Champion 73001i-DF-UK System manual
73001i-DF-UK
Max Watts
Max Watts
r
『
WE ARE HERE TO HELP!
www.championpowe『equipment.com
+
44-1942-715-407
+44-1942-715-407
「「 「.
RED Statement
1. This device complies with Part 15 of the RED
Rules. Operation is subject to the following two
conditions: (1) This device may not cause harmful
interference.(2) This device must accept any
interference received, including interference that
may cause undesired operation.
2. Changes or modifications not expressly approved by
the party responsible for compliance could void the
user’s authority to operate the equipment.
NOTE: This equipment has been tested and found to
comply with the limits for a Class B digital device,
pursuant to Part 15 of the FCC Rules. These limits
are designed to provide reasonable protection against
harmful interference in a residential installation.
This equipment generates uses and can radiate radio
frequency energy and, if not installed and used in
accordance with the instructions, may cause harmful
interference to radio communications. However, there
is no guarantee that interference will not occur in a
particular installation. If this equipment does cause
harmful interference to radio or television reception,
which can be determined by turning the equipment
off and on, the user is encouraged to try to correct the
interference by one or more of the following measures:
–Reorient or relocate the receiving antenna.
–Increase the separation between the equipment and
receiver.
–Connect the equipment into an outlet on a
circuit different from that to which the receiver is
connected.
Consult the dealer or an experienced radio/TV technician
for help.
3500 MMax Watts/3200Running Watts(Gas)
3150 MMax Watts/2880Running Watts(LPG)
Electric Start
TABLE OF CONTENTS
Introduction ........................................................ 1
Introduction........................................................ 1
Manual Conventions................................................ 2
Safety Rules........................................................... 3
Fuel Safety ....................................................... 5
Controls and Featu es............................................... 6
Generator .......................................................... 6
Parts Included.................................................... 6
Power Panel....................................................... 7
Assembly ............................................................... 8
Remove the Generator from the Shipping Carton.... 8
Connect the Battery ............................................8
Add Engine Oil....................................................9
Add Fuel (Gas)................................................... 10
Connecting the Propane (LPG) Cylinder..............11
Grounding ...................................................... 11
Operation.............................................................. 12
Generator Location............................................ 12
Grounding ...................................................... 12
Fuel Selector Switch.......................................... 12
Starting the Inverter .......................................... 13
Gasoline
LPG
.....................................................
............................................................
13
14
15
15
15
Economy Control Switch ....................................
12V DC outlet ..................................................
Connecting Electrical Loads................................
Parallel Operation.............................................. 15
Do Not Overload Generator................................. 16
Capacity ..................................................... 16
Power Management ...................................... 16
Stopping the Engine.......................................... 16
Operation at High Altitude................................ 17
Overload Operation........................................... 17
Smart Charger ................................................. 17
Maintenanceand Storage .......................................18
Engine Maintenance.......................................... 18
Oil...............................................................18
Spark Plugs .................................................18
Air Filter...................................................... 19
Cleaning...................................................... 19
Spark Arrester...............................................19
Adjustments .................................................19
Maintenance Schedule ..................................19
Generator Battery.............................................. 20
Charge the Battery ...................................... 20
Disconnect the Battery ............................... 20
Generator Maintenance..................................... 20
Storage................................................................ 21
Generator Storage ....................................... 21
Specifications ..................................................... 22
Engine Specifications ....................................... 22
Generator Specifications ................................... 22
Fuel................................................................ 22
Spark Plugs...................................................... 22
MaintenanceValve Clearance............................. 22
Oil .................................................................. 22
An Important Message About Temperature......... 22
Troubleshooting ................................................... 23
DUAL FUEL INVERTER GENERATOR
73001i-DF-UK
+44-1942-715-407
MANUAL CONVENTIONS
DANGER
WARNING
QNOTE
If you have questions regarding your generator, we can
help. Please call our help line at
0044-1942-715-407
CAUTION 、
2
SAFETY RULES
3
DO NOT install any exhaust/muffler extension, by doing so will void
any warranties offered.
Generator exhaust contains carbon monoxide, a
colourless, odourless, poison gas. Breathing carbon
monoxide will cause nausea, dizziness, fainting or
death. If you start to feel dizzy or weak, get to fresh
air immediately.
Operate generator outdoors only in a well ventilated
area.
