Chrysler 2004 Concorde User manual

SERVICE MANUAL
2004
300M, CONCORDE
AND INTREPID
To order the special service tools used and
illustrated, please refer to the instructions on
inside back cover.
NO PART OF THIS PUBLICATION MAY BE
REPRODUCED, STORED IN A RETRIEVAL
SYSTEM, OR TRANSMITTED, IN ANY FORM OR
BY ANY MEANS, ELECTRONIC, MECHANICAL,
PHOTOCOPYING, RECORDING, OR OTHERWISE,
WITHOUT THE PRIOR WRITTEN PERMISSION
OF DAIMLERCHRYSLER CORPORATION.
DaimlerChrysler Corporation reserves the right to make changes in design or
to make additions to or improvements in its products without imposing any
obligations upon itself to install them on its products previously manufac-
tured.
Litho in U.S.A. Copyright © 2003 DaimlerChrysler Corporation
7.0M0203

FOREWORD
The information contained in this service manual has been prepared for the professional automotive tech-
nician involved in daily repair operations. Information describing the operation and use of standard and
optional equipment is included in the Owner’s Manual provided with the vehicle.
Information in this manual is divided into groups. These groups contain description, operation, diagnosis,
testing, adjustments, removal, installation, disassembly, and assembly procedures for the systems and compo-
nents. To assist in locating a group title page, use the Group Tab Locator by clicking to the following page. The
solid bar after the group title is aligned to a solid tab on the first page of each group. The first page of the
group has a contents section that lists major topics within the group. If you are not sure which Group contains
the information you need, look up the Component/System in the alphabetical index located in the rear of this
manual.
A Service Manual Comment form is included at the rear of this manual. Use the form to provide
DaimlerChrysler Corporation with your comments and suggestions.
Tightening torques are provided as a specific value throughout this manual. This value represents the
midpoint of the acceptable engineering torque range for a given fastener application. These torque values are
intended for use in service assembly and installation procedures using the correct OEM fasteners. When
replacing fasteners, always use the same type (part number) fastener as removed.
DaimlerChrysler Corporation reserves the right to change testing procedures, specifications, diagnosis,
repair methods, or vehicle wiring at any time without prior notice or incurring obligation.

TABLE OF CONTENTS
1.0 INTRODUCTION .........................................................1
1.1 SYSTEM COVERAGE ...............................................1
1.2 SIX STEP TROUBLESHOOTING PROCEDURE ..........................1
1.3 FUSES AND LIGHT BULBS ...........................................1
2.0 IDENTIFICATION OF SYSTEM .............................................1
3.0 SYSTEM DESCRIPTION AND FUNCTIONAL OPERATION ......................1
3.1 AIRBAG SYSTEM ...................................................2
3.1.1 DRIVER AIRBAG (DAB) ......................................2
3.1.2 CLOCKSPRING.............................................3
3.1.3 PASSENGER AIRBAG (PAB)..................................3
3.1.4 SIDE IMPACT AIRBAG CONTROL MODULES (SIACM) ............3
3.1.5 SEAT AIRBAG ..............................................4
3.1.6 SPECIAL TOOLS............................................4
3.1.7 DIAGNOSTIC TROUBLE CODES ..............................4
3.1.7.1 ACTIVE CODES ............................................4
3.1.7.2 STORED CODES ...........................................5
3.2 AUDIO SYSTEM ....................................................5
3.3 BODY CONTROL MODULE...........................................6
3.4 CHIME SYSTEM ....................................................8
3.5 DOOR AJAR SYSTEM ...............................................8
3.6 CLIMATE CONTROL SYSTEMS .......................................8
3.6.1 AUTOMATIC TEMPERATURE CONTROL (ATC) ..................8
3.6.2 MANUAL TEMPERATURE CONTROL...........................8
3.6.3 HVAC BLEND, MODE, AND RECIRCULATION DOOR OPERATION . .8
3.6.4 REAR WINDOW DEFOGGER .................................9
3.7 EXTERIOR LIGHTING SYSTEM .......................................9
