Cadac STRATOS 98721 User manual

LIVE THE BRAAI LIFE 503-0314 LEV8
STRATOS 2 BURNER
mOdEL No’s 98721, 98723
USER INSTRUCTIONS

11
CAUTION
For Outdoor use only!
This appliance may not be used in an exterior enclosed balcony, porch or entertainment area!
IMPORTANT
Read these instructions for use carefully so as to familiarize yourself with the appliance before connecting it to
its gas container. Keep these instructions for future reference
GB
1. Introduction
• ThisappliancecomplieswithBSEN498:2012andSANS1539:2012
• Thisappliancemustonlybeusedwithanapprovedhoseandregulator.
• Thegascylinderistobeusedonlyintheuprightposition.
• Onlytobeusedwithagascylinderthatdoesnotexceed500mminheightand350mminwidth(Includingtheregulator)
• Gasappliancesrequireventilationforefcientperformanceandtoensurethesafetyofusersandotherpersonsincloseproximity.
Use outdoors only!
• Warning:Accessiblepartsmaybeveryhot.Keepyoungchildrenaway
• Whenusingapot,theminimumrecommendedpotsizeis150mmandmaximumrecommendedpotsizeis300mm.
Gas Supply Sources Anapprovedhoseandregulatorconnectedtoarellablegascontainernotexceeding9kgand
complyingwithlocalregulationinforce
Country Name and Abbreviations
AE=UnitedArabEmirates AL=Albania AT=Austria BE=Belgium CH=Switzerland
CZ=CzechRepublic DE=Germany DK=Denmark ES=Spain FI=Finland
FR=France GB=UnitedKingdom GR=Greece HR=Croatia IT=Italy
JP=Japan KR=Korea NL=Netherlands NO=Norway PL=Poland
PT=Portugal RO=Romania RU=Russia RS=Serbia SI=Slovenia
SK=Slovakia SE=Sweden TR=Turkey
98721, 98723
Country of Use BE,CH,CY,CZ,ES, FR,GB,GR,IE,IT,LT,
LU,LV,PT,SK&SI PL
BE,CY,DK,EE,FR,
FI,HU,IT,LT,NL,
NO,SE,SI,SK,RO,
HR,TR,BG,IS,LU,
MT,&ZA
AT,CH,DE&SK
Appliance Catagories I3+(28-30/37) I3B/P(37) I3B/P(30) I3B/P(50)
Allowable gasses Butane Propane Butane,Propaneortheirmixture
Gas Pressure 28-
30mBar 37mBar 37mBar
28-30mBar
(2.8kPaforSouth
Africa)
50mBar
Main BBQ Unit
Jet Number 0.92 0.81
Nominal Usage (Butane) 255g/hrperburner 277g/hrperburner 255g/hrperburner 255g/hrperburner
Gross nom. heat input 3.5kwPerBuner
(3.5kWx2=7.0kW)
3.8kwPerBuner
(3.8kWx2=7.6kW)
3.5kwPerBuner
(3.5kWx2=7.0kW)
3.5kwPerBuner
(3.5kWx2=7.0kW)
Side Burner (98723)
Jet Number 0.88 0.75
Nominal Usage (Butane) 218g/hr 255g/hr 218g/hr 218g/hr
Gross nom. heat input 3.0kW 3.5kW 3.0kW 3.0kW
For gas category I3B/P(30); I3+(28~30/37) & I3B/P(50):
Stratos 2 with side burner, model 98723, Total heat input: 10KW / Butane 728g/hour
Stratos 2 with side tables, model 98721, Total heat input: 7KW / Butane 510g/hour
For gas category I3B/P(37):
Stratos 2 with side burner, model 98723, Total heat input: 11.1KW / Butane 772g/hour
Stratos 2 with side tables, model 98721, Total heat input: 7.6KW / Butane 554g/hour

22
2. Safety Information
• Thehoseandsealontheregulatormustbecheckedforwearordamage
beforeeveryuseandbeforeconnectingtothegascylinder(seeFig.1).
