Cumberland Stove Works MF3800 Manual

INSTALLATION AND
SERVICE MANUAL
MF3800
MULTI-FUEL
PARLOR STOVE
OMMF3800IS
Rev. Date 11/17/10
© 2010 Ardisam, Inc.
All Rights Reserved.
For Qualied Installers Only
WARNING
PRIOR TO OPERATION, THIS UNIT
MUST BE INSTALLED PROPERLY. FOR
OPERATION AND MAINTENANCE
PROCEDURES, SEE THE OPERATION
AND MAINTENANCE MANUAL THAT
COMES WITH THE STOVE OR CONTACT
A CERTIFIED DEALER. STOVES SHOULD
BE INSTALLED BY A QUALIFIED
INSTALLATION DEALER.
Please read this entire manual before installation and
using this multi-fuel-burning room heater. Failure
to follow these instructions could result in property
damage, bodily injury or even death.
 

 


 




Check building codes prior to installation.
   

 

 
HOT! DO NOT TOUCH. SEVERE BURNS MAY RESULT.
CLOTHING IGNITION MAY RESULT.
Glass and other surfaces are hot during operation and
cool down.
 
 
 
 
  




• LEAVE THIS MANUAL WITH ANY PARTY RESPONSIBLE FOR
INSTALLATION AND SERVICE.
•This stove should not be used as the only source of heat in the
house. Power outages and periodic maintenance will result in
a total loss of heat.

INSTALLATION
Model MF3800
Page 2 CumberlandStoveWorks.com
FOR QUALIFIED INSTALLERS ONLY
TABLE OF CONTENTS
............................................................................................................................................................................................. 
 .............................................................................................................................................................................................................................................6-7
.......................................................................................................................................................................................................................................... 6
....................................................................................................................................................................................................................................................... 6
................................................................................................................................................................................................................................................................... 7
............................................................................................................................................................................................................................ 7
...................................................................................................................................................................................................................... 8
............................................................................................................................................................................................................................... 9
.......................10
...............................................................................................................................................................................................................................................11
 ........................................................................................................................................................................................................................................... 
.............................................................................................................................................................................................................................................12
.................................................................................................................................................................................................................12
 ........................................................................................................................................................................................................................13
....................................................................................................................................................................................................................................................... 
 .....................................................................................................................................................................................................................................................14
 .................................................................................................................................................................................................................................14
..................................................................................................................................................................................................
..........................................................................................................................................................................................................................................16
 ...............................................................................................................................................................................................................................17
.........................................................................................................................................................................................................18
.............................................................................................................................................................................................. 
 .......................................................................................................................................................................................24
 ..................................................................................................................................................................................24
 ............................................................................................................................................................................... 
.........................................................................................................................................................................................................................................
......................................................................................................................................................................................................................................................26
....................................................................................................................................................................................................................................................27
 ........................................................................................................................................................................................28
...................................................................................................................................................................................................... 
...........................................................................................................................................................................................................................................31
............................................................................................................................................................................................................ 
............................................................................................................................................................................................................................................................. 
...........................................................................................................................................................................................................................................41

Page 3
CumberlandStoveWorks.com
INSTALLATION
Model MF3800
FOR QUALIFIED INSTALLERS ONLY
WARNINGS AND SAFETY PRECAUTIONS
     
   


 



   
  




    
   
     
       



    must 
   
    



      


    

 


     
   


 

      

technician.
    



    

 
    

       


    

    

GAS
OK
SEALANT
      
    
    
      

??
Ash Vac

INSTALLATION
Model MF3800
Page 4 CumberlandStoveWorks.com
FOR QUALIFIED INSTALLERS ONLY
WARNINGS AND SAFETY PRECAUTIONS
 
    
  
    
   

 
  
      
     
reignited.
     
      
   




 
    
 
 
 
 
  


 

MUST BE maintained.
 
  
NOTE: Turning the Mode Switch
to “OFF” does not disconnect all
power to the heater.
     
     
     
    

      

  

    

      


    
     

      
     

    



    

      
     




Manual

Page 5
CumberlandStoveWorks.com
INSTALLATION
Model MF3800
FOR QUALIFIED INSTALLERS ONLY
DO NOT



DO NOT

DO NOT

DO NOT
 

  
 

    




 

  

.
 


•This stove should not be used as the only source
of heat in the house. Power outages and periodic
maintenance will result in a total loss of heat.
CAUTION
 


 


 

 



 

  



in.
 

 


  

 


 
  

WARNINGS AND SAFETY PRECAUTIONS
WARNING
NEVER SHUT THE STOVE DOWN BY LEAVING THE HOPPER
LID OPEN. THIS CAN CAUSE AN UNSAFE CONDITION.
ALWAYS USETHE OFF BUTTONTO SHUT DOWNTHE STOVE.

INSTALLATION
Model MF3800
Page 6 CumberlandStoveWorks.com
FOR QUALIFIED INSTALLERS ONLY
INTRODUCTION
       



 
         

BURNING SOLID FUELS








SHELLED CORN
 Corn must contain less than 14% moisture content.Wet
 


 

Ask for screened corn
only.


