EXPERT GRILL XGS236178263003 User manual

Table of Contents
Important Safeguard s.................... Page 2
Expanded View & Hardware .............. 6 & 7
Assembly Instructions........................ 8
Operating Instructions....................... 11
Cleaning and Care ......................... 13
Limited Warranty .......................... 15
Troubleshooting ........................... 16
The use and installation must conform with local
codes or, in the absence of local codes, with either the
National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural
Gas and Propane Installation Code, CSA B149.1, or
Propane Storage and Handling Code, B149.2, or the
Standard for Recreational Vehicles, ANSI A 119.2/NFPA
1192, and CSA Z240 RV Series, Recreational Vehicle
Code, as applicable.
THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT
SAFETY INFORMATION. PLEASE READ AND KEEP FOR
FUTURE REFERENCE.
If you are assembling this unit for someone else, give
this manual to him or her to read and save for future
reference.
OWNER’SOWNER’S MANUALMANUAL
Outdoor LP Gas Barbecue Grill
Model No. XGS236178263003 / GBT2210WModel No. XGS236178263003 / GBT2210W
WARNING
FOR YOUR SAFETY:
1. Do NOT store or use gasoline or
other flammable liquids or vapors in
the vicinity of this or any other
appliance.
2. An LP cylinder not connected for
use shall not be stored in the vicinity
of this or any other appliance.
DANGER
Do not leave this appliance
unattended, especially cooking the
fatty meat and close lid too long time.
Failure to follow the dangers,
warnings and cautions in this manual
may result in serious bodily injury
or death, or in a fire or an explosion
causing damage to property.
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only! (outside any enclosure)
DANGER
If you smell gas:
1. Shut off gas to appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from
the appliance and immediately
call your fire department. Failure
to follow these instructions could
result in fire or explosion which
could cause property damage,
personal injury or death.
GBT2210W-OM-E-F100
Walmart call center:
Service hours 7 days/week, 7:00 AM - 9:00 PM CST
Contact number: 1-833-908-2026
Manufactured in China for:
RevoAce Inc. Limited / Hong Kong, China

2
FOR YOUR SAFETY
WWARNINGS:
1. Improper installation, adjustment, alteration, service or maintenance can
cause injury or property damage.
2. Read the installation, operation, and maintenance instructions thoroughly
before installing or servicing this equipment.
3. Failure to follow these instructions could result in fire or explosion, which
could cause property damage, personal injury, or death.
4. This instruction manual contains Important information necessary for the
proper assembly and safe use of the appliance.
5. Read and follow all warnings and instructions before assembling and using
the appliance.
6. Follow all warnings and instructions when using the appliance.
7. Keep this manual for future reference.
IMPORTANT SAFEGUARDS
Failure to follow these istructions could result in fire or explosion which
could cause property damage, personal injury or death.
WThis grill is for outdoor use only, and should not be used in a building, garage or any other enclosed area.
WDo NOT operate, light or use this appliance within ten feet (3.05 m) of walls, structures or buildings.
WFor residential use only. This grill is NOT for commercial use.
WThis grill is not intended for and should never be used as a heater. TOXIC fumes can accumulate and cause
asphyxiation.
WThis grill is safety certified for use in the United States and/or Canada only. Do NOT modify for use in any
other location. Modification will result in a safety hazard and will void your warranty.
WThis grill is for use with liquid propane (LP) gas only. The conversion to or attempted use of natural gas in
this LP gas grill is dangerous, may cause bodily harm and will void your warranty.
WLP gas characteristics:
a. LP gas is flammable and hazardous if handled improperly. Become aware of the characteristics before
using any LP gas product.
b. LP gas is explosive under pressure, heavier than air, and settles/pools in low areas.
c. LP gas in its natural state has no odor. For your safety, an odorant is added that smells like rotten
cabbage.
d. Contact with LP gas can cause freeze burns to skin.
WApartment dwellers: Check with management to learn the requirements and fire codes for using a LP gas
grill in your apartment complex. If allowed, use outside on the ground floor with a ten foot (3.05 m) clearance
from any structure. Do NOT use on or under balconies.
WLP gas cylinder needed to operate. Only cylinders marked “propane” may be used.
WThe LP gas cylinder must be constructed and marked in accordance with the Specifications for LP-
gas Cylinders of the U.S. Department of Transportation (D.O.T.), Cylinders, Spheres and Tubes for the
Transportation of Dangerous Goods; and Commissionor the National Standard of Canada, CAN/CSA-B339 .
WLP gas cylinder must be arranged for vapor withdrawal.
WThe LP gas cylinder must have a listed overfilling prevention device (OPD).

