EZiCaddy EZi-5 Digital User manual

EZiCaddy
EZi-5 Digital User Manual

Page 2
YOUR EZiCaddy EZI-5 DIGITAL TROLLEY

Page 3
1Front Wheel Adjuster Nut
2Camlock Lever
3Lower Bungee Strap
4Bottom Bag Stay
5Front Wheel Release Lever (on Right-Hand side of
trolley)
6Quick Release Lever for wheel
7Rear Wheel
8Motor
9Battery
10 Unfolding Release Lever and Battery Release Lever
(Battery Catch)
11 Lower/Main Spar
12 Upper Bungee Strap
13 Upper Bag Stay
14 Height Adjustment Screw
15 Folding Release Lever
16 Upper Spar
17 Handle, Controls and Display
18 USB Port

Page 4
YOUR EZICADDY EZI-5 DIGITAL
Congratulations on your purchase of the new EZi-5 Digital - a brand new
powered trolley from a brand new company. New maybe, but one
founded by two of the most experienced professionals in the business,
with over 50 years’ experience in electric golf trolleys between us. From
the earliest stages of development, the mantra has been ‘make it easy’ –
easy to open, easy to fold, easy to carry, easy to manoeuvre, easy
plug’n’play battery, easy to operate, even easy-on-the-eye. Every little
detail was designed and engineered to be ‘easy’. We hope you enjoy
your new trolley and welcome your feedback and comments.
Your new cart has also been designed for easy, minimum maintenance.
Please read these instructions carefully, and your new EZiCaddy trolley
should give you many years of faithful service.
FINDING YOUR TROLLEY SERIAL NUMBER
The serial number for your EZi-5 Digital trolley can be found on the
underside of the main spar. The same number is on the box you
received with your trolley. Please keep this box for shipping purposes.
YOUR EZICADDY TROLLEY IS SIMPLE TO MAINTAIN:
Store in a dry protected place.
Never jet-wash it or immerse it in water.
Avoid using detergents, oils or solvents on it.
Wipe clean whenever it gets wet or wipe with a damp cloth
when it gets dirty.
Occasionally remove the wheels and apply grease to the axle.

Page 5
FOLDING AND UNFOLDING YOUR TROLLEY
To unfold the upper section of your trolley, depress the release lever 10
and pull the handle away from the main spar. Continue unfolding until
the upper spar clicks into place. To unfold the bottom bag-stay section,
depress the release lever 5 and pull the wheel away from the main spar.
Continue unfolding until the bottom bag-stay clicks into place.
To fold your trolley, make sure you have removed your battery. Then
depress lever 15 to release the upper handle section and continue
folding until it clicks closed. Then depress lever 5 to release the front
wheel and continue folding until it clicks into place.
The folded trolley is designed to be stable standing upright or flat on its
back.
Never put your trolley into your car boot with the battery plugged in.
It could get switched on.

Page 6
ADJUSTING THE HANDLE HEIGHT
Your EziCaddy has 5 height adjustment settings. To adjust the handle
height, first fold the trolley. Then unscrew the locking screw 14 by about
8 mm until the handle adjuster plate can be lifted off the teeth below.
This then allows you to select one of the 5 available handle heights.
Move the plate forward to raise the handle height and backwards to
reduce the handle height. Please note that the adjustment plate cannot
be moved if the trolley is open. Finally, re-do screw 14 tightly.

Page 7
FITTING THE PLUG-N-PLAY BATTERY
To fit the battery, hold it vertically and, from the rear of the trolley,
present it base downwards to the main chassis. The notch in the base of
the battery will locate in the recess of the chassis. The top of the
battery can then be pushed firmly forwards to engage with the battery
catch at the top of the battery.
To release the battery, press the battery release lever at the top and pull
the battery out of its docking station.
Always remove the battery before folding your trolley.
ADJUSTING THE FRONT WHEEL.
If the steering of your trolley gets knocked out of alignment, it can
usually be corrected using the front wheel adjustment nut. Tracking /
poor steering can also be affected by the way you load your bag. This is
why an anti-twisting “cart bag” often provides a better driving
experience.
Lift the cam-lock lever 2 to release it. Rotate the front wheel
adjustment nut clockwise to make the trolley go more to the right and
anticlockwise to get it to track more to the left. When you are happy
that it is tracking correctly, push back the cam-lock lever 2 to fix it back
in position. The cam-lock needs to grip very firmly to prevent
subsequent movement.
REMOVING THE MAIN WHEELS.
You might occasionally want to take off the main wheels either for
cleaning purposes or to squeeze your trolley into a tighter space.