3.7.1 EXTERIOR LIGHTING BATTERY SAVER........................9
3.7.2 HEADLAMP DELAY .........................................9
3.7.3 HEADLAMP SWITCH ........................................9
3.7.4 FOG LAMP CONTROL .......................................9
3.7.5 AUTO HEADLAMPS .........................................9
3.8 INTERIOR LIGHTING ................................................9
3.8.1 COURTESY LAMP CONTROL.................................9
3.8.2 ILLUMINATED ENTRY .......................................9
3.9 MECHANICAL INSTRUMENT CLUSTER ................................9
3.10 MEMORY SYSTEM.................................................10
3.10.1 POWER SEAT.............................................10
3.10.2 MEMORY SEAT GLIDE .....................................10
3.10.3 GUARD BANDS ...........................................10
3.10.4 MEMORY MIRROR.........................................10
3.10.5 HEATEDSEATS...........................................11
3.11 COMPASS/MINI-TRIP COMPUTER OR ELECTRONIC VEHICLE
INFORMATION CENTER ............................................11
3.11.1 TRAVELER DISPLAY FUNCTIONS ............................12
3.11.2 SETTING MAGNETIC ZONE VARIANCE .......................13
3.11.3 COMPASS CALIBRATION ...................................13
3.11.4 DIAGNOSIS AND TESTING ..................................13
3.11.5 AMBIENT TEMPERATURE SENSOR ..........................14
3.11.6 HOMELINKTUNIVERSAL TRANSMITTER......................14
i

TABLE OF CONTENTS - Continued
3.12 TIRE PRESSURE MONITORING SYSTEM .............................14
3.12.1 TRAINING THE EVIC .......................................14
3.12.2 PRESSURE THRESHOLDS ...................................15
3.12.3 CRITICAL AND NON-CRITICAL PRESSURE ALERTS ............15
3.12.4 SYSTEM FAULTS..........................................16
3.12.5 SPARE WHEEL AUTO-LOCATE (5-TIRE TPM SYSTEM ONLY) ....16
3.12.6 REMOVE MAGNET FROM SPARE (5-TIRE TPM SYSTEM ONLY) . .16
3.12.7 TIRE PRESSURE NOW AVAILABLE...........................16
3.12.8 DIAGNOSING AND CLEARING SYSTEM FAULTS ...............16
3.12.9 SYSTEM TEST ............................................17
3.13 POWER DOOR LOCK SYSTEM ......................................17
3.14 SENTRY KEY IMMOBILIZER SYSTEM (SKIS)...........................17
3.15 SPEED PROPORTIONAL STEERING (IF EQUIPPED) ....................17
3.16 VEHICLE COMMUNICATION.........................................18
3.16.1 BUS FAILURE MESSAGE ...................................20
3.17 VEHICLE THEFT SECURITY SYSTEM.................................20
3.18 WIPER SYSTEM...................................................20
3.18.1 SYSTEM FEATURES .......................................21
3.19 USING THE DRBIIIT................................................21
3.20 DRBIIITERROR MESSAGES ........................................21
3.21 DRBIIITDOES NOT POWER UP (BLANK SCREEN)......................21
3.22 DISPLAY IS NOT VISIBLE ...........................................21
4.0 DISCLAIMERS, SAFETY, WARNINGS ......................................21
4.1 DISCLAIMERS.....................................................21
4.2 SAFETY..........................................................22
4.2.1 TECHNICIAN SAFETY INFORMATION.........................22
4.2.2 VEHICLE PREPARATION FOR TESTING.......................22
4.2.3 SERVICING SUB-ASSEMBLIES ..............................22
4.2.4 DRBIIITSAFETY INFORMATION..............................22
4.3 WARNINGS .......................................................23
4.3.1 VEHICLE DAMAGE WRANINGS..............................23
4.3.2 ROAD TESTING A COMPLAINT VEHICLE......................23
5.0 REQUIRED TOOLS AND EQUIPMENT .....................................23
6.0 GLOSSARY OF TERMS..................................................23
7.0 DIAGNOSTIC INFORMATION AND PROCEDURES ...........................25
AIRBAG
ACCELEROMETER 1....................................................26
ACCELEROMETER 2....................................................26
INTERNAL 1 ...........................................................26
INTERNAL 2 ...........................................................26
