Charge Amps Aura Pole Mount User manual

Charge Amps Aura Pole Mount
Installation manual

© 2021 Charge Amps AB
Installation manual for
Ch
arge Amps Aura Pole Mount
Doc. Nr:
101249
Rev 01
Address:
Charge Amps AB
Frösundaleden 2B
SE
-169 75 Solna
Sweden
Contact:
[phone]
2000
info@charge
-amps.com
www.chargeamps.com
Org. No. 556897-7192
Registered office: Solna
2
Table of Contents
Greetings installer! ........................................................................................ 3
About Aura Pole Mount ................................................................................. 4
Contents of the package ................................................................................. 4
Provided by the installer .................................................................................. 4
Before installation ......................................................................................... 5
Model view Aura Pole Mount ........................................................................ 6
Mounting Aura on the pole mount ................................................................. 7
Warranty conditions ........................................................................................ 14
Safety precaution ............................................................................................ 14
Mechanical information................................................................................... 14
Product recycling ............................................................................................ 14
Rights ............................................................................................................ 15

© 2021 Charge Amps AB
Installation manual for
Ch
arge Amps Aura Pole Mount
Doc. Nr:
101249
Rev 01
Address:
Charge Amps AB
Frösundaleden 2B
SE
-169 75 Solna
Sweden
Contact:
[phone]
2000
info@charge
-amps.com
www.chargeamps.com
Org. No. 556897-7192
Registered office: Solna
3
Greetings installer!
This installation manual is intended for qualified Aura Pole Mount installers and describes
how to install the product safely and properly.
Installation may only be carried out by a qualified installer who follows:
•Basic safety precautions for safe and correct installation.
•Local, regional, and national installation regulations.
•The instructions in this Aura Pole Mount installation manual.

© 2021 Charge Amps AB
Installation manual for
Ch
arge Amps Aura Pole Mount
Doc. Nr:
101249
Rev 01
Address:
Charge Amps AB
Frösundaleden 2B
SE
-169 75 Solna
Sweden
Contact:
[phone]
2000
info@charge
-amps.com
www.chargeamps.com
Org. No. 556897-7192
Registered office: Solna
4
About Aura Pole Mount
By adding the Pole Mount, specifically designed for Aura, you open up the possibilities for
installing the charger on a 60 mm outer diameter pole e.g. an existing pole.
Contact your supplier for more information about your specific Aura Pole Mount.
Contents of the package
In the packaging, below is included:
•Aura Pole Mount
•Installation kit, zip-lock bag containing O-ring 60x3mm, 4 pcs. of M6 carriage
bolts, 4 pcs. of M6 flange nuts and 6 pcs. of M8 pin stop screws.
•NOTE: The two M6x20mm screws included in the Aura product kit will be used for
mounting Aura on the pole mount.
•Installation manual
Provided by the installer
•Torx drive T30 (used for M6 x 20mm screws)
•M6 socket wrench size 10 (used for M6 flange nuts)
•Hex key M8 (used for M8 pin stop screws)
•Screwdriver (manual or power tool)

© 2021 Charge Amps AB
Installation manual for
Ch
arge Amps Aura Pole Mount
Doc. Nr:
101249
Rev 01
Address:
Charge Amps AB
Frösundaleden 2B
SE
-169 75 Solna
Sweden
Contact:
[phone]
2000
info@charge
-amps.com
www.chargeamps.com
Org. No. 556897-7192
Registered office: Solna
5
Before installation
Make sure that the right conditions and materials are in place before installation. The
installation must be done in accordance with the instructions in this installation manual as
well as basic safety precautions.

© 2021 Charge Amps AB
Installation manual for
Ch
arge Amps Aura Pole Mount
Doc. Nr:
101249
Rev 01
Address:
Charge Amps AB
Frösundaleden 2B
SE
-169 75 Solna
Sweden
Contact:
[phone]
2000
info@charge
-amps.com
www.chargeamps.com
Org. No. 556897-7192
Registered office: Solna
6
Model view Aura Pole Mount

© 2021 Charge Amps AB
Installation manual for
Ch
arge Amps Aura Pole Mount
Doc. Nr:
101249
Rev 01
Address:
Charge Amps AB
Frösundaleden 2B
SE
-169 75 Solna
Sweden
Contact:
[phone]
2000
info@charge
-amps.com
www.chargeamps.com
Org. No. 556897-7192
Registered office: Solna
7
1. Aura Pole Mount
2. 4 pcs. of each M6 carriage bolts and flange nuts
3. 2 pcs. of M6x20mm (included in Aura product kit)
4. 6 pcs. of M8 pin stop screws
Mounting Aura on the pole mount
Before starting the installation, the following is important to check:
•That incoming cable is of correct dimension.
•That power is shut off.
First step is to slide the O-ring onto the pole. Then slide the pole mount onto the pole.
Make sure that the O-ring is between the pole mount and the pole.

