Climate+ CM-12000 User manual

EVAPORATIVE AIR COOLER CM-12000
www.climateplus.ae
ENERGY SAVING & ENVIRONMENTAL MACHINE

EVAPORATIVE AIR COOLER CM-12000
www.climateplus.ae
CONTENTS
CONTENTS……………………………………………………………………….1
INTRODUCTION………………………………………………………………...2
TECHNOLOGY SPECIFICATION…………………………………………….3
FEATURES……………………………………………………………………….4
IMPORTANT REMINDERS…………………………………………………….5
CLEAN AND PROTECTION…………………………………………………...6
TROUBLE SHOOTING………………………………………………………….7
BASIC PRINCIPLE……………………………………………………………...8
1

EVAPORATIVE AIR COOLER CM-12000
www.climateplus.ae
TECHNICAL SPECIFICATION
●INTRODUCTION
Thank you for purchasing our product. We trust it will give you long and trouble free
service.
WARNING
This appliance is not intended for use by persons (including children) with
reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless
1. They have been given supervision or instruction concerning use of the appliance by a person
responsible for their safety.
2. Children should be supervised to ensure that they do not play with the appliance.
3. Ensure that the fan is switched off from the supply mains before removing the guard.
4. If the supply cord is damaged, it must be replaced by the manufacturer, its service agent or
similarly qualified persons in order to avoid a hazard.
5. Unplug the appliance during filling and cleaning.
TECHNOLOGY SPECIFICATION
MODEL NO.
CM12000
MAX AIR FLOW
12000m3/H
VOLTAGE
220V
FREQUENCY
50/60HZ
RATED POWER
450W
WATER CONSUMPTION
8-10L/H
WATER CAPACITY
80L
SIZE
1135*750*140MM
WEIGHT
41KGS
EFFECTIVE AREA
80m3
2

EVAPORATIVE AIR COOLER CM-12000
www.climateplus.ae
FEATURES
The evaporative air cooler has the special advantages:
1. 3 speed for the wind
2. The thicker and bigger cooling pad for better heat absorption.
3. Wheel footing is easy moving.
4. There is a water inlet valve. When without water, there will be alarm.
5. Big capacity for the water tank, no need to add water frequently.
IMPORTANT REMINDERS
Please read the manual carefully before operating the cooler.
A) Operating conditions:
1- Temperature: 18'C to 45'C, Water Temperature: < 45'C.
2- Power supply must not exceed the required voltage (+/-) 5%.
3- Air supply must be largely free of dust or extra cleaning is required.
B) Protect the power cable from vehicle or foot traffic. Connection to incorrect
Electric voltage, or faulty installation, will cause danger of electric shock
C) If the product malfunctions at startup, please disconnect from electric power immediately
and refer to dealer for service.
D) Necessary caution measure including grounding
3

EVAPORATIVE AIR COOLER CM-12000
www.climateplus.ae
1- Keep doors and windows open to allow fresh air to enter, and treated air to exit, when cooler
is operating.
2-Flashing red light on the control panel means water level in reservoir is low.
3- Rinse the reservoir with fresh water and clean prior to use after a period where the cooler
has not been in operation.
4- Take care when moving the cooler, especially when it is full of water. Pushing too hard will
cause the cooler to overbalance and tip over, which may cause injury and will damage the
cooler.
5- Simplified description of the cooler installation process and the connection modes to supply
main water and electricity.
Open the carton, make sure the cooling machine is in good looking, put water tank, put plug on,
power supply is 220-240V/50Hz including grounding.
No lubricating process for there is a belt.
B-Clean the water reservoir and change the water in the reservoir each month
Make sure the power is off, open the cooling pad, wash pad and water tank in clean water each
month.
CLEAN AND PROTECTION
AIR FILTER
Switch off the power and take away the plug, pull out the handle for the filter. Then you can
use the cleaner to wash it.
Outside the machine clean with the dry-wet cloth
WET CURTAIN
Switch off the power and open the plug. First take out the air filter, then for the wet curtain.
Use the soft brush to wash it.
WATER TANK
Switch off the power and open the back wet curtain. Use the cloth and clean water to wash it.
4