Cas Hire WDS 40 User manual

WDS40Dehumidifier
www.cashire.co.ukFreePhone0800525082
OperatingInstructions
www.cashire.co.ukFreePhone0800525082
ON/OFFSwitch
Depresstheswitchtostartorstopthe
dehumidifier."O"forpoweroff,"I"for
poweron.
HourCounter
Thecounterwillaccumulateanddisplay
thetotalrunninghoursoftheunit
in1/100ofanhour.Itcannotbereset
tozero.Nouserinputisrequired.
OperatingYourDehumidifier
Location
Minimum25cmdistancefromwalls.Closealldoorsandwindows.
IntialStartup
Checktheratingplatefortheappropriatepowersupplyneeded
byyourunit.Thiswillbeoneofthefollowing:230Volt50
Hz,115Volt50Hzor120Volt60Hz.Connectthedehumidifier.
Ensurethatoneofthewatercollectionoptionsisworking
andactive.DepresstheONswitch.
ControlPanelSettings

www.cashire.co.ukFreePhone0800525082 www.cashire.co.ukFreePhone0800525082
RemovingCollectedWater
Thewatercollectedfromtheaircanbedisposedinoneof
fourconvenientways:
Watercontainer:Removeandempty.Seediagram.Startthe
removalofthewatercontainerbyfirstopeningthewater
compartmentdoors(depresstheblackspringloadeddoorlatch
downwardthusallowingthedoortorotatedowntowardsthe
ground).Slidethewatercontaineroutbygraspingthetoprim
ofthecontainer.Removethewatercontainerbygrippingthe
containerwithbothhands,thenslidingoutofthewater
compartment.
GravityDrain:Placethedehumidifierdirectlyoveranexisting
floordrain.
HoseAttachment:Onsomemodels,auniversaldrainadapter
isincluded.Thiscanbethreadedtothebottomoftheplastic
driptray.Connectthehosetothedrainadapter.
CondensatePump:Someofourmodelscomealready
equippedwithanelectricallypoweredCondensatepump.If
yourmodelisnotequippedwithone,thenacondensatepump
kitcanbepurchasedseperately.Thenecessaryinternalelectrical
connectionsalreadyexistineveryunit.
AutomaticDefrost
Allunitsareequippedwithanautomaticallyactivated(thermostat
controlled)Defrostcycletoautomaticallydefrostthe
evaporatorcoils.
DANGER:Electricalshockhazard.Disconnectpower
beforecleaning
ExteriorParts
Useamild,nonabrasivesoapandcleanwatersolutionto
cleanthepaintedmetalcabinet,handlesandwheels.Wipedry.
AirFilter
Removefilter.Washinamildsoapandwater.Rinsewithclean
water.Airdrybeforereinstalling.Tornorrippedfiltersshouldbe
replacedwithanewfilter.
FanMotor
Doesnotrequirelubrication.
1
CondenserandEvaporatorCoils
1.Lightcleaning:Removetheair
filterandsprayevaporatorcoilwith
water.
2
2.Heavycleaning:Openupperdoor.
Removeplasticcleanoutbypushing
thetwolockingtabsandlifting.Spray
wateratcoils.Replacethecleanout.
Important
Condensatepumporbucketaccessdoor.
Depressdoorlatchdownwardtoopen

www.cashire.co.ukFreePhone0800525082 www.cashire.co.ukFreePhone0800525082
HowaDehumidifierWorks
Thedehumidifierremovesmoisturefromtheairbypassingthe
moistairoveracolddehumidifyingcoil.Themoisturecondenses
outoftheaironthiscoilandthendrainsfromthecoil
intoabucket.
Adehumidifierreducestherelativehumidityofthesurrounding
airtwoways.Theremovalofmoisturefromtheair(asjust
described)reducesitshumidity.Therelativehumidityoftheair
isfurtherreducedbyheatingasthedryairisdischargedover
thecondenserandoutthefront.Theairisactuallyheated
severaldegreesinthisprocess.Itisnormalforthesurrounding
airtoslightlyincreaseintemperatureasthedehumidifieroperates.
Condenser
Evaporator
HumidAirIn DryAirOut
Compressor
ContinuousDrain
Connector
Bucket
Float
AirCirculatingFan
BeforeCallingforService
performthesesimplechecks
ConditionUnitisnotworking
•Isthedehumidifierconnectedtoaliveandcorrectvoltage
electricalsupply?
•Isthereablownfuseortrippedcircuitbreaker?(Checkthe
outletwithanotherappliance).
•IsthePowerSwitchpushedtothe"I"position?
•Isthewatercontainer(ifused)fullandrequiresemptying?
•Isthewaterlevelplasticfloatfreelyhanginginsidebucket(if
bucketisused),orhangsfreelyinair(ifnobucket)?
ConditionMoistureRemovalSeemsInsufficient
•Arethedehumidifier'sventsandairfilterclearofobstructions
anddirt?
•Doesthelocationselectedpresentsufficientairflowaroundthe
unit?
Specification
Refrigerantcharge R407C/0.36kg
NoiseleveldB(A) 62.9
Power(W) 600
Supplyvoltage(V~) 220240
Frequency(Hz) 50
Productdimensions(HxWxDcm) 93x55.5x60.5
Boxdimensions(HxWxDcm) 72x50x52
Netweight(kg) 41
Grossweightbox(kg) 43