3
IMPORTANT SAFEGUARDS
WOnly use LP gas cylinders equipped with a cylinder connection device compatible with the connection for
outdoor cooking appliances.
WThe LP gas cylinder must have a cylinder collar to protect the cylinder valve.
WNever use an LP gas cylinder with a damaged body, valve, collar or footing.
WDented or rusted LP gas cylinders may be hazardous and should be checked by your LP gas supplier prior to
use.
WThe LP gas cylinder should not be dropped or handled roughly.
WLP gas cylinders must be stored outdoors out of the reach of children and must not be stored in a building,
garage or any other enclosed area. Your cylinder must never be stored where temperatures can reach over
125°F.
WDo NOT insert any tool or foreign object into the valve outlet or safety relief valve. You may damage the valve
and cause a leak. Leaking propane may result in an explosion, fire, severe personal injury or death.
WDo NOT block holes in sides or back of grill.
WNever keep an LP gas cylinder in a hot car or trunk. Heat will cause the gas pressure to increase, which may
open the relief valve and allow gas to escape.
WPlace dust cap on cylinder valve outlet whenever the cylinder is not in use. Only install the type of dust cap
on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in
leakage of propane.
WIf grill is not in use, the gas must be turned off at the supply cylinder and disconnected.
WDo NOT store a spare LP gas cylinder under or near this appliance.
WNever fill the cylinder beyond 80 percent full.A fire causing serious injury or damage to property may occur if
the above is not followed exactly.
WNever attempt to attach this grill to the self-contained LP gas system of a camper trailer, motor home or
house.
WNever use charcoal, lighter fluid, lava rocks, gasoline, kerosene or alcohol with this product.
WYour grill has been checked at all factory connections for leaks. Re-check all connections as described in the
“Operating Instructions” section, as shipping can loosen connections.
WCheck for leaks even if your unit was assembled for you by someone else.
WDo NOT operate if a gas leak is present. Gas leaks may cause a fire or explosion.
WYou must follow all instructions in the “Checking for Leaks” section before operating. To prevent fire or
explosion hazard when testing for a leak:
a. Always perform a leak test before lighting the grill and each time the cylinder is connected for use.
b. No smoking. Do NOT use or permit sources of ignition in the area while conducting a leak test.
c. Conduct the leak test outdoors in a well-ventilated area.
d. Do NOT use matches, lighters, or a flame to check for leaks.
e. The use of alcohol, prescription or non-prescription drugs may impair the consumer’s ability to properly
assemble or safely operate the appliance.
f. Strong odors, colds, sinus congestion, etc. may prevent the detection of propane. Use caution and
common sense when testing for leaks.
g. Do NOT use grill until any and all leaks are corrected.
If you are unable to stop a leak, disconnect the LP gas supply. Call a gas appliance serviceman or your
local LP gas supplier.
WThis grill is designed to operate at an inlet pressure of: 11 inches water column.
WDo NOT store or use gasoline or other flammable liquids or vapors within 25 feet (7.62 m) of this appliance.

4
IMPORTANT SAFEGUARDS
WDo NOT use in an explosive atmosphere. Keep grill area clear and free from combustible materials, gasoline
and other flammable vapors and liquids.
WMinimum clearance from sides and back of unit to combustible construction is 36 inches (91.4 cm). Do NOT
use this appliance under any type of overhang or roof.
WIt is essential to keep the grill’s valve compartment, burners and circulating air passages clean.
WInspect grill before each use.
WDo NOT alter grill in any manner. Any alteration will void your warranty.
WDo NOT use the grill unless it is COMPLETELY assembled and all parts are securely fastened and tightened.
WDo NOT build this model of grill in any built-in or slide-in construction. Ignoring this warning could cause a
fire or an explosion that can damage property and cause serious bodily injury or death.
WThis grill should be thoroughly cleaned and inspected on a regular basis.
WClean and inspect the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts or
leaks, the hose must be replaced prior to operation.
WUse only the regulator and hose assembly provided. Use only the replacement regulator and hose assembly
specified by RevoAce Inc. Limited
WUse only RevoAce Inc. Limited factory-authorized parts. The use of any part that is not factory-authorized can
be dangerous and will void your warranty.
WDo NOT operate this appliance without reading “Operating Instructions” in this manual.
WDo NOT touch metal parts of grill until they have completely cooled to avoid burns, unless you are wearing
protective gear (pot holders, gloves, BBQ mittens, etc.).
WDo NOT install or use in or on boats or recreational vehicles.
WWhen cooking, fire extinguishing materials should be readily accessible. In the event of an oil/grease fire, do
NOT attempt to extinguish with water. Use type BC dry chemical fire extinguisher or smother with dirt, sand
or baking soda.
WDo NOT use grill in high winds.
WNever lean over the grill when lighting.
WDo NOT leave a lit grill unattended. Keep children and pets away from grill at all times.
WDo NOT leave grill unattended while preheating or burning off food residue on high. If grill has not been
cleaned, a grease fire can occur that may damage the product.
WDo NOT place empty cooking vessels on the appliance while in operation.
WUse caution when placing anything on the grill while the appliance is in operation.
WDo NOT attempt to move grill when in use. Allow the grill to cool before moving or storing.
WLP gas cylinder must be properly disconnected and removed prior to moving this grill.
WStorage of grill indoors is permissible only if the cylinder is disconnected, removed from the grill and properly
stored outdoors.
WAlways open grill lid carefully and slowly as heat and steam trapped within grill can cause severe burns.
WDo NOT attempt to disconnect the gas regulator from the cylinder or any gas fitting while the grill is in use.
WAlways place your grill on a hard, non-combustible, level surface. An asphalt or blacktop surface may not be
acceptable for this purpose.
WMove gas hoses as far away as possible from hot surfaces and dripping hot grease.
WKeep all electrical cords away from a hot grill.
WAfter a period of storage and/or nonuse, check for leaks, burner obstructions and inspect for any abrasion,
wear or cuts to the hose.
WFailure to open lid while igniting the grill’s burners, or not waiting 5 minutes to allow the gas to clear if the

