Coleman Fyreknight Hyperflame 9966 Series User manual

LPG Stoves
Instructions for use
9966 Series
* The griddles are only included for certain models.
IMPORTANT
Read these instructions for use carefully. Familiarise yourself with
the appliance before connecting it to a gas cylinder. Keep these
instructions for future reference.
This instruction manual contains important information necessary for
the proper assembly and safe use of the appliance. Follow all warnings
and instructions when using the appliance. If you have questions about
assembly, operation, servicing or repair of this product, please call
Coleman on 1800 224 350. Newell Australia Pty Ltd.
Gas cylinders shall be changed in a well-ventilated location, preferably
outside away from people and any sources of ignition, such as naked
ames, pilot ames, electric heaters / equipment. If there is a leak
on your appliance (smell of gas) and you cannot stop the gas ow,
immediately turn off the cylinder valve and remove the appliance to
a well-ventilated location away from any ignition source. Check for
leaks using soapy water. Do not try to detect leaks using a ame.
This appliance must only be serviced by an authorised person. Gas
cylinders must be stored outdoors in a well ventilated area out of the
reach of children, any indoor storage shall comply with AS/NZS 1596.
This appliance shall only be used with propane LPG Coleman
disposable gas cylinders certied to DOT-39 NRC 232/290 M1110.
OR rellable Universal LPG cylinder certied to AS2030/AS2469 &
Coleman hose assembly. IT MAY BE HAZARDOUS TO ATTEMPT TO
FIT OTHER TYPES OF GAS CONTAINERS. DO NOT USE ADAPTORS.
Not suitable for installation or connection to a reticulated gas supply.
CAUTION: accessible parts may be very hot. Keep young children
away, USE OUTDOORS ONLY. Must only be operated on a horizontal
surface. Not suitable for marine environments. Do not modify this
appliance.
INSTASTART™ Electronic Ignition
Standard Ignition
Camp Stove

1
Do not store or use
gasoline or other
flammable vapors and
liquids in the vicinity
of this or any other
appliance.
FOR YOUR
SAFETY
CARBON MONOXIDE
HAZARD
This appliance can
produce carbon
monoxide which is
poisonous and has no
odor.
Using it in an enclosed
space can kill you.
Never use this appliance
in an enclosed space
such as a camper, tent,
car or home.
DANGER
WARNING
FIRE OR EXPLOSION
HAZARD
If you smell gas:
1. Do not attempt to
light appliance.
2. Make sure appliance
is in the off position.
3. Extinguish any
nearby flame(s).
4. Shut off cylinder
fuel supply valve
if so equipped, or
if equipped with
a disposable fuel
cylinder, disconnect
cylinder.
5. Leave the area
immediately.
6. Allow gas to
dissipate 5 minutes.
7. If gas smell has
dissipated from
the area, of the
appliance, and
fuel supply, follow
gas connection
procedures.
8. If you smell gas
again, follow steps
1-6 and have
appliance serviced.
Failure to follow
these instructions
could result in fire
or explosion, which
could cause property
damage, personal
injury, or death.
WARNING
Improper installation,
use, adjustment, altera-
tion, service, or mainte-
nance can cause injury
or property damage.
Refer to this manual.
For assistance or addi-
tional information con-
sult a qualified installer,
service agency or gas
supplier.