OUTPUT DRIVER 1 .....................................................26
OUTPUT DRIVER 2 .....................................................26
STORED ENERGY FIRING 1..............................................26
AIRBAG WARNING INDICATOR OPEN .....................................28
AIRBAG WARNING INDICATOR SHORT ....................................28
CALIBRATION MISMATCH................................................30
CLUSTER MESSAGE MISMATCH .........................................32
CONFIGURATION ERROR ...............................................34
ii

TABLE OF CONTENTS - Continued
DRIVER SQUIB 1 CIRCUIT OPEN .........................................36
DRIVER SQUIB 1 CIRCUIT SHORT ........................................39
DRIVER SQUIB 1 SHORT TO BATTERY ....................................41
DRIVER SQUIB 1 SHORT TO GROUND ....................................44
INTERROGATE LEFT SIACM .............................................47
INTERROGATE RIGHT SIACM ............................................49
LOSS OF IGNITION RUN - START.........................................51
LOSS OF IGNITION RUN ONLY ...........................................54
MODULE NOT CONFIGURED FOR SAB ....................................57
NO CLUSTER MESSAGE ................................................59
NO LEFT SIACM MESSAGE ..............................................61
NO ODOMETER MESSAGE ..............................................63
NO PCI TRANSMISSION .................................................65
NO RIGHT SIACM MESSAGE.............................................68
PASSENGER SQUIB 1 CIRCUIT OPEN .....................................70
PASSENGER SQUIB 1 CIRCUIT SHORT....................................73
PASSENGER SQUIB 1 SHORT TO BATTERY................................75
PASSENGER SQUIB 1 SHORT TO GROUND ................................77
SEAT SQUIB CIRCUIT OPEN .............................................79
SEAT SQUIB CIRCUIT SHORT ............................................82
SEAT SQUIB SHORT TO BATTERY ........................................85
SEAT SQUIB SHORT TO GROUND ........................................88
VEHICLE BODY STYLE UNKNOWN........................................91
*AIRBAG INDICATOR ON WITHOUT ACM TROUBLE CODES ..................93
AUDIO
ALL OUTPUTS SHORT ..................................................94
CASSETTE PLAYER INOP ...............................................96
CD MECHANICAL FAILURE ..............................................96
*AM/FM SWITCH INOPERATIVE...........................................96
*ANY STATION PRESET SWITCH INOPERATIVE.............................96
*BALANCE INOPERATIVE ................................................96
*CD EJECT SWITCH INOPERATIVE........................................96
*EQUALIZER INOPERATIVE ..............................................96
*FADER INOPERATIVE ..................................................96
*FF/RW SWITCH INOPERATIVE...........................................96
*HOUR/MINUTE SWITCHES INOPERATIVE .................................96
*PAUSE/PLAY SWITCH INOPERATIVE .....................................96
*PWR SWITCH INOPERATIVE ............................................96
*SCAN SWITCH INOPERATIVE............................................96
*SEEK SWITCH INOPERATIVE............................................96
*SET SWITCH INOPERATIVE .............................................96
*TAPE EJECT SWITCH INOPERATIVE......................................96
*TIME SWITCH INOPERATIVE ............................................96
*TUNE SWITCH INOPERATIVE............................................96
CD CHANGER MECHANICAL FAILURE.....................................98
CD CHANGER READ FAILURE............................................99
CD CHANGER TEMPERATURE HIGH .....................................100
CD PLAY FAILURE .....................................................101
CD READ FAILURE ....................................................102
CD TEMPERATURE HIGH...............................................103
LOW VOLTAGE LEVEL .................................................104
NO ANTENNA CONNECTION ............................................105
iii

TABLE OF CONTENTS - Continued