© 2021 Charge Amps AB
Installation manual for
Ch
arge Amps Aura Pole Mount
Doc. Nr:
101249
Rev 01
Address:
Charge Amps AB
Frösundaleden 2B
SE
-169 75 Solna
Sweden
Contact:
[phone]
2000
info@charge
-amps.com
www.chargeamps.com
Org. No. 556897-7192
Registered office: Solna
8
Step 2
Tighten the 6 pcs. of M8 pin stop screws which fixates the pole mount onto the pole. Use
the hex key M8. Make sure that the pole mount is fixated and in an upright position. If the
pole has a slight angle, the pole mount can be straightened by tightening the pin stops
screws differently.
Step 3
Put the installation cable from the pole into Aura. It might require to rotate Aura a bit
depending on installation cable.

© 2021 Charge Amps AB
Installation manual for
Ch
arge Amps Aura Pole Mount
Doc. Nr:
101249
Rev 01
Address:
Charge Amps AB
Frösundaleden 2B
SE
-169 75 Solna
Sweden
Contact:
[phone]
2000
info@charge
-amps.com
www.chargeamps.com
Org. No. 556897-7192
Registered office: Solna
9
Step 4
Slide Aura into correct position.

© 2021 Charge Amps AB
Installation manual for
Ch
arge Amps Aura Pole Mount
Doc. Nr:
101249
Rev 01
Address:
Charge Amps AB
Frösundaleden 2B
SE
-169 75 Solna
Sweden
Contact:
[phone]
2000
info@charge
-amps.com
www.chargeamps.com
Org. No. 556897-7192
Registered office: Solna
10
Step 5
Mount the M6 carriage screws and screw on the M6 flange nuts. NOTE: Do not tighten
the nuts, just thread the nuts.

© 2021 Charge Amps AB
Installation manual for
Ch
arge Amps Aura Pole Mount
Doc. Nr:
101249
Rev 01
Address:
Charge Amps AB
Frösundaleden 2B
SE
-169 75 Solna
Sweden
Contact:
[phone]
2000
info@charge
-amps.com
www.chargeamps.com
Org. No. 556897-7192
Registered office: Solna
11
Step 6
Screw the M6 x 20 mm screws tightly.
Step 7
Screw the M6 flange nuts tightly.

© 2021 Charge Amps AB
Installation manual for
Ch
arge Amps Aura Pole Mount
Doc. Nr:
101249
Rev 01
Address:
Charge Amps AB
Frösundaleden 2B
SE
-169 75 Solna
Sweden
Contact:
[phone]
2000
info@charge
-amps.com
www.chargeamps.com
Org. No. 556897-7192
Registered office: Solna
12
Step 8
Install the installation cables according to the Aura installation manual and then close and
lock the front. NOTE: If you are installing Aura on a 4 cable conductor system, Zero cable
(N) will not be installed in the blue colored topjob.

© 2021 Charge Amps AB
Installation manual for
Ch
arge Amps Aura Pole Mount
Doc. Nr:
101249
Rev 01
Address:
Charge Amps AB
Frösundaleden 2B
SE
-169 75 Solna
Sweden
Contact:
[phone]
2000
info@charge
-amps.com
www.chargeamps.com
Org. No. 556897-7192
Registered office: Solna
13

© 2021 Charge Amps AB
Installation manual for
Ch
arge Amps Aura Pole Mount
Doc. Nr:
101249
Rev 01
Address:
Charge Amps AB
Frösundaleden 2B
SE
-169 75 Solna
Sweden
Contact:
[phone]
2000
info@charge
-amps.com
www.chargeamps.com
Org. No. 556897-7192
Registered office: Solna
14
Warranty conditions
Check the warranty conditions on our website: https://cms.charge-amps.com/wp-
content/uploads/2020/11/warranty_policy-1.pdf
Safety precaution
To be able to install and mount Aura, you have to be a licensed electrician and follow all
safety precautions to ensure a safe and correct installation. Installation should follow
according to instructions in this document.
Mechanical information
•Weight: 2 kg
•Product dimension: Height 465 mm, width 303 mm, depth 81 mm
•Product material: Stainless steel
Product recycling
Recycling is part of any products lifecycle. Aura pole mount contains stainless steel and
should be recycled accordingly.

© 2021 Charge Amps AB
Installation manual for
Ch
arge Amps Aura Pole Mount
Doc. Nr:
101249
Rev 01
Address:
Charge Amps AB
Frösundaleden 2B
SE
-169 75 Solna
Sweden
Contact:
[phone]
2000
info@charge
-amps.com
www.chargeamps.com
Org. No. 556897-7192
Registered office: Solna
15
Rights
The information in this document has been checked for accuracy. Charge Amps AB
reserves the right to make technical changes and changes to the contents of the
document without prior notice. Charge Amps AB can not guarantee that all of the content
of this particular document is accurate, up-to-date, and free from printing and
proofreading errors. Moreover, Charge Amps AB cannot be held liable for any mistakes,
near-misses, injuries/damage or incidents – direct or indirect – that can be linked to the
use of the safety precautions or products in this document.
Charge Amps AB reserves all rights to this document, as well as the information and
illustrations therein. It is strictly forbidden to – in whole or in part – copy, adapt or
translate the information without prior written permission from Charge Amps AB.
© Copyright 2021, Charge Amps AB. All rights reserved.