standards,NationalFuelGasCodeANSIZ223.1/
NFPA54orB149.1.1.
Theappliance,wheninstalled,mustbe
electricallygroundedinaccordancewithlocal
codesor,intheabsenceoflocalcodes,withthe
NationalElectricalCode,ANSI/NFPA70.
Iflocalcodespermit,aflexiblemetalappliance
connectionwiththenewAGAorCGAcertified
design,max.5feet(1,5m)long,½”I.D.is
recommendedforconnectingthisapplianceto
thegassupplyline.Donotbendordamagethe
flexibleconnectorwhenmovingtheappliance.
Thisappliancemustbeusedwiththepressure
regulatorprovided.Theregulatorshallbe
properlyinstalledinordertobeaccessiblewhen
theapplianceisinstalledinitsfinallocation.The
pressureregulatormustbesetforthetypeofgas
tobeused.Thepressureregulatorhas½”female
pipethread.Theappropriatefittingmustbe
determinedbasedonthesizeofyourgassupply
line,theflexiblemetalconnectorandtheshutoff
valve.
Theappliancemustbeisolatedfromthegas
supplypipingsystembyclosingitsindividual
manualshutoffvalveduringanypressuretesting
ofthegassupplypipingsystemattestpressures
equaltoorlessthan½psi(3.5kPa).
Allopeningandholesinthewallandfloor,back
andundertheapplianceshallbesealedbefore
installationoftheappliance.
Amanualvalveshallbeinstalledinanaccessible
locationinthegaslineexternaltotheappliance
forthepurposeofturningonorshuttingoffgas
totheappliance

WARNING!
Donotuseaerosolspraysinthevicinityofthis
appliancewhileitisinoperation
ROOMVENTILATION:Anexhaustfanmaybe
usedwiththeappliance;ineachcaseitshallbe
installedinconformitywiththeappropriate
nationalandlocalstandards.Exhausthood
operationmayaffectotherventedappliances;in
eachcaseitshallbeinstalledinconformitywith
theappropriatenationalandlocalstandards.

TYPEOFGAS
Thisapplianceisshippedfromthefactoryforuse
withpropanelp.Forusewithnaturalgasplease
followtheconversionproceduredescribedonpg.
14.Astepbystepconversionprocedureisalso
includedwitheachsetofnaturalgasnozzles.

GASPRESSURE
Themaximuminletgassupplypressureincoming
tothegasappliancepressureregulatoris½psi
(13,8w.c.or3.5kPa).
Theminimumgassupplypressureforchecking
theregulatorsettingshallbeatleast1“w.c.(249
Pa)abovetheinletspecifiedmanifoldpressureto
theappliance(thisoperatingpressureis11”w.c.
(2.75kPa)forLPGasand4”w.c.(1.00kPa)for
NaturalGas.




7
INSTALLINGTHELEGS
Bertazzonirangesmustbeusedonlywiththe
legsproperlyinstalled.
Fourheight‐adjustablelegsareshippedwiththe
rangeinthepolysterenecontainersituatedover
theappliance.
Beforeinstallingthelegs,positiontheappliance
nearitsfinallocationasthelegsarenotsuitable
formovingtheapplianceoverlongdistances.
Afterunpackingtherange,raiseitenoughto
insertthelegsintheappropriatereceptacles
situatedonthelowerpartoftheappliance.
Lowertherangegentlytokeepanyunduestrain
fromlegsandmountinghardware.Ifpossibleuse
apalletorliftjackinsteadoftiltingtheunit.
Adjustlegheighttothedesiredlevelbytwisting
theinsideportionofthelegassemblyuntilthe
properheightisreached.Checkwithalevelthat
thecooktopisperfectlylevel.



INSTALLINGTHEWORKTOP
FRONTGUARD
Toincreasetheclearancebetweenthefrontedge
oftheworktopandtheburnersitispossibleto
installtheworktopfrontguardshippedwiththe
appliance.
Toinstallthefrontguard,holditwiththepointed
edgeslookingup.Aligntheedgesofthe
frontguardwiththeappropriatereceptaclesin
thebottomoftheworktopandpressfirmlyuntil
thefrontguardissecurelyattachedtothe
worktop.
ATTENTION:onceinstalledthefrontguardmay
onlyberemovedbydisassemblingtheworktop.
Attemptingtoremovethefrontguardwithout
disassemblingtheworktopwillresultin
permanentdamagetotheworktop.