POWER AMP SHUTDOWN ..............................................107
REMOTE RADIO SWITCH OPEN .........................................109
REMOTE RADIO SWITCH SHORTED TO GROUND..........................111
*NO SOUND FROM ALL SPEAKERS ......................................114
*ONE REMOTE RADIO SWITCH INOPERATIVE .............................118
*REMOTE RADIO SWITCHES INOPERATIVE WITH IGNITION ON..............119
CHIME
*CHIME INOPERATIVE..................................................120
*CHIME SOUNDS WITH DRIVER DOOR OPEN KEY REMOVED ...............121
*KEY IN IGNITION AND DRIVER’S DOOR OPEN CHIME INOPERATIVE.........122
*VEHICLE SPEED WARNING CHIME PROBLEM ............................124
COMMUNICATION
ATC MESSAGES NOT RECEIVED ........................................125
BATTERY POWER TO MODULE DISCONNECTED ..........................126
EATX BUS COMMUNICATION FAILURE ...................................127
EEPROM CHECKSUM FAILURE..........................................128
HEAD STATUS RX FAILURE.............................................129
INTERNAL BASE/PREM SELECT CIRCUIT .................................131
MHSMM MESSAGES NOT RECEIVED ....................................132
MIC MESSAGES NOT RECEIVED ........................................133
NO PCI MESSAGES FROM CD CHANGER.................................134
OTIS MESSAGES NOT RECEIVED .......................................136
POST FAILURE........................................................137
SBEC BUS COMMUNICATION FAILURE ...................................138
SKIM MESSAGES NOT RECEIVED .......................................140
*NO RESPONSE FROM ACM ............................................141
*NO RESPONSE FROM AUTOMATIC TEMPERATURE CONTROL MODULE .....143
*NO RESPONSE FROM BODY CONTROL MODULE .........................145
*NO RESPONSE FROM CONTROLLER ANTILOCK BRAKE ...................147
*NO RESPONSE FROM INSTRUMENT CLUSTER...........................150
*NO RESPONSE FROM LEFT SIACM .....................................152
*NO RESPONSE FROM MEMORY HEATED SEAT/MIRROR MODULE ..........155
*NO RESPONSE FROM OTIS/EVIC .......................................157
*NO RESPONSE FROM PCM (PCI BUS)...................................159
*NO RESPONSE FROM PCM (PCM SCI ONLY) .............................161
*NO RESPONSE FROM RADIO ..........................................164
*NO RESPONSE FROM RIGHT SIACM ....................................167
*NO RESPONSE FROM SENTRY KEY IMMOBILIZER MODULE ...............170
*NO RESPONSE FROM TRANSMISSION CONTROL MODULE ................172
*ODOMETER DISPLAYS NO BUS ........................................175
*PCI BUS COMMUNICATION FAILURE ....................................176
DOOR AJAR
*DRIVER DOOR AJAR CKT OPEN ........................................179
*DRIVER DOOR AJAR CKT STG .........................................180
*LEFT REAR DOOR AJAR CKT OPEN.....................................181
*LEFT REAR DOOR AJAR CKT STG ......................................182
*PASS DOOR AJAR CKT OPEN ..........................................183
*PASS DOOR AJAR CKT STG............................................184
*RIGHT REAR DOOR AJAR CKT OPEN ...................................185
*RIGHT REAR DOOR AJAR CKT STG .....................................186
iv

TABLE OF CONTENTS - Continued
ELECTRICALLY HEATED SYSTEMS
DRIVER HEATED SEAT SWITCH OPEN/SHORTED TO GROUND ..............187
DRIVER HEATED SEAT SWITCH STUCK IN HIGH STATE ....................189
DRIVER HEATED SEAT SWITCH STUCK IN LOW STATE.....................189
DRIVER SEAT HEAT OUTPUT OPEN......................................191
DRIVER SEAT HEAT OUTPUT SHORT TO GND.............................193
DRIVER THERMISTOR OUT OF RANGE HIGH .............................195
DRIVER THERMISTOR OUT OF RANGE LOW..............................197
PASSENGER HEATED SEAT SWITCH OPEN/SHORTED TO GROUND..........200
PASSENGER HEATED SEAT SWITCH STUCK IN HIGH STATE ................202
PASSENGER HEATED SEAT SWITCH STUCK IN LOW STATE ................202
PASSENGER SEAT HEAT OUTPUT OPEN .................................204
PASSENGER SEAT HEAT OUTPUT SHORT TO GND ........................207
PASSENGER THERMISTOR OUT OF RANGE HIGH .........................209
