Clarion PH-2416N User manual

-1- PH-2416N
Published by Service Dept.
Printed in Japan
Clarion Co., Ltd.
50Kamitoda,Toda-shi,Saitama335-8511Japan
ServiceDept.: 5-66Azuma,Kitamoto-shi,Saitama364-0007Japan
Tel:[phone] FAX: [phone]
298-6117-00 Oct.2003 P
Service Manual
Model
HONDA Automobile Genuine
AM/FM Radio CD Stereo
PH-2416N
(Genuine No. 39100-S3Y-A100)
(ID No. 4XQ0)
SPECIFICATIONS
Radio setion
Receive range: FM 87.75MHz,
87.9MHz to 107.9MHz
AM 530kHz to 1,710kHz
Intermediate frequency: FM 10.7MHz+0.2/-0.2MHz
AM 450kHz+3/-3kHz
Quieting sensitivity: FM Less than 12dBu
(at 30dB S/N)
AM Less than 35dBu
(at 20dB S/N)
S/N ratio: FM More than 45dB
AM More than 40dB
Auto tuning stop sensitivity:
FM 24dBu+6/-6dBu
AM 35dBu+6/-6dBu
CD section
Usable disc: Compact disc
S/N ratio: More than 60dB
Separation: More than 55dB
General
Load impedance: 4ohm x 4
Output power: More than 30W x 4
Power supply voltage: DC13.2V(10.8V to 15.6V)
Negative ground
Current consumption: Less than 1.5A
Dimensions(mm): 187.5(W)x60(H)x171(D)
Weight: 1.65kg
* Specification and design are subject to change without
notice for further improvement.
NOTE
* We cannot supply PWB with component parts in principle.
When a circuit on PWB has failure, please repair it by com-
ponent parts base. Parts which are not mentioned in ser-
vice manual are not supplied.
* Prevent damage caused by static electricity when repair-
ing the pick-up.
The pattern of the pick-up is short-circuiting for prevention.
Remove the soldering with a solder iron whose insulation
resistance is larger than 10Mohm(DC500V) after complete
connection to the main PWB
For repair table shall use copper or conductive sheet (with
impedance is lower to 100Mohm from 1Mohm)such as a
sheet.
Be sure to put on a wrist-strap for prevent electric
static's.(with impedance is to 100Mohm from 1Mohm) The
strap works to drain away the static electricity build-up on
the human body.
And as static electricity build-up on clothes is not drained
away, be careful and not your clothes to touch the pick-up.
Position of short soldering for pick-up protection position is
different by model.
Some units have two short soldering points.
Always short LD circuit to open the short circuit and re-
moves by soldering iron.
COMPONENTS
PH-2416N-A
1. Main unit ----------- 1
2. Identification card 287-1681-05 1
(Anti-Theft Radio)
3. Label 290-7868-03 1
(Serial No./Anti-Theft)

-2-PH-2416N
ANTI-THEFT SYSTEM
* This unit has a built-in Computer Anti-Theft System(CATS)
which makes the radio inoperative if power to the unit is
interrupted for any reason whatsoever(including disconnec-
tion and reconnection of the car battery). The radio will re-
main inoperative unless you enter the correct CATS num-
ber.
* When the unit is switched on after being disconnected from
the battery,"CODE" will be displayed.
Enter the code using the presets buttons.Even if "CODE"
is still displayed after you enter the code No.,input the code
again.
CAUTIONS
Use of controls,adjustment,or performance of procedures
other than those specified herein,may result in hazardous
radiation exposure.
The compact disc player should not be adjusted or repaired
by anyone except properly qualified service personnel.
bonding, gaps to PWB, etc, is involved. The wiring connec-
tion and routing to the PWB are specially planned using
clamps to keep away from heated and high voltage parts.
Ensure that they are placed back in their original positions
after repair or inspection.
If extended damage is caused due to negligence during
repair, the legal responsibility shall be with the repairing
company.
3. Check for safety after repair.
Check that the screws, parts and wires are put back se-
curely in their original position after repair. Ensure for safety
reasonsthere is no possibility of secondaryploblems around
the repaired spots.
If extended damage is caused due to negligence of repair,
the legal responsibility shall be with the repairing company.
4. Caution in removal and making wiring connection to the
parts for the automobile.
Disconnect the battery terminal after turning the ignition
key off. If wrong wiring connections are made with the bat-
tery connected, a short circuit and/or fire may occur. If ex-
tensive damage is caused due to negligence of repair, the
legal responsibility shall be with the repairing company.
5. Cautions regarding chips.
Do not reuse removed chips even when no abnormality is
observed in their appearance. Always replace them with
new ones. (The chip parts include resistors, capacitors,
diodes, transistors, etc). The negative pole of tantalum
capacitors is highly susceptible to heat, so use special care
when replacing them and check the operation afterwards.
6. Cautions in handling flexible PWB
Before working with a soldering iron, make sure that the
iron tip temperature is around 270 . Take care not to ap-
ply the iron tip repeatedly(more than three times)to the
same patterns. Also take care not to apply the tip with force.
7. Turn the unit OFF during disassembly and parts replace-
ment. Recheck all work before you apply power to the unit.
8. Cautions in checking that the optical pickup lights up.
The laser is focused on the disc reflection surface through
the lens of the optical pickup. When checking that the la-
ser optical diode lights up, keep your eyes more than 30cms
away from the lens. Prolonged viewing of the laser within
30cms may damage your eyesight.
9. Cautions in handling the optical pickup
The laser diode of the optical pickup can be damaged by
electrostatic charge caused by your clothes and body. Make
sure to avoid electrostatic charges on your clothes or body,
or discharge static electricity before handling the optical
pickup.
9-1. Laser diode
The laser diode terminals are shorted for transporta-
tion in order to prevent electrostatic damage.
After replacement, open the shorted circuit. When
removing the pickup from the mechanism, short the
terminals by soldering them to prevent this damage.
9-2. Actuator
The actuator has a powerful magnetic circuit. If a
magnetic material is put close to it. Its characteris-
tics will change. Ensure that no foreign substances
enter through the ventilation slots in the cover.
9-3. Cleaning the lens
Dust on the optical lens affects performance. To
clean the lens, apply a small amount of isopropyl
alcohol to lens paper and wipe the lens gently.
To engineers in charge of repair or
inspection of our products.
Before repair or inspection, make sure to follow the
instructions so that customers and Engineers in
charge of repair or inspection can avoid suffering
any risk or injury.
1. Use specified parts.
The system uses parts with special safety features against
fire and voltage. Use only parts with equivalent character-
istics when replacing them.
The use of unspecified parts shall be regarded as remod-
eling for which we shall not be liable. The onus of product
liability (PL) shall not be our responsibility in cases where
an accident or failure is as a result of unspecified parts
being used.
2. Place the parts and wiring back in their original positions
after replacement or re-wiring.
For proper circuit construction, use of insulation tubes,
F R E Q U E N C Y R A N G E
T H I S D E V I C E C O MP L I E S WI T H P A R T 1 5 O F T H E F C C
R U L E S . O P E R A T I O N I S S U B J E C T T O T H E F O L L O WI N G
T WO C O N D I T O I N S : ( 1 ) T H I S D E V I C E M A Y N O T C A U S E
H A R M F U L I N T E R F E R E N C E , A N D ( 2 ) T H I S D E V I C E M U S T
A C C E P T A N Y I N T E R F E R E N C E R E C E I V E D , I N C L U D I N G
I N T E R F E R E N C E T H A T M A Y C A U S E U N D E S I R E D
O P E R A T I O N .
P A R T N o .
P / N
1 2 V N E G . G N D
S E R I A L N O .
5 0 K A M I T O D A , T O D A S H I , S A I T A M A K E N , J A P A N
C l a r i o n C o . , L t d
T H I S P R O D U C T I O N C O M P L I E S WI T H D H H S R U L E S
2 1 C F R S U B C H A P T E R J A P P L I C A B L E A T D A T E O F
M A N U F A C T U R E .
M A N U F A C T U R E D
(Setplate)
(Top view of the unit)

-3- PH-2416N
Clock accuracy 1. Turn on the ACC switch,and push the POWER button.
2. Set a universal timer to TP101(T-BASE), and adjust TC102 so that a reading of
the meter is 0 to 1.0 sec./day.
Universal timer
Item Procedure Measuring instrument
ADJUSTMENT
BLOCK DIAGRAM
BL101
Tuner
Regulator Block
CD Mechanism
IC201
Electrical
Volume
IC401
Radio/CD
System Control
IC102
PLL IC
J901(14P)
H-BUS
IC402
E2PROM
IC206,207
FIX EQ
IC204,208
Buffer
IC301,302
Buffer IC701
LCD Driver
IC306,307
Converter
LCD1
Indicator(LCD)
Key
Matrix
IC205
Power IC SP OUT
ANT
BATT.

