Falcon i-TOP User guide

1
i-TOP & i-TOP DUO
INDUCTION TOPS
INSTALLATION, SERVICING
and USER INSTRUCTIONS
IMPORTANT
The installer must ensure that the installation of the appliance is in conformity with these
instructions and National or Local Regulations in force at the time of installation.
This appliance has been CE-marked on the basis of compliance with the Low Voltage
and EMC Directives for the voltages stated on the data plate.
WARNING: THIS APPLIANCE MUST BE EARTHED.
On completion of the installation, these instructions should be left with the Engineer-in-
Charge for
reference during servicing. Further to this, The Users Instructions should be
handed over to the User,
having had a demonstration of the operation and cleaning of the
appliance.
IT IS MOST IMPORTANT THAT THESE INSTRUCTIONS BE CONSULTED
BEFORE INSTALLING
AND COMMISSIONING THIS APPLIANCE. FAILURE
TO COMPLY WITH THE SPECIFIED
PROCEDURES MAY RESULT IN
DAMAGE OR THE NEED FOR A SERVICE CALL.
FalconFoodserviceEquipment
HeadOfficeandWorks
WallaceView,HillfootsRoad,StirlingFK95PY
Serviceline
t:01438363000f:01438369900

2





TableofContents

1. Foreword3
2. ProductFeatures3
3. TechnicalSpecifications3
4. Installation4
4.1 HeatRadiationRequirements4
4.2 FirePrevention4
4.3 RequirementsonElectricalConnection 4
5. Troubleshooting5‐6
6. InstallationandOperatingInstructions 7
7. SafetyInstructions7
7.1 RisksofNegligenceofSafetyInformation 7
7.2 SafetyNotes8
7.3 NoticetoUser8‐9
7.4 UnauthorizedChangeandPartReplacement9
8. Cleaning&Maintenance10
9. RegularServicing11
10. WasteDisposal11























3
1. Foreword
ThankyouforchoosingourFalconproduct.Beforeinstallationanduseofthisproduct,pleaseread
thismanualcarefullyasitcontainsimportantinformationabouttheinstallation,operationand
maintenanceoftheproduct.Pleasekeepthemanualinaplacereadilyavailableforeasyreference.
2. ProductFeatures
Falconinductioncookershavethefeaturesofstrong,compactconstructionwithastainlesssteel
enclosure,continuouslycontrolledpowerandhigherheatingefficiencythanconventionalcookers.
Theyalsohavethefollowinguniquefeatures:
•Glass‐ceramicpanel,excellentthermalshockperformance,sleekaestheticdesignforeasy
cleaning;
•Modularizeddesign;
•Electroniccircuitwithautomaticmonitor&controlandmultiplesafetyprotection;
•Highefficiencyandlargepowertosavecookingtimeandenergy;
•Compactsizeandlightweight;
•Customizeddesigns.
3. TechnicalSpecifications
PowerSupply:230V~/3N～400V,50Hz/60Hz
OperatingFrequency:20‐40KHz
Power(TableTop):3kW/3.5kW*2
AmbientConditions
Temperature:Storage‐40Ԩ‐+50Ԩ;Operation+5Ԩ‐+40Ԩ
RelativeHumidity:Storage10％‐90％;Operation30％‐90
Maximumweightofemptyappliances:i‐Top–7.5kg.
i‐TopDuo–19.5kg.

4

4.Installation
Falconinductioncookersareoftheplug&playtype,whichisreadyforuseafterpowerandwater
supplies(ifnecessary)areconnected.
4.1HeatRadiationRequirements
•Adequatespaceshallbeleftinthebackandbottomoftheunittoallowfreeflowofair.
Improperinstallationwillresultinblockageordecreaseofairflowandpoorradiationof
heat;

•Theairinletandoutletshouldbeatleast100mmfromanyperipheralobject
(suchaswallandfloor);

•Theinletcoldairshouldnotbemixedwiththeoutlethotair;
•Theinletairtemperatureshouldnotexceed40Ԩ;
•Theinductioncooker(steamer)shouldbeawayfromotherheatsources(suchasgascooker
orhalogenstove).Incaseseveralinductioncookersareused,theyshouldbeatleast
100mmapartfromeachother.Besides,itshouldbeensuredthatthereissufficientsupply
ofcoldairandthehotairdischargedbycookerswillnotenterothercookers.

