Franklin HARD COURT 60116X User manual

www.franklinsports.com/60116X
ITEM NUMBER:
BASKETBALL SET
60116X
HARD COURT®
Made In China
Franklin Sports Inc.
Stoughton, MA 02072

ITEM#: 1
For replacement parts:
Visit: www.franklinsports.com/60116X
Email: [email protected]
Call: 1-800-225-8649
60116X
FAILURE TO FOLLOW THESE SAFETY INSTRUCTIONS MAY RESULT IN
SERIOUS INJURY AND/OR PROPERTY DAMAGE AND WILL VOID WARRANTY.
Owner must ensure that all players know and follow these rules for safe operation of the system.
• If using a ladder during assembly, use extreme caution.
• 2 capable adults are recommended for this operation.
• Check base daily for leakage. Leaks will cause system to fall.
• Assemble the pole sections properly. Failure to do so could cause the pole sections to separate during play or transport.
• Minimum operational height is 6.5’ (1.98m) to the bottom of backboard.
SAFETY INSTRUCTIONS
To ensure safety, do not attempt to assemble this system without following the instructions carefully. Check entire box
and inside all packing material for parts and/or additional instruction material. Before beginning assembly, read the
instructions and identify parts using the hardware identifier and parts list in this document. Proper and complete assembly,
use, and supervision are essential for proper operation and to reduce the risk of accident or injury. A high probability of
serious injury exists if this system is not installed, maintained and operated properly.
Most injuries are caused by misuse and/or not following instructions.
Use caution when using this system.
Save these instructions for future reference.
For assistance:
DO NOT CALL THE STORE!
PLEASE CONTACT OUR CUSTOMER SERVICE
DEPARTMENT at 1-800-225-8649

PARTS LIST
ITEM#: 2
x1
3pc Axel Set
1
QTY
x2
Lower Left & Right Brace
2
QTY
x1
Top Left & Right Brace
3
QTY
x1
Top Pole
4
QTY
x1
Middle Pole
5
QTY
x1
Lower Pole
6
QTY
x1
Rim
7
QTY
x1
Backboard
8
QTY
x1
Net
9
QTY
x2
Wheels
10
QTY
x1
Base
11
QTY
x2
Screw Washer Sets
A
QTY
x3
Bolt, Nut & Washer Sets
B
QTY
x2
Bolt, Nut & Washer Sets
C
QTY
x2
Screws
D
QTY
x4
Bolt, Nut & Washer Sets
E
QTY
x1
Tool Set
F
QTY
x1
Plastic Insert Tube
12 Pre-Installed
QTY
60116X
Rep. Part: 60116X-R4
Rep. Part: 60116X-R1 Rep. Part: 60116X-R1 Rep. Part: 60116X-R1
Rep. Part: 60116X-R6
Rep. Part: 60116X-R1Rep. Part: 60116X-R1Rep. Part: 60116X-R5
Rep. Part: 60116X-R2 Rep. Part: 60116X-R3
For replacement parts:
Visit: www.franklinsports.com/60116X
Email: [email protected]
Call: 1-800-225-8649

ASSEMBLY INSTRUCTIONS
1. Remove all components from the shipping
carton. Remove all protective wrap and layout
all components on the ground.
2. Ensure you have all components shown in the
parts identifier.
GENERAL NOTE
PARTS NOTE
STEP 1
Position the Wheels
(#10) and Lower Pole
(#6) in the locations on
the base, slide the
Axels (#1) through the
Base (#11) to hold
wheels and lower pole
in place.
ITEM#: 3
60116X
1 x1
1
10
11
6 x1
PARTS NOTESTEP 2
Using the Tool Set (F),
screw in the Bolt, Nut
& Washer (B) and the
Bolt, Nut & Washer
Sets (C) to secure the
Lower Left & Right
Brace (#2) to the lower
pole and base.
2 x2
B x1
C x2
1
10
6
10 x2
11 x1
C C
B
2 2
Top View
Bottom View
F x1
For replacement parts:
Visit: www.franklinsports.com/60116X
Email: [email protected]
Call: 1-800-225-8649

ASSEMBLY INSTRUCTIONS
ITEM#: 4
PARTS NOTESTEP 3
The Plastic Insert
Tube (#12) sits inside
the Middle Pole (#5)
and Lower Pole (#6).
Insert the Middle Pole
(#5) into the Lower
Pole (#6). Secure
using Screw (D).
(The screw should be
flush with the pole.)
5 x1
D x1
12 x1
5
12
Pre-Installed
D
6
6 x1
60116X
PARTS NOTESTEP 4
Attach Net (#9) to Rim
(#7) as shown.
7 x1
9 x1
7
9
For replacement parts:
Visit: www.franklinsports.com/60116X
Email: [email protected]
Call: 1-800-225-8649

