Data Video PD-1 User manual

PD1
19”RackMountPowerCenter
User’sGuide
http:// www.datavideotek.com
Rev:230506

1
WarningsandPrecautions
1. Readallofthesewarningsandsavethemforlaterreference.
2. Followallwarningsandinstructionsmarkedonthisunit.
3. Unplugthisunitfromthewalloutletbeforecleaning.Donotuseliquidoraerosolcleaners.Usea
dampclothforcleaning.
4. Donotusethisunitinornearwater.
5. Donotplacethisunitonanunstablecart,stand,ortable.Theunitmayfall,causingserious
damage.
6. Slotsandopeningsonthecabinettop,back,andbottomareprovidedforventilation.Toensure
safeandreliableoperationofthisunit,andtoprotectitfromoverheating,donotblockorcover
theseopenings.Donotplacethisunitonabed,sofa,rug,orsimilarsurface,astheventilation
openingsonthebottomofthecabinetwillbeblocked.Thisunitshouldneverbeplacednearor
overaheatregisterorradiator.Thisunitshouldnotbeplacedinabuiltininstallationunless
properventilationisprovided.
7. Thisproductshouldonlybeoperatedfromthetypeofpowersourceindicatedonthemarking
labeloftheACadapter.Ifyouarenotsureofthetypeofpoweravailable,consultyourDatavideo
dealeroryourlocalpowercompany.
8. Donotallowanythingtorestonthepowercord.Donotlocatethisunitwherethepowercordwill
bewalkedon,rolledover,orotherwisestressed.
9. Ifanextensioncordmustbeusedwiththisunit,makesurethatthetotaloftheampereratings
ontheproductspluggedintotheextensioncorddonotexceedtheextensioncord’srating.
10.Makesurethatthetotalamperesofalltheunitsthatarepluggedintoasinglewalloutletdonot
exceed15amperes.
11.Neverpushobjectsofanykindintothisunitthroughthecabinetventilationslots,astheymay
touchdangerousvoltagepointsorshortoutpartsthatcouldresultinriskoffireorelectricshock.
Neverspillliquidofanykindontoorintothisunit.
12.Exceptasspecificallyexplainedelsewhereinthismanual,donotattempttoservicethisproduct
yourself.Openingorremovingcoversthataremarked“DoNotRemove”mayexposeyouto
dangerousvoltagepointsorotherrisks,andwillvoidyourwarranty.Referallserviceissuesto
qualifiedservicepersonnel.
13.Unplugthisproductfromthewalloutletandrefertoqualifiedservicepersonnelunderthe
followingconditions:
a. Whenthepowercordisdamagedorfrayed;
b. Whenliquidhasspilledintotheunit;
c. Whentheproducthasbeenexposedtorainorwater;
d. Whentheproductdoesnotoperatenormallyundernormaloperatingconditions.Adjust
onlythosecontrolsthatarecoveredbytheoperatinginstructionsinthismanual;
improperadjustmentofothercontrolsmayresultindamagetotheunitandmayoften
requireextensiveworkbyaqualifiedtechniciantorestoretheunittonormaloperation;
e. Whentheproducthasbeendroppedorthecabinethasbeendamaged;
f. Whentheproductexhibitsadistinctchangeinperformance,indicatinganeedfor
service.

2
Warranty
Datavideowarrantsthattheequipmentitmanufacturesshallbefreefromdefectsinmaterialand
workmanshipforaperiodof12monthsfromthedateofproductpurchased.Ifequipmentfailsdueto
suchdefects,Datavideowill,atitsoption,repairorprovideareplacementforthedefectivepartor
product.
Equipmentthatfailsafterthewarrantyperiod,hasbeenoperatedorinstalledinamannerotherthan
thatspecifiedbyDatavideo,orhasbeensubjectedtoabuseormodification,willberepairedfortime
andmaterialchargesattheBuyer’sexpense.Thiswarrantydoesnotaffectyourstatutoryrights
withintheCountryofpurchase.
ForEUCustomersonlyWEEEMarking.
Thissymbolontheproductindicatesthatitwillnotbetreatedashouseholdwaste.Itmustbehanded
overtotheapplicabletakebackschemefortherecyclingofelectricalandelectronicequipment.For
moredetailedinformationabouttherecyclingofthisproduct,pleasecontactyourlocalDatavideo
office.
CONTENTS
INTRODUCTION 3
WHAT’SINTHEPACKAGE 3
FRONTPANELCONNECTIONS 4
REARPANELCONNECTIONS 6
DATAVIDEOPRODUCTVOLTAGEREQUIREMENTS 7
SPECIFICATIONS 8
SERVICEANDSUPPORT 9