-4-PH-2416N
EXPLANATION OF IC
052-3154-15 M30622MAA-F54GP Radio CD system controller
1.Terminal Description
pin 1: REM +5V : O : REM5V Power supply ON signal output.
pin 2: CD +8V : O : Power supply ON signal output for the
Loading motor and the Photo sensors.
pin 3: CD +5V : O : Power supply control signal output for the
CD DSP. "H"= ON.
pin 4: NU : - : Not in use.
pin 5: TIME BASE :IN: Time base signal input.
pin 6: BYTE :IN: Input "L" .
pin 7: CN VSS :IN: Input "L" .
pin 8: NU : - : Not in use.
pin 9: NU : - : Not in use.
pin 10: RESET_ :IN: Reset signal input. Negative logic.
pin 11: X OUT : O : Crystal connection.
pin 12: VSS : - : Negative supply voltage.
pin 13: X IN :IN: Crystal connection. Ceramic resonator con-
nection.
pin 14: VCC : - : Positive supply voltage.
pin 15: NU : - : Not in use.
pin 16: SBSY_ :IN: Sub Q data input from CD.
pin 17: ACC DET_ :IN: ACC detection terminal. "L"= ACC ON.
pin 18: B/U DET_ :IN: Backup voltage ON signal input. "L"=
Backup ON.
pin 19: H bus In/Rx int :IN: H bus data input, and IE-bus start bit de-
tection signal input.
pin 20: NAVI INT L_ : O : Front Left Navi audio signal ON. Negative
logic.
pin 21: NAVI INT R_ : O : Front Right Navi audio signal ON. Negative
logic.
pin 22: MUTE F/L : O : Audio mute signal output to "Front Left".
pin 23: MUTE F/R : O : Audio mute signal output to "Front Right".
pin 24: MUTE REAR : O : Audio mute signal output to "Rear".
pin 25: MUTE AMP : O : Amplifier Mute signal output.
pin 26: BEEP : O : Beep out(3.0kHz).
pin 27: RX_ :IN: GA-NET RX terminal.
pin 28: HB O/GA TX : O : H bus data output, and GA-NET TX.
pin 29: F-ROM/T TXD : O : With testing box, TX terminal.
pin 30: F-ROM/T RXD :IN: With testing box, RX terminal.
pin 31: F-ROM K/T Req :IN: With testing box, REQ input.
pin 32: F-ROM BUSY : O : Fixed to the low level in the normal condi-
tion.
pin 33: E VOL DO : O : Serial data output to the volume IC.
pin 34: NAVI MUTE_ :IN: NAVI mute signal input. Negative logic.
pin 35: E VOL CLK : O : Clock pulse output to the E VOL IC.
pin 36: E VOL CE : O : Chip enable signal output to the E VOL IC.
pin 37: SYS ACC ON : O : System ACC ON signal output.
pin 38: Power IC Diag :IN: Power IC diagnosis signal input.
pin 39: F ROM EPM_ : O : Fixed to the low level in the normal condi-
tion.
pin 40: TEST :IN: Test key signal input.
pin 41: EJECT :IN: Eject key input. Negative logic.
pin 42: POWER :IN: "L"= power ON.
pin 43: NU : - : Not in use.
pin 44: F ROM CE_ : O : Fixed to the low level in the normal condi-
tion.
pin 45: EEPROM DI :IN: Serial data input from the EEPROM.
pin 46: EEPROM DO : O : Serial data output to the EEPROM.
pin 47: EEPROM CLK : O : Serial clock output to EEPROM.
pin 48: EEPROM CE : O : Chip enable signal output to the EEPROM.
pin 49: NU : - : Not in use.
pin 50: FM SD :IN: FM station detect signal input.
pin 51: AM SD :IN: AM station detect signal input.
pin 52: FM STEREO_ :IN: FM STEREO ON signal input. Negative
logic.
pin 53: PLL DI :IN: PLL serial data input.
pin 54: PLL DO : O : PLL serial data output.
pin 55: PLL CLK : O : PLL clock pulse output
pin 56: PLL CE : O : Chip enable signal output to PLL.
pin 57: AREA 1 :IN: Destination setting input. Ref. Table 1.
pin 58: AREA 2 :IN: Destination setting input. Ref. Table 1.
pin 59: Clock ON_/OFF :IN: Clock ON_/OFF initial setting input.
pin 60: VCC : - : Positive supply voltage.
pin 61: NU : - : Not in use.
pin 62: VSS : - : Negative supply voltage.
pin 63: 12_ / 24 :IN: "H"= 24 hour mode.
pin 64: NU : - : Not in use.
pin 65: X MODE :IN: "L"= X MODE ON.
pin 66: SW+B_/Rd ON :IN: Radio on port control input. "H"= with Ra-
dio mode, "L"= with Power mode.
pin 67: CD_/AUX : O : The converter input select signal output.
pin 68: RADIO ON : O : Radio ON signal output.
pin 69: CATS KEY_ :IN: Special signal input.
pin 70: Disc ind : O : Disc indicator ON signal output.
pin 71: CATS ind : O : CATS indicator ON signal output.
pin 72: BUC 0 :I/O:CD IC Data input / output.
pin 73: BUC 1 :I/O:CD IC Data input / output.
pin 74: BUC 2 :I/O:CD IC Data input / output.
pin 75: BUC 3 :I/O:CD IC Data input / output.
pin 76: BUC CLOCK : O : CD IC clock pulse output.
pin 77: CCE : O : Chip enable signal output to CD IC.
pin 78: CD RESET : O : Reset signal output to CD mechanism con-
troller. Negative logic.
pin 79: CHUCK :IN: Chucking switch signal input.
pin 80: TR A :IN:Photo sensor signal input from the CD
mechanism.
pin 81: TR B :IN:Photo sensor signal input from the CD
mechanism.
pin 82: TR C :IN:Photo sensor signal input from the CD
mechanism.
pin 83: CW : O : Loading motor control output.
Ref. Table 2.
pin 84: CCW : O : Loading motor control output.
Ref. Table 2.
pin 85: Main Volume A :IN: Main volume control pulse input.
pin 86: Main Volume B :IN: Main volume control pulse input.
pin 87: Sub Volume A :IN: Sub volume control pulse input.
pin 88: Sub Volume B :IN: Sub volume control pulse input.
pin 89: LCD DI_ :IN: LCD driving data input.
pin 90: LCD DO : O : Serial data output to the LCD driver.
pin 91: LCD CLK : O : Serial data clock output to LCD driver.
pin 92: LCD CE : O : Chip enable signal output to the LCD driv-
er.
pin 93: S METER :IN: Input terminal of Internal A/D converter to
detect the Voltage of FM S meter.
pin 94: A VSS : - : Analog ground.
pin 95: REMOCON :IN: Steering wheel remote control switch sig-
nal input.
pin 96: Vref :IN: Reference voltage terminal for the bulit-in
A/D converter.
pin 97: A VCC : - : Positive supply voltage for the internal an-
alog section.
pin 98: Back light ON : O : Back light On signal output.
pin 99: NU : - : Not in use.
pin100: AUDIO ON : O : "H"= Audio power supply ON.
Table 1. Destination setting input Area1(pin57) Area2(pin58)
U.S.A. H-BUS L L
EXP H-BUS H L
Table 2. Loading motor control output
Loading Eject Brake Stop
CW ( pin 83 ) H L H L
CCW ( pin 84 ) L H H L