8
INSTALLINGTHEBACKGUARD
Thebackguardmustbeinstalledpriorto
operationoftheapplianceforappropriate
ventilationoftheovencompartment.
Thesuppliedbackguardisa2‐partassembly.The
boxalsocontainsasetofmetalscrewsfor
securingthebackguardtotheworktop.



Disassemblethebackguardandpositionthefront
partontheworktop.Alignthescrewholeswith
thecorrespondingholesatthebackofthe
worktop.


Iftheholesarenotaligned,partiallyloosenthe
bracketsattthebackoftheworktopasshown
below.


Installthefrontpartofthebackguardby
tighteningthe2centralscrewsfromthetopand
2lateralscrewsfromthebottom.




Positionthebackpartofthebackguardand
secureittotheworktoptightening4screwsfrom
thebottom.



Connectthebackandfrontpartoftheupstand.
Checkfortightassembly.

9
INSTALLINGTHEANTI‐TIPSTABILlTY
DEVICE
Theanti‐tipbracketshippedwiththerangemust
beproperlysecuredtotherearwallasshownin
thepircturebelow.
Theheightofthebracketfromthefloormustbe
determinedaftertherangelegshavebeen
adjustedtothedesiredheightandafterthe
rangehasbeenleveled.
Measurethedistancefromthefloortothe
bottomoftheanti‐tipbracketreceptacleonthe
backoftheappliance.
Positionthetwoanti‐tipbracketsonthewallat
thedesiredheightplus1/8"(0.32cm).The
bracketsmustbeplacedat2”5/16(6,0cm)from
thesideoftherange.Thedistancebetweenthe
twobracketis25”1/4(64,1cm).
Securethebracketstothewallwithappropriate
hardware.
Slidetherangeagainstthewalluntilthebrackets
arefullyinsertedintotheirreceptaclesonthe
backoftherange.



INSTALLATIONREQUIREMENTS

ELECTRICAL
Aproperly‐groundedhorizontally‐mounted
electricalreceptacleshouldbeinstallednohigher
than3"(7.6cm)abovethefloor,nolessthan2”
(5cm)andnomorethan8”(20,3cm)fromthe
leftside(facingproduct).
Checkalllocalcoderequirements.

GAS
Anagency‐approved,properly‐sizedmanualshut‐
offvalveshouldbeinstallednohigherthan3"
(7.6cm)abovethefloorandnolessthan2”(5
cm)andnomorethan8”(20.3cm)fromtheleft
side(facingproduct).
Toconnectgasbetweenshut‐offvalveand
regulator,useagency‐approved,properlysized
flexibleorrigidpipe.Checkalllocalcode
requirements.


10

INSTALLATIONADJACENTTOKITCHEN
CABINETS
Thisrangemaybeinstalleddirectlyadjacentto
existingcountertophighcabinets(36"or91.5cm
fromthefloor).
Forthebestlook,theworktopshouldbelevel
withthecabinetcountertop.Thiscanbe
accomplishedbyraisingtheunitusingthe
adjustmentspindlesonthelegs.
ATTENTION:therangeCANNOTbeinstalled
directlyadjacenttokitchenwalls,tallcabinets,
tallappliances,orotherverticalsurfacesabove
36"(91.4cm)high.Theminimumsideclearance
insuchcasesis6"(15.2cm).
Wallcabinetswithminimumsideclearancemust
beinstalled18"(45.7cm)abovethecountertop
withcountertopheightbetween35½”(90.2cm)
and37¼”(94.6cm).Themaximumdepthofwall
cabinetsabovetherangeshallbe13"(33.0cm)








EXHAUSTHOODINSTALLATION
ThisrangewillbestperformwhenusedwithPRO
lineBertazzoniexhausthoods.Thesehoodshave
beendesignedtoworkinconjunctionwiththe
Bertazzonirangeandhavethesamefinishfora
perfectlook.
Formaximumperformance,theheightofthe
bottomofthehoodfromtheworktopshouldbe
between251/2"(65cm)and311/2"(80cm).
Thiswouldtypicallyresultinthebottomofthe
hoodbeing611/2"(156.2cm)to671/2"(171.5
cm)abovethefloor.Thesemeasurements
provideforsafeandefficientoperationofthe
hood.
Beforeinstallationoftheexhausthood,consult
localorregionalbuildingandinstallationcodes
foradditionalspecificclearancerequirements.
Refertotherangehoodinstallationinstructions
providedbythemanufacturerforadditional
information.