Page 8
Press button 6 to allow you to release and pull off the wheel. Replace
the wheel by sliding the wheel into the clutch, align the wheel so that it
starts to engage properly and then push until you hear the engagement
click
THE UPPER AND LOWER BAG STAYS
The upper and lower bag stays are designed to accommodate a wide
range of golf-bag shapes and sizes. Ideally, you will be using a “Cart-Bag”
with symmetrically balanced pockets and an anti-twist base.
To lock the base of your bag in place, stretch the bungee strap 3 over
the bottom of the bag. This strap is not adjustable because most bag
bases have the same dimensions.
To hold the top of your bag in place, stretch the upper bungee straps 12
and clip in place as shown opposite.

Page 9

Page 10
EZICADDY CHARGER
Only use this charger with your EZiCaddy Standard battery or EZiCaddy
Lithium battery. It recognises which EZiCaddy battery you are using and
adjusts accordingly. Do not use a non-EZiCaddy charger with your
EZiCaddy battery or vice versa; a mismatch of battery and charger could
cause damage.
Your charger should be placed on a hard surface, in a dry, well-
ventilated place. Do not charge in direct sunlight. Unplug it from the
mains supply before connecting or disconnecting the battery.
Do not open the charger casing there are no serviceable components
inside
Always check that the charger casing and cables are in a good condition.
1Connect your battery to your charger when you first receive it
and, thereafter, as soon as possible after use.
2Plug in and switch on at the mains supply. The red light will
come on.
3After some minutes or several hours, according to the initial
charge on the battery, the red light will go out and the green
light will come on. If you are charging a brand new battery (and,
so, relatively well charged battery), the light may go green
relatively quickly. Even so, please still leave it on charge.

Page 11
4We recommend that you leave your battery “on charge” until
your next game.
5Never leave the charger connected to the battery with the
mains supply switched off
EZICADDY BATTERY
Your EZiCaddy battery is designed to play 18 holes. Avoid exceeding 18
holes on one charge to maximise battery life. If you regularly want to
play more than 18 holes, please buy another battery.
Always remember to charge your battery after use, even if you have
only played a few holes, and then leave it on charge until your next
game.
Note, the charging light for a brand new battery should turn green much
sooner than for one that has done a full round of golf. Even so, please
still leave it on charge.

Page 12
USING YOUR EZICADDY EZI-5 DIGITAL
When you have fitted your battery and secured your bag, you are ready to go.
Depress and release the control knob on the handle to turn on
the power.
Rotate the control knob clockwise to increase the power. You
will see the Power reading increase and your EZi-5 Digital should
start moving and speed up. Your actual speed is shown top
right.
Rotate the control knob anti-clockwise to reduce the power.
Your EZi-5 Digital should slow down accordingly.

Page 13
Depress and release the control knob on the handle to turn off
the power.
If you turn off the power when moving, the trolley will
remember your power setting and you will see the Power
reading flashing. On turning the trolley back on, it will gradually
accelerate back to that power setting.
If you have turned off the power when moving and do not want
to start off with the same setting, simply rotate the control knob
anti-clockwise. You will see the flashing power setting reduce.
Your trolley will always forget its power setting and revert to
zero if you disconnect the battery.
If the Power reading on your EZi-5 Digital is a steady “1” or above,
it will be trying to move and will be consuming battery power.
So don’t inadvertently drain your battery by leaving it in that
condition up against an obstacle.
DISTANCE READINGS
There are three distance read-out options:
1Drive
2Approach
3Total distance
You can toggle between these readings by repeatedly pressing the Left
Hand button.

Page 14

Page 15
Both “Drive” and “Approach” are set to zero on connecting the battery.
To re-set “Drive” to zero, turn off the power to your EZiCaddy by
pressing the Control knob and when the display is already showing
“Drive” press and hold the Left Hand button for about 3 seconds. This
also sets “Approach” to zero.
To measure how far you have driven the ball off the tee, zero the
“Drive” reading and walk directly to your golf ball. You will see the
“Drive” reading increase until you reach your ball.
To re-set “Approach” to zero, turn off the power to your EZiCaddy by
pressing Control knob and then when the display is already showing
“Approach” press and hold the Left Hand button for 3 seconds.
To measure how far your approach will be, zero the “Approach” reading
as you go past the nearest Fairway Distance Marker (make a mental note
of the marker distance reading!). Continue walking to your ball and
subtract (or add) the Approach measurement from the Distance Marker
(according to whether your ball is beyond or before that marker) to give
you the distance to the green.
“Total Distance” cannot be re-set, even if you unplug the battery. It
simply displays the lifetime mileage of your EZiCaddy to date including
the in-factory testing.

