Copal electronics Pa-870 series User manual

PressureTransducerswithAmp.

INSTRUCTIONMANUAL

Ver.2.0

PA-870/PA-878series

PressureSwitch

PS87

series

HandlingNotesforSafetyuse

CAUTION …ThiscautionmarkdescribeswhenthereisapossibilitythatundermaysufferfromdamageorPhysicaldamage

mayoccuriftheproductisusedimproperly.

Caution

Beforeoperatingourproduct,readthismanualthoroughly. Youmaynotunderstandalloftheexplanationsthefirsttimethorough,butbeonthelookoutfor

anyspecialdirections.



Piping:

Installtheproductbyscrewingthepressureporttothematchingfitting.

Duringthisoperation,putthewrenchonlytothehexagonalportionanddonotgiveanyunnecessaryforcetothemainbodyandtheleadwire.

Wiring:

Theconnectionofwiringisasshowninthetablebelow.



Others:

_Thisproductcanbeusedforliquids/gasescompatiblewithSUS316andHastelloyÑC-22.

`Neverinsertaforeignmattersuchaswirethroughthepressureport.

aNevertakeintheover-pressureexceedingthemaximumpressure.

bNevershort-circuittheswitchoutputtotheotherterminals,norconnectthemtothelowimpedanceloadthatwouldallowtheoutputcurrentover100mA.

Theseconductmightdamagetheinternalcircuitry.

cUseastableDCpowersupplyforthepowersource.Asurgeabsorbingcircuit(diodes,varistor,etc.)isnecessaryifaninductiveloadsuchasarelayor

solenoidisconnectedtothepowerlineand/ortotheswitchoutput(s).TheFGterminalontheunitpowersupplyshouldbeearthed.

（Pleaserefertothefollowingdiagrams）

ThankyouforpurchasingNIDECCOPALELECTRONICS

CORP.product.

In order to use the product correctly and most

appropriately, please completely read this manual before

useandkeepitforfuturereference.

Nishi-ShinjukuKimurayaBidg.,7-5-25

Nishi-ShinjukuShinjuku-kuTokyo160-0023,JapanPhone.：（03）3364-7055

Formoredetailedinformationpleaseaskforthe

nearestdistributororthefollowingsalescenter.

EarthingtoFGterminal

TheterminalFGisgrounded

SurgesbsorbingCircuit

SwitchingPowerSupply PowerLine

Power(+)

Relay

or

Solenoid

ex.Diodes,Varistor

DCoutput

ACinput

＊Nevershort-circuittheswitchoutput(s)totheotherterminals,

norconnect themto thelow impedanceload thatwould allow

theoutputcurrent over100mA. These conductmight damage

theinternalcircuitry.

PA-870 PA-878 PS87

P/N

Wirecolor

Red

Black

White

Green

Gray(Shield)

Power(+)

Common

Analogoutput

None

Fitting

Power(+)

NoConnection

Output

None

Fitting

Power(+)

Power(-)

Switchoutput(+)

Switchoutput(-)

None

1.PARTNUMBERDESIGNATION

2.ACCESSORIES

*Pleaseconfirmthepartnumberoftheproductyoupurchased.

InstructionManual

3.SETTINGMETHODOFSWITCHINGPRESSURE

4.INTERNALELECTRICALSCHEMATICS

①TurntheHysteresissettingVR(ontheleftside)atasuitableangle.

②Applypressureuptothepointwhereswitchoperationisneeded.ThenslowlyturntheVR(ontherightside)totheclockwiseuntiltheLEDturnson.

③ReducepressureandconfirmtheLEDisturnsoff.

Ａ:PartnamePA−870

PA-870:PressureTransducerwithAmp.（Analogvoltageoutput）

PA-878:PressureTransducerwithAmp.（Analogcurrentoutput）

PS87:PressureSwitch

Ｂ:Ratedpressurerange

203P:2［MPa］ 353P:3.5［MPa］ 503P:5［MPa］

＊Note1.203PisnotavailableinPS87series

Ｃ:Drip-proofstructure

B:Withoutdrip-proofcover（IP-54）

H:Withdrip-proofcover（IP-65）

Ｄ:Fitting

R2:R1/4（PT1/4）

PA−870−＊＊＊P−B−R2

ABCD

PA−870 PA−878

PS87

Pressure

Sensor

Main

circuit

Main

circuit

Main

circuit

Pressure

Sensor

Pressure

Sensor

Red:Power(+)DC Red:Power(+)DC

Red:Power(+)DC

White:SwitchOutput(+)

Green:SwitchOutput(-)

Black:Power(-)

Black：N.C.

White:

Output

White:AnalogOutput

Black:Common

Gray(Shield):Fitting Gray(Shield):Fitting

IndicatorLED

Note：NPNOutputApproximation

＋

−

＋

−

＋

−

Directcurrent

Directcurrent Directcurrent

RLRL

5．OUTLINEDIMENSIONS

6.SPECIFICATIONS

5.1 Outlinedimentions 5.2 Drip-proofcovertype

5.3 Rear

Please make sure that the drip-proof cover is properly placed

overthemainbodyandthecable.

（47.5）

15 6.5 26 Label

Housing

（SUS316）

0

−0.4

Pressureport

φ4 2000±20

φ5

R1／4（PT1／4）

（SUS316）

HysteresissettingVR

IndicatorLED

PressuresettingVR

PA−870／PA−878 PS87

Drip-proofcover

6.1 Generalspecifications

Item

Operatingtemp.range

Compensatedtemp.range

Operatinghumidity

Stirangetemp.

Pressuremedium

Cable



Drip-proofstructure

NetWeight

Specifications

-10〜75℃

0〜50℃

35〜85％RH（Nocondensation)

-20〜90℃（

Atmosphericpressure,humidity65%RHmaximum

）

Corrosivegases/liquidscompatiblewithSUS316andHastelloy

C-22



3-coreshieldedcable（PA-870,PA-878）

4-corecable（PS87）

Withoutdrip-proofcover:IP-54,Withdrip-proofcover:IP-65

Approx.190g

6.2 Power

Item

Supplyvoltage

Consumptioncurrent



Specifications

10.8〜26.4VDC

10mAmaximum(PA-870)

15mAmaximum(PS87)

7.WARRANTY

Thisproductiscoveredbywarrantyforaperiodofoneyearfromthedateofdelivery.Thiswarrantyisonlyapplicabletothisproductitself.Thiswarrantycoversfree-of-

chargerepairandreplacementfordefectsoccurringthroughdesignormanufacturinginadequacyofNIDECCOPALELECTRONICSCORP.Evenduringthewarranty

period,thefollowingfailureswillbehandledonafeebasis.

1）Failureordamagesoccurringthroughmisuseordisoperationperformednotfollowingtheinstructionmanual,thecatalogandthespecificationsheet.

2）Failureordamagesoccurringthroughimpropermodification,adjustment,orrepair.

3）Failureordamagesoccurringthroughtechnicallyandscientificallyunpredictablefactors.

4）Replacementofaccessories(e.g.O-ringrubber,etc.)

6.3 Switchoutput（PS87）

Item

No.ofoutputs

Outputinterface

Settingmethod

Adjustablerange

Display

Accuracy