• Ensuretheapplianceisusedawayfromammablematerials.Minimum
safedistancesare1.2mabovetheapplianceand600mmtotherear
andsidesoftheappliance(seeFig.2).
• Donotuseanappliancethatisdamaged,leaking,orwhichdoesnot
operateproperly.
• Keepgascylindersawayfromheatandames.Donotplaceonastove
oranyotherhotsurface.
• Ensurethattheassembledunitisstableanddoesnotrock.
• Donotcoverorchangetheprimaryairsupplyopeningsintheburners
asthiswillaffecttheperformanceoftheproductandmayleadtoan
unstableame.
• Intheeventofburnback,(wheretheameburnsbackandignitesat
thejet),immediatelyturnoffthegassupplybyrstclosingthecontrol
valveonthegascylinderandthentheappliancevalve.Aftertheame
isextinguishedremovetheregulatorandchecktheconditionofits
seal.Replacethesealifindoubt.Re-lighttheapplianceasdescribed
inSection3below.Shouldtheamelightbackpersistentlyreturnthe
producttoyourauthorizedCADACrepairagent.
• Ifthereisaleakonyourappliance(smellofgas),immediatelyclosethe
controlknobonthegascylinder.Ifyouwishtocheckforleaksonyour
appliance,doitoutside.Donottrytodetectleaksusingaame;use
soapywater.
• Thecorrectwayistosmearthejointswithsoapywater.Ifabubbleor
bubblesformthenthereisagasleak.Immediatelyturnoffthegas
supplyrstlybyclosingthecontrolvalveonthegascontainerandthen
theappliancevalve.Checkthatalltheconnectionsareproperlytted.
Re-checkwithsoapywater.Ifagasleakpersists,returntheproductto
yourCADACdealerforinspection/repair.
• Donotmodifytheapplianceoruseitforanythingwhichithasnotbeen
designedfor.
• Duringuse,partoftheappliancewillbecomehot,particularlythe
cookingareasandthehood.Avoidtouchinghotpartswithyourbare
hands.Theuseofovenglovesisrecommended.
• Keepyoungchildrenawayfromtheapplianceatalltimes.
• Thisapplianceconsumesoxygenandneedsventilationforoptimum
performanceandforthesafetyofthoseincloseproximity.Use
Outdoors Only!
• Donotmovetheappliancewhileinuse.
• Thepartssealedbythemanufactureroritsagentmustnotbealtered
bytheuser.
NOTE
• Donottwistorpinchthehose.Ensurethatitiskeptawayfromthe
BBQbodysoastopreventdeterioration/damagetothehosecausedby
heat.
• Fitoneendofthelowpressurehoseontotheregulatornozzle.Thread
theotherendfrominsidecabinet,throughtheholeontheleftside
panel,ontothePatioBBQnozzle.Pushtheendsonasrmlyas
possible.Clampthemintopositionusinghoseclampsatbothendsof
thehose.
• Ensurethattheconnectionsaremadesecurelyanddonotallowgasto
leak.
• Checkforgasleaksbeforeusingtheappliance.
• Forusewithanapprovedhoseandregulatorconnectedtoarellable
gascontainernotexceeding9kgandcomplyingwithlocalregulationin
force.
• Donotobstructtheventilationopeningsofthecabinet.
• Donotmodifytheappliance.Modifyingtheappliancemaybe
dangerous.
• Warning:AnLPcylindernotconnectedforuseshallnotbestoredinthe
vicinityofthisoranyotherappliance.
Fig.2
Fig.3
Fig.1
Seal
Cylinder Valve
Fit hose clamp
here
RegulatorHose

33
3. Using the Appliance
• Placethecylinderinsidethecabinetthroughthebackofthecabinetintotheallocatedspace. 
• Usethisapplianceonlyonarmlevelsurface.
• Beforeuseensurethatthedripcupisinplace.
• Makesurethegascylinderiscorrectlyttedtotheappliance.
• Ensurethecylindercontrolvalveisintheopenposition.
• Note!Allburnersarettedwithanautomaticigniter.