2
CARBON MONOXIDE HAZARD
• This stove is a combustion
appliance. All combustion appliances
produce carbon monoxide (CO)
during the combustion process.
This product is designed to produce
extremely minute, non-hazardous
amounts of CO if used and
maintained in accordance with all
warnings and instructions. Do not
block air flow into or out of the stove.
• Carbon Monoxide (CO) poisoning
produces flu-like symptoms, watery
eyes, headaches, dizziness, fatigue
and possibly death. You can’t see it
and you can’t smell it. It’s an invisible
killer. If these symptoms are present
during operation of this product get
fresh air immediately!
• For outdoor use only.
• Never use inside house, camper,
tent, vehicle or other unventilated
or enclosed areas. This stove
consumes air (oxygen) and
produces carbon monoxide
(CO). Do not use in unventilated
or enclosed areas to avoid
endangering your life.
DANGER
DANGER
DANGER indicates an imminently hazardous
situation which, if not avoided, will result in
death or serious injury.
WARNING
WARNING indicates a panentially hazardous
situation which, if not avoided, could result in
death or serious injury.
CAUTION
CAUTION indicates a panentially hazardous
situation which, if not avoided, may result in
minor or moderate personal injury, or property
damage.
This manual contains important
information about the assembly, operation
and maintenance of this outdoor LPG
appliance. General safety information
is presented on this page and is also
located throughout these instructions.
Particular attention should be paid to
information accompanied by the safety
alert symbol
“ DANGER”, “ WARNING”,
“ CAUTION”.
Keep this manual for future reference and
to educate new users of this product. This
manual should be read in conjunction with
the labeling on the product.
Safety precautions are essential when
any mechanical or LPG fueled equipment is
involved. These precautions are necessary
when using, storing, and servicing.
Using this equipment with the respect
and caution demanded will reduce the
possibilities of personal injury or property
damage.
The following symbols shown
below are used extensively throughout
these instructions. Always heed these
precautions, as they are essential when
using any mechanical or LPG fueled
equipment.
CALIFORNIA PROPOSITION 65:
WARNING: This fuel, and byproducts
or combustion of this fuel, contains Carbon
Monoxide, which is known to the State of
California to cause cancer and birth defects
or other reproductive harm. For more infor-
mation go to www.P65Warnings.ca.gov
EXPLOSION - FIRE HAZARD
• Never store LPG near high heat,
open flames, pilot lights, direct
sunlight, other ignition sources or
where temperatures exceed
120 ºF (49 °C).
• LPG is heavier than air and can
accumulate in low places. If you
smell gas, leave the
area immediately.
• Never install or remove LPG tank
while outdoor stove is lighted, near
flame, pilot lights, other ignition
sources or while outdoor stove is hot
to touch.
• During lighting and operation, this
product can be a source of ignition.
Never use the stove in spaces that
contain or may contain volatile or
airborne combustibles, or products
such as gasoline, solvents, paint
thinner, dust particles or unknown
chemicals.
• Minimum clearances from
combustible materials: 12 inches
(304.8 mm) from the sides and 48
inches (1219.2 mm) from the top.
• Provide adequate clearances around
air openings into the
combustion chamber.
DANGER
Failure to comply with the precautions and
instructions provided with these stoves can
result in death, serious bodily injury and
property loss or damage from hazards of fire,
explosion, burn, asphyxiation, and/or carbon
monoxide poisoning.
Only persons who can understand and follow
the instructions should use or service
these stoves.
If you need assistance or information such
as an instruction manual or labels, contact
The Coleman Company, Inc.
DANGER