-5- PH-2416N
EXPLODED VIEW・PARTS LIST
Escutcheon section
1 940-7949-22 ESCUTCHEON ASSY 1
1-1 716-0872-00 PAD SCREW(M1.7x5) 2
2 331-3029-00 LCD COVER 1
3 379-1250-30 INDICATOR(LCD) 1
4 335-6413-00 COLOR FILTER 1
5 335-6515-10 LCD ILLUMI 1
6 335-6441-00 ILLUMI HOLDER 1
7 ----------- SWITCH PWB 1
8 016-0014-05 VR-W-SHAFT 2
9 017-0433-87 PILOT LAMP(14V40mA) 7
10 017-0429-21 PILOT LAMP(8V105mA) 2
11 013-6201-50 PUSH SWITCH 13
12 074-1151-20 OUTLET SOCKET (20P) 1
13 001-0518-96 LED 1
NO. PART NO. DESCRIPTION Q'TY
NO. PART NO. DESCRIPTION Q'TY
14 340-4323-00 SPACER 1
15 001-0412-17 DIODE 1
16 380-5522-22 KNOB 2
17 373-0963-22 DIAL COVER 1
18 335-6650-00 FILTER 1
19 346-0124-10 LEATHER SHEET 1
20 331-3030-00 SHIELD PLATE 1
21 335-6567-00 DISC GUIDE 1
22 335-6566-00 DISC INDICATOR 1
23 347-6410-00 DOUBLE FACE(50m) 1
24 345-8188-20 ESCUTCHEON RUBBER 1
25 716-0872-11 PAD SCREW(M1.7x6) 4
26 716-1889-00 SCREW(M2.6x5) 2
(x13)

-6-PH-2416N
1 ----------- MAIN PWB 1
2 305-0293-20 SIDE PLATE L 1
3 305-0294-20 SIDE PLATE R 1
4 331-3034-00 ES PLATE 1
5 929-0097-80 CD MECHA MODULE 1
6 331-2874-20 MECHA BRACKET 1
7 816-2488-01 FLAT WIRE 1
8 311-1799-21 LOWER CASE 1
9 310-1703-20 UPPER CASE 1
10 286-9412-28 SETPLATE 1
11 716-0878-00 IT SCREW(M2.6x5) 2
12 714-2303-81 MACHINE SCREW (M2.3x3) 5
13 714-2606-81 MACHINE SCREW (M2.6x6) 6
14 345-4138-00 RUBBER PARTS 1
15 347-2022-02 PAPER PARTS 1
16 714-2606-11 MACHINE SCREW(M2.6x6) 5
17 073-0762-90 TERMINAL 2
18 076-0540-20 PLAG (20P) 1
19 074-1186-26 OUTLET SOCKET (26P) 1
20 103-2012-00 TRANSISTOR 2
21 074-1166-00 OUTLET SOCKET 1
22 009-0666-0L CHOKE 1
23 051-2023-01 IC(TA8260AH) 1
24 880-1920E TUNER PACK(AM/FM) 1
25 307-0658-20 REAR PLATE L 1
26 307-0659-20 REAR PLATE R 1
27 092-0702-00 ANT RECEPT 1
28 313-1824-00 HEAT SINK 1
29 716-1494-00 IT SCREW (M2.6x6) 2
30 714-2612-81 MACHINE SCREW (M2.6x12) 2
31 714-2606-81 MACHINE SCREW (M2.6x6) 2
NO. PART NO. DESCRIPTION Q'TY
NO. PART NO. DESCRIPTION Q'TY
Main section

-7- PH-2416N
NO. PART NO. DESCRIPTION Q'TY
1 SMA-151-100 MOTOR ASSY(SPINDLE) 1
2 750-3098-00 L-LINK SPRING 1
3 716-1468-00 SCREW(M2x2.5) 3
4 714-2003-81 SCREW(M2x3) 10
5 SMA-146-100 MOTOR ASSY(SLED) 1
6 969-0008-12 PICK UP UNIT 1
7 HBS-432-100 LS-GEAR ASSY 1
8 966-0447-07 DR-PLATE-ASSY 1
9 966-0449-04 CLAMP-LINK-ASSY 1
10 621-0205-02 CLAMPER RING 1
11 621-0251-24 LOCK LINK 1
12 620-0198-03 CLAMPER PLATE 1
13 966-0314-01 STOP LINK-ASSY 1
14 966-0448-01 SIDE PLATE-ASSY 1
15 621-0252-03 DISC STOPPER 1
16 620-0491-03 SPRING PLATE 1
17 966-0454-00 SCREW H-RACK-ASSY 1
18 621-0358-02 LS-HOLDER-F 1
19 013-7100-00 SWITCH(LIMIT) 1
20 621-0357-03 PICK UP GUIDE 1
21 621-0253-02 MOTOR HOLDER 1
22 621-0255-02 SECOND GEAR 1
23 622-1073-02 CLAMPER ROLLER 1
24 621-0359-02 LS-HOLDER-R 1
25 621-0375-00 SH-BASE 1
26 716-0675-00 SCREW(M2x5.5) 2
27 716-1555-00 WAVE SCREW(M2x8) 1
28 732-2004-11 SEMS SCREW(M2x4) 2
29 739-1735-17 PRECISION SCREW 2
(M1.7x3.5)
30 620-0690-01 RATTLE PLATE 1
31 746-0761-00 WASHER 2
32 716-1733-00 SCREW(M1.7x2.3) 2
33 750-3099-00 ES-SPRING 1
34 750-3097-03 CLAMPER SPRING 1
35 816-2373-00 LEAD WIRE(WHT) 1
36 816-2372-00 LEAD WIRE(BLU) 1
37 ----------- CD PWB 1
38 001-0563-00 LED 3
39 716-1670-00 SCREW(M2x4) 2
40 620-0803-00 CE-SP PLATE 1
41 750-3096-01 DR-SPRING R 1
42 750-3164-00 DR-SPRING LR 1
43 750-3188-00 DR-SPRING F-B 1
44 750-3201-00 DR-SPRING F-R 1
45 039-1768-00 FPC 1
CD mechanism section
(Drive unit)

-8-PH-2416N
CD mechanism section
(Main chassis)