4.2FirePrevention
Allobjectsincontactwiththecooker(steamer)shouldbemadeofnon‐inflammablematerials.
4.3RequirementsonElectricalConnection
•Checkandmakesurethatthepowersupplyisconsistentwiththeratingonthenameplate
oftheproduct;

•Theelectricalconnectionmustcomplywithexistingnationalandlocalregulations;
•Theelectricalcableoftheproductmustbeconnectedtothepowersupplywithan
appropriateplug;

•Incaseleakageprotectionisadopted,themaximumcircuit‐breakingcurrentis30mA.








5

5.Troubleshooting
Warning:Thereishighvoltageinside!Donotopenthecooker!
Thecookercanonlybeopenedbyauthorizedservicingpersonnel.
Incasetheglass‐ceramicpanelbreaksorcracks,immediatelyswitchoffthecookeranddisconnect
thepower.Nevertouchanyexposedpartinsidethecooker.
Whenmalfunctionoccurs,theindicatorwillshowsomeinformationasfollows:
CodeMeaningRemarks
E–01
Nopan‐Placeproperpanonthecooker;
‐Consultprofessionalpersonnel
E–03
Over‐temperatureinpower
module,shutdown
‐CoolingNeededor
‐Consultprofessionalpersonnel;
E–05
Damageofpowerpotentiometer,
orthepowerlevelisnotsetatthe
“0”position.
‐Setthepowerlevelnotsetat“0”positionbefore
use.
‐Problemofthepowercontrol,Consult
professionalpersonnel
E–07IGBTtemperaturesensorerror‐Consultprofessionalpersonnel
E–10Toolowvoltageofpowersupply ‐Checkthepowersupply
E–12
Over‐temperatureinpan,
shutdown
‐Checkifthecoolingfanofthecoilsworksproperly.
‐Oiltemperatureinthepantoohigh.Lowerthe
powerlevel.
E–13Temperaturesensorerror‐Consultprofessionalpersonnel








6

FaultPossibleCauseCorrectingMeasure
Thereisnoheating,
lamporindicatoris
blinking
Erroroccurs.ChecktheErrorcodelistandfollowthe
instructions.
Thereisnoheating,
lamporindicatoris
off
Nopowersupply;
Checkwhetherthepowercordiswell
connected.
PCB/ComponentsareBrokenConsultprofessionalpersonnel
Heatingeffectisgood
butindicatororlamp
isoff.
LamporIndicatorisbroken.
ReplacetheLamporIndicator
Consultprofessionalpersonnel
Switchdoesnotwork
orthepowercould
notbeadjustedby
rotating/sliding
Switch.
Switchfailure;
ReplacetheSwitch.
Consultprofessionalpersonnel
Powerbecomes
lowerthannormal
power.
Thepowerislimitedbytheprogram
becausethetemperatureofIGBTor
Panisrisingtoofast.
Waitforamoment;
Avoidheatingtheemptypan.
Thepan/wokisnotproper,pleasereplacethe
pan/wok;


Thepowerislimitedbytheprogram
becausetheambienttemperatureis
toohigh
Pleasetrytoimprovetheambientconditions:
Cooldowntheambienttemperature;
Keeptheinductionproductsawayfromthehot
sources;
Checkiftheventilationofinductionproductsis
good,oriftheairfilterisblocked.
InappropriateInternalSetting
ParametersConsultprofessionalpersonnel


7

6.InstallationandOperatingInstructions

i‐Topi‐TopDuo
Installation:
①Openthepackageandmakesurethattheappearanceoftheunitisingoodcondition.
②Placetheunitattheinstallationplace.Payattentiontotheventilationconditions.
③ConnectthecabletotheterminalblockorCircuitbreakeraccordingtothelabelling.
Allconnectionsmustbesecure.

