Diamond DA40 NG User manual

DA40 NG
Version 5.2
Handout
DA40 NG Systems

INTENTIONALLY BLANK

1
Diamond DA40 NG
Com
p
iled b
y
Peter Schmidleitner
1
Dimensions
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 2
Dimensions
11,63 m

2
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 3
Dimensions
8,01 m
1,97 m
1,68 m 1,85 with increased MLW
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 4
Dimensions
2,97 m
1,90 m

3
Diamond DA40 NG
Com
p
iled b
y
Peter Schmidleitner
5
Exterior
Com
p
iled b
y
Peter Schmidleitner
DA40 NG
Antenna locations

4
Com
p
iled b
y
Peter Schmidleitner
DA40 NG
ELT and VHF COM 1 Antenna
ELT antenna in fuselage structure
VHF COM 1
Com
p
iled b
y
Peter Schmidleitner
DA40 NG
VHF COM 2 antenna

5
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 9
VHF NAV + GP Antennas
in the horizontal stabilizer
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 10
Marker Antenna
Fuselage belly

6
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 11
GPS antennas
11
Cabin roof
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 12
DME, TXPDR, TAS Antenna
DME
Transponder
TAS

7
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 13
ADF antenna
ADF
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 14
Pitot Probe
Left wing

8
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 15
Static Ports
Both sides of fuselage
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 16
Lift Detector (Stall Warning)
Left wing

9
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 17
Landing/Taxi Light
Left wing
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 18
Engine Oil and Gear Oil

10
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 19
Engine Oil and Gear Oil
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 20
Engine Oil and Gear Oil

11
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 21
Engine Oil
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 22
Gear Oil

12
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 23
Air Inlets
Intercooler
Coolant heat
exchanger
Cabin air heater
and
Reduction Gear cooling
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 24
Air Inlets
Cabin air heater
and
Reduction Gear cooling
Cabin air heater
Reduction Gear cooling

13
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 25
Coolant Radiator Inlet Baffle
Must be installed when OAT at take-off is below -
30°C, but operation with baffle only up to 0°C
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 26
RH frontVentilation
Engine air intake
Air Inlets

14
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 27
LH front Ventilation
Air Inlets
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 28
Air Inlets
Rear Ventilation
May be closed in cold weather with „Ventilation inlet baffle“
With ventilation inlet baffle installed: max OAT for Take-off:
15°C

15
Diamond DA40 NG
Com
p
iled b
y
Peter Schmidleitner
29
Operating Limitations
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 30
Temperature Limitations
Airplane temperature:
Below -20°C:
Pre-heating required for engine (until oil temp. above -
20°C, between -15°C and -10°C recommended) and cockpit
Below -30°C:
Batteries must be pre-heated
Below -40°C:
Operation prohibited
Outside Air Temperature at TKOF:
Below -30°C:
Coolantradiatorinletbafflemustbeinstalled
Above 0°C:
Coolant radiator inlet baffle must be removed
Above 15°C:
Ventilation inlet baffle must be removed
Above 20°C:
Fuel cooler inlet baffle must be removed

16
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 31
Altitude Limitation
Maximum operating altitude:
16.400 ft (5.000 m) Pressure Altitude
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 32
Other Limitations
Aerobatics, spinning, more than
60°bank are prohibited
Canopy and passenger door must
be unlocked during operation
Max. demonstrated crosswind:
25 kts

17
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 33
Other Limitations
No Take-off for Night-VFR or IFR
with an empty main batttery
No engine start with external power
because of an empty main battery if
IFR or Night-VFR flight is planned.
Battery must be charged first.
No IFR flight if seal on the
Emergency Switch is broken
Com
p
iled b
y
Peter Schmidleitner
DA40 NG
Intentionally blank

18
Diamond DA40 NG
Com
p
iled b
y
Peter Schmidleitner
35
Mass
Com
p
iled b
y
Peter Schmidleitner
DA40 NG 36
Mass Option
„574“
Option
„662“
Empty (typical) 900 kg
Max TKOF 1280 kg 1310 kg
Max Ramp + 4 kg
Max LDG 1216 kg 1280 kg
Max ZFW 1200 kg 1265 kg
Min flight 940 kg