ASSEMBLY INSTRUCTIONS
ITEM#: 5
60116X
PARTS NOTESTEP 5
Attach Rim (#7) to the
Backboard (#8) using
Bolt, Nut & Washer
Sets (E) as shown.
Secure the Top Pole
(#4) to the Top Left &
Right Brace (#3) as
shown.
Attach Top Left &
Right Brace (#3) to
the back of the
Backboard (#8) as
shown.
3 x1
4 x1
A
B
3
4
7
8
E
E
7 x1
8 x1
A x2
B x2
E x4
PARTS NOTESTEP 6
Insert the Top Pole
(#4) into the Middle
Pole (#5). Secure
using Screw (D).
(The screw should be
flush with the pole.)
D
4
5
D x1
5 x1
4 x1
F x1
HEIGHT
ADJUSTMENT
SYSTEM:
With 2 adults, loosen
bottom screw, adjust
middle pole upward to
desired height and
tighten screw. Repeat
for top screw and pole
for increased height.
Height adjusts from
6.5ft (1.98m) to 10ft
(3m).
For replacement parts:
Visit: www.franklinsports.com/60116X
Email: [email protected]
Call: 1-800-225-8649

ASSEMBLY INSTRUCTIONS
ITEM#: 6
60116X
PARTS NOTESTEP 7
(2) Adults are
required to complete
assembly. To prevent
serious injuries, the
pole should be held
down by one adult at
all times while the
base is being filled.
Lean system forward,
resting rim on the
ground. Remove cap
from hole furthest from
the pole. Using a
funnel (not included),
fill the Base (#11) with
sand until the sand is
just below the hole.
Using 2 adults, stand
the base up on a flat
surface and finish
filling the base with
sand.
11 x1
For safety reasons, we recommend that sand be used instead of water to fill the base. If a leak develops, water
could run out unnoticed, allowing the system to fall over, resulting in serious injuries, or property damage.
If using water, check the base carefully for leaks. If a leak is found, lay the system down on the ground and call
customer service. Do not use, stand up, or play on a leaking system.
SAND
362 lbs (164 kg)
11
The system must only be moved by at least 2 adults that are capable of handling weight. DO NOT allow children to move unit.
a. Adjust the system to its lowest position and lock in place to prevent the height mechanism from adjusting.
b. Standing in front of the unit, pull the pole down until unit is balanced on the 2 wheels.
c. Move the unit to the desired location and carefully lower unit back down.
The system must only be moved when balanced on the wheels. Sliding the unit any other way may cause damage to the base
and could result in sand leakage and/or system tipping over.
CAUTION:
MOVING THE SYSTEM
For replacement parts:
Visit: www.franklinsports.com/60116X
Email: [email protected]
Call: 1-800-225-8649

For replacement parts:
Visit: www.franklinsports.com/60116X
Email: [email protected]
Call: 1-800-225-8649
YOU ARE NOW READY TO PLAY!
Failure to observe this warning may cause
property damage and/or serious injury.
This product is NOT designed to support a player hanging from any
component of this basketball system.
Rim height adjustments should be made by ADULTS ONLY.
Wear a mouth guard when playing to avoid dental injuries.
During play, do not wear jewelry (rings, watches, necklaces, etc.).
Objects may entangle in net.
FAILURE TO FOLLOW THESE WARNINGS MAY RESULT IN SERIOUS INJURY AND/OR PROPERTY DAMAGE.
Owner must ensure that all players know and follow these rules for operation of the system.
• Only hang from the rim briefly to regain balance or avoid injuring others. Release the rim as safely as possible.
• During play, especially when performing dunk type activities, keep players face away from the backboard, rim and net. Serious injuries could
occur if teeth/face come in contact with backboard, rim, or net.
• Do not slide, climb, or play on base or pole.
• Completely fill base according to manufacturers instructions or the system will tip quickly causing serious personal injury.
• When adjusting height or moving system, keep hands and fingers away from moving parts.
• Do not allow children to move or adjust system.
• During play, do not wear jewelry (rings, watches, necklaces, etc.) Objects may entangle in net.
• Surface beneath the base must be smooth and free of gravel or other objects. Punctures can cause leakage and could cause system to tip over.
• Keep water and organic materials away from pole. Pole can rust and fall.
• Once a month check pole and all metal parts for rust. Completely remove rust and repaint with exterior enamel. If rust has penetrated any
steel part, replace that part immediately.
• Check system before each use for proper ballast, loose hardware, instability, and signs of corrosion and repair before each use. Never play on
damaged equipment.
• Do not use system during windy or severe weather. System may tip over. Place system in an area protected from the wind or in an area away
from property that may be damaged if the system falls.
FRANKLIN SPORTS
1-800-225-8649
SWINGING ON THIS RIM
MAY CAUSE SERIOUS INJURY
OR DEATH