Breville Puck Sucker BEA503 User manual

the Puck Sucker™
Instruction Book – BEA503

2
Contents
2Breville Recommends Safety First
6Components
7Assembly
8Functions
9Care & Cleaning
10 Troubleshooting
12 Warranty
BREVILLE
RECOMMENDS
SAFETY FIRST
At Breville we are very safety
conscious. We design and
manufacture consumer
products with the safety of you,
our valued customer, foremost
in mind. In addition, we ask
that you exercise a degree of
care when using any electrical
appliance and adhere to the
following precautions. Misuse
can cause potential injuries.
IMPORTANT
SAFEGUARDS
READ ALL INSTRUCTIONS
BEFORE USE AND SAVE FOR
FUTURE REFERENCE
• Remove and safely
discard any packaging
material or promotional
labels on the product
or on any of the
attachments before using
for the first time.
• Ensure the product is
properly assembled
before use.
• This appliance is not
intended for use by
persons (including
children) with reduced
physical, sensory or
mental capabilities,
or lack of experience
and knowledge,
unless they have been
given supervision or
instruction concerning
the use of the appliance
by a person responsible
for their safety.

3
• Children should be
supervised to ensure that
they do not play with the
appliance.
• The Puck Sucker™ is only
intended for use with
Breville 58mm portafilter
and basket.
• Always remove the
battery before storing or
when not in use for an
extended period of time.
• Keep the appliance clean.
• Do not use this appliance
if it is worn, has been
dropped or is damaged in
any way.
• Any maintenance other
than cleaning should
be performed at an
authorised Breville
Service Centre.
• This appliance is for
household use only.
Do not use the appliance
for anything other than
its intended purpose.
Do not use in moving
vehicles or boats.
Do not use outdoors.
Do not use on a sink
drain board. Misuse may
cause injury.
• Never use attachments
or accessories that
are not supplied with
this product. Failing to
follow this instruction
may cause product
malfunction, product
damage or even pose
safety risk.
• Do not attempt to operate
the appliance by any
method other than those
described in this book.
• Do not incinerate this
appliance even if it is
severely damaged.
• Do not use the Puck
Sucker™ with a plastic
bag in the container.
• Do not knock the
portafilter on the
Puck Sucker™ with
sudden force.

4
TYPES OF BATTERY
THAT MAY BE USED:
• 9V batteries:
• Alkaline 9V battery
(6LR61 6LF22 1604A)
• Lithium 9V battery
(1604LC)
WARNING
• Non-rechargeable
batteries are not to be
recharged.
• Different types of
batteries or new and
used batteries are not
to be mixed.
• Do not expose the
appliance or battery to
excessive temperatures.
• Batteries can contain
flammable substances,
and if handled improperly
may leak, heat up, ignite,
or explode.
• Terminals of the battery-
operated appliance
or battery being short
circuited by metal objects
can overheat and cause
injury or fire.
• Keep batteries out
of reach of children.
Swallowing can lead
to chemical burns,
perforation of soft
tissue, and death. Severe
burns can occur within
2 hours of ingestion.
Seek medical attention
immediately.
CAUTION
• Batteries are to be
inserted with the correct
polarity.
• Exhausted batteries are
to be removed from the
appliance and safely
disposed of.
• Do not use modified or
damaged batteries.
• The supply terminals
must not be short-
circuited.
• On battery leakage,
remove the battery
immediately, but proceed
with caution: work in a
well-ventilated area,
away from heat sources.

FOR HOUSEHOLD USE ONLY
SAVE THESE INSTRUCTIONS
5
Wear protective eyewear
and gloves if possible, to
avoid contact with the
residue. After removing
the leaked batteries,
clean out the battery
compartment with a
cotton swab or an old
toothbrush. Put the
batteries in a plastic bag
and recycle. Be sure to
avoid contact with the
battery leak residue at all
times. Wash your hands
thoroughly with soap and
water afterwards. In case
of eye and skin contact,
seek medical attention
immediately.
Do not immerse the
lid in water or any
liquid. The lid is not
dishwasher safe. Only the
container is dishwasher
safe. Use only a damp
sponge to clean.
The symbol shown
indicates that this
appliance should not
be disposed of in normal
household waste. It should
be taken to a local
authority waste collection
centre designated for this
purpose or to a dealer
providing this service. For
more information, please
contact your local council
office. Please dispose of
batteries in an
environmentally friendly
manner. Do not throw
batteries into normal
household waste. Please
use the return and
collection systems in your
community or contact the
retailer where you
purchased the product.

