Empire PIONEER LPR(18 User manual

35988-0-0615 Page 1
INSTALLATION
INSTRUCTIONS
IMPORTANT! Read these instructions carefully
before installing or operating this gas appli-
ance. These instructions should be left with the
homeowner for future reference.
WARNING: If the information in this manual
LVQRWIROORZHGH[DFWO\D¿UHRUH[SORVLRQ
may result causing property damage, per-
sonal injury or loss of life.
WARNING: This log set is to be installed only
LQDVROLGIXHOEXUQLQJ¿UHSODFHZLWKDZRUNLQJ
ÀXHFRQVWUXFWHGRIQRQFRPEXVWLEOHPDWHULDO
The vent damper must also have a damper
FODPSDWWDFKHGWRLWWRNHHSWKHGDPSHUIURP
accidentally closing during operation.
PIONEER
VENTED DECORATIVE GAS LOG SET
MODELS
LPR(18,24,30)-1
For use on burner models:
BX(R,M)(18,24,30)N-1
CONGRATULATIONS on the purchase
of your new DECORATIVE VENTED GAS
LOG SET! Your Decorative Gas Log Set is
designed and intended for installation in
an approved, existing, fully vented, wood-
EXUQLQJ¿UHSODFHZLWKDJDVKRRNXS
2QFH\RXSODFHWKHEULFNULVHUDQGEDVH
logs, you are free to arrange the remaining
logs to suit your taste and even re-arrange
them from time to time to suit your whimsy.
The log placement shown in this manual
replicates the set-up shown in the brochure
DQGSURYLGHVDJUHDWÀDPHSDWWHUQ
LPR30-1 Logs shown on BX30

35988-0-0615Page 2
LOG A - Rear Log
Part No. R12198
LOG B - Curvy Y Log
Part No. R12182
LOG C - Forked Log
Part No. R12191
LOG D - Y Branch
Part No. R12181
LOG E - Small Knotted Log
Part No. R12195
LOG F - Curved Branch
Part No. R12187
LOG G - O Log
Part No. R12196
LOG H - Small Charred Log
Part No. R12197
LOG I - Straight Log
Part No. R12184
Note: Logs are not shown to scale.
Note: Logs may differ from those shown.
LPR18-1 LOG IDENTIFICATION

35988-0-0615 Page 3
LPR18-1 LOG PLACEMENT
1. Attention: The placement of the logs in this step is mandatory. Place Logs Athrough C as shown.
A
C
B
2. Empire recommends placing the remaining logs as shown. However, placement of Logs D through H is at the discretion of the
homeowner.
A
B
C
D
E
F
G
H
Lo
g
A is behind Lo
g
B and under Lo
g
C.

35988-0-0615Page 4
LPR24-1 LOG IDENTIFICATION
LOG A - Rear Log
Part No. R12199
LOG B - Forked Log
Part No. R12191
LOG C - Left Log
Part No. R12190
LOG D - Y Branch
Part No. R12181
LOG E - Curvy Y Log
Part No. R12182
LOG F - Large Knotted Log
Part No. R12188
LOG G - Short Y Log
Part No. R12183
LOG H - Straight Log
Part No. R12184

35988-0-0615 Page 5
LOG I - Curved Branch
Part No. R12187
LOG J - O Log
Part No. R12196
LOG K - Small Charred Log
Part No. R12197
LOG L - Small Knotted Log
Part No. R12195
Note: Logs are not shown to scale.
Note: Logs may differ from those shown.
LPR24-1 LOG IDENTIFICATION

35988-0-0615Page 6
LPR24-1 LOG PLACEMENT
1. Attention: The placement of the logs in this step is mandatory. Place Logs A and B as shown.
B
A
2. Attention: The placement of the logs in this step is mandatory. Place Logs C through E as shown.
E
A
C
DB

35988-0-0615 Page 7
3. Empire recommends placing the remaining logs as shown. However, placement of Logs F through L is at the discretion of the
homeowner.
AF
G
H
B
C
D
E
I
J
K
L
LPR24-1 LOG PLACEMENT