Page 16
ADF ( AUTOMATIC DISTANCE FUNCTION ) MODE
Your EZi-5 Digital features a convenient Automatic Distance Function.
This is particularly useful when you want to, say, send off your trolley by
itself towards the next tee whilst you go on to the green. But please be
very mindful of people and obstacles that might end up in your path.
Hold down the control knob for at least 3 seconds until the letters
“ADF”light up in the display and then release it. Rotate the control knob
clockwise to increase the distance (in increments of 5 yards to a
maximum of 50 yards) you want the cart to travel by itself.
Then press the control knob to start off your cart. Your EZi-5 Digital will
then travel for the distance you have chosen at a power setting of 5
(which can be adjusted instantaneously, should you wish) and then stop.

Page 17
When you return to your EZi-5 Digital it will still remember the speed at
which you left it and will accelerate to that speed when you next
depress the control knob
TO TOGGLE BETWEEN CLOCK AND ELAPSED TIME
Press the Right Hand Button. The words “Elapsed” will appear and
disappear when your EZiCaddy is displaying the selected time
measurement.
TO ZERO THE ELAPSED TIME
The elapsed time is set to zero when you disconnect the battery.
TO SET THE CLOCK CORRECTLY
Turn off the power to your EZiCaddy by pressing the control
knob.
Press and hold down both Left Hand and Right Hand buttons
simultaneously for three seconds and the first feature that you
can change (Time) will flash slowly.

Page 18
Press the control knob to select Time.
Rotate the control knob to select the first digit you want.
Press the control knob to save and move on to the next digit.
Repeat steps 4 and 5 until you have the correct time flashing.
To save and exit, press and hold down both Left Hand and Right
Hand buttons simultaneously until the time stops flashing.
COMPETITION MODE
You can temporarily disable the distance measuring functions should
competition rules dictate.
Indeed, you should always check competition rules before using your
EZiCaddy with the distance readings enabled.
1. Turn off the power to your EZiCaddy
2. Press and hold down both Left Hand and Right Hand buttons
simultaneously for three seconds and the Time will flash slowly.
3. Press the right hand button and you will see a flashing “COMP”
4. Press the control knob to select “ON” or “OFF”.
5. To save and exit, press and hold down both Left Hand and Right
Hand buttons simultaneously until the flashing stops.
6. If Competition mode has been selected, it will display “COMP”.
If Competition mode is not active, that element will be blank.

Page 19
TO ENABLE THE PIN FACILITY
1. The factory default is for there to be no requirement for a PIN
before using your EZiCaddy. The PIN number is not a security
device and is not intended to prevent your EZiCaddy being
stolen. It is simply a way of helping to prevent people from
tampering with your personal settings or, indeed, enabling a PIN
on your EZiCaddy without your knowledge. It is therefore VERY
important that you choose a PIN that you are not going to
forget!
2. Turn off the power to your EZiCaddy.
3. Press and hold down both Left Hand and Right Hand buttons
simultaneously for three seconds and the first feature that you
can change (Time) will flash slowly.

Page 20
4. Press the right hand button and the next feature you can change
(COMP) will flash.
5. Press the right hand button again and the next feature you can
change (PIN) will flash.
6. Press the control knob to and you will be presented with a
flashing first digit.
7. Rotate the control knob to the digit of your choice.
8. Press the control knob to save and move on to the next digit.
9. Repeat until you have saved the number.
10. The display will read “PIN” and “ON”
11. To save and exit, press and hold down both Left Hand and Right
Hand buttons simultaneously.
Now, whenever you connect your battery, your display screen will light
up with a flashing “0---“ and you will need to enter your 4 digit PIN as
follows:
1. Select the first number of the PIN by rotating the control knob.
2. Push this knob to confirm and move on to the next number.
3. Repeat steps 1 and two for the remaining numbers.
If you get the PIN wrong, the screen will revert to the first digit and you
will not be able to use your EZiCaddy until you enter the correct PIN.
There are no limits to the number of attempts at getting the PIN right.