EARDATEK KINGSAT Z3 Original operating instructions

www.eardatek.com
4G Antenna Z3/Z6
Quick Installation

Contents
Installation
Appendix
Preparation for Installation
Antenna Installation Site
Material Check
1
3
Step 1 Mounting Antenna
Step 2 SIM Card Installation
Step 3 Connection Diagram
Step 4 Z3 Antenna Connection
Step 5 Z6 Antenna Connection
Step 6 Indoor Unit Connection
Step 7 Surf Internet
1-Network Troubleshooting
2-Radome Dimension
3-Specification-Z3
4-Specification-Z6
4
5
6
7
8
9
10
11
15
16
17
www.eardatek.com

Check mounting mast site. The optimized site has
(1) Minimum vibration(better far from engine).
(2) Free of obstruction(better far from boom on dock).
(3) Keep safe distance to Radar or other RF transmitter(avoid fan beam ±15° of Radar, keep distance
to Radar minimum 3m).
15°
Radar
Minimum 3M
15°
www.eardatek.com
1
Antenna Installation Site

The following installation cases are the optimal sites.
www.eardatek.com
2
Antenna Installation Site

Unpack the carton and check whether the materials in the carton are matched with Material
Check List.
www.eardatek.com
3
Material Check
Material Check List
POE Adapter

www.eardatek.com
4
Mounting antenna with below accessories on the pedestal of mast.
Step 1 Mounting antenna
M8 Flat Washer
M8 Spring Washer
M8 Hex Nut
M8 Flat Washer M8 Spring Washer M8 Hex Nut
M8 Bolt from Antenna Pedestal

www.eardatek.com
5
Step 1. Unscrew six screws of the radome and take off the radome.
Step 2. Insert the activated SIM card into the 4G router card slot(Pay attention to the direction of
SIM card while inserting).
Step 2 SIM Card Installation

www.eardatek.com
6
The cable connection of the 4G antenna is as follows:
Step 1. Connect the 4G antenna and POE adapter with 20m network cable.
Step 2. Connect the POE adapter and PC / router with 1m network cable.
Step 3 Connection Diagram
Outdoor Unit Indoor Unit
Router（Not supplied)POE adapter（12V 1A）
4G Antenna
20m Network Cable（black） 1m Network Cable(yellow）
POE LAN

www.eardatek.com
7
Z3 Antenna Connection Step
Step 1 FIG 1, from the hole of base plate, insert RJ45 connector of 20m network cable into radome.
Step 2 FIG 2&3&4, secure RJ45 connector and waterproof connector as below shows.
Step 3 FIG 5&6, fastern the connector on base plate with cable ties.
Step 4 Z3 Antenna Connection
FIG 1 FIG 2 FIG 3
FIG 4 FIG 5
Z3 Antenna Connection Diagram
FIG 6

www.eardatek.com
8
FIG 1
FIG 2
FIG 3 FIG 4
Z6 Antenna Connection Diagram
Z6 Antenna Connection Step
Step 1 FIG 1, RJ45 connector insert through water proof connector.
Step 2 FIG 2&3&4, secure RJ45 connector and waterproof connector as below shows.
Step 5 Z6 Antenna Connection

Indoor Unit Connection Step
Step 1 Connect RJ45 of 20m network cable to POE port of POE adapter.
Step 2 LAN port is for local network. You can connect to PC or router for testing.
Step 6 Indoor Unit Connection www.eardatek.com
9

www.eardatek.com
10
Step 7 Surf Internet
HOW to test?
Wireless
Default SSID: KINGSAT_4G_WIFI
Default WIFI password: 4G12345678
Wired
1. PC/Laptop directly connects to LAN of POE adapter.
2. Or use WIFI router for signal coverage of below deck room.

www.eardatek.com
11
If CAN'T access network , please follow below steps.
Step 1. Access 4G router to check router status.
4G router default IP: 192.168.88.1
Default password: 4G12345678
Appendix 1 Network Troubleshooting

www.eardatek.com
12
Step 2. Check 4G network status of router.
FIG1 shows NORMAL, working well. FIG2 shows ABNORMAL, means no signal or bad signal or SIM
card out of service.
FIG 1 FIG 2
Appendix 1 Network Troubleshooting

www.eardatek.com
13
CASE 1
If speed of 4G router shows 0bps, what does it mean?
In this case, firstly check SIM card service if it is out of charge.
Appendix 1 Network Troubleshooting