-9- PH-2416N
NO. PART NO. DESCRIPTION Q'TY
NO. PART NO. DESCRIPTION Q'TY
1 966-0309-05 L-DISC-G-ASSY 1
2 966-0310-06 SHIFT-P-CH-ASSY 1
3 HBS-430-100 GEAR PLATE ASSY 1
4 966-0312-06 SHIFT-PLATE-ASSY 1
5 966-0358-01 DRIVE-L-PLATE-ASSY 1
6 966-0359-03 SIDE-L-PLATE-ASSY 1
7 SMA-147-100 MOTOR ASSY(LOADING) 1
8 013-3879-01 CHUCKING SWITCH 1
9 804-4910-60 VINYL-COAT-WIRE(YEL) 1
10 ----------- CHUCKING SWITCH PWB 1
11 ----------- SENSOR PWB 1
12 060-0252-01 PHOTO-TR 3
13 345-7513-01 CLAMPER SHEET 1
14 345-7514-00 SENSOR PWB SHEET 1
15 802-4910-60 VINYL-COAT-WIRE(RED) 1
16 620-0485-04 FRONT PLATE 1
17 620-0488-01 S-L-LINK PLATE 1
18 620-0489-02 MOTOR PLATE 1
19 802-4904-60 VINYL-COAT-WIRE(RED) 1
20 620-0492-01 MOTOR BRACKET 1
21 801-4910-60 VINYL-COAT-WIRE(BRN) 1
22 620-0773-01 CD-MECH-BRKT 1
23 800-4910-60 VINYL-COAT-WIRE(BLK) 1
24 621-0402-02 U-DISC GUIDE-F 1
25 621-0243-02 ROLLER SLEEVE 2
26 800-4904-60 VINYL-COAT-WIRE(BLK) 1
27 750-3189-00 SIDE-L-SPRING 1
28 750-3098-00 L-LINK SPRING 1
29 750-3094-00 S-ARM SPRING 1
30 621-0248-08 RACK GEAR 1
31 621-0249-02 ROLLER GEAR 1
32 629-0074-00 DAMPER 4
33 750-3092-03 SHIFT SPRING 1
34 750-3091-03 LOADING-SPRING-R 1
35 750-3090-02 LOADING-SPRING-L 1
36 746-0877-02 WASHER 2
37 746-0762-00 WASHER 1
38 746-0712-23 WASHER 1
39 743-1500-10 E-RING 3
40 621-0258-03 LOADING ROLLER 2
41 716-1742-00 SCREW(M2x5) 1
42 716-1704-00 SCREW(M2x7) 1
43 716-1677-00 SCREW(M2x5) 1
44 716-1507-00 SCREW(M2x3) 2
45 622-1072-05 ROLLER SHAFT 1
46 716-1468-00 SCREW(M2x2.5) 2
47 622-1219-01 SHIFT ROLLER 1
48 714-2603-81 SCREW(M2.6x3) 5
49 966-0308-11 CHASSIS ASSY 1
50 714-2003-81 SCREW(M2x3) 9
51 716-1670-00 SCREW(M2x4) 4
52 620-0804-00 CE-SP PLATE F 1
53 750-3348-00 CENTER SPRING 1

-10-PH-2416N
ELECTRICAL PARTS LIST
Main PWB section(B1)
REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION
ANT101 092-0702-00 ANT RECEPT
BL101 880-1920E TUNER PACK
C101 119-0000-05 1/10W 0 ohm JW
C102 166-1801-50 18pF CH
C103 166-1007-50 10pF CH
C104 168-2232-55 0.022uF
C105 168-4735-56 0.047uF
C106 188-1073-27 10V 100uF
C107 166-1801-50 18pF CH
C109 188-1073-27 10V 100uF
C111 188-1073-27 10V 100uF
C112 042-1458-50 50V 1uF LN
C113 168-1045-56 0.1uF
C114 166-1011-50 100pF CH
C115 166-1011-50 100pF CH
C116 168-2222-55 2200pF
C117 166-1011-50 100pF CH
C118 166-1011-50 100pF CH
C119 166-2201-50 22pF CH
C120 168-3322-55 3300pF
C121 188-1063-37 16V10uF
C124 168-1022-55 1000pF
C125 188-4763-37 16V 47uF
C126 168-4735-56 0.047uF
C127 188-1543-67 50V0.15uF
C128 168-8222-55 8200pF
C129 168-2722-55 2700pF
C130 188-1543-67 50V0.15uF
C131 168-4735-56 0.047uF
C132 168-8222-55 8200pF
C133 168-2722-55 2700pF
C134 168-2232-55 0.022uF
C135 168-2232-55 0.022uF
C137 188-1056-67 50V1uF NP
C138 168-1232-55 0.012uF
C139 168-2232-55 0.022uF
C140 168-2232-55 0.022uF
C141 166-1007-50 10pF CH
C142 166-1007-50 10pF CH
C143 168-2232-55 0.022uF
C203 188-4763-37 16V 47uF
C204 188-1053-67 50V 1uF
C205 188-1053-67 50V 1uF
C208 178-2242-78 0.22uF
C209 178-2242-78 0.22uF
C210 188-1063-37 16V10uF
C211 188-1063-37 16V10uF
C212 188-1063-37 16V10uF
C213 188-1063-37 16V10uF
C214 043-0309-90 10V 1uF
C215 043-0309-90 10V 1uF
C216 168-6835-56 0.068uF
C217 168-6835-56 0.068uF
C218 168-1032-55 0.01uF
C219 168-1032-55 0.01uF
C220 168-4712-55 470pF
C221 168-4712-55 470pF
C222 188-1063-37 16V10uF
C223 188-1063-37 16V10uF
C224 168-3335-56 0.033uF
C225 166-1011-50 100pF CH
C226 166-1011-50 100pF CH
C227 188-2253-67 50V2.2uF
C228 188-2253-67 50V2.2uF
C229 188-2263-37 16V22uF
C230 188-2263-37 16V22uF
C238 168-5612-55 560pF
C241 188-1063-37 16V10uF
C243 168-4735-56 0.047uF
C244 178-8232-78 0.082uF
C245 178-8232-78 0.082uF
C248 178-8232-78 0.082uF
C249 178-1842-78 0.18uF
C252 178-8232-78 0.082uF
C253 178-1842-78 0.18uF
C254 178-1532-78 0.015uF
C255 178-3922-78 3900pF
C256 178-4722-78 4700pF
C257 178-1232-78 0.012uF
C258 178-1532-78 0.015uF
C259 178-3922-78 3900pF
C260 178-4722-78 4700pF
C261 178-1232-78 0.012uF
C262 178-2232-78 0.022uF
C263 178-6822-78 6800pF
C266 178-2232-78 0.022uF
C267 178-6822-78 6800pF
C270 178-3342-78 0.33uF
C271 178-3342-78 0.33uF
C272 188-2256-57 35V2.2uF NP
C273 188-2256-57 35V2.2uF NP
C274 188-2256-57 35V2.2uF NP
C275 188-2256-57 35V2.2uF NP
C276 188-1073-27 10V 100uF
C279 188-1073-27 10V 100uF
C282 168-1022-55 1000pF
C283 168-1022-55 1000pF
C284 168-1022-55 1000pF
C285 168-1022-55 1000pF
C286 042-1466-00 16V4700uF
C287 188-2263-37 16V22uF
C288 166-1011-50 100pF CH
C290 166-1011-50 100pF CH
C292 168-1545-56 0.15uF
C293 168-1545-56 0.15uF
C294 168-1545-56 0.15uF
C295 168-1545-56 0.15uF
C296 172-1041-15 0.1uF
C298 188-2253-67 50V2.2uF
C299 188-2253-67 50V2.2uF
C301 188-4763-37 16V 47uF
C302 168-2212-55 220pF
C303 168-2212-55 220pF
C304 188-2263-37 16V22uF
C305 188-2263-37 16V22uF
C308 188-1063-37 16V10uF
C309 188-1063-37 16V10uF
C312 168-8232-78 0.082uF
C313 168-8232-78 0.082uF
C314 168-1822-55 1800pF
C315 168-1822-55 1800pF
C316 168-1222-55 1200pF
C319 168-1222-55 1200pF
C320 188-2253-67 50V2.2uF
C321 188-2253-67 50V2.2uF
C330 168-2222-55 2200pF
C331 168-2222-55 2200pF
C332 188-2253-67 50V2.2uF
C333 188-2253-67 50V2.2uF
C334 188-2253-67 50V2.2uF
C335 188-2253-67 50V2.2uF
C336 188-2253-67 50V2.2uF
C337 188-2253-67 50V2.2uF
C338 188-2253-67 50V2.2uF
C339 188-2253-67 50V2.2uF
C340 188-1073-27 10V 100uF
C341 188-3363-27 10V33uF
C342 188-3363-27 10V33uF
C343 188-1073-27 10V 100uF
C344 188-2253-67 50V2.2uF
C345 188-2253-67 50V2.2uF
C346 188-2253-67 50V2.2uF
C347 188-2253-67 50V2.2uF
C348 188-2253-67 50V2.2uF
C349 188-2253-67 50V2.2uF
C350 178-2242-78 0.22uF
C351 178-2242-78 0.22uF
C352 166-1011-50 100pF CH
C353 166-1011-50 100pF CH
C354 188-1063-37 16V10uF
C355 188-1063-37 16V10uF
C358 166-1011-50 100pF CH
C359 166-1011-50 100pF CH
C401 168-1045-56 0.1uF
C403 166-1501-50 15pF CH
C404 166-1801-50 18pF CH
C405 168-1045-56 0.1uF
C406 168-1045-56 0.1uF
C407 168-4735-56 0.047uF
C408 168-1045-56 0.1uF
C412 168-3312-55 330pF
C416 188-6853-47 25V6.8uF
C501 188-2263-37 16V22uF
C502 188-2263-37 16V22uF
C503 168-1022-55 1000pF
C508 188-1063-37 16V10uF
C509 168-1022-55 1000pF
C510 188-1063-37 16V10uF
C512 168-1032-55 0.01uF
C513 168-1022-55 1000pF
C516 188-2253-67 50V2.2uF
C517 178-2242-78 0.22uF
C518 178-2242-78 0.22uF
C519 178-2242-78 0.22uF
C520 189-4773-12 6.3V470uF
C521 188-1063-37 16V10uF
C522 042-1452-81 10V220uF
C523 188-4763-37 16V 47uF
C527 172-1041-15 0.1uF
C528 188-1063-37 16V10uF
C529 189-4773-12 6.3V470uF
C530 188-3353-61 50V3.3uF
C531 172-1041-15 0.1uF
C532 172-1041-15 0.1uF
C533 188-1063-37 16V10uF
D404 001-0516-90 MA111
D503 001-0529-55 MA8120-L
D505 001-0529-42 MA8075-H
D506 001-0529-33 MA8056-H
D507 001-0529-45 MA8082-H
D508 001-0529-43 MA8082-L
D509 001-0330-00 1SS119
D510 001-0516-90 MA111
D511 001-0516-90 MA111
D512 001-0516-90 MA111
D513 001-0535-90 MA729
D514 001-0529-47 MA8091-M
D515 001-0503-34 HZS6 C1L
D516 001-0516-90 MA111
D517 001-0592-00 RM4Z
D518 001-0466-90 S5688B
D519 001-0466-90 S5688B
D521 001-0466-90 S5688B
D522 001-0516-90 MA111
D523 001-0503-42 HZS7C3L
D524 001-0516-90 MA111
IC102 051-6201-90 LC72146M
IC201 051-5012-10 LC75386NE-L
IC204 051-1080-91 NJM4560M
IC205 051-2023-01 TA8260AH
IC206 051-5827-90 M5243AFP09-600D
IC207 051-5827-90 M5243AFP09-600D
IC208 051-1080-91 NJM4560M
IC301 051-3013-90 M5203AFP
IC302 051-3013-90 M5203AFP
IC306 051-0722-90 SA571D
IC307 051-0722-90 SA571D
IC401 052-3154-15 M30622MAA-F54GP
IC402 051-9400-18 AT93C46-10SI
IC501 051-1822-09 S-80832CNUA-B8R
J301 074-1186-26 26P
J302 076-0540-20 20P
J901 074-1166-00 34P
L101 010-2003-04 COIL
L102 010-6009-88 220uH
L701 010-6009-64 2.2uH
Q101 190-1298-00 2SA1298
Q102 190-1298-00 2SA1298
Q103 125-2004-92 RN1402
Q210 192-2712-00 2SC2712
Q211 192-2712-00 2SC2712
Q301 192-2712-00 2SC2712
Q302 192-2712-00 2SC2712
Q304 125-2004-93 RN1403
Q305 192-2712-00 2SC2712
Q306 192-2712-00 2SC2712
Q402 190-1162-00 2SA1162
Q403 125-2004-92 RN1402
Q404 192-2712-00 2SC2712
Q406 125-2004-92 RN1402