 Tolighttheapplianceusingtheautomaticigniter,rstensurethedomeisintheopenposition.Pushinandturnthecontrolknob
inananti-clockwisedirectionuntilspringresistanceisfelt.Holdtheknobinthispositionfor3–5secondstoallowthegastoow
andthenturntheknobfullyanti-clockwisetotheHIGHposition.Thiswillcausetheautomaticlightertolighttheburner.Should
theburnernotignitethersttime,turnthecontrolknobtotheOFFpositionandwait5minutes,repeattheprocessuntiltheburner
ignites.
• Manual ignition:Tolighttheburnersmanually,rstremovethegrillplateandthedeectorplatedirectlyunderneathit.Igniteamatch
orrelighterandpositionitnexttothelefthandburner.Turnonthegassupplytothatburneronlybypushingthecontrolvalveinand
turningitinananti-clockwisedirection.Thiswillignitetheburner.Oncetheburnerisignited,carefullyreplacethedeectorplate
andcastirongrillplate.Youwillnowbeabletolighttheremainderoftheburnersasabove.
• Usethecontrolknobstoadjusttheindividualburnerameintensitytothedesiredlevelbyturningtheknobanti-clockwiseto
decreasetheameandclockwisetoincreaseit(seeFig.3).
• Afteruse,rstclosethevalveonthegascylinder.Whentheameisextinguished,closetheburnercontrolvalvesontheapplianceby
turningcontrolknobsfullyclockwise.
4. Fitting and Changing the Gas Cylinder
• Beforeconnectingtheappliancetoagascylinder,ensurethattherubbersealontheregulatorisinpositionandingoodcondition.
• Carryoutthischeckeachtimeyouttheappliancetoagascylinder(seeg.1).
• Blowoutanydustfromthecylinderopeningtopreventpossibleblockageofthejet.
• Ensurethegascylinderisttedorchangedoutdoors,awayfromanysourceofignitionsuchasnakedames,andawayfromother
people.
• Makesurethatthegascylinderiskeptuprightatalltimes.Handtightentheregulatorontothecylinderuntilitisfullyengaged.
• Ifthereisaleakonyourappliance(smellofgas),extinguishallsourcesofignitioninthevicinityoftheappliance.Ifyouwishto
checkforleaksonyourappliance,usesoapywaterwhichisappliedtothesuspectedarea.Aformationofbubbleswillindicateagas
leak.Checkthatalltheconnectionsaresecurelyttedandre-checkwithsoapywater.Ifyoucannotrectifythegasleak,donotuse
theappliance.ContactyourlocalCADACstockistforassistance.
• Whenchangingagascylinder,rstclosethecylindervalveandthentheappliancevalve,makingsuretheameisextinguishedand
unscrewtheregulator.Re-ttheregulatortoafullcylinderfollowingthesameprecautionsasdescribedabove.
• Aftertheappliancehasbeenfullyassembled,performagasleaktestbeforeoperatingtheappliance.
5. General Maintenance
• Therearenopredeterminedmaintenanceintervalsforthisappliance.
• Itisdangeroustouseanappliancewithacrackedorperishedsealand/orhose.Inspectbothsealsandhoseregularlyandreplaceif
theyarenotinorderbeforeusingtheappliance.
• Iftheappliancewasinuseitwillbehot.Allowtocoolsufcientlybeforeattemptinganymaintenance.
• CADACPatioBBQ’sarettedwithspesicCADACjetstoregulatethecorrectamountofgas.ShouldtheholeintheJetbecome
blockeditmayresultinasmallameornoameatall.DonotattempttocleantheJetwithapinorothersuchdeviceasthismay
damagethehole,whichcouldmaketheapplianceunsafe.Referto“Introduction“(Section1)forjetsizes.
5.1.Replacing a Blocked Jet
• Ensurethatthecylindervalveisclosed,thendisconnecttheappliancefromthegascylinder.
• Removethegrillplates.Removetheametamerstoexposetheburners.Removetheretainingscrewsoftheaffectedburner.
• Removetheaffectedburnerbyliftingitoutofitslocationtakingcarenottodamagethecontrolvalvewhilstdoingso.Thiswillexpose
theJet.