14
CASE 2
If 4G signal goes weak, it will show as below. How can we do ?
In this case, vessel is sailing out of signal coverage. Signal is too weak to setup link. So 4G signal
come back stronger , 4G router will automatically work to access internet.
www.eardatek.com
Appendix 1 Network Troubleshooting

405mm
841.5mm
200mm
200mm
Z3 Radome Dimension Z6 Radome Dimension
780mm
305mm
800mm
305mm
www.eardatek.com
15
Appendix 2 Radome Dimension

www.eardatek.com
Appendix 3 Specification-Z3
16
Radome Material: ASA
Mechanical Specification
Electrical Performance
4G Router parameters
Radome Size:
Frequency Range: 698-960Mhz/1710-2700Mhz
H:360° / (65°X6 Omnidirectional)
E:12° ±2°
Beamwidth:
Roundness:
VSWR:
Input Resistance:
Low Band≥7dBi & high Band≥5dBi
Gain:
50Ω
Lightning Protection: DC ground
Connector Type: N Type
Polarization: Vertical
Theoretical bandwidth:
WIFI:
LAN Port:
SIM Card Port: Only supports micro-SIM(3FF)(Provide Cato)
POE Power Adapter: AC110-220V to POE Adaptor
Output 24V/1A
LTE CAT4 standard speed 150MHz max
Working Environment
Operating Temperature : -22°~+55°
Humidity: Up to 95%@40°C
Wind Speed: 60 m/sec max from any direction
Waterproof: IP65
Storage Temperature: -30°~+85
≤2/≤1.7
Third-order Intercept: ≤ 107dBm(2x33dBm)
Weight:
Antenna Type:
Radome Color: White
4G cluster omnidirectional antenna
16.5Kg(Includes 4G router&20m network cable)
41 X 42 cm (16” X 16.5”)
IEEE 802.11a/b/g/n/ac WLAN speed 1.2Gbs max
±3dB
1 access indoor
LTE Category:
LTE FDD Bands:
3G Bands:
3GPP Release 11, LTE CAT7(300Mbps/100Mbps)
B1/B3/B7/B8/B20/B28/B32/B38
B1/B8

www.eardatek.com
Appendix 4 Specification-Z6
17
Radome Material: ASA
Mechanical Specification
Electrical Performance
4G Router parameters
Radome Size:
Frequency Range: 698-960Mhz/1710-2700Mhz
H:360° / 360°
E:20° / 32°
Beamwidth:
Roundness:
VSWR:
Input Resistance:
LTE Category:
LTE FDD Bands:
3G Bands:
Low Band≥7dBi & high Band≥5dBi
Gain:
50Ω
Lightning Protection: DC ground
Connector Type: N Type
Polarization: Vertical
3GPP Release 11, LTE CAT7(300Mbps/100Mbps)
B1/B3/B7/B8/B20/B28/B32/B38
B1/B8
Theoretical bandwidth:
WIFI:
LAN Port:
SIM Card Port: Only supports micro-SIM(3FF)(Provide Cato)
POE Power Adapter: AC110-220V to POE Adaptor
Output 24V/1A
LTE CAT4 standard speed 150MHz max
Working Environment
Operating Temperature : -22°~+55°
Humidity: Up to 95%@40°C
Wind Speed: 60 m/sec max from any direction
Waterproof: IP65
Storage Temperature: -30°~+85
≤2/≤1.7
Third-order Intercept: ≤ 107dBm(2x33dBm)
Weight:
Antenna Type:
Radome Color: White
4G cluster omnidirectional antenna
38Kg(Includes 4G router&20m network cable)
78 X 80 cm (31” X 31.5”)
IEEE 802.11a/b/g/n/ac WLAN speed 1.2Gbs max
±3dB
1 access indoor