3
SERVICE SAFETY
• Keep all connections and fittings
clean. Inspect LPG cylinder and stove
LPG connections for damage before
attaching.
• During set up, check all connections
and fittings for leaks using soapy water.
Never use a flame. Bubbles indicate
a leak. Check that the connection is
not cross-threaded and that it is tight.
Perform another leak check. If there
is still a leak, remove the cylinder and
contact Coleman
®
for service or repairs.
• Use as a cooking appliance only. Never
alter in any way or use with any device
or part not expressly approved by
Coleman
®
.
• Clean stove and stove griddle (if
equipped) frequently to avoid grease
accumulation and possible grease fires.
CAUTION
Not for home or
recreational vehicle use.
We cannot foresee every use which
may be made of our products. Check
with your local fire safety authority
if you have questions about use.
Other standards govern the use of fuel
gases and heat producing products for
specific uses. Your local authorities can
advise you about these.
• Never refill disposable cylinders.
• Use the preset regulator that came
with the stove. Do not attempt
to adjust.
• Use only Coleman
®
accessories or
parts. During stove set-up, check all
fittings for leaks using soapy water.
Never use a flame.
WARNING
BURN HAZARD
Do not leave this appliance unattended
while the appliance is in operation;
keep children and pets away from the
appliance at all times.
WARNING
• This product is fueled by LPG gas.
LPG gas is invisible, odorless, and
flammable. An odorant is normally
added to help detect leaks and can be
described as a “rotten egg” smell. The
odorant can fade over time so leaking
gas is not always detectable by smell
alone.
• LPG gas is heavier than air and
leaking LPG will sink to the lowest
level possible. It can ignite by ignition
sources including matches, lighters,
sparks or open flames of any kind
many feet away from the original leak.
Use only LPG gas set up for vapor
withdrawal.
• LPG gas should be stored or used in
compliance with local ordinances and
codes or with ANSI/NFPA 58. Turn off
LPG when not in use.
WARNING
• To avoid overheating the gas
cartridge and controls by the use of
multiple or excessive sized cooking
devices, plates, etc.
• Not to use multiple appliances to
heat a single vessel.
• The maximum vessel size to be used
is 190 mm diameter.
• To avoid boil over and spillage.
• Not to use as a space heater.
WARNING
Technical
Characteristics
To Set Up
CARBON MONOXIDE HAZARD
• For outdoor use only.
• Never use inside house, camper,
tent, vehicle or other unventilated
or enclosed areas. This stove
consumes air (oxygen) and produces
carbon monoxide (CO). Do not use
in unventilated or enclosed areas to
avoid endangering your life.
• ONLY USE IN WELL-VENTILATED
AREAS.
• CARBON MONOXIDE HAZARD—
USING THIS APPLIANCE IN
AN ENCLOSED SPACE MAY
CAUSE DEATH. DO NOT USE
IN CARAVANS, TENTS, MARINE
CRAFT, CARS, MOBILE HOMES OR
SIMILAR LOCATIONS.
DANGER
NOTE:
Use Coleman®16.4 oz. disposable
propane cylinders. The LP-gas cylinder(s)
used with stoves must be constructed
and marked in accordance with the
specications for LP-gas cylinders of
the U.S. Department of Transportation or
Transport Canada, CAN/CSA B339. OR
rellable Universal LPG cylinder certied
to AS2030/AS2469 & Coleman hose
assembly.
Only use the hose assembly as supplied
with this appliance for connection to the
cylinder – DO NOT USE ADAPTORS.
Input: 12.5 MJ/h per burner
Category: Pressure regulated Universal LPG
Regulator: 5430
Injector: 0.42 mm

4
1. Remove components from carton.
(Fig. 1)
Regulator
Wind Shield
Pan Support
Griddle
(If included)
Stove
Fig. 1
2. To open the lid, move the handle
slightly to the “ ” location. Pull the
latch hook panel out and push it
upwards right above the handle to
release. (Fig. 2)
NOTE: The handle can’t be pulled
down fully.
Fig. 2
3. Assemble Lid Stopper to stove.
(Fig. 3)
Lid
Lid
stopper
stopper
Fig. 3
4. Install Wind Shield Pan Support as
shown (Fig. 4). Please place cooking
pot / pan directly on the the Pan
Supports.
Fig. 4
5. Optionally, you may install the griddles
(if included) as shown. (Fig. 5)
NOTE: Don’t use griddle without
Wind Shield Pan Support.
Fig. 5
NOTE TO PREVENT DAMAGE
WHICH WILL VOID THE
WARRANTY:
ƔDo not use pots, pans, ovens,
etc., on this griddle surface.
ƔDo not use this griddle on a
campfire or other open fire.
ƔUse this griddle only on the
Coleman®stove for which it
was designed.
6. Control Knob Identification (Fig. 6)
Right Burner
Valve
Igniter
Button Left Burner
Valve Fig. 6
7. Close both burner valves firmly.
(Fig. 7)
Fig. 7
SERVICE SAFETY
ƔKeep all connections and
fittings clean. Inspect LPG
cylinder and stove LPG
connections for damage
before attaching.
ƔDuring set up, check all
connections and fittings for
leaks using soapy water.
Bubbles indicate a leak. Never
use a flame.
CAUTION