• UnscrewtheblockedJetwithasuitablespannerandreplaceitwithanewJet.DonotusepliersontheJetastheycancausedamage,
makingtheJetunusableorimpossibletoremove.
• Tore-assemble,reversetheaboveprocedure.DonotovertightenasthismaydamagetheJet.
5.2.Replacement of Hose
• Thehoselengthshouldnotbelessthan0.8morexceed1.2m.Checktheexpirydateonthehoseandreplacewhennecessary.Fitting
ofahoseisdescribedinSection2.OnlyanLPGhosethatcomplieswithSANS1156-2,BS3212orDIN4815maybeusedwiththis
appliance.

44
9. Spares and Accessories
• AlwaysusegenuineCADACsparesastheyhavebeendesignedtogiveoptimumperformance.
6. Troubleshooting
• Anormalameisblueandmayhaveanorangeoryellowtip.Iftheameiscompletelyyellow,itmaybethatthejetisnotsecurely
tted.Re-tightenthejettoensurethereisnogasleakage.Anoverlledgascylindercanalsocauselargeyellowames.Ifthisisthe
casethecylindershouldbereturnedtothellingstationandcheckedbyweight.
• Checkthattheprimaryairsupplyholesintheburnersareclearandfreeofobstructions.
• Iftheamepowerdropsorthegaswillnotlight,checkthatthegascylinderstillcontainsgas(shaketohearthenoisemadebya
liquid).Ifthereisstillgas,thejetmightbeblockedorpartiallyblocked.
• Ifyoususpectablockedjet,followtheinstructionsabovetocleanorreplaceit.
7. Cleaning
• Tocleanthebody,simplywipewithadampclothusingalittledetergentifnecessary.
• Donotuseabrasivecleanersorscourersasthiswillcausepermanentdamagetothepaintedsurface.
• Eventhoughstainlesssteelisremarkablyresistanttotarnishandrustrelativetoordinarysteels,itstillrequirespropercare.We
recommendthefollowing:
• Afteruse,cleanthestainlesssteelsurfaceswithcleanwaterandasoftclothforlightcleaning,whileacommerciallyavailable
stainlesssteelcleanerwithasoftclothshouldbeusedfortougherareas.Ensurethatyouremoveallexcessstainlesssteelcleaner
aftercleaningyourBBQ.
• Torepairminorteastainingorpitting,youcanusealight,non-metallicscourer.Itisimportantthatyourubwiththenaturalgrainof
thestainlesssteelsurfacetoavoidleavingvisiblescratchmarks.
• Betweenuses,itisagoodideatoleavethebarbequecoveredtopreventdustandairbornesaltssettlingonthestainlesssteel
surfaces.
• Withasmallamountofcare,yourinvestmentinqualitystainlesssteelwillkeepitsbeautifulnishaswellasitsvalueforalongtime
tocome.
8. Storage
• Handletheappliancewithcare.Donotdropit.
• Afteruse,waituntiltheappliancehascooleddown,disconnectitfromthegascylinderandstoreinacooldryplaceawayfromheat.
• Keepthedomeclosedwhennotinusetopreventdirtandinsectsfallingintotheunit,whichmayaffectthegasow.
• UseaCADACBBQcover,especiallyiftheunitisstoredoutdoors.
• Beforeeveryuse,ensurethattheburnersandventuriesarefreeofinsects,dustandspiderwebs.
Description Part No.
JetNo.0.92(28/37mBar)/(2.8kPa-SAOnly) 0.92
JetNo.0.81(50mBar) 0.81
JetN0.0.88(SideBurner)(28/37mBar)/(2.8kPa-SAOnly) 0.88
JetN0.0.75(SideBurner)(50mBar) 0.75
Stratos3BCover 98700-30-CVR
Stratos4BCover 98700-40-CVR
StratosWarmerPan 98700-50
StratosReversibleGrillPlate 98700-51
5. General Maintenance cont.
5.3.Replacement of Regulator
• InSouthAfricatheregulatorusedmustbe2.8kpaanditmustcomplywithSANS1237.