-11- PH-2416N
REF No. PART No. DESCRIPTION
Q501 125-0002-93 RN2403
Q502 193-1858-00 2SD1858
Q503 193-1858-00 2SD1858
Q504 193-1858-00 2SD1858
Q505 125-0002-92 RN2402
Q506 125-2004-92 RN1402
Q507 125-0013-96 RN2426
Q508 193-1858-00 2SD1858
Q509 103-2012-00 2SD2012
Q511 125-0002-92 RN2402
Q512 125-2004-92 RN1402
Q513 193-1858-00 2SD1858
Q514 193-1858-00 2SD1858
Q515 125-0002-92 RN2402
Q516 125-2004-92 RN1402
Q517 103-2012-00 2SD2012
Q518 125-0002-92 RN2402
Q519 125-2004-92 RN1402
Q520 192-2712-00 2SC2712
Q522 125-0013-97 RN2427
Q523 125-2004-92 RN1402
Q524 193-1858-00 2SD1858
Q525 125-2004-92 RN1402
Q526 193-1858-00 2SD1858
Q527 193-1858-00 2SD1858
Q528 125-0002-92 RN2402
Q529 125-2004-92 RN1402
Q530 190-1431-00 2SA1431
Q533 193-1858-00 2SD1858
Q537 192-2712-00 2SC2712
Q538 192-2712-00 2SC2712
Q539 193-1858-00 2SD1858
Q540 193-1858-00 2SD1858
Q541 192-2712-00 2SC2712
Q542 193-1858-00 2SD1858
R101 119-4721-15 1/10W 4.7k ohm
R102 119-2221-15 1/10W 2.2k ohm
R103 111-6891-94 1/4W 6.8 ohm
R104 119-2221-15 1/10W 2.2k ohm
R105 119-2221-15 1/10W 2.2k ohm
R106 119-3321-15 1/10W 3.3k ohm
R107 119-2221-15 1/10W 2.2k ohm
R108 119-2231-15 1/10W 22k ohm
R109 119-2221-15 1/10W 2.2k ohm
R110 119-1221-15 1/10W 1.2k ohm
R111 119-4731-15 1/10W 47k ohm
R112 119-1031-15 1/10W 10k ohm
R113 119-1031-15 1/10W 10k ohm
R114 119-1221-15 1/10W 1.2k ohm
R117 119-1021-15 1/10W 1k ohm
R118 119-1041-15 1/10W 100k ohm
R119 111-6891-94 1/4W 6.8 ohm
R120 119-0000-05 1/10W 0 ohm JW
R121 119-1021-15 1/10W 1k ohm
R122 119-1831-15 1/10W 18k ohm
R123 111-1001-94 1/4W 10 ohm
R124 119-1021-15 1/10W 1k ohm
R125 119-2221-15 1/10W 2.2k ohm
R201 168-4732-78 0.047uF
R202 119-3931-15 1/10W 39k ohm
R203 119-1041-15 1/10W 100k ohm
R204 119-1041-15 1/10W 100k ohm
R205 119-3931-15 1/10W 39k ohm
R206 168-4732-78 0.047uF
R209 119-3321-15 1/10W 3.3k ohm
R210 119-3321-15 1/10W 3.3k ohm
R211 119-4741-15 1/10W 470k ohm
R212 119-2221-15 1/10W 2.2k ohm
R213 119-2221-15 1/10W 2.2k ohm
R214 119-2221-15 1/10W 2.2k ohm
R215 119-4731-15 1/10W 47k ohm
R216 119-1031-15 1/10W 10k ohm
R217 119-4721-15 1/10W 4.7k ohm
R218 119-4721-15 1/10W 4.7k ohm
R224 119-1031-15 1/10W 10k ohm
R225 119-1031-15 1/10W 10k ohm
R228 119-3331-15 1/10W 33k ohm
R229 119-3331-15 1/10W 33k ohm
R232 119-1031-15 1/10W 10k ohm
R233 119-1031-15 1/10W 10k ohm
R234 119-1521-15 1/10W 1.5k ohm
R235 119-1521-15 1/10W 1.5k ohm
R236 119-6821-15 1/10W 6.8k ohm
REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION
R237 119-6821-15 1/10W 6.8k ohm
R238 119-2221-15 1/10W 2.2k ohm
R239 119-2221-15 1/10W 2.2k ohm
R244 119-1031-15 1/10W 10k ohm
R245 119-1031-15 1/10W 10k ohm
R246 119-1031-15 1/10W 10k ohm
R247 119-1031-15 1/10W 10k ohm
R251 119-1031-15 1/10W 10k ohm
R256 119-1021-15 1/10W 1k ohm
R257 119-1531-15 1/10W 15k ohm
R258 117-4721-15 1/8W 4.7k ohm
R259 117-4721-15 1/8W 4.7k ohm
R261 117-6811-15 1/8W 680 ohm
R263 117-6811-15 1/8W 680 ohm
R269 117-8221-15 1/8W 8.2k ohm
R271 117-8221-15 1/8W 8.2k ohm
R272 117-1821-15 1/8W 1.8k ohm
R274 117-1821-15 1/8W 1.8k ohm
R280 117-0000-05 1/8W 0 ohm JW
R282 117-0000-05 1/8W 0 ohm JW
R284 117-4721-15 1/8W 4.7k ohm
R285 117-4721-15 1/8W 4.7k ohm
R286 117-4721-15 1/8W 4.7k ohm
R287 117-4721-15 1/8W 4.7k ohm
R288 117-4721-15 1/8W 4.7k ohm
R289 117-4721-15 1/8W 4.7k ohm
R290 119-1001-15 1/10W 10 ohm
R291 119-1031-15 1/10W 10k ohm
R292 119-1001-15 1/10W 10 ohm
R293 119-2721-15 1/10W 2.7k ohm
R294 119-2221-15 1/10W 2.2k ohm
R295 119-2721-15 1/10W 2.7k ohm
R296 119-2221-15 1/10W 2.2k ohm
R297 119-1821-15 1/10W 1.8k ohm
R298 119-1821-15 1/10W 1.8k ohm
R300 119-0000-05 1/10W 0 ohm JW
R301 119-1031-15 1/10W 10k ohm
R302 119-1021-15 1/10W 1k ohm
R303 119-1021-15 1/10W 1k ohm
R306 119-4731-15 1/10W 47k ohm
R307 119-4731-15 1/10W 47k ohm
R308 119-6821-15 1/10W 6.8k ohm
R309 119-6821-15 1/10W 6.8k ohm
R310 119-1031-15 1/10W 10k ohm
R311 119-2221-15 1/10W 2.2k ohm
R312 119-1031-15 1/10W 10k ohm
R313 119-2221-15 1/10W 2.2k ohm
R314 119-1521-15 1/10W 1.5k ohm
R317 119-1031-15 1/10W 10k ohm
R318 119-1031-15 1/10W 10k ohm
R321 119-1521-15 1/10W 1.5k ohm
R322 119-1531-15 1/10W 15k ohm
R323 119-1531-15 1/10W 15k ohm
R326 119-2231-15 1/10W 22k ohm
R327 119-2231-15 1/10W 22k ohm
R328 119-2731-15 1/10W 27k ohm
R329 119-2731-15 1/10W 27k ohm
R334 119-6831-15 1/10W 68k ohm
R335 119-4731-15 1/10W 47k ohm
R336 119-4731-15 1/10W 47k ohm
R337 119-6831-15 1/10W 68k ohm
R338 119-2231-15 1/10W 22k ohm
R339 119-4721-15 1/10W 4.7k ohm
R340 119-1031-15 1/10W 10k ohm
R341 119-1031-15 1/10W 10k ohm
R342 119-4721-15 1/10W 4.7k ohm
R343 119-2231-15 1/10W 22k ohm
R344 119-1031-15 1/10W 10k ohm
R345 119-1031-15 1/10W 10k ohm
R346 119-1031-15 1/10W 10k ohm
R347 119-1031-15 1/10W 10k ohm
R348 119-1031-15 1/10W 10k ohm
R349 119-1031-15 1/10W 10k ohm
R350 119-2731-15 1/10W 27k ohm
R351 119-1031-15 1/10W 10k ohm
R352 119-2221-15 1/10W 2.2k ohm
R353 119-1021-15 1/10W 1k ohm
R354 119-1031-15 1/10W 10k ohm
R355 119-2731-15 1/10W 27k ohm
R356 119-1021-15 1/10W 1k ohm
R357 119-2221-15 1/10W 2.2k ohm
R360 119-1021-15 1/10W 1k ohm
R361 119-1021-15 1/10W 1k ohm
R362 119-1021-15 1/10W 1k ohm
R363 119-1021-15 1/10W 1k ohm
R364 119-1021-15 1/10W 1k ohm
R365 119-1021-15 1/10W 1k ohm
R366 119-1021-15 1/10W 1k ohm
R367 119-1021-15 1/10W 1k ohm
R368 119-1031-15 1/10W 10k ohm
R369 119-1031-15 1/10W 10k ohm
R370 119-2721-15 1/10W 2.7k ohm
R371 119-2721-15 1/10W 2.7k ohm
R401 119-4741-15 1/10W 470k ohm
R402 119-4721-15 1/10W 4.7k ohm
R403 119-4721-15 1/10W 4.7k ohm
R404 119-4721-15 1/10W 4.7k ohm
R406 119-4731-15 1/10W 47k ohm
R409 119-2231-15 1/10W 22k ohm
R411 119-2231-15 1/10W 22k ohm
R413 119-2231-15 1/10W 22k ohm
R415 119-2231-15 1/10W 22k ohm
R417 119-2231-15 1/10W 22k ohm
R419 119-2231-15 1/10W 22k ohm
R421 119-2231-15 1/10W 22k ohm
R422 119-1021-15 1/10W 1k ohm
R423 119-2231-15 1/10W 22k ohm
R424 119-4721-15 1/10W 4.7k ohm
R425 119-4721-15 1/10W 4.7k ohm
R426 119-4721-15 1/10W 4.7k ohm
R427 119-4721-15 1/10W 4.7k ohm
R436 119-1021-15 1/10W 1k ohm
R437 119-1021-15 1/10W 1k ohm
R438 119-4721-15 1/10W 4.7k ohm
R439 119-4731-15 1/10W 47k ohm
R440 119-4731-15 1/10W 47k ohm
R441 119-4731-15 1/10W 47k ohm
R442 119-4731-15 1/10W 47k ohm
R443 119-2231-15 1/10W 22k ohm
R444 119-2231-15 1/10W 22k ohm
R445 119-2231-15 1/10W 22k ohm
R446 111-2211-94 1/4W 220 ohm
R447 119-4721-15 1/10W 4.7k ohm
R448 119-4731-15 1/10W 47k ohm
R450 119-4721-15 1/10W 4.7k ohm
R452 119-3921-15 1/10W 3.9k ohm
R453 119-4731-15 1/10W 47k ohm
R455 119-4731-15 1/10W 47k ohm
R456 119-1831-15 1/10W 18k ohm
R457 119-1031-15 1/10W 10k ohm
R458 119-4731-15 1/10W 47k ohm
R461 119-4731-15 1/10W 47k ohm
R462 119-4731-15 1/10W 47k ohm
R464 119-1021-15 1/10W 1k ohm