DO NOT operate the generator inside any building,
including garages, basements, crawlspaces and
sheds, enclosure or compartment confined spaces,
vehicles, including the generator compartment of a
recreational vehicle.
DO NOT allow exhaust fumes to enter a confined
area through windows, doors, vents or other
openings.
DANGER CARBON MONOXIDE: using a generator
indoors CAN KILL YOU IN MINUTES.
DANGER
DO NOT add or attach any exhaust/muffler extension
or filtration, By doing this with result in any warranty
offered being voided
DO NOT install or add any exhaust/muffler extensions,
by doing so will void any warranty offered.
SAFETY RULES
Fuel Safety
『凶DANGER 、
Gasoline and Gasoline Vapo『s(Gas):
Liquefied Petroleum Gas (Propane/LPG):
When adding or removing Gas:
When starting the generator:
When operating the generator:
When transporting or servicing the generato『:
When storing the generator:
5
DO NOT try to refill fuel tank whilst generator is running
or hot.
6
73001i-DF-UK
AC Socket
7
or use both AC/DC together this will possible damaged
equipment or generator.
8
01942 715407
9
No oil in unit
We recommend the first 5hours of run time to be
10
11
During operation the muffler and exhaust fumes
produced will become hot. If adequate cooling and
breathing space are not supplied, or if the generator
is blocked or contained, temperatures can become
extremely heated and may lead to fire.
DO NOT extend or add an exhaust/muffler extension
or filtration, by doing so you will void any warranty
offered.
12
Generator Location
NEVER operate the generator inside any building,
including garages, basements, crawlspaces and sheds,
enclosure or compartment, confined spaces, vehicles
including the generator compartment of a recreational
vehicle. Please consult your local authority. In some
areas, generators must be registered with the local utility.
Generators used at construction sites may be subject
to additional rules and regulations. Generators should
be on a flat, level surface at all times (even while not in
operation). Generators must have at least 5 ft. (1.5 m)
of clearance from all combustible material. In addition
to clearance from all combustible material, generators
must also have at least 3 ft. (91.4 cm) of clearance on
all sides to allow for adequate cooling, maintenance and
servicing. Generators should never be started or operated
in the back of a SUV, camper, trailer, in the bed of a truck
(regular, flat or otherwise), under staircases/stairwells,
next to walls or buildings, or in any other location that
will not allow for adequate cooling of the generator and/or
the muffler. DO NOT contain generators during operation.
Allow generators to properly cool before transport or
storage.
Place the generator in a well-ventilated area. DO NOT
place the generator near vents or intakes where exhaust
fumes could be drawn into occupied or confined spaces.
Carefully consider wind and air currents when positioning
generator.
13
The supplied 12v 7Ah battery does re-charge while
the engine is running but it is also recommended
that to prevent damage to the cells the battery is
fully charged at least one a month using the smart
charger or a main charger.
14
220-240
15
DO NOT operate both DC/AC together, by doing so
you can possible damage generator or equipment
DO NOT operate any equipment when plugged
directly in to the 12v DC outlet, it is designed for
01942 715407
battery charging and is unregulated.
WARNING
16
17
DO NOT use the smart charger whilst the generator is
running, by doing so you will cause a fire risk of the
lead overloading and melting.
WARNING
Other Champion Portable Generator manuals
Champion
Champion Category 5 46538 Manual
Champion
Champion 41030 System manual
Champion
Champion 41513 Manual
Champion
Champion 201189 User manual
Champion
Champion 40026 System manual
Champion
Champion 100460 User manual
Champion
Champion 100156 System manual
Champion
Champion 201286 User manual
Champion
Champion 200959 User manual
Champion
Champion 41537 System manual
Champion
Champion 100199 User manual
Champion
Champion 201042 User manual
Champion
Champion 201280 User manual
Champion
Champion 201169 User manual
Champion
Champion 100455 User manual
Champion
Champion 46551 System manual
Champion
Champion 201184 User manual
Champion
Champion 65525 User manual
Champion
Champion 42451 System manual
Champion
Champion 100485 User manual
Popular Portable Generator manuals by other brands
Briggs & Stratton
Briggs & Stratton BSP3200 owner's manual
WhisperPower
WhisperPower Piccolo Genverter installation manual
Sportsman
Sportsman GEN2000I instruction manual
Durapac
Durapac 30 Series instruction manual
EINHELL
EINHELL TC-PG 2800/1 Original operating instructions
Generac Power Systems
Generac Power Systems 45kW owner's manual