PASSENGER THERMISTOR OUT OF RANGE LOW..........................211
*HEATED SEATS INOPERATIVE DUE TO KEY-IN IGNITION SWITCH INPUT.....214
*REAR WINDOW DEFOGGER INOPERATIVE MANUAL AIR CONDITIONING.....216
*REAR WINDOW DEFOGGER INOPERATIVE WITH ATC .....................219
EXTERIOR LIGHTING
HEADLAMP SWITCH INPUT FAILURE.....................................222
*AUTO HEADLAMPS AND OR FOG LAMPS NOT OPERATING PROPERLY ......224
*FOG LAMPS WILL NOT TURN OFF ......................................227
*FOG LAMPS WILL NOT TURN ON .......................................228
*HEADLAMP TIME DELAY INOPERATIVE ..................................230
*HIGH BEAM HEADLAMPS WILL NOT TURN OFF...........................231
*HIGH BEAM HEADLAMPS WILL NOT TURN ON............................232
*LOW BEAM HEADLAMPS WILL NOT TURN OFF ...........................235
*LOW BEAM HEADLAMPS WILL NOT TURN ON ............................236
*PARK LAMPS WILL NOT TURN OFF .....................................238
*PARK LAMPS WILL NOT TURN ON ......................................239
HEATING & A/C
A/C CONTROL A/C SWITCH FAILURE (MANUAL A/C)........................242
A/C CONTROL BLEND DOOR INPUT OPEN OR SHORTED TO GROUND
(MANUAL A/C).........................................................244
A/C CONTROL BLEND DOOR INPUT SHORTED TO BATTERY (MANUAL A/C) . . .246
A/C CONTROL EBL SWITCH FAILURE (MANUAL A/C) .......................247
A/C CONTROL MODE DOOR INPUT OPEN OR SHORTED TO BATTERY
(MANUAL A/C).........................................................249
A/C CONTROL MODE DOOR INPUT SHORTED TO GROUND (MANUAL A/C). . . .251
ATC A/C SWITCH FAILURE..............................................252
ATC AUTO SWITCH FAILURE............................................253
ATC BILEVEL SWITCH FAILURE .........................................254
ATC DEFROST SWITCH FAILURE ........................................255
ATC EBL SWITCH FAILURE .............................................256
ATC FLOOR SWITCH FAILURE ..........................................257
ATC MIX SWITCH FAILURE .............................................258
ATC OFF SWITCH FAILURE .............................................259
ATC PANEL SWITCH FAILURE ...........................................260
ATC RECIRCULATION SWITCH FAILURE..................................261
ATC TEMPERATURE DOWN SWITCH FAILURE.............................262
ATC TEMPERATURE UP SWITCH FAILURE ................................263
v

TABLE OF CONTENTS - Continued
BLEND DOOR FEEDBACK FAILURE ......................................264
BLEND DOOR OUTPUT SHORTED TO BATTERY ...........................271
BLEND DOOR OUTPUT SHORTED TO GROUND ...........................274
BLEND DOOR STALL TEST FAILURE .....................................276
COMMON OUTPUT SHORTED TO BATTERY...............................283
COMMON OUTPUT SHORTED TO GROUND...............................286
EVAPORATOR TEMPERATURE SENSOR FAILURE..........................288
HEAD STATUS RX FAILURE.............................................291
IN CAR TEMP SENSOR FAILURE (ATC ASPIRATOR FAILURE)................292
MODE DOOR FEEDBACK FAILURE.......................................297
MODE DOOR OUTPUT SHORTED TO BATTERY............................304
MODE DOOR OUTPUT SHORTED TO GROUND............................307
MODE DOOR STALL TEST FAILURE......................................309
RECIRC DOOR OUTPUT SHORTED TO BATTERY ..........................316
RECIRC DOOR OUTPUT SHORTED TO GROUND ..........................319
RECIRCULATION DOOR TEST FAILURE (INOPERATIVE OR STALL) ...........320
SUN LOAD SENSOR FAILURE...........................................323
*ATC BLOWER MOTOR INOPERATIVE ....................................325
*ATC BLOWER MOTOR SPEEDS INCORRECT .............................328
*ATC HEAD ILLUMINATION INOPERATIVE.................................330
*ATC SYSTEM TEST ...................................................331
*ATC TEMPERATURE CONTROL INCORRECT IN SUN OR SHADE ............332
*BLEND DOOR INOPERATIVE ...........................................334
*MANUAL A/C BLOWER MOTOR INOPERATIVE ............................336
*MANUAL A/C BLOWER MOTOR SPEEDS INCORRECT......................339