A 30” (76,2 cm)
B 36” (91,5 cm)
C 13” (33,0 cm)
D 18” (45,7 cm)
E 35”1/2(90,2 cm) / 37” ¼ (94,6 cm)
F 6” (15,2 cm)
G 6” (15,2 cm)

11
ELECTRICALCONNECTION
Thisunitismanufacturedforapolarized,
grounded120volt/60Hz,15ampsystem.
Electricpowerconsumptionisabout300W.
Theminimumof102VACisrequiredforproper
operationofgasignitionsystems.
Thecircuitmustbegroundedandproperly
polarized.
TheunitisequippedwitthaSJTpowercord.In
caseofreplacement,thepowercordshallbe
replacedwithoneofthesametype,sizeand
length.
ELECTRICALGROUNDING
Thisapplianceisequippedwithathree‐prong
plugforyourprotectionagainstshockhazardand
shouldbepluggeddirectlyintoaproperly
groundedsocket.Donotcutorremovethe
groundingprongfromthisplug.

WARNING!
ELECTRICALSHOCKHAZARD
Disconnectelectricalpoweratthecircuit
breakerboxorfuseboxbeforeinstallingthe
appliance.
Provideappropriategroundfortheappliance.
Usecopperconductorsonly.
Failuretofollowtheseinstructionscouldresult
inseriousinjuryordeath

CAUTION
Labelallwirespriortodisconnectingwhen
servicingcontrols.Wiringerrorscancause
improperanddangerousoperation.
Verifyproperoperationafterservicing.



WIRINGDIAGRAM




12
GASCONNECTION
Allgasconnectionsmustcomplywithnational
andlocalcodes.Thegassupplyline(service)
mustbethesamesizeorgreaterthantheinlet
lineoftheappliance.Thisrangeusesa1/2"NPT
inlet(seedrawingbelowfordetailsofgas
connection).Onallpipejointsuseappropriate
sealantresistanttogas.
ThisrangecanbeusedwithNaturalor
LP/Propanegas.Therangeisshippedfromthe
factoryforusewithLP/Propanegas.
ForLP/propanehouseholdinstallation,the
appliancemustbeconvertedbythedealer,bya
factory‐trainedprofessionalorbyaqualified
licensedplumberorgasservicecompany.
Gasconversionisimportantforsafeandeffective
useoftheappliance.Itistheresponsibilityofthe
dealerandtheowneroftherangetoperformthe
appropriategasconversionfollowingthe
directionsofthemanufacturer.
THEGASCONVERSIONPROCEDUREISDESCRIBED
INTHISMANUALANDINTHEPACKAGE
CONTAININGTHECONVERSIONNOZZLES
SHIPPEDWITHEVERYRANGE.
Pleaseprovidetheservicepersonwiththis
manualbeforeworkisstartedontherange.

WARNING!
DONOTUSEANOPENFLAMEWHENCHECKING
FORLEAKS!
Leaktestingoftheapplianceshallbeconducted
accordingtothemanufacturer'sinstructions.
Beforeplacingtheovenintooperation,always
checkforleakswithsoapywatersolutionor
otheracceptablemethod.
Checkforgasleakagewithsoapywatersolution
orotheracceptablemethodsinallgas
connectionsinstalledbetweeninletgaspipeof
theappliance,gasregulator,tilltothemanual
shut‐offvalve.

MANUALSHUT‐OFFVALVE
THISVALVEISNOTSHIPPEDWITHTHEAPPLIANC
ANDMUSTBESUPPLIEDBYTHEINSTALLER.
Themanualshut‐offvalvemustbeinstalledin
thegasservicelinebetweenthegashook‐upon
thewallandtheapplianceinlet,inaposition
whereitcanbereachedquicklyintheeventofan
emergency.
InMassachusetts:A'T'handletypemanualgas
valvemustbeinstalledinthegassupplylineto
thisappliance.