• Use30mBarbutane(orpropane)regulatorwithgascategoryI3B/P(30)
• Use30mBarbutaneregulatorwithgascategoryI3+(28-30/37)forbutane.
• Use37mbarbutane(orpropane)regulatorwithgascategoryI3B/P(37)
• Use37mbarpropaneregulatorwithgascategoryI3+(28-30/37)
• Use50mBarbutane(orpropane)regulatorwithgascategoryI3B/P(50)
• Itisimportantthattheconnectionbetweentheregulatoroutletandthelowpressurehoseistightandthatitissecuredwithametal
hoseclamp.Alwayscheckthejointforgasleaksasdescribedinsection4above.

55
10. Returning the Appliance for Repair or Service
• Donotmodifytheappliance.Thismaycausetheappliancetobecomeunsafe.
• AnymodicationswillrendertheCADAC(Pty)Ltdwarrantynullandvoid.
• Ifyoucannotrectifyanyfaultbyfollowingtheseinstructions,contactyourlocalCADACstockistforinspection
and/orrepair.
11. Warranty
• CADAC(Pty)LtdherebywarrantstotheORIGINALPURCHASERofthisCADACGasBarbecue,thatitwillbefreeofdefectsin
materialandworkmanshipfromthedateofpurchaseasfollows:
Valves:   5Years
Plastic parts:  NoWarranty
Enamel parts (ExceptFlameTamers): 5Years
Cast Iron:   5Years
Painted Frames:  1Year
Stainless Steel Burners:  2Years
Enamel Flame Tamers: 2Years
Thewarrantywillonlyapplyiftheunitisassembledandoperatedinaccordancewiththeprintedinstructions.
CADACmayrequirereasonableproofofyourdateofpurchase.THEREFORE,YOUSHOULDRETAINYOURSALESSLIPORINVOICE.
ThisLimitedWarrantyshallbelimitedtotherepairorreplacementofpartsthatprovedefectiveundernormaluseandserviceandwhich
onexaminationshallindicate,toCADAC’ssatisfaction,theyaredefective.Beforereturninganyparts,contactthecustomerservice
representativeinyourregionusingthecontactinformationprovidedwithyourmanualorcall0860223220(RSAonly).IfCADAC
conrmsthedefectandapprovestheclaim,CADACwillelecttoreplacesuchpartswithoutcharge.CADACwillreturnpartstothe
purchaser,freightorpostageprepaid.
ThisLimitedWarrantydoesnotcoveranyfailuresoroperatingdifcultiesduetoaccident,abuse,misuse,alteration,misapplication,
vandalism,improperinstallationorimpropermaintenanceorservice,orfailuretoperformnormalandroutinemaintenance,includingbut
notlimitedtodamagecausedbyinsectswithintheburnertubes,assetoutinthisowner’smanual.
Deteriorationordamageduetosevereweatherconditionssuchashail,hurricanes,earthquakesortornadoes,discolorationdueto
exposuretochemicalseitherdirectlyorintheatmosphere,isnotcoveredbythisLimitedWarranty.
Therearenootherexpresswarrantsexceptassetforthhereinandanyapplicableimpliedwarrantiesofmerchantabilityandtnessare
limitedindurationtotheperiodofcoverageofthisexpresswrittenLimitedWarranty.Someregionsdonotallowlimitationonhowlongan
impliedwarrantylasts,sothislimitationmaynotapplytoyou.
CADACisnotliableforanyspecial,indirectorconsequentialdamages.Someregionsdonotallowtheexclusionorlimitationofincidental
orconsequentialdamages,tothislimitationorexclusionmaynotapplytoyou.
CADACdoesnotauthorizeanypersonorcompanytoassumeforitanyobligationorliabilityinconnectionwiththesale,installation,use,
removal,return,orreplacementofitsequipment;andnosuchrepresentationsarebindingonCADAC.
ThisWarrantyappliesonlytoproductssoldatretail.
ToenjoyandensurelongevityofyourCADACproduct,pleaserefertothecleaningandmaintenancesectionoftheusermanualwith
particularattentiontothecareoftheStainlessSteel.

5151
LIVE THE BRAAI LIFE