Cub Crafters CC11-100 Owner's manual

CUB CRAFTERS
CC11-100
Issued: 08/01/06 REPORT SC10000AFM
Date of Revision: 11/23/18 Page Number: 0-i
CUB CRAFTERS, INC.
CC11-100 PILOT’S OPERATING HANDBOOK
AND FLIGHT TRAINING SUPPLEMENT
Airplane Serial Number:
Airplane Registration Number:
This airplane is approved as a special light-sport category
aircraft (S-LSA) as defined by 14CFR§1.1 and meets the
requirements of ASTM consensus standard F2245. This
document must be carried in the airplane at all times.
CUB CRAFTERS, INC.
1918 S 16th Avenue,
Yakima WA. 98903 USA
Website: www.cubcrafters.com
Email: [email protected]

CUB CRAFTERS
CC11-100
REPORT SC10000AFM Issued: 08/01/06
Page Number: 0-ii Date of Revision: 11/23/18
INTENTIONALLY LEFT BLANK

CUB CRAFTERS
CC11-100
Issued: 08/01/06 REPORT SC10000AFM
Date of Revision: 11/23/18 Page Number: 0-iii
WARNING
THIS OPERATING MANUAL IS ONLY VALID FOR USE
WITH THE AIRCRAFT IDENTIFIED ON THE FACE
PAGE. ANY REVISIONS TO THIS MANUAL MUST BE
INSERTED AS APPROPRIATE
NOTE
This document (SC10000AFM) is applicable to
CC11-100 serial numbers CC11-00001 – CC11-00092.

CUB CRAFTERS
CC11-100
REPORT SC10000AFM Issued: 08/01/06
Page Number: 0-iv Date of Revision: 11/23/18
INTENTIONALLY LEFT BLANK

CUB CRAFTERS
CC11-100
Issued: 03/16/06 REPORT SC10000AFM
Date of Revision: 11/23/18 Page Number: 0-1
INTRODUCTION
Welcome to the group of discriminating pilots that truly
enjoy flying and have selected the Sport Cub. It is our
aim at Cub Crafters to ensure that you get the most from
your airplane. This manual has been prepared to provide
you with information about your airplane's equipment,
operating procedures, performance, and suggested care.
It also provides you with contact information for Cub
Crafters to help you contact us at any time. However,
you must do your part and study this manual carefully. It
has been prepared to provide you with information about
your airplane's equipment, operating procedures,
performance, and suggested performance and care.
This POH, which was put in your aircraft at the time of
delivery, is specifically applicable to CC11-100 Serial
Number . To operate the aircraft
legally, it must be kept up to date as new revisions
become available and are sent to you.
In order to send you information in a timely manner, you
must ensure that we have your current address. Please
use the change of address form found in the
Supplements section of this manual. You can also log on
to our website, follow the owner support link and
download the Change of Address/Ownership form. This
will allow us to know send updated information to you as
it becomes available
Our website is:
www.cubcrafters.com

CUB CRAFTERS
CC11-100
REPORT SC10000AFM Issued: 08/01/06
Page Number: 0-2 Date of Revision: 11/23/18
This manual has been prepared in accordance with
consensus standard ASTM F 2746. The Sport Cub has
been shown to comply with consensus standard ASTM F
2245. The airplane must be maintained in accordance
with consensus standard ASTM F 2295, Standard
Practice for Continued Operational Safety Monitoring of a
Light Sport Aircraft. Please note that this standard
describes the responsibilities of the Owner/Operator.
REVISIONS
Whenever revisions are issued, they must be inserted in
the appropriate place in the manual.
A black vertical line along the outside margin of the page
will identify revised text and illustrations. Changes in
spelling, punctuation and formatting will not be marked.

CUB CRAFTERS
CC11-100
Issued: 03/16/06 REPORT SC10000AFM
Date of Revision: 11/23/18 Page Number: 0-3
LOG OF REVISIONS
Current revisions to the CC11-100 Pilot’s Operating
Manual and Flight Manual, Report SC10000AFM.
Revision
Number
Revised
Sections
Description of
Revision
NC
ALL
Manual created as
SC10000AFM.
A
Section 0
Section 2
Revision to Handbook.
Table 2-2 for Oil Pressure
and Oil Temperature
Gauge Markings.
B
Section 0
Section 2
Section 3
Revision to Handbook.
Revised Table 2-2 for Oil
Pressure and Oil
Temperature Gauge
Markings.
Revised all Airspeeds to
IAS.
Revised Maximum
Operating Altitude.
Removed Single Tank
Reference.
Revised Maneuvering
Speed VAto 93 IAS.
C
Section 0
Section 2
Section 4
Section 5
Section 7
Revision to Handbook
Revised Oil Temperature to
240.
Revised wording to
“retract”.
Revised Figure 5-5 for Fuel
Flows.
Revised Figure 5-6 to state
“landing”.
Revised Flap Operation
description.
Added description of Spin-
On Oil Filter Option.