FLEXIBLECONNECTIONS
Incaseofinstallationwithflexiblecouplings
and/orquick‐disconnectfittings,theinstaller
mustuseaheavy‐duty,AGAdesign‐certified
commercialflexibleconnectorofatleast1/2"
(1.3cm)IDNPT(withsuitablestrainreliefs)in
compliancewithANSIZ21.41andZ21.69
standards.
InMassachusetts:Theunitmustbeinstalled
witha36"(3‐foot)longflexiblegasconnector.
InCanada:useCAN1‐6.10‐88metalconnectors
forgasappliancesandCAN1‐6.9M79quick
disconnectdeviceforusewithgasfuel.

PRESSURETEST‐POINTSTOPPERVALVE
Toavoidgasleaks,thepressuretest‐point
stoppervalveandgasketsuppliedwiththerange
mustbeinstalledonthegasfittingatthebackof
therangeaccordingtothediagrambelow.






13

PRESSUREREGULATOR
Sinceservicepressuremayfluctuatewithlocal
demand,everygascookingappliancemustbe
equippedwithapressureregulatoronthe
incomingservicelineforsafeandefficient
operation.
Thepressureregulatorshippedwiththe
appliancehashastwofemalethreads½”NPT.
Theregulatorshallbeinstalledproperlyinorder
tobeaccessiblewhentheapplianceisinstalledin
itsfinalposition.

Manifoldpressureshouldbecheckedwitha
manometerandcomplywiththevaluesindicated
below:
Naturalgas4.0"W.c.P.
LP/Propane11.0"W.C.P.
Incominglinepressureupstreamfromthe
regulatormustbe1"W.c.P.higherthanthe
manifoldpressureinordertocheckthe
regulator.
Theregulatorusedonthisrangecanwithstanda
maximuminputpressureof1/2PSI(13,8"w.c.or
3,5kPa)Ifthelinepressureexceedsthatamount,
astepdownregulatorisrequired.
Theappliance,itsindividualshut‐offvalve,and
thepressureregulatormustbedisconnected
fromthegaslineduringanypressuretestingof
thatsystematpressuresinexcessof1/2PSI
(13,8"w.c.or3,5kPa).
TheindividuaLmanualshut‐offvalvemustbein
theOFFpositionduringanypressuretestingof
thegassupplypipingsystemattestpressures
equaltoorlessthan1/2PSI(13,8"w.c.or3,5
kPa).


14
APPLIANCESERVICING
Beforecarryinganyservicingoperation
disconnecttheappliancefromgasandelectric
supplyandextraappliancefromfinalinstallation
placeinordertohaveaccesstotheappliancefor
properservicingintervention.

GASCONVERSION

WARNING!
Beforecarryingoutthisoperation,disconnect
theappliancefromgasandelectricity.
Gasconversionshallbeconductedbyafactory‐
trainedprofessional.
Callthecustomerservicehotlinetoidentifya
factory‐trainedprofessionalnearyourhome.
Thegasconversionprocedureforthisrange
includes6steps:
1. Pressureregulator
2. Surfaceburners
3. Mainovenburner
4. Broilerburner
5. Visualcheckspriortoclosureofovenbottom
panel
6. Adjustmentofminimumsetting
Theconversionisnotcompletedifall6steps
havenotbeenconcludedproperly.
Beforeperformingthegasconversion,locatethe
packagecontainingthereplacementnozzle
shippedwitheveryrange.IMPORTANT:Each
nozzlehasanumberindicatingitsflowdiameter
printedonthebody.Consultthetableonpage20
formatchingnozzlestoburners.
Savethenozzlesremovedfromtherangefor
futureuse.