35988-0-0615Page 8
LPR30-1 LOG IDENTIFICATION
LOG A - Rear Log
Part No. R12194
LOG B - Curvy Y Log
Part No. R12182
LOG C - Left Log
Part No. R12190
LOG D - Forked Log
Part No. R12191
LOG E - Pegged Y Log
Part No. R12186
LOG F - Short Y Log
Part No. R12183
LOG G - Y Branch
Part No. RR12181
LOG H - Curved Branch
Part No. R12187
LOG I - Small Knotted Log
Part No. R12195

35988-0-0615 Page 9
LPR30-1 LOG IDENTIFICATION
LOG J - Small Charred Log
Part No. R12197
LOG K - O Log
Part No. R12196
LOG L - Large Knotted Log
Part No. R12188
LOG M - Straight Log
Part No. R12184
Note: Logs are not shown to scale.
Note: Logs may differ from those shown.

35988-0-0615Page 10
LPR30-1 LOG PLACEMENT
1. Attention: The placement of the logs in this step is mandatory. Place Logs A through E and as shown.
D
E
A
B
C
2. Empire recommends placing the remaining logs as shown. However, placement of Logs F through M is at the discretion of the
homeowner.
G
A
B
C
D
EF
H
I
J
K

35988-0-0615 Page 11
To Order Parts Under Warranty, please contact your local Empire dealer. See the dealer locator at www.empirecomfort.
com. To provide warranty service, your dealer will need your name and address, purchase date and serial number, and the
nature of the problem with the unit.
To Order Parts After the Warranty Period, please contact your dealer or one of the Master Parts Distributors listed below.
This list changes from time to time. For the current list, please click on the Master Parts button at www.empirecomfort.com.
Please note: Master Parts Distributors are independent businesses that stock the most commonly ordered Original
Equipment repair parts for Heaters, Grills, and Fireplaces manufactured by Empire Comfort Systems Inc.
MASTER PARTS DISTRIBUTOR LIST
Parts Not Under Warranty
Parts can be ordered through your Service Person, Dealer, or a Master Parts Distributor. See this page for the Master Parts Distribu-
tors list. For best results, the service person or dealer should order parts through the distributor. Parts can be shipped directly to the
service person/dealer.
Warranty Parts
Warranty parts will need a proof of purchase and can be ordered by your Service Person or Dealer. Proof of purchase is required for
warranty parts.
$OOSDUWVOLVWHGLQWKH3DUWV/LVWKDYHD3DUW1XPEHU:KHQRUGHULQJSDUWV¿UVWREWDLQWKH0RGHO1XPEHUDQG6HULDO1XPEHUIURPWKH
name plate on your equipment. Then determine the Part Number (not the Index Number) and the Description of each part from the fol-
lowing illustration and part list. Be sure to give all this information . . .
Appliance Model Number Part Description
Appliance Serial Number Part Number
Type of Gas (Propane or Natural)
Do not order bolts, screws, washers or nuts. They are standard hardware items and can be purchased at any local hardware store.
6KLSPHQWVFRQWLQJHQWXSRQVWULNHV¿UHVDQGDOOFDXVHVEH\RQGRXUFRQWURO
HOW TO ORDER REPAIR PARTS
Dey Distributing
1401 Willow Lake Boulevard
Vadnais Heights, MN 55101
Phone: [phone]
Toll Free: 800-397-1339
Website: www.deydistributing.com
Parts: Heater, Hearth and Grills
Victor Division of F. W. Webb Company
200 Locust Street
Hartford, CT 06114
Phone: [phone]
Toll Free: 800-243-9360
Fax: [phone]
Toll Free Fax: [phone]
Websites: www.fwwebb.com & www.victormfg.com
Parts: Heater, Hearth and Grills
East Coast Energy Products
10 East Route 36
West Long Branch, NJ 07764
Phone: [phone]
Toll Free: 800-755-8809
Fax: [phone]
Website: www.eastcoastenergy.com
Parts: Heater, Hearth and Grills

35988-0-0615Page 12
Empire Comfort Systems Inc.
918 Freeburg Ave. Belleville, IL 62220
If you have a general question about our products, please e-mail us at
[email protected].
If you have a service or repair question, please contact your dealer.
www.empirecomfort.com