CUB CRAFTERS
CC11-100
REPORT SC10000AFM Issued: 08/01/06
Page Number: 0-4 Date of Revision: 11/23/18
Revision
Number
Revised
Sections
Description of
Revision
D
Section 0
Section 1
Section 2
Section 3
Section 4
Section 5
Section 6
Section 7
Section 8
Revision to Handbook
Revised Introduction
Added Performance
Specifications
Added Stall Speeds.
Removed “cold only” from
Oil Pressure Red Radial
Line.
Corrected Oil Temperature.
Added Max. Weight
Options.
Added “if equipped” to 2.10
and 2.13.
Added Total Fuel Capacity.
Added Operating
Maneuvering Speed for
Floats.
Removed “fully” from 3.3.2.
Added radio frequency to
3.3.4 and 3.3.5.
Revised 3.4.10.
Added Loss of Primary
Instruments.
Added Loss of Flight
Controls.
Added Short and Soft Field
Procedures.
Added NOTE to 4.4.3.10.
Corrected 5.2.3 for
Pressure Altitude.
Corrected Oil Quantity in
6.3.1.
Revised 6.3.2 for Leveling.
Revised 7.5.9 for Fuel
System.
New Section for “Handling
and Servicing”
E
Section 0
Section 3
Section 8
Revision to Handbook
Revised Alternator Failure.
Revised Approved Oils.

CUB CRAFTERS
CC11-100
Issued: 03/16/06 REPORT SC10000AFM
Date of Revision: 11/23/18 Page Number: 0-5
Revision
Number
Revised
Sections
Description of
Revision
F
Section 0
Section 1
Section 2
Section 3
Section 7
Revision to Handbook
Update to Figure 1-1.
Added IMC to 2.11
Corrected Carburetor Heat
Reference.
Revised fiberglass to
composite or composite
materials.
Added AOSS to 7.3.
Removed "Optional" from
7.4.
Added LED Light Option to
7.5.11.
Revised 7.5.12 to Left
Wing.
Revised 7.7.
Added 7.11 - Music Jack
G
Section 0
Section 4
Section 7
Section 8
Revision to Handbook
Added Preflight check for
Front and Rear Seats.
Added Rear Seat Strap
Routing Information.
Removed Wax and Polish
Information.
H
ALL
Renamed Manual to "and
Flight Training
Supplement".
Updated all Sections.
Added Supplements 9.3
and 9.4.
J
Section 3
Section 9
Added 3.3.14 and 3.4.16
for Uncommanded Trim
Actuation
Added Supplement 9.5
K
Section 0
Section 2
Section 4
Revision to Handbook
Revised 2.2 for Window
Operation.
Added Converted Units to
Various Sections.
Added Window Operation
Placard to 2.19.
Revised 4.2 for Converted
Units.

CUB CRAFTERS
CC11-100
REPORT SC10000AFM Issued: 08/01/06
Page Number: 0-6 Date of Revision: 11/23/18
Revision
Number
Revised
Sections
Description of
Revision
K cont
Section 4
Revised 4.3.1.1 Circuit
Breakers Check and Moved
Master Switch.
Revised 4.3.1.2 “Cowling”
to “Cowl”.
Revised 4.3.3.6.1 for
Closed Doors and
Windows.
Revised 4.4.1.1 for Circuit
Breaker Locations.
Revised 4.4.1.3 for
Formatting.
L
Section 0
Section 2
Section 4
Section 7
Section 9.1
Revision to Handbook.
Added Placard to 2.19.
Added Step to 4.3.1.2.
Revised Procedure in
4.4.1.2.
Added Figures to 7.5.9.
Added Seat Caution to 7.6.
Added Step to 9.1.6.4.3.
M
Section 0
Section 1
Section 2
Section 3
Section 4
Section 7
Revision to Handbook.
Added Serial Number
Effectivity
Revised Figure 1-1.
Added Recommended Oil
Qty.
Separated Environmental
Limitations by S-LSA and
E-LSA.
Updated Tank Filler
Placards.
Added Static Port Placard.
Added Recommended Oil
Qty.
Revised Caution
Statement.
Added Recommended Oil
Qty.
Changed Standard Prop to
McCauley 71” x 41”