OperatingInstructions:
Afterthedeviceispoweredonandthereisnoabnormalindication,itisreadyforuse.
Operateaccordingtothefollowingsteps:
①Placeawok/panwhichisrecommendedbythemanufactureronthecookerandaddthe
appropriateamountofwater.Theinstructionsforappliancesincorporatinginductionheating
sourcesshallindicatethesizeofthesmallestcookingvesseltobeused.

②Switchonthepower,theindicatorwillgoon.
③Dependingonthefoodtobecooked,turntheknobslowlytoanappropriatepositionbetween
“0”and“Max”.Acorrespondingnumberwillbeshownontheindicator.

④Afteruse,turnthehandleto“Off”andcutoffthepower.








8

7.SafetyInstructions
7.1RisksofNegligenceofSafetyInformation
Thismanualcontainssafetywarningsandprecautionsontheinstallation,commissioningand
operationoftheinductioncooker.Negligenceofsuchinformationmayleadtoharmstopeople,
environmentandequipment,aswellaspotentialrisksasfollows:
Electricshock;
Overheatingofwok/pan;and
Overheatingofcookersurface.
7.2SafetyNotes
Thesafetyinstructionscontainedinthismanual,theapplicablenationalregulationsonthe
preventionofaccidentsaswellasuser’sinternalsafetyrulesmustbestrictlyobserved.
7.3NoticetoUser
•Topreventelectricalshocks,theinstallationandelectricalconnectionoftheinduction
cookermustbeperformedbyaqualifiedcontractoraspernationalandlocalregulations.

•Theheatingzonehashightemperature.Toavoidinjury(scalding),donottouchthisarea.
•Toavoiddryheating(glowing)ofwok/pan,don’tleavetheapplianceonunattended.
Forthesakeofsafety,switchthepoweroff.

•Topreventaccidentscausedbyautomaticheatingofwok/pan,switchoffthecookerbefore
removingthewok/pan.Donotrelyonthepandetector.Thisensuresthatanyonewho
wantstousethecookermustswitchitonhim/herself.

•Don’tinsertanypieceofpaper,cardboard,cloth,etc.betweenthewok/panandtheheating
area,asthismayinitiateafire.

•Donotplacemetallicobjectssuchaskitchenutensils,cutlery,cans,aluminiumfoilandkeys
onthehobsurfacewithinthecookingzonebecausesuchthingscanbeheatedupquickly.

•Donotwearwatchesandringsastheseobjectscanbeheatedupwhenincloseproximity
tothehobsurface.

•Peoplewithheartpacemakersshouldconsultwiththemanufacturerorphysicianbefore
usingtheinductioncooker.

•Theentireunitmustbereliablygrounded.Oncethecookerbodyorelectriccableis
foundbroken,immediatelyswitchtheunitoff,disconnectthepowerandcontactthe
manufactureroritsauthorizedservicingpersonnel.

•Donotplacealuminiumfoilorplasticutensilsontheglass‐ceramicsurfaceintheheating
zonenoruseitasstorage.



9

•Thecontactsurfaceofwok/panmustmatchthatoftheglass‐ceramicpanel;otherwise,
Itmayleadtoreducedperformance,malfunctionandevendamagetotheinductioncooker.
Therefore,onlythosewoks/panssuppliedorrecommendedbythemanufacturercanbe
used.(Wokdiameter:360mm,Minimalpandiameter:220mm,ferrousorcompoundsteel
bottom)

•Don’tplacecreditcards,phonecards,passengercards,cassettetapesorothermagnetic
objectsonthesurfaceoftheinductioncooker.

•Thereisaircoolingsystemintheinductioncooker.Toavoidoverheatinginducedshutdown,
donotblocktheairvents.

•Donotletanyliquidenterthecooker.Donotspillwaterorfoodoverthewok/pan.
Donotflushthecookerwithwater.Donotcleanthecookerwithasteamcleaner.
•Incasetheglass‐ceramicpanelbreaksorcracks,immediatelyswitchoffthecookerand
disconnectthepower.Nevertouchanyexposedpartinsidethecooker.

