Brinkmann Max Million II User manual

SPOTLIGHT OWNER’S MANUAL
OPERATING INSTRUCTIONS
For 1-year from date of purchase, The Brinkmann Corporation warrants the Max Million Million II Rechargeable Light against defects
due to workmanship or materials to the original purchaser. The Brinkmann Corporation’s obligations under this warranty are limited to
the following guidelines:
• This warranty does not extend to the bulb or battery.
• This warranty does not cover rechargeable lights that have been altered or damaged due to: normal wear, abuse, improper
maintenance, improper use, disassembly of parts and/or attempted repair by anyone other than an authorized employee of
The Brinkmann Corporation.
• This warranty does not cover surface scratches or weathering as this is considered normal wear.
• Warranty service is limited to repair or replacement of rechargeable lights which prove defective under normal use and which
upon examination shall indicate to Brinkmann’s satisfaction, they are defective. If Brinkmann confirms the defect and approves the
claim, Brinkmann will elect to repair or replace the rechargeable light as covered by the terms of this warranty.
• This warranty extends to the original purchaser only and is not transferable or assignable to subsequent purchasers.
The Brinkmann Corporation requires reasonable proof of purchase. Therefore, we strongly recommend that you retain your sales
receipt or invoice. To obtain repair or replacement of your Max Million II Rechargeable Light under the terms of this warranty, please
call Customer Service Department at 1-800-527-0717 for a Return Authorization Number and further instructions. A receipt will be
required. Rechargeable lights returned to Brinkmann must include your name, address and telephone number. Please make sure the
light is properly packed, postage prepaid, and insured. A Return Authorization Number must be clearly marked on the outside of the
box. Brinkmann cannot be responsible for any rechargeable lights forwarded to us without a Return Authorization Number.
EXCEPT AS ABOVE STATED, THE BRINKMANN CORPORATION MAKES NO OTHER EXPRESS WARRANTY.
THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED IN DURATION TO
1-YEAR FROM THE DATE OF PURCHASE. SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY
LASTS, SO THE ABOVE LIMITATION MAY NOT APPLY TO YOU.
ANY LIABILITY FOR INDIRECT, INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING FROM THE FAILURE OF THE MAX MILLION II
RECHARGEABLE LIGHT TO COMPLY WITH THIS WARRANTY OR ANY IMPLIED WARRANTY IS EXCLUDED. CUSTOMER
ACKNOWLEDGES THAT THE PURCHASE PRICE CHARGED IS BASED UPON THE LIMITATIONS CONTAINED IN THE WARRANTY SET
OUT ABOVE. SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO
THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO YOU. THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS, AND
YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE.
1-YEAR LIMITED WARRANTY
RECHARGEABLE
2,000,000
CANDLEPOWER
®
R
140-2655-0
5/02, 7/02, 8/03
Owner’s Manual for Model
800-2655-2 & 800-2655-1
©2002 The Brinkmann Corporation
Dallas, Texas 75244 U.S.A
www.brinkmanncorp.com
WARNING
READ AND FOLLOW ALL WARNINGS
AND INSTRUCTIONS IN THIS
MANUAL TO AVOID PERSONAL
INJURY OR PROPERTY DAMAGE.