R465 119-4731-15 1/10W 47k ohm
R466 119-0000-05 1/10W 0 ohm JW
R467 119-4731-15 1/10W 47k ohm
R468 119-1021-15 1/10W 1k ohm
R469 119-1021-15 1/10W 1k ohm
R470 119-1011-15 1/10W 100 ohm
R471 119-1011-15 1/10W 100 ohm
R472 119-1011-15 1/10W 100 ohm
R501 119-4721-15 1/10W 4.7k ohm
R502 119-4721-15 1/10W 4.7k ohm
R503 119-4721-15 1/10W 4.7k ohm
R504 119-4721-15 1/10W 4.7k ohm
R505 111-2291-94 1/4W 2.2 ohm
R506 111-2291-94 1/4W 2.2 ohm
R507 111-6811-94 1/4W 680 ohm
R509 111-3311-94 1/4W 330 ohm
R510 111-2291-94 1/4W 2.2 ohm
R511 111-2291-94 1/4W 2.2 ohm
R525 111-2291-94 1/4W 2.2 ohm
R526 111-2291-94 1/4W 2.2 ohm
R527 119-5611-15 1/10W 560 ohm
R528 111-4711-94 1/4W 470 ohm
R529 111-4711-94 1/4W 470 ohm
R530 119-4731-15 1/10W 47k ohm
R531 119-1031-15 1/10W 10k ohm
R532 119-2221-15 1/10W 2.2k ohm
R533 111-1011-94 1/4W 100 ohm
R534 111-2221-94 1/4W 2.2k ohm
R536 119-1041-15 1/10W 100k ohm
R537 119-2241-15 1/10W 220k ohm
R538 119-2241-15 1/10W 220k ohm
R539 119-3331-15 1/10W 33k ohm
REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION
R541 119-1021-15 1/10W 1k ohm
R542 119-4711-15 1/10W 470 ohm
R543 111-2291-94 1/4W 2.2 ohm
R544 111-2291-94 1/4W 2.2 ohm
R545 111-1521-94 1/4W 1.5k ohm
R547 119-1531-15 1/10W 15k ohm
R548 111-3311-94 1/4W 330 ohm
R549 119-4731-15 1/10W 47k ohm
R554 111-2291-94 1/4W 2.2 ohm
R557 119-3311-15 1/10W 330 ohm
R558 119-1031-15 1/10W 10k ohm
R559 119-1511-15 1/10W 150 ohm
R560 119-1031-15 1/10W 10k ohm
R561 111-1221-94 1/4W 1.2k ohm
R562 114-4791-11 1W 4.7 ohm
R563 111-2291-94 1/4W 2.2 ohm
R565 119-8221-15 1/10W 8.2k ohm
R566 111-1031-94 1/4W 10k ohm
R568 111-2291-94 1/4W 2.2 ohm
R569 111-6811-94 1/4W 680 ohm
R570 117-4721-15 1/8W 4.7k ohm
R571 119-2721-15 1/10W 2.7k ohm
R572 119-4721-15 1/10W 4.7k ohm
R601 119-2221-15 1/10W 2.2k ohm
R602 119-2221-15 1/10W 2.2k ohm
R603 119-1041-15 1/10W 100k ohm
R604 119-1041-15 1/10W 100k ohm
R605 119-1031-15 1/10W 10k ohm
R606 119-1031-15 1/10W 10k ohm
SUP101 060-0122-20 DSP-141N-S00B
T501 009-0666-0L 0.4mH
TC102 004-1580-60 30pF
TH501 002-0222-90 PTH61G30BD
TM101 073-0762-90 TERMINAL
TM102 073-0762-90 TERMINAL
X102 061-1066-00 7.2MHz
X401 061-3504-90 CX-5F 10MHz
PWB 039-2159-00 PWB
REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION
Switch PWB section(B2)
C701 178-1042-78 0.1uF
C702 042-0423-94 10V 4.7uF
C703 178-1042-78 0.1uF
C704 178-1042-78 0.1uF
C705 178-6812-78 680pF
D701 001-0412-17 GC-3HD8
D702 001-0518-96 BG1101W-240
IC701 051-6000-20 LC7583NW
LCD1 379-1250-30 LCD
P701 074-1151-20 20P
PL701 017-0429-21 8V108mA
PL702 017-0429-21 8V108mA
PL703 017-0433-87 14V40mA
PL704 017-0433-87 14V40mA
PL705 017-0433-87 14V40mA
PL706 017-0433-87 14V40mA
PL707 017-0433-87 14V40mA
PL708 017-0433-87 14V40mA
PL709 017-0433-87 14V40mA
R702 117-0000-05 1/8W 0 ohm JW
R703 117-0000-05 1/8W 0 ohm JW
R706 117-0000-05 1/8W 0 ohm JW
R707 117-0000-05 1/8W 0 ohm JW
R711 117-6831-15 1/8W 68k ohm
R721 117-0000-05 1/8W 0 ohm JW
R722 117-0000-05 1/8W 0 ohm JW
R723 117-0000-05 1/8W 0 ohm JW
R724 117-0000-05 1/8W 0 ohm JW
S701 013-6201-50 SKPMAA
S702 013-6201-50 SKPMAA
S703 013-6201-50 SKPMAA
S704 013-6201-50 SKPMAA
S705 013-6201-50 SKPMAA
S706 013-6201-50 SKPMAA
S707 013-6201-50 SKPMAA
S708 013-6201-50 SKPMAA
S709 013-6201-50 SKPMAA
S710 013-6201-50 SKPMAA
S711 013-6201-50 SKPMAA
S712 013-6201-50 SKPMAA
S713 013-6201-50 SKPMAA
VR701 016-0014-05 VR W-SHAFT
VR702 016-0014-05 VR W-SHAFT
PWB 039-1974-00 PWB
CD PWB section(B3) : CD mechanism
REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION
C1 163-1073-10 6.3V100uF
C3 178-1042-78 0.1uF
C4 178-2222-78 2200pF
C5 178-1042-78 0.1uF
C6 178-1042-78 0.1uF
C7 178-1042-78 0.1uF
C8 176-1501-50 15pF CH
C9 176-1501-50 15pF CH
C10 176-1201-50 12pF CH
C11 178-1042-78 0.1uF
C13 178-1042-78 0.1uF
C14 178-1042-78 0.1uF
C15 178-1042-78 0.1uF
C16 178-1042-78 0.1uF
C17 163-1073-31 16V100uF
C18 176-4701-50 47pF CH
C19 178-1532-78 0.015uF
C20 178-1032-78 0.01uF
C21 178-2722-78 2700pF
C22 178-4722-78 4700pF
C23 178-1042-78 0.1uF
C24 178-1042-78 0.1uF
C25 178-1042-78 0.1uF
C26 178-4712-78 470pF
C27 178-4712-78 470pF
C28 178-4732-78 0.047uF
C29 178-4732-78 0.047uF
C30 178-4732-78 0.047uF
C31 178-4732-78 0.047uF
C32 163-4763-05 4V47uF
C33 163-4763-05 4V47uF
C34 176-1801-50 18pF CH
C35 176-6097-50 6pF CH
C36 176-6801-50 68pF CH
C37 176-2201-50 22pF CH
C38 178-1042-78 0.1uF
C39 163-4763-05 4V47uF
C44 178-2242-78 0.22uF
C45 178-2242-78 0.22uF
C46 163-4763-15 6.3V47uF
C47 178-8222-78 8200pF
C48 178-1042-78 0.1uF
C50 163-1073-15 6.3V100uF
C51 178-1042-78 0.1uF
C52 178-2232-78 0.022uF
C54 176-2201-50 22pF CH
C61 178-1042-78 0.1uF
C63 178-1042-78 0.1uF
C64 178-1042-78 0.1uF
C65 178-1042-78 0.1uF
D1 001-0563-00 GL380
D2 001-0563-00 GL380
D3 001-0563-00 GL380
D4 001-0516-90 MA111
IC1 051-5704-90 TA2096FN
IC2 051-6342-00 TC9462F
IC3 051-6045-08 BA5984FP
J1 074-1138-66 16P
J2 074-1138-56 6P
L1 010-3050-93 10uH
Q1 101-1188-50 2SB1188PQR
R1 117-2211-15 1/10W 220 ohm
R2 117-2211-15 1/10W 220 ohm
R3 117-5611-15 1/10W 560 ohm
R4 117-5611-15 1/10W 560 ohm
R5 117-4711-15 1/10W 470 ohm
R6 117-3311-15 1/10W 330 ohm
R7 117-4721-15 1/10W 4.7k ohm
R8 117-1041-15 1/10W 100k ohm
R9 117-1031-15 1/10W 10k ohm
R10 117-4731-15 1/10W 47k ohm
R12 117-4741-15 1/10W 470k ohm
R13 117-3331-15 1/10W 33k ohm
R14 117-3321-15 1/10W 3.3k ohm
R15 117-1031-15 1/10W 10k ohm
R16 117-3321-15 1/10W 3.3k ohm
R17 117-3321-15 1/10W 3.3k ohm
R18 117-3321-15 1/10W 3.3k ohm
R19 117-3321-15 1/10W 3.3k ohm
R20 117-3321-15 1/10W 3.3k ohm
R21 117-2221-15 1/10W 2.2k ohm
R22 117-8211-15 1/10W 820 ohm
R23 117-9131-15 1/10W 91k ohm
R24 117-1041-15 1/10W 100k ohm
R25 117-1041-15 1/10W 100k ohm
R26 117-1841-15 1/10W 180k ohm
R27 117-1841-15 1/10W 180k ohm
R28 117-2211-15 1/10W 220 ohm
R29 117-2201-15 1/10W 22 ohm
R30 117-1041-15 1/10W 100k ohm
R31 117-1041-15 1/10W 100k ohm
R32 117-1041-15 1/10W 100k ohm
R33 117-1041-15 1/10W 100k ohm
R34 117-1041-15 1/10W 100k ohm
R35 117-2241-15 1/10W 220k ohm
R36 117-1041-15 1/10W 100k ohm
R37 117-1041-15 1/10W 100k ohm
R38 117-8231-15 1/10W 82k ohm
R39 117-1841-15 1/10W 180k ohm
X1 061-3500-90 16.920MHz
PWB 039-2201-01 PWB
REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION
Sensor PWB section(B4) : CD mechanism
Q101 060-0252-01 PT4850F
Q102 060-0252-01 PT4850F Q103 060-0252-01 PT4850F PWB 039-0588-01 PWB
REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION
M3 SMA-147-100 LOADING S2 013-3879-01 SPPB12
Limit switch PWB section(B6) : CD mechanism
REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION
M1 SMA-151-100 SPINDLE
M2 SMA-146-100 SLED S1 013-7100-00 SPPB11
PWB 039-0586-01 PWB
PWB 039-0585-01 PWB
Chucking switch PWB section(B5) : CD mechanism