6
Components
A. Activation switch
B. Lid with battery compartment
– fits 58 mm Breville portafilters
C. * Air Outlet port
D. * Air Inlet port with filter
E. 9V Battery
F. Container
– dishwasher safe (top rack only)
NOTE
*Keep the inlet and outlet port area clean and
free from any coffee grounds or any particles to
maintain good quality suction.
A
E
B
F
C
D

7
Assembly
INSTALLING & REMOVING
THE 9V BATTERY
1. Holding the container on one hand,
pull upwards to remove the lid with the
other hand.
2. Using a Philips-head screwdriver, unscrew
the battery cover, found underneath.
3. Carefully set-aside the battery cover.
4. Insert the 9V battery, bottom side up, and
align the male (positive) connector to the
side of the screw lock.
5. Replace the battery cover and screw back
to close.
6. Secure the lid back to the container.

8
Functions
HOW TO USE THE PUCK SUCKER™
1. Ensure the Puck Sucker™ is stable and
upright on a flat surface.
2. Place the portafilter into the Puck Sucker™
ensuring the portafilter touches the
red switch.
3. Press and hold the portafilter horizontally
straight and flat on the Puck Sucker™ lid
until the coffee puck falls into the container.
NOTE
Avoid moving or wiggling the portafilter on
the Puck Sucker™ as this will void the build of
the vacuum. If the puck hasn’t come out after
10 seconds, remove the portafilter and try
again. This could be due to a lack of seal with
the Puck Sucker™.
NOTE
The machine has a continuous vacuum sound
until the portafilter is removed.
WARNING
Do not knock the portafilter on the
Puck Sucker™ with sudden force.

9
Care & Cleaning
HOW TO CLEAN THE CONTAINER
1. Separate the Puck Sucker™ lid from the
container and dispose the coffee pucks
into the bin. The easiest way to remove the
vessel is by popping the top out with your
thumbs on each side of the lid.
2. Once the container is completely empty,
wash the container with warm soapy water
and rinse thoroughly.
3. Using soft dry cloth, wipe the inside and the
outside of the container thoroughly.
NOTE
The container is dishwasher safe
(top rack only).
HOW TO CLEAN THE
PUCK SUCKER™ LID
Use a damp cloth to wipe any coffee residues
off the lid and dry thoroughly.
WARNING
• DO NOT wash the Puck Sucker™ lid under
running water or clean by rinsing.
• DO NOT submerge the Puck Sucker™ lid in
water or any other liquid.
• Keep the *inlet and *outlet port area clean
and free from any coffee grounds or any
particles to maintain good quality suction.
*refer to Components section
USED BATTERIES
• Exhausted batteries are to be removed from
the appliance and safely disposed of.
• Refer to the safety section of this manual
for cautions and warnings on handling and
disposing of batteries.
NOTE
Depending on the daily usage, the battery life
should be a minimum of 12 months.
TBC

10
Troubleshooting
PROBLEM POSSIBLE CAUSES EASY SOLUTIONS
Coffee puck does not come out. Incomplete seal between the portafilter and the puck extractor.
→Ensure there are no gaps between the portafilter and the seal to enable
the vacuum to build. Check the portafilter handle is horizontal and
centred on the extractor lid.
Extractor lid is not placed correctly on the vessel.
→Ensure the extractor lid is firmly flat in place on the vessel. Check the
seal is clean and not damaged.
Portafilter not kept on the extractor lid long enough.
→Wait a few more seconds to ensure enough vacuum is being created.
Filter basket comes loose
when using the puck extractor.
When using a dual wall filter basket, a greater vacuum will be built
compared to using a single wall filter basket resulting the drop of the filter
basket from the portafilter.
→Keep the portafilter on the puck extractor for a maximum of 5 seconds
and try again.
Filter basket catches
(or stuck underneath)
the switch.
Incorrect portafilter removing action.
→Lift the handle on the portafilter first, then take the portafilter out
vertically.
Puck Sucker™ would not start. Puck Sucker™ may be low in battery.
→Replace batteries.
Avoid moving or wiggling
the portafilter on the
Puck Sucker™.
Do not knock the portafilter
on the Puck Sucker™ with
sudden force.