1
• Never place spotlight face down when light is on or is still hot from recent use. Doing so could burn/ignite
surfaces such as seats, carpeting, etc. and cause major property damage. Always turn spotlight off when not
in use.
• To prevent serious damage to eyesight, never look into spotlight when light is on. DO NOT shine light into the
face of someone else.
• DO NOT touch lens of spotlight when light is on or if it was recently on. The lens will be hot and could cause
serious burns.
• DO NOT place spotlight in water. Keep all components dry and out of water at all times.
• DO NOT allow children to handle or operate this spotlight.
• DO NOT use this product for other than its intended use.
• DO NOT charge or operate in close proximity of combustible or flammable materials.
• DO NOT charge battery in gas tight enclosures.
• DO NOT attempt to charge battery pack using both AC and DC chargers at the same time.
• DO NOT attempt to charge or operate this spotlight if cord, plug, battery, bulb or any part of the spotlight is
damaged or corroded.
• DO NOT allow metal parts to touch metal contacts on battery as this can cause a short circuit and result in a fire.
• DO NOT use an outdoor AC outlet to recharge battery.
• To prevent accidental electrical shock we recommend this product always be charged on a GFCI (Ground Fault
Circuit Interrupter) outlet.
• Only use charging devices that are provided with the Q-Beam Max Million II Rechargeable Spotlight or its
replacements.
• DO NOT disassemble or tamper with the battery.
• DO NOT dispose of battery in fire as this may result in explosion.
• When disposing of battery, place electrical tape over metal contacts on battery to prevent short circuit which
could cause a fire.
• The sealed battery contains lead and must be recycled or disposed of properly. Contact your local county solid
waste authority for proper recycling or disposal information.
USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR RECHARGEABLE LIGHT.
FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS MANUAL
COULD RESULT IN BODILY INJURY OR PROPERTY DAMAGE.
SAVE THIS MANUAL FOR FUTURE REFERENCE.
IMPORTANT SAFETY WARNINGS
READ AND FOLLOW ALL SAFETY WARNINGS AND INSTRUCTIONS IN THE OWNER’S MANUAL
BEFORE OPERATING SPOTLIGHT.
WARNING
ACCESSORIES
12-Volt DC Charger/Adapter
Model 802-0019-0
12-volt DC charger/adapter for use with Max
Million II Rechargeable Spotlight.
120-Volt AC Charger
Model 802-0018-0
120-volt AC charger for use with Max Million II
Rechargeable Spotlight.
12-Volt Rechargeable Battery
Model 802-2655-0
Replacement lead acid, 12-volt, 2.8 Ah.
rechargeable battery for use with Q-Beam
Max Million II Rechargeable Spotlight.
Replacement Bulb for
Max Million II Rechargeable
Model 802-1747-0
12-volt, halogen 75-watt bulb is an original
replacement for Q-Beam Max Million II
Rechargeable Spotlight.
Charging Tips
To Prevent Damage to Spotlight and Battery:
•Do not attempt to use spotlight while charging directly from AC
outlet. Doing so may cause damage to battery and AC charger.
•12-volt DC charger/adapter operates from a cigarette lighter
receptacle for charging battery in spotlight or continuous corded
operation with or without battery.
•Do not attempt to charge battery pack using both AC an DC
chargers at the same time.
• Only use charging devices that are provided with the Q-Beam Max
Million II Rechargeable Spotlight or its replacements.
•For DC Charger/Adapter - Allow battery to fully charge using the
DC charger/adapter for at least 8 hours. Do not charge for more
than 10 hours.
For AC Charger - Allow battery to fully charge using the AC charger
for at least 10 hours. Do not charge for more than 12 hours.
See chart for recommended charge times.
• Do not allow battery to completely discharge. A dim light indicates a
low battery. Recharge battery as soon as possible after each use.
• Always keep the battery fully charged when not in use.
10
46810
20 DC Charge
AC Charge
USAGE (Minutes)
CHARGE TIME (Hours)
Charge Times
Charge times are dependent on usage of the
product. See chart below for recommended charge times.
6