*MANUAL A/C CONTROL HEAD ILLUMINATION.............................340
*MANUAL A/C CONTROL HEAD SWITCH INOPERATIVE .....................341
*MANUAL A/C SYSTEM TEST............................................342
*MODE DOOR INOPERATIVE............................................343
INSTRUMENT CLUSTER
BCM - DIMMING LEVEL SWITCH FAILURE.................................345
BCM - FUEL LEVEL SENDING UNIT FAILURE ..............................349
NO MESSAGES FROM ABS .............................................351
NO MESSAGES FROM AECM ...........................................351
NO MESSAGES FROM BCM.............................................351
NO MESSAGES FROM EATX ............................................351
NO MESSAGES FROM PCM.............................................351
*AIRBAG WARNING INDICATOR NOT OPERATING PROPERLY ...............353
*ALL GAUGES INOPERATIVE............................................354
*BRAKE WARNING INDICATOR INOPERATIVE .............................356
*CHARGING INDICATOR NOT OPERATING PROPERLY......................359
*CHECK ENGINE INDICATOR NOT OPERATING PROPERLY .................360
*CLUSTER AND PANEL ILLUMINATION PROBLEMS.........................361
*CRUISE ON INDICATOR NOT OPERATING PROPERLY .....................364
*DECKLID AJAR INDICATOR NOT OPERATING PROPERLY ..................365
*DOOR AJAR INDICATOR NOT OPERATING PROPERLY.....................367
*ENGINE COOLANT TEMPERATURE INDICATOR NOT OPERATING PROPERLY.368
*FUEL GAUGE NOT OPERATING PROPERLY ..............................369
*LOW FUEL INDICATOR NOT OPERATING PROPERLY ......................372
*LOW WASHER FLUID INDICATOR NOT OPERATING PROPERLY.............373
*ODOMETER NOT OPERATING PROPERLY ...............................375
*OIL PRESSURE WARNING INDICATOR NOT OPERATING PROPERLY.........376
vi

TABLE OF CONTENTS - Continued
*PRND3L INDICATOR MALFUNCTION.....................................379
*SEAT BELT INDICATOR NOT OPERATING PROPERLY......................380
*SPEEDOMETER GAUGE NOT OPERATING PROPERLY.....................383
*TACHOMETER NOT OPERATING PROPERLY .............................385
*TEMPERATURE GAUGE NOT OPERATING PROPERLY .....................387
INTERIOR LIGHTING
COURTESY LAMP OUTPUT SHORT TO BATTERY ..........................389
*COURT LMPS INOP ...................................................391
*COURTESY LAMPS INOPERATIVE FROM DRIVERS DOOR..................391
*COURTESY LAMPS INOPERATIVE - ALL LAMPS...........................392
*COURTESY LAMPS INOPERATIVE - DOOR LAMPS ........................393
*COURTESY LAMPS INOPERATIVE - OVERHEAD LAMPS....................394
*COURTESY LAMPS INOPERATIVE FROM DOME LAMP SWITCH ONLY .......395
*COURTESY LAMPS INOPERATIVE FROM LEFT REAR DOOR................396
*COURTESY LAMPS INOPERATIVE FROM PASSENGER DOOR ..............397
*COURTESY LAMPS INOPERATIVE FROM RIGHT REAR DOOR ..............398
*COURTESY LAMPS STAY ON AT ALL TIMES ..............................399
MEMORY SEAT
CHARGING VOLTAGE HIGH MESSAGE ...................................402
CHARGING VOLTAGE LOW MESSAGE....................................404
DRIVER MIRROR HORIZONTAL SENSOR OUT OF RANGE HIGH .............406
DRIVER MIRROR HORIZONTAL SENSOR OUT OF RANGE LOW..............407
DRIVER MIRROR VERTICAL SENSOR OUT OF RANGE HIGH ................409
DRIVER MIRROR VERTICAL SENSOR OUT OF RANGE LOW.................410
EEPROM REFRESH FAILURE ...........................................412
FRONT RISER DOWN POSITION STUCK..................................413
FRONT RISER SENSOR OUT OF RANGE HIGH ............................414
FRONT RISER SENSOR OUT OF RANGE LOW.............................416
FRONT RISER UP POSITION STUCK .....................................419
HORIZONTAL FORWARD POSITION STUCK ...............................420
HORIZONTAL REARWARD POSITION STUCK ..............................421
HORIZONTAL SENSOR OUT OF RANGE HIGH .............................422
HORIZONTAL SENSOR OUT OF RANGE LOW .............................424
IGNITION STATUS MESSAGE NOT RECEIVED .............................427
LOSS OF ENGINE RPM MESSAGE.......................................429
MEMORY POSITION #1 STUCK ..........................................430
MEMORY POSITION #2 STUCK ..........................................431