5
8. Screw regulator into stove hand tight.
(Fig. 8)
9. Remove plastic cap from top of LPG
bottle and screw LPG bottle into
regulator hand tight. (Fig. 9)
Fig. 9Fig. 8
10. LPG cylinder correctly installed.
(Fig. 10)
11. Never operate stove with LPG
cylinder in an inverted position.
(Fig. 11)
Fig. 10 Fig. 11
Check that all seals between the
appliance and the gas cylinder are in
place and in good condition before
connecting the gas cartridge. Remove
all transit protection material.
DO NOT move the appliance during
operation. After use, turn the gas
cylinder valve off, wait for the flame
to go out, then turn the appliance
control valve(s) off.
Flexible gas hose maximum length is
1.5 meters, Avoid twisting or kinking
the flexible hose.
Leak Check
ƔPerform leak test outdoors.
ƔExtinguish all open flames.
ƔNEVER leak test when
smoking.
ƔDo not use the outdoor stove
until connection has been leak
tested and does not leak.
WARNING
•CHECK FOR LEAKS in one or more ways:
Apply soapy water to connections. Look
for bubbles. Listen for hiss of escaping
gas. Feel for extreme cold. Smell for rotten
egg odor. Never use a flame. Do not use if
leaking.
To Light
EXPLOSION - FIRE HAZARD
ƔLPG is heavier than air and
can accumulate in low places.
If you smell gas, leave the area
immediately.
ƔAlways attach or detach LPG
source outdoors; never while
stove is lighted, near flame,
pilot lights, other ignition
sources or while stove is hot
to touch.
ƔThis stove is red hot during
use and can ignite flammables
too close to the burners. Keep
flammables at least 12 inches
from the sides and 48 inches
from the top of the stove.
Keep gasoline and other
flammable liquids and vapors
well away from stove.
ƔThe stove must not be
exposed to flammable vapors
or liquids during lighting.
DANGER
BURN HAZARD
Do not leave this appliance
unattended while the appliance is in
operation; keep children and pets
away from the appliance at all times.
WARNING
INSTASTART™
Electronic Ignition Stoves
1. Set stove on sturdy, flat surface. For
outdoor use only.
2. Open burner valve and repeatedly
push igniter button until burner
ignites. (Fig. 12)
3. Repeat for both burners.
NOTE: If the igniter still fails to light
stove, use match to light burner. If
the stove is wet the igniter may not
spark.
Fig. 12

6
Match Lighting
1. Set stove on sturdy, flat surface. For
outdoor use only.
2. Hold lighted match near burner and
open burner valve. (Fig. 13)
3. Repeat for both burners.
Fig. 13
4. Adjust flame with burner valves.
(Fig. 14). Flame should be blue with a
hint of yellow on tips.
Fig. 14
To Turn Off
1. Close the burner valves firmly.
(Fig. 15)
Fig. 15
To Clean
1. Make sure stove is cool.
2. Move stove away from flame
(including pilot lights) and other
ignition sources.
3. Remove LPG cylinder from regulator
and replace protective cap on
cylinder. (Fig. 16)
4. Remove regulator from stove.
(Fig. 17)
Fig. 16 Fig. 17
Cleaning the Griddle (if
included)
1. Make sure stove and griddle are
cool.
2. Wipe clean with soft cloth and mild
dish detergent. Do not use abrasives
on the non-stick griddle surface.
MAINTENANCE
ƔKeep stove area clear and free
from combustible materials,
gasoline and other flammable
vapors and liquids.
ƔDo not obstruct the flow of
combustion and ventilation air.
ƔA good flame should be
blue with minimal yellow tip.
Some yellow tips on flames
are acceptable as long as
no carbon or soot deposits
appear.
ƔWipe clean with soft cloth and
mild dish detergent. Do not
use abrasives. (Fig. 18)
Fig. 18
To check if the gas cylinder is empty,
disconnect the cylinder from the
appliance and shake from side to
side.
If there is no sound or movement of
liquid, the cylinder is empty.
Annual service by an authorised
person is recommended. Or if any of
the following conditions are noticed;
incomplete ignition, appreciable
yellow tipping, carbon deposition,
lifting, floating, lighting back or
objectionable odor.
DO NOT use this appliance if it has
damaged or worn seals. DO NOT use
this appliance if it is leaking, damaged
or does not operate properly.