4.7 4.7
4.7
4.7
4.7 4.7 4.7
4.7
4.7
4.7
4.7
3.0 3.0
3.0 3.0 3.0
4.3 4.3 4.34.3
4.3 4.3
3.0 3.0
3.0 3.0 3.0
4.3 4.3 4.34.3
4.3 4.3
Tuner
PLL
TC102
(CLOCK)
TP101
(CLOCK)
Electrical Volume
Power
Radio/CD System Control
CD+5V CD+8V
Audio+8V
Remocon REM+5V
ACC-DET RESET B/U-DET VDD
CATS-ROM
ILL-ON
BL-ON
EQ
Buffer
CATS/CD
IND-SW
CIRCUIT DIAGRAM
Main PWB section (B1)
-12- PH-2416N
B
*To J3 of CD PWB
P16
C101
JW
8.2K
8.2K
680
680
0.18
0.18
0.33
0.33
0.082
0.082
0.012
0.012
4700p
4700p 0.015
0.015 R2714
1.8K 3900p
3900p
6800p
6800p
0.022
0.022
JW
JW
R272
1.8K
1200p
1200p
4.7K
4.7K
R300 JW
R466 JW
MA111
*To P701 of
Switch PWB
M30622MAA-F54GP
AP15

1 Audio COM
2 R-CH(+)
3 NC
4 BUS
5 ACC
6 NC
7 Illumi(+)
8 Shield GND
9 L-CH(+)
10BUS Shield
11BUS GND
12GND
13Back Up
14Illumi CONT
A SW +B
B ACC
C Remote CONT
D Security IN
E Rear Right SP(+)
F Rear Left SP(+)
G Front Right SP(+)
H Front Left SP(+)
I Illumi(+)
J Back Up
K NC
L NC
M NC
N NC
O Rear Right SP(-)
P Rear Left SP(-)
Q Front Right SP(-)
R Front Left SP(-)
S Illumi CONT
T GND
PRINTED WIRING BOARD
 Main PWB section (B1)
-13- PH-2416N
COMPONENT SIDE
Caution:
COMPONENT SIDE: Parts on the
component side seen from the
component side are indicated.
SOLDER SIDE: Parts on the solder
side seen from the solder side are
indicated.
*To P701 of Switch PWB
A
P15
*To J3 of CD PWB
B
P18
I7
AB
CDEFGH
J
KL
MNOPQR
T S
6 5 4 3 12
14 13 12 11 10 8 9
Main PWB(B1)
TP101
TC102
TP101 TC102
49
R272
R274

