Dragonfly Rio Mobility User manual

Manual Handcycle
User Manual
Rio Mobility
Phone: [phone]
Email: [email protected]
Website: www.riomobility.com

IMPORTANT!
Consult with your health care professional to determine if the DragonflyTM
is appropriate for you.
DO NOT OPERATE THIS EQUIPMENT WITHOUT FIRST
READING AND UNDERSTANDING THIS MANUAL.
IT IS RECOMMENDED THAT INITIAL SETUP OF THIS
HANDCYCLE BE PERFORMED BY A QUALIFIED
TECHNICIAN, SUCH AS A WHEELCHAIR OR BICYCLE
MECHANIC.
AS WITH ANY THREE-WHEELED VEHICLE, SIDE-TO-SIDE
STABILITY IS DECREASED COMPARED TO A WHEELCHAIR
ALONE, SO USE CAUTION WHEN TURNING AT HIGH SPEEDS.
Follow the recommendations in your wheelchair manual.
The Dragonfly
TM
The operation of a handcycle involves a certain level of risk and the potential for serious
bodily injury.
is intended for use for mobility in sporting and/or recreational purposes only and
is not intended as an exclusive means of mobility. Check local vehicle/wheelchair regulations.

2
1. Wheelchair Requirements
The DragonflyTM is compatible with almost all wheelchairs without the need for any special
adapters.
Wheelchair
Frame
Configuration
For a complete listing of compatible wheelchairs, visit
riomobility.com. If your wheelchair is not listed, please contact
customer service at [e-mail].
The DragonflyTM can accommodate chairs of seat width 35.5 cm-
55.8 cm / 14 inches-22 inches. If your chair falls outside this range,
contact customer service.
Wheelchair
Frame Tube
Diameter
The frame tube diameter must be either:
22.2 mm / 7/8 inch, 25.4mm / 1 inch, 28.6mm / 1.125 inch
30.5mm / 1.2 inch, or 31.8mm / 1.25 inch
If your tubing is a different shape or diameter contact
[e-mail]
If you do not know the diameter of your tubing, contact your
wheelchair manufacturer or dealer, or cut out the ruler printed below
to measure. Wrap the ruler around your tubing and note where the
markings line up.
Anti-Tips
and
Seatbelts
When seated in the wheelchair, your center of gravity must be
far enough forward to prevent tipping backwards. IMPORTANT:
If the chair is set up such that “wheelies” are easy, it may be too
unstable to attach or detach the handcycle. Anti-tips MUST be
installed on your wheelchair. A seat belt is also strongly
recommended.
Weight
Combined wheelchair and user weight must be less than 130kg/280lb.
S
T
A
R
T
H
E
R
E
1
”
RULER MUST BE PRINTED AT 100%
NO SCALING - RULER IS 6”(152mm) LONG CUT
ALONG DASHED LINE
AND WRAP AROUND TUBE, check with a ruler
1 1/8”
FRAME MUST BE STRAIGHT
1.2”FOR WIDTH OF RULER
1 1/4”
7/8”

2. Installing The Dragonfly
Visit www.riomobility.com for the Dragonfly installation video:
The installation of the clamp and frame system for the Dragonfly is the same as the Firefly.
The handcranks can be moved to the closest position, like the handlebars on the Firefly.
Set handcranks so that your arms are slightly bent, not locked and it clears your legs on the
downstroke.
HAND GRIP
CRANK HEIGHT
ADJUSTMENT COLLAR
CRANK
COUPLER
FRAME ADJUSTMENT SCREWS
DERAILER
FRAME QUICK
RELEASE PIN
PINS & CLAMPS

3. Controls
V - BRAKE AND
SHIFTER LEVERS
DISC BRAKE LEVER
REMOVABLE HANDLES

4. Maintenance
Inspection / Maintenance Item
Initially
Weekly
6 Months
Check and Tighten Hardware
✓
✓
✓
Brake Pad Wear
✓
All screws must be tightened using a torque limiter wrench (included in packaging).
Clean the handcycle with a damp cloth. Do not soak or spray with water or use detergent.
Lubricate as necessary after cleaning.
Immediately replace any damaged, missing, or badly worn parts with manufacturer or
approved parts. Please contact your dealer or [e-mail] for information on
replacement parts.
We recommend keeping the box your DragonflyTM was shipped in; it makes a handy container
for storage of your handcycle, your handcycle accessories, the included tools, and the manual
for storage and travel. It can also be used to ship the unit to the factory in case of maintenance
or warranty repairs.