MAX
MILLIONII
RECHARGEABLE
2,000,000
CANDLEPOWER
Inspect contents of the box to ensure all parts are included and undamaged.
2
OPERATING INSTRUCTIONS
READ AND FOLLOW ALL SAFETY WARNINGS AND INSTRUCTIONS IN THE OWNER’S MANUAL
BEFORE OPERATING SPOTLIGHT.
Part List:
Q-Beam Max Million II
Rechargeable Spotlight
Rechargeable Battery
(Extra Battery with
Model 800-2655-1)
12-volt DC Charger/Adapter
120-volt AC Charger
Owner’s Manual
1
2
3
4
3
4
1
2
Step 5: Holding the front housing secure, slowly lift the rear housing off.
Step 6: Pull reflector away from rear housing being careful not to pull
wire connections inside. Do not touch the inside of reflector.
NOTE: The glass lens is not attached to front housing. Use care when
disassembling to avoid breaking lens.
Step 7: Pinch the ends of the wire retainer together and lift up as
illustrated.
Step 8: Pull bulb straight out from the reflector mounting plate.
Step 9: Disconnect bulb wire from connector by holding the connector
firmly with fingers then pulling bulb wire straight out.
Step 10: To install new bulb, grasp the bulb from the metal end (DO NOT
TOUCH THE GLASS PART) and insert into the reflector mounting
plate. Align the slots in the bulb base with those in the reflector
mounting plate.
Step 11: Replace wire retainer by pinching ends together while pressing
down. Push ends apart so they catch on the reflector mounting
plate.
Step 12: Reconnect the bulb wire to the connector as illustrated.
Step 13: To reassemble, place the front housing face (lens) down on a
flat surface. Set the reflector into the rear housing. Insert the
rear housing into the font housing of the spotlight.
Step 14: Replace the two screws that were removed in Step 3. Do not
over tighten screws.
Replacement bulbs may be purchased from The Brinkmann Corporation
Customer Service Department by calling 1-800-468-5252.
Lock Button
Trigger
Switch
To Operate
IMPORTANT:
Unlock and turn spotlight OFF before charging
from AC or DC outlet. The battery cannot charge if
the spotlight is ON. Leaving spotlight ON during
charging may cause damage to battery and AC
charger.
12-volt DC charger/adapter operates from a
cigarette lighter receptacle for charging battery in
spotlight or continuous corded operation with or
without battery.
NOTE: To prevent car battery from completely
discharging, it is recommended that car
engine remain running while in use.
Step 1: Follow charging instructions on page 3 of this manual and allow
battery to fully charge.
Step 2: Depress trigger switch in handle to turn spotlight ON. Release
trigger switch to turn spotlight OFF.
Step 3: To lock trigger switch to ON, depress trigger switch and slide
down lock button on side of handle. To unlock and turn spotlight
OFF, depress trigger and slide lock button up.
WARNING: Never place spotlight face down when light is on or is still
hot from recent use. Doing so could burn/ignite surfaces
such as seats, carpeting, etc. and cause major property
damage. Always turn spotlight off when not in use.
• The life expectancy of the battery is approximately 500 cycles, at
which time a replacement battery is recommended. A replacement
battery may be purchased from The Brinkmann Corporation Customer
Service Department by calling 1-800-468-5252.
• This spotlight features a battery protection circuit which will shut
down spotlight after approximately 20 minutes of continuous light.
• Do not allow battery to completely discharge. A dim light indicates a
low battery. Turn OFF and UNLOCK spotlight and recharge battery as
soon as possible.
CHARGEABLE
2,000,000
ANDLEPOWER
Connector
5
RECHARGEABLE
2,000,000
CANDLEPOWER
Connector