7
Use Outdoors Only
This appliance shall only be used in an above ground open air situation with natural
ventilation, without stagnant areas, where gas leakage and products of combustion
are rapidly dispersed by wind and natural convection.
Any enclosure in which the appliance is used shall comply with one of the following:
(A) An enclosure with walls on all sides, but with no overhead cover.
(See Figure D.1)
(B) Within a partial enclosure that includes an overhead cover and no more than
two walls. (See Figure D.2 & D.3)
(C) Within a partial enclosure that includes an overhead cover and more than two
walls, the following shall apply: (see Figure D.4 & D.5)
(1) At least 25 % of the total wall area is completely open.
(2) 30 % or more in total of the remaining wall side, back and front wall areas is
open and unrestricted.
(3) In the case of balconies, 20 % or more of the total wall area shall remain
open and unrestricted.
Figure D.1 - Outdoor area - Example 1
Figure D.2 - Outdoor area - Example 2
Figure D.3 - Outdoor area - Example 3
Figure D.4 - Outdoor area - Example 4
Figure D.5 - Outdoor area - Example 5
Both ends open
Open side at least
25% of total wall
area
Open side at least
25% of total wall
area
30 percent or more in total
of the remaining wall area is
open and unrestricted
30 percent or more in total
of the remaining wall area is
open and unrestricted

8
To Store
EXPLOSION - FIRE HAZARD
ƔNever store LPG near high
heat, open flames, pilot
lights, direct sunlight, other
ignition sources or where
temperatures exceed 120
degrees F (49 °C).
ƔThe cylinder must be
disconnected when the stove
is in storage.
ƔSafely store and operate
the appliance where the
environmental temperature
will not fall below -0.4°F
(-18°C).
DANGER
1. For storage or transport, the
regulator may be located between
the Wind Shield Pan Support.
(Fig. 19)
2. Place the griddle (if included) on the
Wind Shield Pan Support.
Fig. 19
3. Secure the lid latch.
4. To carry the stove, firmly grasp the
stove by the handle. (Fig. 20)
Fig. 20
Things You Should
Know
ƔIt is unsafe and illegal in some
places to store or use LPG
cylinders of greater than 1.14
kg (2.5 lbs.) water capacity
(approximately 1 lb. LPG) in
occupied enclosures.
ƔThe usual storage areas
for camping and picnic
equipment are the basement,
attic, or garage. To avoid the
accumulation of dust, cobwebs,
etc., that is common in these
storage areas, place your stove
in a plastic bag and seal it with a
rubber band.
ƔFor repair service call one of
the numbers listed on the front
cover for location of your nearest
Coleman Service Center.
ƔIf not completely satisfied with
the performance of this product,
please call one of the numbers
listed on the cover of this
manual.
www.colemanaustralia.com.au

9
Replacement Parts List
Item Part No. Description
1 5010002508 Windshield Pan Support - Hyperflame
2 R430B565T Regulator Assembly
3 5010002509 Handle Assy - 9966 Models
4 5010002507 Knob - 9966 Models
1
34
2
Accessories:
5 2000017528 Griddle
5
Replacement Parts List
Warranty
LIMITED THREE YEAR WARRANTY
EXPRESS WARRANTY
Newell Australia Pty. Ltd. (“Newell”) warrants that for a period of three (3) years from
the date of original retail purchase, this product will be free from defects in material
and workmanship. Coleman will, depending on the circumstances, refund, repair or
replace this product or any component of the product found to be defective during
the warranty period. Replacement will be made with a new or remanufactured product
or component. If the product is no longer available, replacement may be made with a
similar product of equal or greater value. To the extent permitted by law and subject
to your non-excludable rights under the Australian Consumer Law (Schedule 2 to
the Competition and Consumer Act 2010 (Cth)) and the New Zealand Consumer
Guarantees Act, which are not limited to a one (1) year period, this is your exclusive
remedy for any breach of this limited warranty or for any other claims otherwise
relating to this limited warranty.
In Australia, our goods come with guarantees that cannot be excluded under the
Australian Consumer Law. You are entitled to a replacement or refund for a major
failure and compensation for any other reasonably foreseeable loss or damage. You
are also entitled to have the goods repaired or replaced if the goods fail to be of
acceptable quality and the failure does not amount to a major failure. The benets
provided under this warranty are in addition to and do not affect purchaser’s statutory
rights under the Australian Consumer Law or other rights at law.
This warranty is valid for the original retail purchaser from the date of initial retail