STEP1:PRESSUREREGULATOR
Thepressureregulatorsuppliedwiththe
applianceisaconvertibletypepressureregulator
forusewithLP/PropaneGasatanominaloutlet
pressureof11”w.c.orNaturalgasatanominal
outletpressureof4”w.c.anditispre‐arranged
fromthefactorytooperatewithoneofthese
gas/pressureasindicatedinthelabelsaffixedon
theappliance,packageandInstructionbooklet.
Toconverttheregulatorforusewithother
naturalgas:
1. Unscrewbyhandtheuppercapofthe
regulator,removethewhiteplastic
attachmentfromthecap,reverseits
directionandscrewitagainfirmlyagainstthe
cap.Thewhiteplasticattachmenthasarrows
indicatingthepositionforLPgas(LP)and
naturalgas(NAT).
2. Screwbyhandthemetalcapintheoriginal
positionontheregulator.









15
STEP2:SURFACEBURNERS
Toreplacethenozzlesofthesurfaceburners,lift
uptheburnersandunscrewthenozzlesshipped
withtherangeusinga7mm{sochetwrench).
Replacenozzlesusingtheconversionsetsupplied
withtherangeorbyaBertazzoniauthorized
partswarehouse.Eachnozzlehasanumber
indicatingitsflowdiameterprintedonthebody.
Consultthetableonpage20formatchingnozzles
toburners.






STEP3:MAINOVENBURNER
Toreplacethenozzlesofthemainovenburner,
startby:
Removetheovendoor
Toreplacethenozzlesofthemainovenburner,
startbyremovingthebottompaneloftheoven.






















16
LoosenandthescrewVandpullouttheburner
fromthesupportbeingcarefulnottodamagethe
ignitionplugandthethermocouple
UnscrewthenozzleRusinga7mm.spannerand
replaceitwiththenozzleforthenewtypeofgas
accordingtowhatisindicateinthetablebelow
ATTENTION:payextraattentiontoavoiddamage
totheigniterandthermocouple.
Re‐installallthepartsinreverssequence





STEP4:BROILERBURNER
Loosenthescrewandpullouttheburnerfrom
thesupportbeingcarefulnottodamagethe
ignitionplugandthethermocouple.


Usinga7mm[nameofthetool]unscrewthe
nozzle.Replacethenozzleusingtheconversion
setsuppliedwiththerangeorbyaBertazzoni
authorizedpartswarehouse.Eachnozzlehasa
numberindicatingitsflowdiameterprintedon
thebody.Consultthetableonpage20for
matchingnozzlestoburners.

AdjustthegapXbysettingittofullyopen
position.

17
STEP5:VISUALCHECKS
Beforereinstallingthebottompanel,the
followingvisualcheckmustbeperformedto
ensurethattheconversionhasbeencarriedout
properlyandwithoutdamagetoother
componentsoftherange.
Verifythattheflameoftheoven/broilerburner
becompletelyblueandwithregularaspectas
shownbelow.


A) CONNECTIONOFTHERMOCOUPLESTO
THERMOSTAT
Thethermocouplesforbothbroilerandmain
ovenburnerareconnectedtothesamemagnet.
Tightgentlythetwoconnectionsalternating
actiononthetwonuts.Donotfullytightenone
thermocouplebeforehavingstartedtotighten
thesecondone.


B) OVENIGNITERANDTHERMOCOUPLE
POSITION
Theappropriategapbetweenthetipofthespark
plugorthermocoupleandtheburnershallbe
approximately1/8’’.


Thetipofthesparkplugorthermocouplemust
fullyoverlapatleastthefirstgasemissionholeof
theburner.


Afterperformingallthesevisualchecks,reinstall
thebottompaneloftheovencompartmentand
proceedtosettingtheminimumforeach
burner.

18

STEP6:MINIMUMFLAMEADJUSTMENT

WARNING!
Theseadjustmentsshouldbemadeonlyforuse
oftheappliancewithnaturalgas.Forusewith
liquidpropanegas,thechokescrewmustbe
fullyturnedinaclockwisedirection.

SURFACEBURNERS
1. Lightoneburneratatimeandsettheknob
totheMINIMUMposition(smallflame).
2. Removetheknob.
3. Therangeisequippedwithasafetyvalve.
Usingasmall‐sizeslottedscrewdriver,locate
thechokevalveonthevalvebodyandturn
thechokescrewtotherightorleftuntilthe
burnerflameisadjustedtodesiredminimum.
4. Makesurethattheflamedoesnotgoout
whenswitchingquicklyfromtheMAXIMUM
totheMINIMUMposition.