THE BATTERY CAN BE CHARGED INSIDE OR OUTSIDE OF SPOTLIGHT.
To Charge Battery Inside of Spotlight:
Step 1: Make sure the trigger switch is not locked ON.
Step 2: Plug the AC charger directly into back of battery or DC charger/
adapter into bottom of spotlight handle.
Note: Red light will indicate when battery is charging from
AC charger only.
Step 3: For DC Charger/Adapter - Allow battery to fully charge using the DC
charger/adapter for at least 8 hours. Do not charge for more than
10 hours.
For AC Charger - Allow battery to fully charge using the
AC charger for at least 10 hours. Do not charge for more
than 12 hours.
See chart for recommended charge times.
WARNING:
A damaged battery can leak acid. Avoid contact with eyes and
skin. If contact occurs, flush immediately with large amounts of
water. DO NOT ingest. If contact with eyes or ingestion occurs,
consult physician immediately.
3 4
Only use Brinkmann’s 12V75W halogen bulb that is designed for the
Q-Beam Max Million II Rechargeable spotlight as a replacement. Use
of any other bulb may result in poor performance and may damage
your spotlight.
IMPORTANT: Do not touch the glass part of bulb with fingers as natural
oils affect the life and performance of bulb. Handle bulb by
metal end only.
Step 1: Disconnect spotlight from power source.
Step 2: Remove battery from spotlight.
Step 3: Remove the two screws from top and bottom of front housing.
Step 4: Lay the spotlight face (lens) down on a flat surface.
To Charge
To Replace Bulb
RECHARGEABLE
2,000,000
CANDLEPOWER
MAX
MILLIONII
RECHARGEABLE
2,000,000
CANDLEPOWER
MAX
MILLIONII
Battery
Red Indicator Light
RECHARGEABLE
2,000,000
CANDLEPOWER
MAX
MILLIONII
Glass Lens
Rear
Housing
Front
Housing
Reflector
10
46810
20 DC Charge
AC Charge
USAGE (Minutes)
CHARGE TIME (Hours)
Charge Times
Charge times are dependent on usage of the
product. See chart below for recommended charge times.
IMPORTANT: If battery is not used for more than 90 days, remove
battery from the spotlight. Charge battery every
2 months for 12 hours to ensure battery does not
completely lose charge. A completely discharged battery
may not recharge properly.
IMPORTANT: The EPA
Certified RBRC®Battery
Recycling Seal on the lead
acid (Pb) battery contained in
our product indicates The
Brinkmann Corporation is
voluntarily participating in an
industry program to collect and recycle these
batteries at the end of their useful life, when taken
out of service in the United States or Canada. The
RBRC®program provides a convenient alternative
to placing used Pb batteries into the trash or the
municipal waste stream, which may be illegal in
your area. Please call 1-800-8-BATTERY™ for
information on Pb battery recycling and disposal
bans/restrictions in your area. The Brinkmann
Corporation’s involvement in this program is part of
our commitment to preserving our environment and
conserving our natural resources.
To Charge Battery Outside of Spotlight:
Step 1: Remove battery from back of spotlight by pressing on the
quick-release tabs.
Step 2: Plug the AC charger into battery as illustrated.
Note: Red light will indicate when battery is charging
from AC charger only.
Step 3: For AC Charger - Allow battery to fully charge using the AC
charger for at least 10 hours. Do not charge for more than
12 hours. See chart for recommended charge times.
IMPORTANT: If battery is not used for more than 90 days, remove
battery from the spotlight. Charge battery every
2 months for 12 hours to ensure battery does not
completely lose charge. A completely discharged
battery may not recharge properly.
WARNING:
A damaged battery can leak acid. Avoid contact with eyes
and skin. If contact occurs, flush immediately with large
amounts of water. DO NOT ingest. If contact with eyes or
ingestion occurs, consult physician immediately.
Step 4: Place charged battery inside light so that metal contacts on
battery and light are making contact.
Note: Press battery firmly until fully inserted and locked
with quick-release tabs.
For extended lighting requirements, we recommend purchasing an
additional battery as a back-up. Additional/replacement batteries may
be purchased from The Brinkmann Corporation Customer Service
Department by calling 1-800-468-5252.
Red Indicator Light