MEMORY SET 9S9POSITION STUCK .....................................432
PASSENGER MIRROR HORIZONTAL SENSOR OUT OF RANGE HIGH
(IF EQUIPPED) ........................................................433
PASSENGER MIRROR HORIZONTAL SENSOR OUT OF RANGE LOW
(IF EQUIPPED) ........................................................434
PASSENGER MIRROR VERTICAL SENSOR OUT OF RANGE HIGH
(IF EQUIPPED) ........................................................436
PASSENGER MIRROR VERTICAL SENSOR OUT OF RANGE LOW
(IF EQUIPPED) ........................................................437
PRNDL DISP MSG NOT RECEIVED.......................................439
REAR RISER DOWN POSITION STUCK ...................................441
REAR RISER SENSOR OUT OF RANGE HIGH .............................442
REAR RISER SENSOR OUT OF RANGE LOW..............................444
REAR RISER UP POSITION STUCK ......................................447
vii

TABLE OF CONTENTS - Continued
RECLINER DOWN POSITION STUCK .....................................448
RECLINER SENSOR OUT OF RANGE HIGH ...............................449
RECLINER SENSOR OUT OF RANGE LOW................................451
RECLINER UP POSITION STUCK ........................................454
*DRIVER MIRROR INOPERATIVE FROM MEMORY..........................455
*MEMORY SWITCH INOPERATIVE .......................................457
*PASSENGER MIRROR INOPERATIVE FROM MEMORY (IF EQUIPPED)........459
OVERHEAD CONSOLE
BUS MESSAGES MISSING ..............................................461
CMTC INTERNAL FAILURE..............................................462
EVIC INTERNAL FAILURE...............................................462
COMPASS TEST FAILURE ..............................................463
DEMAGNETIZE COMPASS ..............................................464
NO BCM MESSAGES RECEIVED.........................................465
NO PCM MESSAGES RECEIVED.........................................466
SET COMPASS VARIANCE AS PER SERVICE INFORMATION.................467
*DISPLAY SEGMENTS FAIL TO ILLUMINATE ...............................468
*DISTANCE TO EMPTY INOPERATIVE OR WRONG .........................468
*ELAPSED TIME INOPERATIVE OR WRONG...............................468
*MILEAGE AND DISTANCE FUNCTIONS...................................468
*EVIC INOPERATIVE ...................................................469
*EVIC SELF TEST .....................................................470
*OTIS SCREEN DISPLAYS FAIL..........................................471
*TEMPERATURE DISPLAY INOPERATIVE OR WRONG ......................472
POWER DOOR LOCKS/RKE
DECKLID RELEASE SOLENOID OUTPUT FAILURE .........................473
DECKLID RELEASE SWITCH FAILURE....................................476
DRIVER DOOR CENTRAL LOCK (ARM)/UNLOCK (DISARM) SWITCH FAILURE . .478
RKE FOB BATTERY LOW ...............................................480
RKE PROGRAM MODE ENTERED WITHOUT PROGRAM REQUEST...........481
RKE UNABLE TO ENTER PROGRAM MODE ...............................482
*ALL DOORS FAILING TO LOCK AND UNLOCK FROM ANY SWITCH...........483
*ALL DOORS FAILING TO LOCK AND UNLOCK FROM ONE SWITCH ..........489
*ALL DOORS FAILING TO LOCK FROM ANY SWITCH .......................492
*ALL DOORS FAILING TO LOCK FROM ONE SWITCH .......................494
*ALL DOORS FAILING TO UNLOCK FROM ANY SWITCH.....................495
*ALL DOORS FAILING TO UNLOCK FROM ONE SWITCH ....................497
*AUTOMATIC (ROLLING) DOOR LOCKS INOPERATIVE ......................498
*DECKLID RELEASE INOPERATIVE ......................................499
*DOOR LOCK INHIBIT INOPERATIVE .....................................501
*DRIVER DOOR FAILS TO LOCK FROM ANY SWITCH.......................503
*DRIVER DOOR FAILS TO UNLOCK FROM ANY SWITCH ....................504
*ONE DOOR FAILS TO LOCK AND UNLOCK FROM ANY SWITCH .............505
*REMOTE KEYLESS ENTRY PROBLEM ...................................507
*RKE HORN CHIRP INOPERATIVE .......................................509
SPEED PRO STEERING
SPEED PRO STEERING CKT SHORT TO VOLTAGE.........................510
SPEED PRO STEERING SOLENOID CKT OPEN/SHORTED TO GROUND.......512
SPEED PRO STEERING SOLENOID OVER-TEMPERATURE ..................515
viii