-14-
SOLDER SIDE
PRINTED WIRING BOARD
 Main PWB section (B1)
PH-2416N
Main PWB(B1)

LCD Driver
1.6
3.1
4.7
4.7
CIRCUIT DIAGRAM
 Switch PWB section (B2) PRINTED WIRING BOARD  Switch PWB section (B2)
-15- PH-2416N
Switch PWB(B2) Switch PWB(B2)
COMPONENT SIDE
Caution:
COMPONENT SIDE: Parts on the
component side seen from the
component side are indicated.
SOLDER SIDE: Parts on the solder
side seen from the solder side are
indicated.
SOLDER SIDE
*To J302 of Main PWB
A
*To J302 of Main PWB
P12
A
P13

Motor Driver
RF AMP
CD control
CIRCUIT DIAGRAM
CD mechanism section (B3-B6)
-16- PH-2416N
*To Pick up unit
Sensor PWB(B4)
CD PWB(B3)
Chucking switch
PWB(B5)
Limit switch PWB(B6)
B
*To J301 of Main PWB
P12

WHT
BLK
RED
BLK
-17- PH-2416N
COMPONENT SIDE
Caution:
COMPONENT SIDE: Parts on the
component side seen from the
component side are indicated.
SOLDER SIDE: Parts on the solder
side seen from the solder side are
indicated.
PRINTED WIRING BOARD
CD mechanism section (B3,B6)
M2
Sled motor
(SMA-146-100)
M1
Spindle motor
(SMA-151-100)
Limit Switch PWB(B6)
CD PWB(B3)

-18-
PH-2416N
BLK
RED
BLK
YEL
BRN
RED
PRINTED WIRING BOARD
CD mechanism section (B3-B5)
Pick up unit
(969-0008-12)
SOLDER SIDE
B*To J301 of Main PWB
P13
CD PWB(B3)
Sensor PWB(B4)
Chucking switch PWB(B5)
M3
Loading motor
(SMA-147-100)
FPC(039-1768-00)