5. Troubleshooting
When climbing a hill, the front wheel slips.
The front wheel is too far forward of your center of gravity. Please adjust the handcycle so that
the front wheel is as close as possible to the footrest without interfering while driving
straight or turning. If possible, you may also want to move the rear axles further back.
When climbing hills, leaning forward in your chair may be necessary.
Check that the front caster wheels are at least 5 cm/ 2 inches off the ground when the
handcycle is installed.

6. Safety
Safety Checklist
▫A helmet and safety belt are recommended.
▫ALWAYS engage the wheel locks on your wheelchair before attaching or
detaching the handcycle.
▫ALWAYS check to make sure that your latches are fully engaged before
operating your handcycle.
▫Check to make sure all nuts and bolts are tight and all latches are secured.
▫Make sure the hand brakes work properly before riding your handcycle.
▫Do not add any parts or accessories not authorized by Rio Mobility to your
handcycle. Any addition could be unsafe and will void your warranty.
Before You Ride
Make sure that your DragonflyTM is installed, adjusted, and maintained properly. Do not use
the DragonflyTM until you and your health care professional determine that you have the
ability to use it safely in an uncontrolled environment.
Use your wheelchair as described in your wheelchair manual and use the DragonflyTM in
the same safe manner that you would a wheelchair with pushrims. Follow all additional
warnings and instructions for the DragonflyTM in this manual.
Outdoor Use
Always watch out for traffic and pedestrians when riding on the road and sidewalk and follow
all traffic regulations. Follow any and all local regulations that apply to this device.
Turning Stability
Always mind your speed, especially when turning. You should have full control of your
wheelchair at all times. Do not exceed the maximum allowable speed recommended by your
wheelchair manufacturer.
Three-wheeled vehicles are less stable in turns compared to wheelchairs alone, so be
careful to keep all three wheels on the ground and moderate your speed when approaching
curves.
Be careful when reaching and leaning left or right from your wheelchair with your handcycle
attached —the longer wheelbase makes it less stable in sideways leans than your regular
wheelchair. Narrow wheelchairs are less stable in general, so be extra careful if your
wheelchair is particularly narrow.

Obstacles
Be careful going over bumps and curbs over 2 inches (50mm) high. Your front casters may
contact these surfaces, causing a loss of control. Use your pushrims to get over bumps, NOT
the handcycle. You should approach bumps and curbs straight on and at low speed to avoid
i n j u r y o r damage to your wheelchair. Your return spring should keep the front wheel
straight, freeing up your hands for the pushrims. Be aware of road surfaces, especially on
inclines and declines. Watch out for water, ice, and oil film.
Transferring
DO NOT attempt to transfer into or out of your chair with the Dragonfly
TM
attached. You
MUST detach the handcycle before transferring.
General Notes & Precautions
Mind your fingers and hands when using your handcycle.
Keep children away from your handcycle to avoid
possible injury to both you and the child.
Do not carry anything that obstructs your view or
interferes with the handlebar operation.
Do not put weight on the wings (objects or people).
Rio Mobility is not responsible for any damage or injury
due to misuse of your handcycle.
This handcycle is meant for everyday recreational or
general sporting use and is not intended for use in competition.

7. Limited Warranty
Rio Mobility warrants the DragonflyTM for one (1) year from the date of initial consumer
purchase. This warranty covers any defects in materials and workmanship.
This warranty is only available for the original owner or purchaser and is non-
transferable.
Limitations
This warranty is VOID if:
•Assembly and installation is not performed according to the instructions
•Preventative and routine maintenance has not been performed
•The serial number is removed or altered
•The handcycle is used in any competitive event
•The handcycle is used in stunt riding, jumping, or similar activity
•The handcycle is submerged in or sprayed with water; includes accidental
exposure such as rain (applies mainly to electrical parts)
•The handcycle is used in a manner contrary to the instructions outlined in
the Owner’s Manual
•Any modifications are made to the device.
Please contact your dealer for installation, service, or warranty
needs.