CUB CRAFTERS
CC11-100
Issued: 08/01/06 REPORT SC10000AFM
Date of Revision: 11/23/18 Page Number: 0-7
List of Effective pages
Rev
Page
Number
Change Date Prepared Checked
NC
All
Initial Issue
08/01/06
A
0-2
2-5
Log of Revisions.
Table 2-2
10/19/07
SJT
GVJ
B
0-2
2-1, 2-2,
& 2-3
2-5
2-7
2-8
3-2
Log of Revisions.
Revised CAS to
IAS.
Table 2-2.
Revised 2.12.
Revised 2.14.
Revised VA from
101 to 93 IAS .
01/28/08
SJT
SJH
C
0-2
2-4
4-26
5-11
5-14
7-5
7-9
Log of Revisions.
Revised Engine
Operating Limits
Oil Temperature
to 240°.
Revised wording
to state “Retract”
flaps.
Revised Figure 5-
5 for Fuel Flow.
Revised wording
to state “Landing”.
Revised
description of flap
operation.
Added description
for Spin-On Oil
Filter Option.
07/31/08
SJH
SJH
D
0-3
0-4
1-1
1-3
2-2
2-5
Log of Revisions
List of Effective
Pages
Revised
Introduction.
Added Summary
of Performance
Specifications.
Added Stall
Speeds.
Removed “Cold
Only” from Oil
Pressure Red
Radial Line.
11/26/08
SJH
SJH

CUB CRAFTERS
CC11-100
REPORT SC10000AFM Issued: 08/01/06
Page Number: 0-8 Date of Revision: 11/23/18
Rev
Page
Number
Change Date Prepared Checked
D
Cont
.
2-5
2-6
2-7
2-8
2-11
3-2
3-4
3-6
and 3-7
3-23
3-26
3-27
4-26
4-27
5-8
6-5
6-6
7-8
8-All
Corrected Oil
Temperature to
240°.
Added Maximum
Weight Options.
Added ‘if
equipped” to 2.10
and 2.13.
Added Total Fuel
Capacity.
Corrected placard
location.
Revised 3.2.
Removed “fully”
from 3.3.2.
Added radio
frequency for
3.3.4 and 3.3.5.
Revised 3.4.10.
Loss of Primary
Instruments.
Added Loss of
Flight Controls.
Added Short Field
Procedures.
Added Soft Field
Procedures.
Added Note to
4.4.3.10.
Corrected
Pressure Altitude.
Revised oil
quantity in 6.3.1.
Corrected
Leveling in 6.3.2.
Revised “Fuel
System” in 7.5.9.
New Section for
“Handling and
Servicing”
11/26/08
E
0-3
0-7
3-11
8-2
Log of Revisions
List of Effective
Pages.
Removed belt
reference.
Revised Oil Types
04/15/09
SJT
SJH

CUB CRAFTERS
CC11-100
Issued: 08/01/06 REPORT SC10000AFM
Date of Revision: 11/23/18 Page Number: 0-9
Rev
Page
Number
Change Date Prepared Checked
F
0-4
0-8
1-4
2-7
3-15
7-1
7-2
7-3
7-4
7-8
7-9
7-10
7-11
Log of Revisions
List of Effective
Pages.
Revised Figure 1-
1.
Added information
to 2.11.
Corrected
Carburetor Heat
reference.
Revised fiberglass
to composite.
Added AOSS.
Removed
"Optional".
Revised fiberglass
to composite
materials.
Added LED Light
Information.
Revised vane
location to left
wing.
Revised 7.7.
Added Music Jack
Information.
04/09/10
SJT
SJH
G
0-4
0-8
4-3
4-16
7-10
8-3
Log of Revisions
List of Effective
Pages.
Revised 4.3.1.1 to
add Front and
Rear Seats.
Revised 4.4.1.1
Added Rear Seat
Strap Routing and
Figure 1.
Removed all wax
and polish
references.
01/31/11
SJT
ECL
H
All
Updated manual
to meet ASTM
F2245.
10/31/11
SJT
ECL
J
0-5
0-9
0-10
3-i—ii
Log of Revisions
List of Effective
Pages
Updated TOC
Updated TOC
03/13/12
AMS
ECL