OVENBURNER
1. Settheoventemperaturecontrolknobtothe
MAXIMUMsetting.
2. Closetheovendoorandoperatetheovenfor
atleast10minutes.
3. SettheknobtotheMINIMUMsetting.
4. Removetheknob.
5. Withaslottedscrewdriverturnthechoking
screw(by‐passscrewattheleftsideofthe
thermostatbar)and,whileobservingthe
flameatthesametimethroughthebottom
ovenporthole,evaluatetheconsistencyof
theflamesoitremainsonwhenswitching
quicklyfromMINIMUMtoMAXIMUM
setting.




Broilerburner:thebroilerburneralways
operatesatmaximum,thereforenominimum
adjustmentisrequired.


19

ModelsMAS304GASLP01[M7S0GNA8X2A]

Burner Position Injector Gas Pressure Max Rate Min Rate By-pass
diam. [mm.] Type [i.w.c.] [BTU/h] [W] [BTU/h] [W] diam. [mm]
Auxiliary Rear L 0,92NG 4” 37501098 900 264 Regulated
0,56LP (Propane) 11” 37501098 900 264 0,29
Semi-Rapid Front R 1,17NG 4” 60001759 1500 439 Regulated
0,73LP (Propane) 11” 63001845 1500 439 0,36
Rapid Rear R 1,55NG 4” 104003046 2500 732 Regulated
0,98LP (Propane) 11” 114003339 2500 732 0,47
Front L Inner 0,80NG 4” 2730799900 264 Regulated
Dual Burner 0,50LP (Propane) 11” 2900849900 264 0,29
Front L Outer N°2x1,30NG 4” 150004394 4500 1318 Regulated
N°2x0,83LP (Propane) 11” 164004804 4500 1318 0,65
Oven Oven 1,85 NG 4” 14500 4248 3500 1025 Regulated
downside 1,10 LP (Propane) 11” 14500 4248 3500 1025 0,54
Broiler Oven 1,70 NG 4” 12000 3516 Only Max Only Max No by-pass
upside 0,98 LP (Propane) 11” 12000 3516 Only Max Only Max No by-pass

20
INSTALLATIONCHECKLlST
1. Istherangemountedonitslegs?
2. Isthebackguardsecurelyconnected?
3. Hastheanti‐tipdevicebeenproperly
installed?
4. Doestheclearancefromthesidecabinets
complywiththemanufacturersdirections?
5. Istheelectricityproperlygrounded?
6. Isthegasservicelineconnectedfollowing
thedirectionsofthemanufacturer?
7. Haveallthepropervalves,stoppersand
gasketbeeninstalledbetweentherangeand
theserviceline?
8. Hasthegasconnectionbeencheckedfor
leaks?
9. Hastherangebeensetforthetypeofgas
availableinthehousehold?
10. Istheignitionofallovenburnersfunctioning
properly?
11. Istheairflowtotheoverandbroilerburners
properlyadjusted?
12. Doestheflameappearsharpblue,withno
yellowtipping,sootingorflamelifting?
13. Hastheminimumsettingforallburnersbeen
adjusted?
14. Istheovenandbroilerignitionworking
properly?
15. Doestheovenlightworkproperly?

FINALPREPARATION
Beforeusingtheoven,removeanyprotective
wrapfromthestainlesssteel.
Allstainlesssteelbodypartsshouldbewiped
withhot,soapywaterandwithaliquidstainless
steelcleanser.
Ifbuildupoccurs,donotusesteelwool,abrasive
cloths,cleaners,orpowders!Ifitisnecessaryto
scrapestainlesssteeltoremoveencrusted
materials,soakwithhot,wetclothstoloosenthe
material,thenuseawoodornylonscraper.Do
notuseametalknife,spatula,oranyothermetal
tooltoscrapestainlesssteel!Scratchesare
almostimpossibletoremove.
Beforeusingtheovenforfoodpreparation,wash
thecavitythoroughlywithawarmsoapand
watersolutiontoremovefilmresiduesandany
dustordebrisfrominstallation,thenrinseand
wipeddry.