5
IMPORTANT SAFEGUARDS
grill does not light, may result in an explosive flame-up.
WNever operate grill without its heat plates installed.
WAlways use a meat thermometer to ensure food is cooked to a safe temperature.
WUse protective gloves when assembling this product.
WDo NOT force parts together as this can result in personal injury or damage to the product.
WNever cover entire cooking area with aluminum foil.
WDeaths, serious injury or damage to property may occur if the above is not followed exactly.

6
Expanded View
1
2
3
4
5
7
7
6
8
13
109
11
11
12
12
1414

7
Hardware
AScrew M4x15 Nickel Plated Phillips Truss Head 4 pcs
B Screw M6x12 Nickel Plated Phillips Truss Head 5 pcs
CWing Nut M4 Steel 4 pcs
DWing Nut M6 Steel 6 pcs
EWasher ø22 Nickel Plated 2 pcs
Tools Required for Assembly (Not Included)
#2 Phillips Head Screwdriver 1 pc
1Handle G1904-010
2Brand Plate* B0109-LBA
3Lid G2210-010
4Lid Handle Plate G2014-020
5Cooking Grid G2014-040
6Heat Plate B0230-C00
7Heat Plate Support (2) B0231-B00
8Burner G2014-050
9Bottom Bowl G2210-020
10 Regulator/Control Knob G2210-030
11 Leg Support A (2) G2210-040
12 Leg Support B (2) G2210-050
13 Heat Shield G1814-040
14 Leg (2) G2014-090
* Pre-assembled
Parts List

8 Assembly Instructions
DO NOT RETURN TO PLACE OF PURCHASE.
1
Attach Legs
4
Attach Leg Support A & Leg Support B
3
Attach Lid Handle and Lid Handle Plate
2
Dx 2
E
x 2
Please have your owner’s manual and model number
available for reference.
Note: The model number can be found on the back or side
of the grill.
Assembly Tips:
1. Select an area where you will assemble this
product. To protect components, choose a smooth
surface that’s free of cracks or openings.
2. Spread out all parts.
3. Tighten all hardware connections by hand first.
Then, before completing each step, go back and
fully tighten all hardware. Be careful not to over-
tighten. That could damage surfaces or strip
threads.
4. For best results, complete each step in the order
presented.
To complete assembly you will need:
• (1) Leak Detection Solution (instructions on how
to make solution are included in “Operating
Instructions” section).
• (1) 14.1 oz or (1) 16.4 oz LP gas tank (not included).
Typical assembly is approximately 15 minutes.
D
E
Ax 4
Cx 4
A
C
12
11
11
12

9
1
2
Attach Heat Plate Supports
5
Attach Heat Shield and Burner
6
Cover Lid
8
Insert Heat Plate, Cooking Grid and attach
Regulator/Control Knob
7
B
D
B
x 4 B
Note: Once attached, the regulator/control knob will freely
rotate to accomodate for the LP gas tank.
Dx 4 B
x 1

10
9
1
2
1
1
2
1
Fold Legs and Lock Lid
Note: Lid must be locked before transporting grill.
Unfold Legs and Unlock Lid
Note: Always open legs completely and secure in place befor lighting grill..