CUB CRAFTERS
CC11-100
REPORT SC10000AFM Issued: 08/01/06
Page Number: 0-10 Date of Revision: 11/23/18
Rev
Page
Number
Change Date Prepared Checked
J
cont
3-13
3-28
9-0-i
Added 3.3.14
Added 3.4.16
Added
Supplement 9.5
03/13/12
K
0-5 – 0-6
0-10
2-1 – 2-8
2-2
2-14
4-1
4-3
4-4
4-11
4-13
4-14
4-17
4-18
Log of Revisions
List of Effective
Pages
Revised for
converted units.
Added Window
Open Operation.
Added Window
Operation Placard
Revised for
converted units.
Revised Ciruit
Breaker Check.
Revised “Cowling”
to “Cowl”.
Added Circuit
Breakers,
Windows, and
Landing Lights
sections to
4.3.3.1.
Added Doors and
Windows section.
Added Carburetor
Heat section.
Added circuit
breaker location
note.
Added “wing” to
clarify sentence.
08/09/12
AMS
ECL
L
0 ALL
2 ALL
4 ALL
7 ALL
9-1 ALL
As noted in log.
Complete section
re-issued.
As noted in log.
Complete section
re-issued.
As noted in log.
Complete section
re-issued.
As noted in log.
Complete section
re-issued.
As noted in log.
Complete section
re-issued.
04/09/13
AMS

CUB CRAFTERS
CC11-100
Issued: 08/01/06 REPORT SC10000AFM
Date of Revision: 11/23/18 Page Number: 0-11
Rev
Page
Number
Change Date Prepared Checked
M
0-6
0-11
0-iii
1-3
1-4
2-4
2-7
2-12
2-13
3-8
4-4
4-16
7-4
Log of Revisions.
List of Effective
Pages.
Added Serial
Number
Effectivity.
Added Rec. Oil
Qty.
Revised Figure 1-
1.
Added Rec. Oil
Qty.
Separated
Environmental
Limitations by S-
LSA and E-LSA.
Updated Tank
Filler Placard.
Updated Tank
Filler Placard.
Revised Caution
Statement.
Revised Rec. Oil
Qty.
Added Rec. Oil
Qty.
Changed
Standard Prop to
McCauley 71” x
41”.
11/23/18 MH ECL

CUB CRAFTERS
CC11-100
REPORT SC10000AFM Issued: 08/01/06
Page Number: 0-12 Date of Revision: 11/23/18
INTENTIONALLY LEFT BLANK

CUB CRAFTERS
CC11-100
Issued: 08/01/06 REPORT SC10000AFM
Date of Revision: 11/23/18 Page Number: 0-13
TABLE OF CONTENTS
SECTION 1 GENERAL INFORMATION
SECTION 2 LIMITATIONS
SECTION 3 EMERGENCY PROCEDURES
SECTION 4 NORMAL PROCEDURES
SECTION 5 PERFORMANCE
SECTION 6 WEIGHT AND BALANCE
SECTION 7 AIRCRAFT AND SYSTEMS
SECTION 8 HANDLING AND SERVICING
SECTION 9 SUPPLEMENTS
9.1 STRAIGHT AND AMPHIBIOUS
FLOATS
9.2 SINGLE PLACE CONVERSION
9.3 CONVERSION TABLES
9.4 FORMS
9.5 TWO-SWITCH ELEVATOR TRIM
SYSTEM

CUB CRAFTERS
CC11-100
REPORT SC10000AFM Issued: 08/01/06
Page Number: 0-14 Date of Revision: 11/23/18
INTENTIONALLY LEFT BLANK

CUB CRAFTERS SECTION 1
CC11-100 GENERAL INFORMATION
Issued: 08/01/06 REPORT SC10000AFM
Date of Revision: 11/23/18 Page Number: 1-i
TABLE OF CONTENTS
SECTION 1
GENERAL INFORMATION
Paragraph Page
1 GENERAL INFORMATION
1.1 INTRODUCTION......................................... 1-1
1.2 WARNING, CAUTIONS, AND NOTES........ 1-1
1.3 SUMMARY OF PERFORMANCE
SPECIFICATIONS...................................... 1-3

SECTION 1 CUB CRAFTERS
GENERAL INFORMATION CC11-100
REPORT SC10000AFM Issued: 08/01/06
Page Number: 1-ii Date of Revision: 11/23/18
INTENTIONALLY LEFT BLANK