3
Introduction
ThePD1isa19”RackMountPowerCentre.Itisabletosupplymultiple12Vand
5Vpoweroutputsfroman110V/220VACInput.
ThePD1isanessentialaccessoryforDatavideoMobileStudioapplications,
togetherwiththeSE800switcher,LCD,recorders…thePD1makestheintegration
ofaMobileStudiobecomeeasierandmoreprofessional.Builtintimedelaypower
oncontroltoinitiateeachDCoutputterminalinsequence,andinstalledwithan
autorecoverfuseineveryterminaltosafelyprotecteveryworkingdevice.
SupportsinputpowersourcefromAC110Vor220V(differentmodels)orinputfrom
theDC12V/30Ampinputterminal.
What’sinthePackage
1. PD1mainunit
2. XLR4P(male)to4P(Female)1.2mcablex2
3. 2.1mmDCtoDCPlugto1.2mcablex3
4. 2.1mmDCtoDCPlugto0.8mcablex1
5. 2.1mmDCtoDCPlugto0.7mcablex2
6. 2.1mmDCtoDCPlugto0.5mcablex1
7. 2.1mmDCtoDCPlugto0.3mcablex1
8. ACPowercord.
9. User’sGuide

4
FrontPanel:
On/OffSwitch
PowersthePD1On/OffwhenusingACPower.
N.B.FromDCPowertheOn/OffSwitchisredundant
ACInwithbuiltinfuse
ACInletforconnectingtosuitablemainspoweroutlet–100~120V
or220~240Vaccordingtomodel.Thesocketcontainsafuseholder
fittedwitha10Afuse.
N.B.PleaseensurethatyouusethecorrectACVoltageforthe
PD1thatyouhavepurchased,110Vand220Varedifferent
models–Ifyouareinanydoubtpleasecontactyoursupplieror
yourlocalDatavideoofficelistedatthebackofthismanual.
CoolingFan
ThePD1hastwobuiltincoolingfans,pleaseensurethattheseare
notblocked,andthatsomeairflowisavailable.
SelectInputsource
fromDCorAC
TwobypassACoutputs
Twocoolingfans
External ACinput.
*Note:AC110and220aredifferentmodels
ExternalDC12Volt/30AInput
PowerSwitch

5
ACOutlet110V/240V5A
2xACOutletatsamevoltageasACInput(110~120/220~240V
accordingtomodel)
N.B.SocketsareredundantwhenPD1ispoweredfromDC
DCIn
ThePD1canbepoweredfromasuitable12Vpowersource.When
workingfromDCthePD1willnotregulatethepoweroutlets.
Pleaseensurethatthe12Vpowersourcethatyouuseisregulated.
IfyouintendtorunthePD1fromacarorvanpoweroutletmake
surethatasuitableregulatorisusedonthepowerfeed.
Pin4shouldbewiredpositiveandPin1shouldbeground.
N.B.TheACOutletsarenotactivewhenthePD1ispowered
viatheDCIn.
N.B.TheOn/OffswitchisredundantwhenthePD1ispowered
fromaDCsupply.
InputSelectAC/DC
TheInputselectswitchcanbesettoACorDCaccordingtothe
powerinputthatyouintendtouse.
N.B.DonotconnectACandDCpowerinletsatthesametime.