THE BATTERY CAN BE CHARGED INSIDE OR OUTSIDE OF SPOTLIGHT.
To Charge Battery Inside of Spotlight:
Step 1: Make sure the trigger switch is not locked ON.
Step 2: Plug the AC charger directly into back of battery or DC charger/
adapter into bottom of spotlight handle.
Note: Red light will indicate when battery is charging from
AC charger only.
Step 3: For DC Charger/Adapter - Allow battery to fully charge using the DC
charger/adapter for at least 8 hours. Do not charge for more than
10 hours.
For AC Charger - Allow battery to fully charge using the
AC charger for at least 10 hours. Do not charge for more
than 12 hours.
See chart for recommended charge times.
WARNING:
A damaged battery can leak acid. Avoid contact with eyes and
skin. If contact occurs, flush immediately with large amounts of
water. DO NOT ingest. If contact with eyes or ingestion occurs,
consult physician immediately.
3 4
Only use Brinkmann’s 12V75W halogen bulb that is designed for the
Q-Beam Max Million II Rechargeable spotlight as a replacement. Use
of any other bulb may result in poor performance and may damage
your spotlight.
IMPORTANT: Do not touch the glass part of bulb with fingers as natural
oils affect the life and performance of bulb. Handle bulb by
metal end only.
Step 1: Disconnect spotlight from power source.
Step 2: Remove battery from spotlight.
Step 3: Remove the two screws from top and bottom of front housing.
Step 4: Lay the spotlight face (lens) down on a flat surface.
To Charge
To Replace Bulb
RECHARGEABLE
2,000,000
CANDLEPOWER
MAX
MILLIONII
RECHARGEABLE
2,000,000
CANDLEPOWER
MAX
MILLIONII
Battery
Red Indicator Light
RECHARGEABLE
2,000,000
CANDLEPOWER
MAX
MILLIONII
Glass Lens
Rear
Housing
Front
Housing
Reflector
10
46810
20 DC Charge
AC Charge
USAGE (Minutes)
CHARGE TIME (Hours)
Charge Times
Charge times are dependent on usage of the
product. See chart below for recommended charge times.
IMPORTANT: If battery is not used for more than 90 days, remove
battery from the spotlight. Charge battery every
2 months for 12 hours to ensure battery does not
completely lose charge. A completely discharged battery
may not recharge properly.
IMPORTANT: The EPA
Certified RBRC®Battery
Recycling Seal on the lead
acid (Pb) battery contained in
our product indicates The
Brinkmann Corporation is
voluntarily participating in an
industry program to collect and recycle these
batteries at the end of their useful life, when taken
out of service in the United States or Canada. The
RBRC®program provides a convenient alternative
to placing used Pb batteries into the trash or the
municipal waste stream, which may be illegal in
your area. Please call 1-800-8-BATTERY™ for
information on Pb battery recycling and disposal
bans/restrictions in your area. The Brinkmann
Corporation’s involvement in this program is part of
our commitment to preserving our environment and
conserving our natural resources.
To Charge Battery Outside of Spotlight:
Step 1: Remove battery from back of spotlight by pressing on the
quick-release tabs.
Step 2: Plug the AC charger into battery as illustrated.
Note: Red light will indicate when battery is charging
from AC charger only.
Step 3: For AC Charger - Allow battery to fully charge using the AC
charger for at least 10 hours. Do not charge for more than
12 hours. See chart for recommended charge times.
IMPORTANT: If battery is not used for more than 90 days, remove
battery from the spotlight. Charge battery every
2 months for 12 hours to ensure battery does not
completely lose charge. A completely discharged
battery may not recharge properly.
WARNING:
A damaged battery can leak acid. Avoid contact with eyes
and skin. If contact occurs, flush immediately with large
amounts of water. DO NOT ingest. If contact with eyes or
ingestion occurs, consult physician immediately.
Step 4: Place charged battery inside light so that metal contacts on
battery and light are making contact.
Note: Press battery firmly until fully inserted and locked
with quick-release tabs.
For extended lighting requirements, we recommend purchasing an
additional battery as a back-up. Additional/replacement batteries may
be purchased from The Brinkmann Corporation Customer Service
Department by calling 1-800-468-5252.
Red Indicator Light