 



 



WARNING
NEVER BURN SEED CORN IN THE STOVE. SEED CORN IS
TREATEDWITH CHEMICAL PESTICIDES THAT ARE HARMFUL
OR FATAL IF SWALLOWED. SEED CORN IS DANGEROUS TO
HAVE IN THE HOUSE, ESPECIALLY WHERE CHILDREN CAN
REACH IT.
NEVER BURN “DEER CORN”. IT FREQUENTLY CONTAINS
MOLASSES SUGARS.
DO NOT STORE ITEMS SUCH AS START PELLETS OR BURN
GEL IN PARLOR STOVE OR WITHIN INSTALLED CLEARANCES
OF PARLOR STOVE.
CAUTION
BURNING ONLY CORN WITH THE RECOMMENDED
MOISTURE CONTENT WILL ASSURE LONGER STOVE LIFE
AND LESS FREQUENT CLEANING.
CAUTION
CUMBERLAND STOVE WORKS DOES NOT RECOMMEND
BURNING THE STOVE ON THERMOSTAT MODE, EITHER
LOCAL OR REMOTE, WHEN BURNING CORN OR PELLET
BLENDS. SPENT ASH MATERIALWILL BUILD UP IN THE POT,
INHIBIT THE IGNITOR FUNCTION AND CAUSE A VIOLENT
IGNITION.

Page 7
CumberlandStoveWorks.com
INSTALLATION
Model MF3800
FOR QUALIFIED INSTALLERS ONLY
PELLETS
 



 


   

    



 Wood pellets




 



 Cherry Pits


CAUTION
BURNING WOOD PELLETS ACCORDING TO
RECOMMENDATIONS WILL ENSURE LONGER STOVE LIFE
AND LESS FREQUENT CLEANING.
THE USE OF GRATES OR OTHER METHODS OF SUPPORTING
THE FUEL IS NOT AUTHORIZED IN THIS PARLOR STOVE.
CAUTION
FOLLOW ALL DAILY,WEEKLY ANDMONTHLY MAINTENANCE
RECOMMENDATIONS FOR OPTIMUM PERFORMANCE.
Figure B: High limit reset button in back panel
AUTOMATIC SAFETY FEATURES
POWER OUTAGE


 


OVERHEATING
Over-Fire Protection:
    
 




 


(SEE FIGURE A)

 SEE FIGURE B.
WARNING
IF THE ELECTRICAL POWER FAILS ANY TIME WHEN THE
STOVE IS HOT, KEEP ALL STOVE DOORS CLOSED.
THE AUTOMATIC SAFETY FEATURES MUST NOT BE
BYPASSED.
WHEN RESETTING THE HIGH LIMIT, NEVER USE ANY
CONDUCTORS ASTHIS COULD CAUSE ELECTRICAL SHOCK
AND/OR DAMAGE TO STOVE.

DETAIL A
SCALE 1 : 4
Figure A: Removing panels

INSTALLATION
Model MF3800
Page 8 CumberlandStoveWorks.com
FOR QUALIFIED INSTALLERS ONLY
MAJOR STOVE COMPONENTS



CONTROLLER
HOPPER
POT ROD
HEAT
EXCHANGER
ROD
DOOR
DOOR
HANDLE
ASH PAN
FIREPOT HOLDER
FIRE PLATE
POWER CORD RECEPTICAL
ACCESS PORT FOR REMOTE
THERMOSTAT
COMMUNICATION CABLE PORT
FOR CONTROL KEY PAD
COMMUNICATION
CABLE FOR CONTROL
KEY PAD
AIR FILTER
Notch
CONTROLLER
MOUNT
44
39
41
24
51
17
63
47
32
35
43 37
23
50
10
33 12
29
25
5
40
46
4
11
16
48
14
22
57
53
21
49
1
6
13
8
3
20
28 18
9
52
27
38
7
30
19
15
2
59
62
42
36
65
34
64
39
66
26
FIREPOT

Page 9
CumberlandStoveWorks.com
INSTALLATION
Model MF3800
FOR QUALIFIED INSTALLERS ONLY
UNPACKING AND ASSEMBLY

















MOUNT LEGS
NOTE: Stove can be installed with or without legs. If legless
installation is preferred, you may skip this step.
NOTE: Stove is heavy. Team lifting is recommended.
 
 AS SHOWN
IN FIGURE 1.
NOTE for MOBILE HOME INSTALLATION: If unit is to be
used in a mobile home, you must install the (4) tie-down
straps to the stove now. Refer to page 17 for instructions.
 

MOUNT HANDLE TO HOPPER DOOR
 
      
SEE FIGURE 2.
ASSEMBLE FIREPOT CLEANING ROD
 
       

SEE FIGURE 3.
NOTE: Firepot must seal tight when pushed in.
•  FIGURE 4,

PLUG IN POWER CORD
       
SEE FIGURE 5.
Figure 1: Leg Assembly
Figure 3: Ash Shuttle Rod Assembly
Figure 2: Hopper Door Handle
Assembly


Figure 5: Power Cord Receptacle
Figure 4: Upper bae in
top of rebox


INSTALLATION
Model MF3800
Page 10 CumberlandStoveWorks.com
FOR QUALIFIED INSTALLERS ONLY
MOUNT DOOR



LATCH ADJUSTMENT



SEE
Figure 8.
MOUNTING THE CONTROLLER
  

1. Back of the stove with controller visible:
(FIGURE
6Ahe metal



 
2. Back of the stove with controller hidden:
FIGURE 6B



 
3. Wall mounted FIGURE 8:



Figure 6a: Controller on metal
bracket in back.
Figure 6b: Controller on plastic
bracket in back.
Figure 7: Controller on wall. Figure 8: Door Latch Adjustment.
INSTALLING REMOTE THERMOSTAT






SEE FIGURE 9.


terminals
Figure 9: Remote Thermostat Terminals
PLUG STOVE INTO CONTROLLER