6
RearPanel:
DCOut5V1A
5V1ADCOutputvia2.1mmInLineSocket(CentrePositive)
DCOut12V2A
2x12V2ADCOutputvia2.1mmInLineSockets(CentrePositive)
DCOut12V4A
4x12V4ADCOutputvia2.1mmInLineSockets(CentrePositive)
2.1mDC5V/1AOutput
2.1mDC12V/2AOutput
2.1mDC12V Jackoutput
x2fortotal4Amaxrating
XLRDC12V+2.1m
DV12V7A Output
XLRDC12V/5AOutput
BypassACOutput
2.1mDC12V/2AOutput
2.1mDC12VJackoutput
x2fortotal4Amaxrating

7
DCOut12V7A
2x12V7ADCOutputs.1x2.1mmInLineSockets(CentrePositive),
and1x4PinXLRSocket(Pin4Positive,Pin1Ground)
DCOut12V5A
1x12V5AOutputvia4PinXLRSocket
(Pin4Positive,Pin1Ground)
ACOutlet1.5A110V/3A240V
ACOutletatsamevoltageasACInput(110~120/220~240V
accordingtomodel)
N.B.SocketisredundantwhenPD1ispoweredfromDC
GroundTerminal
Whenconnectingthisunittoanyothercomponent,makesurethatitis
properlygroundedbyconnectingthisterminaltoanappropriatepoint.
Whenconnecting,usethesocketandbesuretousewirewitha
crosssectionalareaofatleast1.0mm2.
DatavideoProductVoltageRequirements:
ThistableisaguidelineforDatavideoProducts,ifyouareusingproductsfromother
manufacturerspleasechecktheirvoltagerequirementscarefullybeforeconnectingtothe
PD1.
DC5V1A DAC200,DAC100
DC12V2A
BAC03,VP332,DAC15,DAC10,DAC6,DAC5,TLM70D,TLM404,
TLM700,TLM702,TLM350,SE500,DVK100,RMC140,ITC100,
STC100
DC12V4A DN100,CP100,DAC30
DC12V5A MP6000,
DC12V7A SE800,SE800AV

8
Specification:
ITEM Specification
VOLTAGE(AC) 110V,220V–Separatemodels
RANGE 100~120VAC/220~240VAC
FREQ. 50Hz,60Hz
POWER 110V/5A,220V/4A–Separatemodels
VOLTAGE(DC) 12V+/5%
INPUT
POWER 12V300W
VOLTAGE +5V,+12V(dependsondifferentloading
increasevoltagewillsomedecreasing)
RANGE+5V+/3%，+12V+/3%
OUTPUT
CURRENT +5V/1A,+12V/2A,4A,5A,7A
EFFICIENCY >80%
INDICATOR LED
NOISERATIO <1%
OVERLOADPROTECTION YES(AUTORECOVERFUSE)
WORKING
TEMPERATURE
5~45°C
DIMENSION 440mm*214mm*44mm(1Uheight19”rack)
WEIGHT 3.8Kg

9
ServiceandSupport
Itisourgoaltomakeyourproductsownershipasatisfyingexperience.Our
supportingstaffisavailabletoassistyouinsettingupandoperatingyoursystem.
Pleaserefertoourwebsitewww.datavideotek.comforanswerstocommon
questions,supportrequestsorcontactyourlocalofficebelow.
DatavideoCorporation(USA)
12300UEastWashingtonBlvd.,Whittier,CA90606USA
Tel:+15626962324 [e-mail] www.datavideo.us
DatavideoTechnologiesEuropeBV
Californiedreef26  3565BLUtrecht,TheNetherlands
Tel:+31302619656 [e-mail] www.datavideo.info
DatavideoUKLimited
Unit2WatersideBusinessPark,Hadfield,Glossop,DerbyshireSK131BEUK
Tel:+441457851000 [e-mail] www.datavideo.info
DatavideoTechnologiesCo.,Ltd.
10F,176JianYiRd,ChungHoCity,TaipeiHsien,Taiwan235
Tel:+886282272888 [e-mail] www.datavideo.com.tw
DatavideoTechnologiesChinaCo.
2FD,2Lane777,WestGuangzhongRd,ZhabeiDistrict,Shanghai,China
Tel:+862156036599 [e-mail] www.datavideo.cn
DatavideoTechnologies(S)PTELtd.
No.100,Lorong23Geylang,#0103D’CentennialBldg,Singapore388398
Tel:+6567496866 [e-mail] www.datavideo.info
DatavideoHongKongLimited
G/F.,26CrossLane,Wanchai,HK
Tel:+85228331981 [e-mail] www.datavideohk.com