MAX
MILLIONII
RECHARGEABLE
2,000,000
CANDLEPOWER
Inspect contents of the box to ensure all parts are included and undamaged.
2
OPERATING INSTRUCTIONS
READ AND FOLLOW ALL SAFETY WARNINGS AND INSTRUCTIONS IN THE OWNER’S MANUAL
BEFORE OPERATING SPOTLIGHT.
Part List:
Q-Beam Max Million II
Rechargeable Spotlight
Rechargeable Battery
(Extra Battery with
Model 800-2655-1)
12-volt DC Charger/Adapter
120-volt AC Charger
Owner’s Manual
1
2
3
4
3
4
1
2
Step 5: Holding the front housing secure, slowly lift the rear housing off.
Step 6: Pull reflector away from rear housing being careful not to pull
wire connections inside. Do not touch the inside of reflector.
NOTE: The glass lens is not attached to front housing. Use care when
disassembling to avoid breaking lens.
Step 7: Pinch the ends of the wire retainer together and lift up as
illustrated.
Step 8: Pull bulb straight out from the reflector mounting plate.
Step 9: Disconnect bulb wire from connector by holding the connector
firmly with fingers then pulling bulb wire straight out.
Step 10: To install new bulb, grasp the bulb from the metal end (DO NOT
TOUCH THE GLASS PART) and insert into the reflector mounting
plate. Align the slots in the bulb base with those in the reflector
mounting plate.
Step 11: Replace wire retainer by pinching ends together while pressing
down. Push ends apart so they catch on the reflector mounting
plate.
Step 12: Reconnect the bulb wire to the connector as illustrated.
Step 13: To reassemble, place the front housing face (lens) down on a
flat surface. Set the reflector into the rear housing. Insert the
rear housing into the font housing of the spotlight.
Step 14: Replace the two screws that were removed in Step 3. Do not
over tighten screws.
Replacement bulbs may be purchased from The Brinkmann Corporation
Customer Service Department by calling 1-800-468-5252.
Lock Button
Trigger
Switch
To Operate
IMPORTANT:
Unlock and turn spotlight OFF before charging
from AC or DC outlet. The battery cannot charge if
the spotlight is ON. Leaving spotlight ON during
charging may cause damage to battery and AC
charger.
12-volt DC charger/adapter operates from a
cigarette lighter receptacle for charging battery in
spotlight or continuous corded operation with or
without battery.
NOTE: To prevent car battery from completely
discharging, it is recommended that car
engine remain running while in use.
Step 1: Follow charging instructions on page 3 of this manual and allow
battery to fully charge.
Step 2: Depress trigger switch in handle to turn spotlight ON. Release
trigger switch to turn spotlight OFF.
Step 3: To lock trigger switch to ON, depress trigger switch and slide
down lock button on side of handle. To unlock and turn spotlight
OFF, depress trigger and slide lock button up.
WARNING: Never place spotlight face down when light is on or is still
hot from recent use. Doing so could burn/ignite surfaces
such as seats, carpeting, etc. and cause major property
damage. Always turn spotlight off when not in use.
• The life expectancy of the battery is approximately 500 cycles, at
which time a replacement battery is recommended. A replacement
battery may be purchased from The Brinkmann Corporation Customer
Service Department by calling 1-800-468-5252.
• This spotlight features a battery protection circuit which will shut
down spotlight after approximately 20 minutes of continuous light.
• Do not allow battery to completely discharge. A dim light indicates a
low battery. Turn OFF and UNLOCK spotlight and recharge battery as
soon as possible.
CHARGEABLE
2,000,000
ANDLEPOWER
Connector
5
RECHARGEABLE
2,000,000
CANDLEPOWER
Connector

