Flywheels OXY User manual

1
Read Instructions Before Using Your New Electric Scooter

2
TABLE OF CONTENTS
TABLE OF
CONTENTS……………………………….…………….………………2
IMPORTANT
INFORMATION…………………………………….……………... …3-4
SAFETY GUIDE …………………………………………………………5
GETTING TO KNOW YOUR SCOOTER……………………………6-7
PACKAGE CONTENTS…………………………………………………8
GETTING STARTED………………..……………………………..…….8
ASSEMBLY…………………………………………………………… 8-11
SPECIFICATON …………………………………………………………12
BATTERY……………………………………………………………… 12
CHARING AND BATTERY……………………………………………13-15
DRIVING …………………………………………………………………15

3
PLEASE BE SAFE WHEN RIDING
ALWAYS WEAR A HELMET AND OBEY ALL LAWS!
BATTERY MAINTENANCE and
CHARGING INSTRUCTIONS
1. You MUST charge completely prior to initial use. (Follow
charging instructions in your Product Handbook)
2. Charge immediately after each use.
3. Charge before storage. You must charge every 30 days if not
in use.
4. Charge the unit for 6-8 hours or until the light on the charger
turns green.
5. DO NOT allow this unit to deep discharge the battery.
6. For safety purposes, DO NOT charge for over 24 hours.
7. Turn the unit OFF when not in use.
This PRODUCT IS NOT INTENDED FOR EXTREME or
OFF-ROAD Use! Please take care of your scooter!
DO NOT JUMP or ABUSE THIS PRODUCT!
DO NOT RIDE IN WET/ICY CONDITIONS!
IMPORTANT
WARNNING!

4
WARNING
This product does not conform to Federal Motor Vehicle Standards and
is not intended for operation on public streets, roads or highways.
Serious injury can result from the unsafe operations of this product.
Operator can minimize these risks by using certain safety equipment
such as: safety helmet, goggles, gloves, elbow and kneepads and
appropriate footwear.
DO NOT operate this product in traffic, on wet, frozen, oily or unpaved
surfaces or under the influence of drugs and/or alcohol. Avoid uneven
surfaces, potholes, surface cracks and obstacles.
DO NOT use a water hose to clean this product. See Product Handbook
for more information.
This product is recommended for riders 14YEARS OF AGE and older.
SAFETY
Persons without excellent vision, balance, coordination, reflex,
muscle and bone strength and good decision-making capabilities
should not use this product.
Minors without adult supervision should not use this product.
Persons unwilling or unable to take responsibility for their own
actions should not use this product.
The user of this product assumes ALL risks associated with its use.
To minimize these RISKS, the user must wear safety helmet,
goggles, gloves, elbow and kneepads and appropriate footwear.
This product is ELECTRIC! DO NOT ride this product in wet
conditions, puddles or rainy weather.
IMPORTANT
PLEASE READ THIS BEFORE USING THIS PRODUCT
READ THIS FIRST!
QUICK REFERENCE
SAFETY GUIDE

5
SAFETY GUIDE
The recommended minimum age for riding this scooter is 14 years old.
To avoid damage to the motor and footplate, do not overload the scooter.
Never ride with more than one person.
Inspect your scooter thoroughly before each use for loose or missing parts.
Avoid unintentional starts by turning the scooter off while not in use.
To avoid the risk of a short circuit in the electrical parts, do not use your Electric
scooter in the rain and never spray or wash off your scooter with water.
Do not place the battery near fire or heat.
To avoid damage to the battery, do not use the charger if it has been damaged in
any way.
Keep hands, face, feet and hair away from all moving parts.
Do not touch the motor or wheels while they are rotating.
Brakes are designed to control speed as well as stop the scooter. Practice
braking for proper slowing down and smooth stops.
Maintain your SCOOTER as recommended in this Product Handbook.
Use only quality replacement parts as recommended by the manufacturer.
Inspect the entire scooter prior to each use. Replace any part that is cracked,
chipped or damaged before use.
*NEVER ALLOW CHILDREN TO OPERATE THE SCOOTER WITHOUT ADULT
SUPERVISION.
*NEVER ATTEMPT TO OPERATE THE SCOOTER WHILE UNDER THE
INFLUENCE OF ALCOHOL.
If a situation arises that is not covered in the manual,
proceed with caution and use good judgment.
Contact your dealer
if you need further assistance