•Operationbeyondtheratedvaluesandlimitsoftheinductioncookerwillresultinunreliable
operationandevendamage.Itisadvisedthatthecookeroperateatfullpower,i.e.the
powerregulatorissettothemaximumscale.Selectbetween“1”and“3”whenslowfireis
required.

•Neverturntheinductioncookeronandofffrequentlywithoutanypurposeasthismay
causedamagetotheelectricalcircuitandshortentheservicelifeofthecooker.Normally,
thecookershouldnotberestartedwithin3secondsafteritisshutdown.

•Theinductioncookershouldbecleaned,maintainedandservicedonaregularbasistokeep
itingoodconditionandextenditsservicelife.

•Thereishighvoltageinsidethecooker.Itcanonlybeopenedbyauthorizedservicing
personnel.

•Toavoidmisuse,alldiscardedelectricaldevicesmustbedisposedofsafelyandproperly
bytheuser.

•Thereisasmallareaatthebottomcentreofthewok/panthatheatsslowly.
Toensurethatoilisevenlyheated,stirtheoilinthewok/pan.

•Theceranglasspanel,enclosure,wok/pan,tub,potandpotsupportoftheinduction
cookerareoutsidethewarrantyscope.

7.4UnauthorizedChangeandPartReplacement
Donotmakeanychangetotheinductioncooker.Iftheinductioncookerneedstobechanged,
pleasecontactthemanufacturer.Forsafety’ssake,pleaseusepartsandcomponentscertifiedbythe
manufacturer.Useofanyuncertifiedpartsandcomponentswillvoidallthecommitmentsand
warrantiesofthemanufacturer.






10

8.Cleaning&Maintenance
Cleantheglass‐ceramicpanelsurfaceinthesamewayastoglass.Donotusecorrosiveorgrinding
cleanerssuchasgrillspray,detergentpowder,de‐ruster,polishingpowderorcoarsespongetoclean
thepanel.

Topreventscalding,donotcleanthepanelwhenthesurfaceishot.

StainsandRemovingMethod

StainTypeRemovingMethod
Slightlysoiled,withoutburning
remnantWipecleanwithawetcloth,withoutusingcleaningagent.
StickysubstanceScrapewithawoodenscraperandthenwipecleanwithawet
cloth.
Scaleformedbyspilledboiling
waterCleanwithvinegarorspecialcleaningagent.
Oil‐resistantstrainerblockageSoakthestrainerinwarmwaterwithcleaningagent,andthen
cleanwithabrush.
Sugar,sugaryfood,plasticand
aluminiumfoil
Removewithawoodenscraperwhilethestainiswarm,then
cleanwithacleaningagent.
Caution!Avoidscalding.Ifstainisnotremovedintime,tiny
holesmayformonthesurfaceoftheglass‐ceramicpanel.

Othermaintenanceandservicingworkthancleaningandmaintenanceshouldbeconductedby
designatedserviceproviders.

Important:Avoidleakageofliquidintotheinductioncooker.Donotflushwithwaternorcleanwith
steamcleaner.

















11

9.RegularServicing
Tokeeptheinductioncookeringoodconditionandextenditsservicelife,itshouldbecleaned,
maintainedandservicedonaregularbasis.
Thefilteroftheinductioncookermustbecleanedatleastonceeverythreemonths.
Theinductioncookermustbecheckedbyauthorizedtechnicalpersonnelatleastonceayear.
Danger!Donotopentheinductioncooker.Thereishighvoltageinside!
Theinductioncookercanbeopenedbyauthorizedpersonnelonly.

10.WasteDisposal
WEEEDirectiveRegistrationNo.WEE/DC0059TT/PRO
Atendofunitlife,disposeofapplianceandanyreplacementpartsinasafemanner,viaalicensed
wastehandler.
Unitsaredesignedtobedismantledeasilyandrecyclingofallmaterialisencouragedwhenever
practicable.
Donotuseuncertifiedordiscardedinductioncookers.
Ourproductsaremadeofregularmaterials.Nobatteryisusedinsidetheproducts.