10
purchase and is not transferable. Please keep your proof of purchase documentation,
such as the original sales receipt or the relevant credit card statement. Proof of
purchase is required to obtain warranty performance. Coleman dealers, Coleman
service centres, or retail stores selling Coleman®products do not have the right to
alter, modify or in any way change the terms and conditions of this warranty. The
warranty is valid only for products that are purchased new and unused in Australia
and New Zealand, from Coleman or Coleman dealers or retailers.
WARRANTY EXCLUSIONS AND LIMITATIONS
THE AUSTRALIAN CONSUMER LAW PROVIDES CONSUMERS WITH CERTAIN
‘CONSUMER GUARANTEES’. THESE GUARANTEES APPLY WHERE THE GOODS
AND SERVICES COLEMAN SUPPLIES TO YOU ARE OF A KIND ORDINARILY
ACQUIRED FOR PERSONAL, DOMESTIC OR HOUSEHOLD USE OR COST LESS
THAN $40,000, AND IN THE CASE OF GOODS, ARE NOT RE-SUPPLIED BY YOU.
NOTHING IN THIS LIMITED WARRANTY EXCLUDES, RESTRICTS OR MODIFIES
RIGHTS WHICH YOU HAVE UNDER THE AUSTRALIAN CONSUMER LAW IN
RESPECT OF THE CONSUMER GUARANTEES AND ALL OF THE PROVISIONS IN
THIS SECTION ARE TO BE READ SUBJECT TO THE AUSTRALIAN CONSUMER
LAW.
This warranty does not cover: (a) normal wear of the product and/or its parts; (b)
parts that are not genuine Coleman®parts, consumables, lost parts and accessories;
(c) damage resulting from any of the following: negligent use or misuse of the
product, commercial use of the product, use contrary to the operating instructions;
disassembly, repair or alteration by anyone other than Coleman or Coleman service
centre, the use of a part other than a genuine Coleman®part; or (d) acts of God, such
as re, ood, hurricanes and tornadoes.
To the extent permitted by the Australian Consumer Law, the Competition and
Consumer Regulation 2010 and the New Zealand Consumer Guarantees Act,
Coleman’s liability is limited, depending on the circumstances, to refund, replacement
or repair of Coleman®products or components.
For the avoidance of doubt, any and all other warranties or conditions which are
not guaranteed by the Australian Consumer Law, the Competition and Consumer
Regulation 2010 and the New Zealand Consumer Guarantees Act and which are not
expressly included in this warranty as additional warranties or conditions are expressly
excluded, including liability for incidental or consequential damages caused by the
breach of any express or implied warranty or condition.
MAKING A WARRANTY CLAIM - RETURN TO COLEMAN FOR REPAIR
Take the product to an authorised Coleman retailer or Coleman service centre as soon
as the warranty claim arises. You may locate the nearest authorised Coleman retailer
or Coleman service centre by visiting www.colemanaustralia.com.au or calling 1800
224 350. Please ensure that you provide a written description of the problem with the
product, together with your contact name, address and telephone number and proof
of purchase.
Subject to the applicable consumer laws in your jurisdiction, you must pay for the
costs of transporting the product, including packaging, freight and insurance costs, to
an authorised Coleman retailer or Coleman service centre for warranty service. If the
warranty claim is substantiated and accepted by Coleman, Coleman will at its cost,
repair or replace any product or parts and return the product to you. Additionally, if the
warranty claim is substantiated and accepted by Coleman, Coleman will reimburse
you for the costs of transporting the product to an authorized Coleman retailer or
Coleman service centre. Coleman reserves the right to seek reimbursement for any
costs and expenses incurred for a warranty claim if the product is found to be in good
working order.
If you have any questions regarding this warranty please call 1800 224 350.
Newell Australia Pty Ltd
Caribbean Park
Level 3, 35 Dalmore Drive
Scoresby, VIC 3179
Australia
Telephone: [phone]
Email: [email protected]
www.colemanaustralia.com.au

4010041866 (ECN20067183-C)
© 2023 The Coleman Company, Inc. All rights reserved. Coleman®, and are
registered trademarks of The Coleman Company, Inc.
Newell Australia Pty Ltd
Caribbean Park
Level 3, 35 Dalmore Drive
Scoresby, VIC 3179
Australia
Telephone: [phone]
Email: [email protected]
www.colemanaustralia.com.au