6
图
1
(photo 1)
1.Wing2. Wing light 3. Handlebar tube 4. Headlight 5. Front mud
plate 6. front fork 7. Front Disc brake 8. The disc brake 9. Front
12 inch wheel 10. Front 12 inch tire 11.Scooter 12. kick stand 13.
charger pot 14. rear fork 15. Rear Disc brake 16. Rear Disc
brake 17. Rear 12 inch Motor hub18. rear 12 inch tire 19. Rear
dish 20. Back mud plate 21. Rear shock absorber 22. seat post
23.Middle pipe cover 24. Saddle 25.Plastic toilet
1
2
6
3
4
5
21
11
16
10
12
14
15
20
22
24
25
7
19
8
9
13
17
18
23

7
(photo 2)
1. Diad switch
2. Display
3. Handlebars and throttle
Display content
(photo 3)
1. temperature
2. battery level
3. mileage
4. speed
5. fault（Motor 、throttle 、Controller 、brake ）
PACKAGE CONTENTS
1
2
3
1
2
5
4
3

8
Your Scooter comes with the following items in the box. Please locate all of the
following:
1. Electric Scooter
2. 48v lithium Battery Charger
GETTING STARTED
Please read and understand these instructions and the
OPERATING PROCEDURES section, prior to starting or riding your
scooter
Assembly:
1. Open the master carton and take out the scooter and
accessaries.
(photo 4)
2.Take out the screws on the handle bar connection with 4mm
inner hexagon spanner, and then focus on the hole and insert the
handle bar tube. Fix the handle bar tube on the connection part with
the 4mm inner hexagon spanner

9
(photo 5)
(photo 6)
3. Take out the 4pcs screws on the frame, and install the seat tube
with 4pcs inner hexagon screws one by one. Tighten the Nylon

10
nuts on the screws with 5mm inner hexagon spanner and 10mm
nut key.
(photo 7)
(photo 8)

11
4.Tighten the central tube on the treadboard with the cross point
screwdriver.
(photo 9)

12
ELECTRIC SCOOTER SPECIFICATION:
frame
Aluminium frame
motor
48v 240w brushless toothed high speed EP motor
controller
48v 240w motor
battery
48v,12ah lithium battery
charger
48v 2A AC 180-240V DC54.6V
charger time
6------8 hours
Brake(front/rear)
disc brake
front light
yes
rear light
yes
running distance
45-50KM
Speed
25 KM/H
load capacity
75 KGS
Operation
BATTERY
.Do not operate motor while charging!
.Indicator lights in the LED display are intended only for general
knowledge(full/empty) and does not give a precise indication to the battery
status.
.Do not store E-SCOOTER for long terms(more than two months) with fully
charged battery.
.From time to time discharge the battery by riding E-SCOOTER in the red light
position until it slows down and stops

13
DO NOT USE THE BATTERY IF THE BOARD
.Is Broken
.Emits an unusual odor or excessive heat
.Presents any leakage.
Avoid contact with substance oozing form the battery.
Keep the battery away from children and pets.Exposure to the battery voltage
can cause death or serious injury.
The use,sorage or charging of the E-SCOOTER battery outside specified limits
may result in the annulment of the warranty,battery damage,and an ineffective
battery charging
CHARGING AND BATTERY:
photo(10)

14
photo(11)
Your E-SCOOTER has an external charger.Connect the charging
cable to E-SCOOTER charging socket photo(10).
Than connnet the chargers electric cable to an electrical outlet
photo(11).
Your scooter comes charged out of the carton. We still recommend charging
the unit for 6-8hours prior to it’s first use. We also recommend charging your
scooter after each use and prior to storage.
Charging Light RED –Battery is charging .
Charging Light Green-Charging is complete .
Avoid long periods of tim wth an uncharged or fully charged battery.

15
To maximize your E-SCOOTER battery performance,fully charge it
for 6-8 hours once a month,or after each use of twelve hours .
Unplug E-SCOOTER from the outlet before installing ,removing the battery or
performing any maintenance.It is dangerous to work on E-SCOOTER when
plugged into an AC outlet.Electrical shock can cause serious injury and
damage the scooter .
Do not attempt to open the battery.Do not insert anything in the battery and do
not attempt to open it’s case with any tool.Inserting an object into openings or
in th battery can cause electrical shock,injury,burns or fire.Any attempt to open
the battery cause will damage it and cause reease of dangerours toxic
substances.
Charge the battery only using tools approved by E-SCOOTER.
Remove the battery and carry E-SCOOTER according to al applicable local
and national requirements.
Driving
1. insert the key, turn the key, and then the meter
displays the temperature, the battery power and so on. This
scooter is zero start. You need to turn the handle and the car
will go
2.when you meet a pedestrian, please press the left
green button and the horn will send out a call.
3. at night, Press the yellow button at night and you
can turn on the wing and front lights