1
• Never place spotlight face down when light is on or is still hot from recent use. Doing so could burn/ignite
surfaces such as seats, carpeting, etc. and cause major property damage. Always turn spotlight off when not
in use.
• To prevent serious damage to eyesight, never look into spotlight when light is on. DO NOT shine light into the
face of someone else.
• DO NOT touch lens of spotlight when light is on or if it was recently on. The lens will be hot and could cause
serious burns.
• DO NOT place spotlight in water. Keep all components dry and out of water at all times.
• DO NOT allow children to handle or operate this spotlight.
• DO NOT use this product for other than its intended use.
• DO NOT charge or operate in close proximity of combustible or flammable materials.
• DO NOT charge battery in gas tight enclosures.
• DO NOT attempt to charge battery pack using both AC and DC chargers at the same time.
• DO NOT attempt to charge or operate this spotlight if cord, plug, battery, bulb or any part of the spotlight is
damaged or corroded.
• DO NOT allow metal parts to touch metal contacts on battery as this can cause a short circuit and result in a fire.
• DO NOT use an outdoor AC outlet to recharge battery.
• To prevent accidental electrical shock we recommend this product always be charged on a GFCI (Ground Fault
Circuit Interrupter) outlet.
• Only use charging devices that are provided with the Q-Beam Max Million II Rechargeable Spotlight or its
replacements.
• DO NOT disassemble or tamper with the battery.
• DO NOT dispose of battery in fire as this may result in explosion.
• When disposing of battery, place electrical tape over metal contacts on battery to prevent short circuit which
could cause a fire.
• The sealed battery contains lead and must be recycled or disposed of properly. Contact your local county solid
waste authority for proper recycling or disposal information.
USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR RECHARGEABLE LIGHT.
FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS MANUAL
COULD RESULT IN BODILY INJURY OR PROPERTY DAMAGE.
SAVE THIS MANUAL FOR FUTURE REFERENCE.
IMPORTANT SAFETY WARNINGS
READ AND FOLLOW ALL SAFETY WARNINGS AND INSTRUCTIONS IN THE OWNER’S MANUAL
BEFORE OPERATING SPOTLIGHT.
WARNING
ACCESSORIES
12-Volt DC Charger/Adapter
Model 802-0019-0
12-volt DC charger/adapter for use with Max
Million II Rechargeable Spotlight.
120-Volt AC Charger
Model 802-0018-0
120-volt AC charger for use with Max Million II
Rechargeable Spotlight.
12-Volt Rechargeable Battery
Model 802-2655-0
Replacement lead acid, 12-volt, 2.8 Ah.
rechargeable battery for use with Q-Beam
Max Million II Rechargeable Spotlight.
Replacement Bulb for
Max Million II Rechargeable
Model 802-1747-0
12-volt, halogen 75-watt bulb is an original
replacement for Q-Beam Max Million II
Rechargeable Spotlight.
Charging Tips
To Prevent Damage to Spotlight and Battery:
•Do not attempt to use spotlight while charging directly from AC
outlet. Doing so may cause damage to battery and AC charger.
•12-volt DC charger/adapter operates from a cigarette lighter
receptacle for charging battery in spotlight or continuous corded
operation with or without battery.
•Do not attempt to charge battery pack using both AC an DC
chargers at the same time.
• Only use charging devices that are provided with the Q-Beam Max
Million II Rechargeable Spotlight or its replacements.
•For DC Charger/Adapter - Allow battery to fully charge using the
DC charger/adapter for at least 8 hours. Do not charge for more
than 10 hours.
For AC Charger - Allow battery to fully charge using the AC charger
for at least 10 hours. Do not charge for more than 12 hours.
See chart for recommended charge times.
• Do not allow battery to completely discharge. A dim light indicates a
low battery. Recharge battery as soon as possible after each use.
• Always keep the battery fully charged when not in use.
10
46810
20 DC Charge
AC Charge
USAGE (Minutes)
CHARGE TIME (Hours)
Charge Times
Charge times are dependent on usage of the
product. See chart below for recommended charge times.
6

