Buffalo CW147 User manual

Model:
CW147 / CW148
Heated Display
Instruction manual
CW147-CW148_UK_A5_v1_171206.indb 1 2017/12/6 10:46

2
UK Telephone Helpline: 0845 146 2887
Safety Tips
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components on this product.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- BS EN Codes of Practice
- Fire Precautions
- IEE Wiring Regulations
- Building Regulations
• Warning! Hot surface! Always wear safety
gloves when placing or removing foods.
• This product is only designed to store food temporarily. Do not
use for laboratory or industrial purposes.
• DO NOT use jet/pressure washers to clean the appliance.
• DO NOT use the appliance outside.
• DO NOT use the appliance to store medical supplies.
• DO NOT use electrical appliances inside the appliance (e.g.
heaters, ice-cream makers, etc.).
• DO NOT allow oil or fat to come into contact with the plastic
components or door seal. Clean immediately if contact occurs.
• DO NOT store products on top of the appliance.
• Always carry, store and handle the appliance in a vertical
position and move by holding the base of the appliance.
• Always switch off and disconnect the power supply to the unit
before cleaning.
• Keep all packaging away from children. Dispose of the
packaging in accordance to the regulations of local authorities.
CW147-CW148_UK_A5_v1_171206.indb 2 2017/12/6 10:46

3
UK
Telephone Helpline: 0845 146 2887
• If the power cord is damaged, it must be replaced by a
BUFFALO agent or a recommended qualified technician in
order to avoid a hazard.
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience or knowledge, unless they have been
given supervision or instruction concerning the use of the
appliance by a person responsible for their safety.
• Children should be supervised to ensure that they do not play
with the appliance.
• BUFFALO recommend that this appliance is PAT tested
on an annual basis to ensure the product remains safe.
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your BUFFALO product.
Product Description
• CW147 Buffalo Heated Display - 0.8m • CW148 Buffalo Heated Display - 1.2m
Pack Contents
The following is included:
• Buffalo Heated Display • Instruction manual
BUFFALO prides itself on quality and service, ensuring that at the time of packaging the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your BUFFALO dealer immediately.
Installation
1. Remove the appliance from the packaging. Make sure that all protective plastic film and coatings are
thoroughly removed from all surfaces.
2. Maintain a distance of 20cm (7 inches) between the unit and walls or other objects for ventilation.
Note: Wipe all surfaces with a clean, damp cloth before use.
3. Insert the 1/3 GN pans (not supplied) into the stainless steel pan holder underneath.
CW147-CW148_UK_A5_v1_171206.indb 3 2017/12/6 10:46

4
UK Telephone Helpline: 0845 146 2887
Operation
Control panel
The control panel is located at the rear of the appliance.
On/off switch ThermostatIndicator light
Turn On
1. Close the doors of the appliance.
2. Ensure the on/off switch is set to Oand c onnect the appliance to a mains power supply.
3. Set the on/off switch to I.
4. Setting the temperature: Rotate the thermostat to desired temperature (Range: 30°C - 90°C).
5. The indicator light turns on when heating up. When the set temperature is reached, the indicator light
goes out.
6. The appliance is now ready for food to be displayed and kept warm.
Cleaning, Care & Maintenance
Switch off and disconnect the appliance from the power supply. Allow to cool
down before cleaning.
• Remove any food debris that is present in the appliance after use.
• Remove the GN pans. Wipe the pan holder underneath to remove any water.
• Clean the interior of the appliance as often as possible.
• Use warm, soapy water and a damp cloth to clean the appliance.
• Do not use abrasive cleaning agents. These can leave harmful residues.
• Always wipe dry after cleaning.
CW147-CW148_UK_A5_v1_171206.indb 4 2017/12/6 10:46

5
UK
Telephone Helpline: 0845 146 2887
Troubleshooting
Fault Probable Cause Solution
Indicator Light does
not come on & unit
does not heat up
The unit is not switched on Check the unit is plugged in correctly and
switched on
Plug and lead are damaged Call BUFFALO agent or qualified Technician
Fuse in the plug has blown Replace the plug fuse
Power supply Check power supply
Internal wiring fault Call BUFFALO agent or qualified technician
Thermostat has failed Call BUFFALO agent or qualified technician
Indicator Light
comes on but unit
does not heat up
Heating element has failed Call BUFFALO agent or qualified technician
Thermostat has failed Call BUFFALO agent or qualified technician
Loud noises The appliance has not been installed
in a level or stable position
Check installation position and change if
necessary
The appliance is too close to a wall
or other object
Move to a well-ventilated position.
Odour from the unit Unit is not cleaned for long time Clean the unit thoroughly
Technical Specifications
Model Voltage Power Current Temperature
range Capacity Dimensions h x w x d mm Weight
CW147 220-240V
50Hz
500W 2.2A 30°C ~ 90°C 46L 420 x 773 x 336 15kg
CW148 220-240V
50Hz
800W 3.5A 30°C ~ 90°C 68L 420 x 1127 x 336 22kg
CW147-CW148_UK_A5_v1_171206.indb 5 2017/12/6 10:46

6
UK Telephone Helpline: 0845 146 2887
Electrical Wiring
This appliance is supplied with a 3 pin, moulded, BS1363 plug and lead, with a 13 amp fuse as standard.
The plug is to be connected to a suitable mains socket.
This appliance is wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The WEEE logo on this product or its documentation indicates that the product must
not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and
environmentally safe recycling process. For further information on how to dispose of
this product correctly, contact the product supplier, or the local authority responsible for
waste disposal in your area.
BUFFALO parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
BUFFALO products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of BUFFALO.
Every effort is made to ensure all details are correct at the time of going to press, however, BUFFALO reserve the right to
change specifications without notice.
CW147-CW148_UK_A5_v1_171206.indb 6 2017/12/6 10:46

CW147-CW148_UK_A5_v1_171206.indb 7 2017/12/6 10:46

CW147-CW148_UK_A5_v1_171206
http://www.buffalo-appliances.com/
CW147-CW148_UK_A5_v1_171206.indb 8 2017/12/6 10:46