EXTBIKE PILOT V User manual

Thank you for purchasing!
To insure maximum experience and safety, familiarize yourself with
ALL aspects of your new light and battery system.
1. How to mount to a bicycle
2. How to charge
3. Switch operation
4. Warranty, Support, Customer Service

Caution:
1. Before your trip, please make sure the light is firmly mounted to
the bracket, it lights up, and the light is not blocked by baggage,etc.
2. Do not place it within children’s reach.
3. This product is water-proof under normal daily use and can be
used in the rain. However, do not intentionally submerge it in water.
Failure to follow these cautions will void the warranty and can
cause damage to the system.
A lighting system can make riding safer and you more visible, but
lights are no substitute for common sense. Ride within your
capability with consideration for the riding environment.
How to Mount to A Bicycle:
1. Attach the bracket to the handlebar.
2. Screw up the bracket to the handlebar.
3. Insert the light head to the bracket until it locked, and adjust the beam
angle.

How to Charge:
1. Twist-off the end cap of light head.
2. Connect the light head and your PC, or a 5V USB battery charger with
the USB cable. The switch lights up, and charging starts.
3. When the switch turns green, charging is complete. Remove the USB
cable and screw up the end cap.
Tips:
1. When your PC is in sleep state, the light cannot be charged.
2. Flashing light of the switch shows that a charging error has occurred.
Remove and reinsert the USB cable, then begin the recharge process
again.
3. The battery charges to about 80% after approximately 5 hours.
4. Charing and lighting times are approximate values, and will vary by
environmental and user conditions.

Switch Operation(Switching the lighting mode):
Operation Modes: The initial short press of the switch will turn the light on
High. Each additional short press of the button switches the light from one
mode to the next, i.e. High, Medium, Low, Flash
Turn light off: Press and hold the button for one to three seconds.
Check Battery Level: When the light is turned off, press the button for 3
seconds and release. The light will flash from 1 to 9-10 Times indicating
the battery level remaining. (9 flashes indicates full).
High
Medium
Low
Flash
Approx Run Time
2.5 hours
3 hours
6.5 hours
Approx Lumens
500
400
150
Low Battery Level: The switch light (operation button) will glow red when
the battery level is low and the light will automatically turn off when the
battery level is too low. This system protects the battery from damage, but
since it draws a small amount of current, and can drain the battery beyond
the minimum voltage for the battery,
The light must be turned off when the button glows red or within 5
minutes of it glowing red. Do not wait until the light goes
completely out as this will greatly reduce the number of
charge cycles that the battery can be used and can render the
battery unusable.

Model No: PILOT V Specifications
1. Waterproof headlamp Brightness: 500LM
2. Low power consumption
3. Material: Aircraft aluminum
4. Finishing: hard -anodized
5. Fluorescent waterproof indicator ring for greater night visibility
6. Color: colorful LED : CREE XML T6 ultra bright LED
7. LED life span: 50,000hours Battery: 1X18650 / 3.7V Li-ion
Battery Discharge Times : 150 minutes (High)
180 minutes (Medium)
390 minutes (Low)
Charge Time :2~6H
Low Power warning: red light warning (blue fluorescent ring changes to red)
Lighting Modes: 100% brightness 80% brightness 30% brightness
flashing(2.4HZ)
Waterproof Grade:IP65
This product contains components that must be recycled per EU Directive
2002/96/EC and may not be disposed as unsorted municipal waste

Warranty Card:
Our product quality is controlled strictly in accordance within the standards
of our quality certification program. To ensure that all users enjoy the
product, We commits to all users the following:
1). One year warranty Within one year from purchase date, under normal
use, the consumer will be provided free warranty service for any quality
related problems.
2). Lifetime limited repair: We will provide paid warranty service after the
initial one year warranty. The cost of this service is for the actual
replacement part without any additional labor fees. The warranty is limited
to existing stocked models, parts and accessories.
When requesting warranty service, customer should present this page
along with your original purchase receipt or numbers provided by online
retailers or dealer.
Warranty Service Exclusions:
A) Any damages that are caused by other than normal use, including, but
not limited to physical damages.
B) Any user modification, repairs or disassembly of the product without
factory authorization.
C) Missing warranty card or valid receipt documents