SPOTLIGHT OWNER’S MANUAL
OPERATING INSTRUCTIONS
For 1-year from date of purchase, The Brinkmann Corporation warrants the Max Million Million II Rechargeable Light against defects
due to workmanship or materials to the original purchaser. The Brinkmann Corporation’s obligations under this warranty are limited to
the following guidelines:
• This warranty does not extend to the bulb or battery.
• This warranty does not cover rechargeable lights that have been altered or damaged due to: normal wear, abuse, improper
maintenance, improper use, disassembly of parts and/or attempted repair by anyone other than an authorized employee of
The Brinkmann Corporation.
• This warranty does not cover surface scratches or weathering as this is considered normal wear.
• Warranty service is limited to repair or replacement of rechargeable lights which prove defective under normal use and which
upon examination shall indicate to Brinkmann’s satisfaction, they are defective. If Brinkmann confirms the defect and approves the
claim, Brinkmann will elect to repair or replace the rechargeable light as covered by the terms of this warranty.
• This warranty extends to the original purchaser only and is not transferable or assignable to subsequent purchasers.
The Brinkmann Corporation requires reasonable proof of purchase. Therefore, we strongly recommend that you retain your sales
receipt or invoice. To obtain repair or replacement of your Max Million II Rechargeable Light under the terms of this warranty, please
call Customer Service Department at 1-800-527-0717 for a Return Authorization Number and further instructions. A receipt will be
required. Rechargeable lights returned to Brinkmann must include your name, address and telephone number. Please make sure the
light is properly packed, postage prepaid, and insured. A Return Authorization Number must be clearly marked on the outside of the
box. Brinkmann cannot be responsible for any rechargeable lights forwarded to us without a Return Authorization Number.
EXCEPT AS ABOVE STATED, THE BRINKMANN CORPORATION MAKES NO OTHER EXPRESS WARRANTY.
THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED IN DURATION TO
1-YEAR FROM THE DATE OF PURCHASE. SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY
LASTS, SO THE ABOVE LIMITATION MAY NOT APPLY TO YOU.
ANY LIABILITY FOR INDIRECT, INCIDENTAL OR CONSEQUENTIAL DAMAGES ARISING FROM THE FAILURE OF THE MAX MILLION II
RECHARGEABLE LIGHT TO COMPLY WITH THIS WARRANTY OR ANY IMPLIED WARRANTY IS EXCLUDED. CUSTOMER
ACKNOWLEDGES THAT THE PURCHASE PRICE CHARGED IS BASED UPON THE LIMITATIONS CONTAINED IN THE WARRANTY SET
OUT ABOVE. SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO
THE ABOVE LIMITATION OR EXCLUSION MAY NOT APPLY TO YOU. THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS, AND
YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE.
1-YEAR LIMITED WARRANTY
RECHARGEABLE
2,000,000
CANDLEPOWER
®
R
140-2655-0
5/02, 7/02, 8/03
Owner’s Manual for Model
800-2655-2 & 800-2655-1
©2002 The Brinkmann Corporation
Dallas, Texas 75244 U.S.A
www.brinkmanncorp.com
WARNING
READ AND FOLLOW ALL WARNINGS
AND INSTRUCTIONS IN THIS
MANUAL TO AVOID PERSONAL
INJURY OR PROPERTY DAMAGE.
This manual suits for next models
1
Table of contents
Other Brinkmann Spotlight manuals

Brinkmann
Brinkmann Qbeam MAx Million II System manual

Brinkmann
Brinkmann Q-Beam 800-1700-0 User manual

Brinkmann
Brinkmann Maxfire Dual LED System manual

Brinkmann
Brinkmann MAXFIRE XENON DUAL XENON RECHARGABLE System manual

Brinkmann
Brinkmann 1 MILLION CANDLEPOWER System manual

Brinkmann
Brinkmann SpotLigth User manual

Brinkmann
Brinkmann 1 Million MaxPower System manual

Brinkmann
Brinkmann Qbeam System manual

Brinkmann
Brinkmann Qbeam MAX MILLION 2 User manual

Brinkmann
Brinkmann Q Beam 802-1745-0 User manual