Dometic HDC195 User manual

HDC195
Compressor refrigerator
Installation and Operating Manual
EN
REFRIGERATION
COOLMATIC
HDC195-IO-RSA-EN.book Seite 1 Freitag, 17. März 2017 4:20 16

HDC195-IO-RSA-EN.book Seite 2 Freitag, 17. März 2017 4:20 16

EN
HDC195
3
Please read this instruction manual carefully before installation and first
use, and store it in a safe place. If you pass on the product to another
person, hand over this instruction manual along with it.
Table of contents
1 Explanation of symbols. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
2 Safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
3 Scope of delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
4 Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
5 Intended use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
6 Technical description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
7 Installing and connecting the refrigerator . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
8 Using the refrigerator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
9 Cleaning and maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
10 Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
11 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
12 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31
13 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
HDC195-IO-RSA-EN.book Seite 3 Freitag, 17. März 2017 4:20 16

EN
Explanation of symbols HDC195
4
1 Explanation of symbols
D
!
!
A
I
2 Safety instructions
The manufacturer accepts no liability for damage in the following cases:
•Faulty assembly or connection
•Damage to the product resulting from mechanical influences and excess voltage
•Alterations to the product without express permission from the manufacturer
•Use for purposes other than those described in the operating manual
2.1 General safety
!WARNING!
•Have a qualified technician perform the installation in wet rooms.
•Do not operate the device if it is visibly damaged.
•If this device's power cable is damaged, it must be replaced by the
manufacturer, customer service or a similarly qualified person in order
to prevent safety hazards.
DANGER!
Safety instruction: Failure to observe this instruction will cause fatal or
serious injury.
WARNING!
Safety instruction: Failure to observe this instruction can cause fatal or
serious injury.
CAUTION!
Safety instruction: Failure to observe this instruction can lead to injury.
NOTICE!
Failure to observe this instruction can cause material damage and impair
the function of the product.
NOTE
Supplementary information for operating the product.
HDC195-IO-RSA-EN.book Seite 4 Freitag, 17. März 2017 4:20 16

EN
HDC195 Safety instructions
5
•This device may only be repaired by qualified personnel. Inadequate
repairs may cause serious hazards.
•This device can be used by children aged 8 years or over, as well as by
persons with diminished physical, sensory or mental capacities or a
lack of experience and knowledge, providing they are supervised, or
have been taught how to use the device safely and are aware of the
resulting risks.
•Cleaning and user maintenance must not be carried out by children
without supervision.
•Children must be supervised to ensure that they do not play with the
device.
•Always keep and use the device out of the reach of children under
8 years of age.
•Do not store any explosive substances, such as spray cans with
propellants, in the device.
!CAUTION!
•Danger of crushing! Do not put your fingers into the hinge.
•Foodstuff may only be stored in its original packaging or in suitable
containers.
ANOTICE!
•Check that the voltage specification on the type plate is the same as
that of the power supply.
•Never pull the plug out of the socket by the connection cable.
•Disconnect the refrigerator and other electric consumers from the bat-
tery before connecting the quick charging device.
•Disconnect the refrigerator or switch it off when you turn off the
engine. Otherwise you may discharge the battery.
•The refrigerator is not suitable for storing substances which are caustic
or contain solvents.
•Keep the drainage outlet clean at all times.
•Do not open the refrigerant circuit under any circumstances.
•Never transport the device in a horizontal position, so that no oil can
leak out of the compressor.
HDC195-IO-RSA-EN.book Seite 5 Freitag, 17. März 2017 4:20 16

EN
Safety instructions HDC195
6
•Make sure that the refrigerator circuit is not damaged during transpor-
tation. The refrigerant in the refrigerator circuit is highly flammable.
In the event of any damage to the refrigerator circuit:
– Avoid naked flames and sparks.
– Air the room well.
•Set up the device in a dry location where it is protected against splash-
ing water.
2.2 Operating the device safely
DDANGER!
•Do not touch exposed cables with your bare hands.
!CAUTION!
•Before starting the device, ensure that the power supply line and the
plug are dry.
•If you connect the device to a battery, make sure that no food comes
into contact with the battery acid.
ANOTICE!
•Do not use electrical devices inside the cooling device unless they are
recommended by the manufacturer for that purpose.
•Do not place it near naked flames or other heat sources (heaters, direct
sunlight, gas ovens etc.)
•Danger of overheating!
Always ensure sufficient ventilation so that the heat generated during
operation can dissipate. Make sure that the device is sufficiently far
away from walls and other objects so that the air can circulate.
•Ensure that the ventilation vents are not covered.
•Do not fill the inner container with ice or fluid.
•Never immerse the appliance in water.
•Protect the appliance and the cable against heat and moisture.
•Make sure that foodstuffs do not touch the walls of the cooling area.
HDC195-IO-RSA-EN.book Seite 6 Freitag, 17. März 2017 4:20 16

EN
HDC195 Scope of delivery
7
3Scopeofdelivery
4Accessories
Available as accessories (not included in the scope of delivery):
5 Intended use
The HDC195 refrigerator (ref. no. 9105204437) is suitable for refrigerating food-
stuffs and storing frozen foodstuffs.
The device is also suitable for use on boats.
!
Quantity Description
1 Refrigerator
1 Assembly kit for changing the door hinge
1 Operating manual
Description Ref. no.
MPS50 mains adapter 9102600032
MPS80 mains adapter 9102600138
CAUTION! Health hazard!
Please check if the cooling capacity of the device is suitable for storing
the food or medicine you wish to cool.
HDC195-IO-RSA-EN.book Seite 7 Freitag, 17. März 2017 4:20 16

EN
Technical description HDC195
8
6 Technical description
6.1 Function description
The refrigerator is suitable for use with a 12 V or 24 V DC voltage and can therefore
also be used e.g. for camping or on boats.
When used on boats the refrigerator can be subjected to a constant inclination
of 30°.
The refrigerator can chill products at 0 °C to +10 °C and keep them cool. In the
freezer compartment, frozen items can be stored at –18 °C to 0 °C. You can use the
adjustable temperature control to set the desired temperature.
All materials used in the refrigerator are compatible for use with foodstuffs.
The refrigerant circuit is maintenance-free.
6.2 Control elements
5
6
8
7
9
10
1
2
4
3
1
HDC195-IO-RSA-EN.book Seite 8 Freitag, 17. März 2017 4:20 16

EN
HDC195 Installing and connecting the refrigerator
9
7 Installing and connecting the
refrigerator
Please note the following instructions for installation on boats:
D
A
No. Description
1 Freezer compartment
2 Rack shelf
3Shelf
4 Fruit and vegetable compartment
5 Type plate (inside)
6Bottleholder
7 Door compartment
8 Butter and cheese compartment
9 Temperature control
10 Inner lighting
DANGER!
If the device is powered by the mains, ensure that the power supply has
a residual current circuit breaker.
NOTICE!
The device can be tilted sideways up to 30°. When setting up the refrig-
erator, note that it must be fastened to take account of this. If you have
any questions regarding installation, consult your specialist dealer.
HDC195-IO-RSA-EN.book Seite 9 Freitag, 17. März 2017 4:20 16

EN
Installing and connecting the refrigerator HDC195
10
7.1 Changing the door hinge
You can also change the hinge of the door, so that it opens to the left rather than the
right.
➤Proceed as shown in the illustrations (fig. 2, page 10 to fig. 0, page 18).
1.
2.
2
HDC195-IO-RSA-EN.book Seite 10 Freitag, 17. März 2017 4:20 16